Chandana Lakshmi MVV, et al., J Biotech Res Biochem 2019, 1: 003
HSOA Journal of Biotech Research & Biochemistry Research Article
Removal of Fluoride Using Pseudomonas Putida
MVV Chandana Lakshmi*, D Poornima, NS Karishma, Y Vardhan and PS Jyothi Department of Chemical Engineering, Andhra University, Visakhapatnam, India
Abstract In the present investigation, a defluoridation study was carried out using the bacteria Pseudomonas putida. Growth of the bacterial cells and their acclimatization in a fluoride media has been investigated. Optimization of physical parameters for the removal of fluoride was investigated. Optimum pH, temperature, contact time and initial concentration were found 7, 37ºC, 25 hrs and 5 mg/L, respectively. Maximum removal of 93.4% was achieved. Results suggested that Pseudomonas putida could be a potential bacteria in fluoride removal. Keywords: Pseudomonas putida; Fluoride; Nutrient Broth; Bacterial cells; Optimum Parameters
Introduction Water is an essential resource for sustaining life. Over the past few decades, the ever growing population, urbanization, industrialization and unskilled utilization of water resources have led to degradation of water quality in various developing countries. Presence of various hazardous contaminants like fluoride, arsenic, nitrate, and sulfate and other heavy metals, etc. in underground water has been reported from different parts of world including India. Fluoride uptake of up to mg/L has beneficial effects on plants, animals, and human beings. In human, fluoride exhibits bone formation, remineralization and protects against demineralization of teeth. Fluoride is extremely effective in protecting cavities and making teeth stronger. However, excessive fluoride intake over a long duration of time may result in a serious health problem called fluorosis. The starting phase is known to be dental fluorosis, which results in dental deformities with the development of a yellow colour affecting children in the age range of 6-8 years. The next phase is skeletal fluorosis, which brings the fluoride
*Corresponding author: Chandana Lakshmi MVV, Department of Chemical Engineering, Andhra University, Visakhapatnam, India, Tel: +91 9885361749; E-Mail: mahantilakshmi@gmail.com Citation: Chandana Lakshmi MVV, Poornima D, Karishma NS, Vardhan Y, Jyothi PS (2019) Removal of Fluoride Using Pseudomonas Putida. J Biotech Res Biochem 2: 003. Received: August 19, 2019; Accepted: September 13, 2019; Published: September 20, 2019 Copyright: © 2019 Chandana Lakshmi MVV, et al. This is an open-access article distributed under the terms of the Creative Commons Attribution License, which permits unrestricted use, distribution, and reproduction in any medium, provided the original author and source are credited.
deposition in skeletal muscles in children as well as adults. The most alarming stage of fluorosis is crippling fluorosis, which can have life threatening effects. Considering the health impacts of fluoride, World Health Organization (WHO) has set a fluoride concentration limit of 1.5 mg/L for drinking water where the limit of fluoride concentration set by the Central Pollution Control Board (CPCB) is 2.0 mg/L for inland surface water [1]. Fluoride enters a groundwater stream through natural as well as anthropogenic sources such as deep percolation from intensively cultivated fields, disposal of hazardous wastes from industry, liquid solid wastes from industries, sewage disposal, surface impoundments, etc. Some important industries that releases fluoride into a water stream are steel, aluminium, copper, and nickel production, phosphate ore processing, phosphate fertilizer production, glass, brick, and ceramic manufacturing, etc [2]. Fluoride concentrations in different industrial effluents may vary; in the effluent of some industries like phosphatic fertilizer; the fluoride concentration is normally around 20 mg/L. In many cases, the concentration of other ions associated with fluoride-containing effluents is below their permissible limits. To reduce the chance of contamination of groundwater by these industries’ effluents, the removal fluoride from the wastewater stream is essential before it enters the surface water stream and pollutes groundwater. Important methods used for fluoride removal are distillation, membrane separation processes, precipitation, ion exchange, and adsorption [3]. The adsorption method entails the use of physical or the biological adsorbents. The biological treatment method involving living microbial cells evolved as an emerging field for the removal of pollutants from water due to its low cost and eco-friendly nature. Further, in biological removal methods, microorganisms may be used in either a bulk phase or immobilized phase [4,5]. Immobilization can improve the microbial process’s efficiency. Some microbial strains have been used to remove fluoride from water in the bulk phase as well as immobilized phase. Many microbial strains have also been found to have fluoride-resistance capacity; however, there hardly any literature discusses the removal of fluoride from water using living bacterial cells. Pseudomonas putida (Figure 1) microbial type culture collection has been found to have fluoride-resistant properties; however, detailed studies on acclimatization, growth under stress, and fluoride removal under bulk or immobilized phases are not discussed. In the present study, the growth of Pseudomonas putida MTCC 8104 in N.B. media, its acclimatization in a fluoride environment and under substrate stress, and removal of fluoride in the bulk phase has been conducted [6].
Materials and Methods Microorganisms The bacteria used for the study is Pseudomonas putida obtained from our laboratory.
Citation: Chandana Lakshmi MVV, Poornima D, Karishma NS, Vardhan Y, Jyothi PS (2019) Removal of Fluoride Using Pseudomonas Putida. J Biotech Res Biochem 2: 003.
• Page 2 of 6 •
at 30ºC for 24 hours at 125rpm. After 24 hours of incubation, the growth of Pseudomonas putida was measured at 600nm. Effect of temperature Temperature helps in understanding the ability of bacteria survival at high and low temperature in the present study, 50ml of Nutrient Broth has been taken in 6 conical flasks and all were supplemented with 20mg/L of fluoride concentration. The Nutrient Broth was adjusted to optimal pH. The culture flasks were then inoculated with loopfull of bacteria. .These were incubated at different temperatures for 24 hours at 125rpm.After 24 hours of incubation, the growth of Pseudomonas putida was measured at 600nm [8]. Figure 1: Pseudomonas putida.
Preparation of Synthetic Solution 1. A synthetic solution was prepared of 20 mg/L fluoride concentration was prepared. 2. Initial pH of the solution was maintained at 7.1±0.1 by using 0.1 N NaOH and 0.1 N HCL. 3. This solution was steam sterilized to 121±0.5°C for 20 min [7].
Acclimatization Pseudomonas putida was first grown in Nutrient Broth media in a 250ml conical flask. After 24 hours the Nutrient Broth turns viscous indicating significant bacterial growth in the flask.5mg/L of fluoride concentration was added to the above conical flask. Thereafter, the fluorine was periodically added increments in a series of 250ml flasks until the fluoride concentration in the growth media reached 200g/L.
Effect of contact time In the present study, 50ml of Nutrient Broth has been taken in 10 conical flasks and all were supplemented with 20mg/L of fluoride concentration. The Nutrient Broth was adjusted to optimal pH of 7. The culture flasks were then inoculated with loopfull of bacteria. .These were incubated at optimal temperature of 37ºC for different contact time at 125rpm. The growth of Pseudomonas putida was measured at 600nm [9,10]. Effect of initial concentration In the present study, 50ml of Nutrient Broth has been taken in 5 conical flasks and all were supplemented with different concentrations of fluoride. The Nutrient Broth was adjusted to optimal pH. The culture flasks were then inoculated with loopfull of bacteria. These were incubated at optimal temperature for 24 hours at 125rpm. The growth of Pseudomonas putida was measured at 600nm.
Results and Discussion
Growth Study
Growth Study of Bacteria
The growth pattern of Pseudomonas putida in Nutrient Broth [Table 1] has been studied in the absence of fluoride.
The growth pattern of the bacterial strain in the nutrient broth media has been studied at 600 nm in absence of fluoride. From (Figure 2) it is evident that the initial lagperiod is observed up to 2 h of incubation, and a stationary phaseis exhibited after around 18 h of incubation. The highest growth rate is obtained at around 18 h of the incubation time. The bacteria consume only organic carbon present in the nutrient broth media. After thelog phase of their growth, the organic carbon is exhausted, as aresult, the number of cells in the media decreases. The lag phase is supposed to be due to the physiological adaptation of the microbial cell to the culture conditions. This may involve a time requirement for induction of specific messenger RNA (mRNA) and protein synthesis to meet new culture requirements. The bacterial culture reaches a stationary phase primarily because of exhaustion of the carbon and energy source. When a carbon source is used up, it does not necessarily mean that all growth stops. This is because dying cells can lyse and provide a source of nutrients. Growth based on dead cells is called an endogenous metabolism, which occurs throughout the growth cycle, but can be best observed during the stationary phase. Another cause of the stationary phase that may be observed is that waste products build up to a point where they are toxic to cells and begin to inhibit cell growth. In the present case, all the mentioned reason may be applicable [11,12].
Growth Media Medium Components
Composition Mg/L
Distilled water
500ml
Beef extract
0.5g
Yeast extract
1.0g
Peptone
2.5g
Sodium chloride
2.5g
Table 1: Composition of nutrient broth media.
Standardization of physical parameters Effect of pH pH considered to be one of the crucial parameters which decide the survival and degradative activity. In the present study, 50ml of Nutrient Broth has been taken in 8 conical flask and all were supplemented with 20mg/L of fluoride concentration. The Nutrient Broth was adjusted to different pH using NaOH and HCl. The culture flasks were then inoculated with loopful of bacteria. These were incubated J Biotech Res Biochem ISSN: HBRB, Open Access Journal
Volume 1 • Issue 1 • 100003
Citation: Chandana Lakshmi MVV, Poornima D, Karishma NS, Vardhan Y, Jyothi PS (2019) Removal of Fluoride Using Pseudomonas Putida. J Biotech Res Biochem 2: 003.
• Page 3 of 6 •
Effect of temperature
Figure 2: Growth study of bacteria Pseudomonas putida in nutrient broth media.
Standardization of physical parameters Experiments have been conducted in an incubator/shaker to selectthe pH, temperature, contact time and initial fluoride concentration for the optimum removal of fluoride from synthetic wastewater.
Effect of pH (Figure 3) indicates that the percentage removal of fluoride increases with increases in pH up to 7, after which it starts decreasing. The bacteria’s growth is highly sensitive to pH. Therefore, the percentage removal of fluoride is maximum at pH 7. With further increases in pH, the growth of the bacterial cells reduces, which reduces the percentage of fluoride removed [13,14]. pH
% removal of fluoride
2
91.7
3
91.7
4
91.7
5
91.75
6
91.8
7
92
8
91.2
9
91
(Figure 4) represents the influence of temperature on fluoride removal. As per literature review, 37 C is considered to be the optimum temperature for bacterial growth. There was a notable change in the amount of fluoride removed with varying temperature, wherein, the highest removal percentage of 61% was observed when the temperature was 37 C. However least removal was observed at 15 and 42 C temperature respectively which can be due to the lower survival capability of the bacterium at minimum and maximum temperature. When the temperature was further increased to 42 C, the removal decreased from 61% to 42%. Further increase in temperature might have also led to disorientation in the bacterial structure and also associated changes in the ion-binding sites. The optimum growth temperature of Pseudomonas putida is reported to be 37 C [15]. Temperature (℃)
% Removal (%)
15
38
25
42
28
58
37
61
42
40
7
92
8
91.2
9
91
The effect of Temperature on the percentage removal of fluoride species by bioaccumulation is shown in figure 4
The effect of pH on the percentage removal of fluoride species by bioaccumulation is shown in figure 3.
Figure 4: Effect of temperature on fluoride removal in bulk phase by Pseudomonas putida.
Effect of contact time The effect of contact time on the percentage removal of fluoridespecies by bioaccumulation is shown in (Figure 5).
Figure 3: Effect of pH on fluoride removal byPseudomonas putida.
J Biotech Res Biochem ISSN: HBRB, Open Access Journal
From (Figure5), it is evident that the percentage removal of fluorideincreases with contact time. Around 50.8% fluoride removal is obtainedin a short contact time, i.e., only 3 h and the maximum percentage removal of fluoride achieved by Pseudomonas putidais 92.8% at 25 hours contact time. After around 36 h ofcontact time, further increases in percentage removal of fluoride arenegligible.[16] From these observations, it seems that equilibrium is reached with a Volume 1 • Issue 1 • 100003
Citation: Chandana Lakshmi MVV, Poornima D, Karishma NS, Vardhan Y, Jyothi PS (2019) Removal of Fluoride Using Pseudomonas Putida. J Biotech Res Biochem 2: 003.
• Page 4 of 6 •
contact time of around 25 hours. Fluoride’s toxicity doesnot impose a great effect on culture because a fluoride-acclimatizedculture was used in the present study. After overcoming the inhabitationperiod, the bacteria starts rapid accumulation of fluoride at the initial stage of contact time (∼3 h). Due to the increase in contacttime, the percentage removal is increased up to the equilibriumconditions. After this time period, no further fluoride removal is found due to the arrival of the stationary phase.[17] Time in hours
% removal of fluoride
5
50
10
61
15
72
20
78
25
92.7
30
90
35
88
40
87.5
45
87
50
85
The effect of Contact Time on the percentage removal of fluoride species by bioaccumulation is shown in figure 5.
Figure 6: Effect of initial fluoride concentration on fluoride removal by Pseudomonas putida.
(Figure 6), it can be seen that around 93.4%fluoride removal is achieved for the initial concentration, and aslower as 1 mg/L fluoride and 91.7% fluoride removal is achieved for an initial concentration as high as 20 mg/L after 25 hours of agitation.[18,19].The microbial growth is highly dependent on the initial fluoride concentration. Decrease in the fluoride accumulation rate with increases in initial fluoride concentration in the medium may be due to the toxicity of fluoride to Pseudomonas putida at higher fluoride concentrations. The removal efficiency is found as 93.7, 92.2, 91.9, and 91.7% for fluoride concentrations of 5, 10, 15, and 20 mg/L, respectively [20].
Conclusion Optimum conditions for the removal of fluoride from the synthetic water solution observed were pH of 7, temperature at 37ºC, contact period of 25 hours and initial concentration of 5 mg/L. Pseudomonas putida has a good potential for fluoride removal of up to 5 mg/L.
Refrences
Figure 5: Effect of contact time on fluoride removal in the bulk phase by Pseudomonas putida.
1.
Amina C, Lhadi LK, Younsi A, Murdy J (2004) Environmental impact of an urban landfill on a coastal aquifer. J. Afr Earth Sci 39: 509-516.
2.
Anwar F (2003) Assessment and analysis of industrial liquid waste and sludge disposal at unlined landfill sites in arid climate. Waste Manage 23: 817-824.
3.
Christopher HS, Abu Bohran M, Badruzzaman, NicoleKeon B,Winston Yu, et al.(2005) Groundwater arsenic contamination on the Ganges Delta: Biogeochemistry, hydrology, human perturbations and human suffering on a large scale. Comptes Rendus Geosci 337: 285-296.
4.
Amin F, Talpur FN, Balouch A, Surhio MA, Bhutto MA (2015) Biosorption of fluoride from aq fungus Pleurotus eryngii ATCC 90888. Environ. Nanotechnol Monit Manage 3: 30-37.
5.
Chubar N, Behrends T, Behrends PV (2008) Biosorption of metals (Cu2+, Zn2+) and anions (F−H2PO4−) by viable and autoclaved cells of the gram-negative bacterium Shewanella putrefaciens. J. Colloid Interface Sci 65: 126-133.
6.
Kariminiaae-Hamedaani HR, Kanda K, Kato F (2003) Waste water treatment with bacteria immobilized on to a ceramic carrier in an aerated system. J. Biosci Bioeng 95: 128-132.
7.
Kass A, Yechieli GY, Gavrieli I, Vengosh A, Starinsky A (2005) The impact of freshwater and wastewater irrigation on the chemistry of shallow groundwater: A case study from the Israeli Coastal aquifer. J. Hydrol 300: 314-331.
Effect of initial concentration (Figure 6) shows the effects of initial fluoride concentration on the removal of fluoride.
Intial fluoride conc (mg/L)
% removal of fluoride
2
95.5
5
93.52
10
92.20
15
91.59
20
91.55
The effect of Initial Concentration on the percentage removal of fluoride species by bioaccumulation is shown in figure 6.
J Biotech Res Biochem ISSN: HBRB, Open Access Journal
Volume 1 • Issue 1 • 100003
Citation: Chandana Lakshmi MVV, Poornima D, Karishma NS, Vardhan Y, Jyothi PS (2019) Removal of Fluoride Using Pseudomonas Putida. J Biotech Res Biochem 2: 003.
• Page 5 of 6 •
8.
Koshle S, Mahesh S, Swami NS (2016) Isolation and identification of Trichoderma harzianum from ground water: An effective biosorbent for defluoridation of ground water. J. Environ. Biol 37: 135-140.
15. Mondal P, Majumder CB, Mohanty B (2008) Treatment ofarsenic contaminated water in a batch reactor by using Ralstonia eutrophaMTCC 2487 and granular activated carbon. J. Hazard. Mater 153: 588-599.
9.
Lengeler JW, Drews G, Schlegel S (1999) Biology of the prokaryotes, Blackwell Science, New York.
16. Muhammad IT, Afzal S, Hussain I (2004) Pesticides in shallowgroundwater of Bahawalnagar, Muzafargarh, D.G. Khan and RajanPur districts of Punjab, Pakistan. Environ. Int 30: 471-479.
10. Liu A, Ming J, Ankumah RO (2005) Nitrate contamination in private wells in rural Alabama, United States. Sci. Total Environ 346: 112-120. 11. Mallick N (2002) Biotechnological potential of immobilized algae for wastewater N, P and metal removal: A review. Bio Metals 15: 377-390.
17. Mulligan CN, Yong RN, Gibbs BF (2001) Remediation technologies for metal contaminated soils and groundwater: An evaluation. Eng. Geol 60: 193-207.
12. Meenakshi A, Maheshwari RC (2006) Fluoride in drinking water and its removal. J. Hazard. Mater 37: 456-463.
18. Oren O, Yechieli Y, Bohlke JK, Dody A (2004) Contaminationof groundwater under cultivated fields in an arid environment, Central Arava Valley. Isr. J. Hydrol 290: 312-328.
13. Mohan SV, Ramanaiah SV, Rajkumar B, Sarma PN (2007) Biosorption of fluoride from aqueous phase onto algal Spirogyra IO1 and evaluation of adsorption kinetics. Biol. Res. Technol 3: 1006-1011.
19. Ramanaiah SV, Venkata Mohanand S, Sarma PN (2007) Adorptive removal of fluoride from aqueous phase using waste fungus(Pleurotus ostreatus 1804) biosorbent: Kinetics evaluation. Ecol. Eng 31: 47-56.
14. Mondal NK, Kundu M, Das K, Bhaumik R, Dattaa JK (2013) Biosorption of fluoride from aqueous phase onto Aspergillus and itscalcium-impregnated biomass and evaluation of adsorption kinetics. Res. Rep. Fluoride 46: 239-245.
20. Shen F, Chen X, Gao P, Chen G. (2003) Electrochemical removalof fluoride ions from industrial wastewater. Chem. Eng. Sci 58: 987-993.
J Biotech Res Biochem ISSN: HBRB, Open Access Journal
Volume 1 • Issue 1 • 100003
Journal of Anesthesia & Clinical Care
Journal of Genetics & Genomic Sciences
Journal of Addiction & Addictive Disorders
Journal of Hematology, Blood Transfusion & Disorders
Advances in Microbiology Research
Journal of Human Endocrinology
Advances in Industrial Biotechnology
Journal of Hospice & Palliative Medical Care
Journal of Agronomy & Agricultural Science
Journal of Internal Medicine & Primary Healthcare
Journal of AIDS Clinical Research & STDs
Journal of Infectious & Non Infectious Diseases
Journal of Alcoholism, Drug Abuse & Substance Dependence
Journal of Light & Laser: Current Trends
Journal of Allergy Disorders & Therapy
Journal of Modern Chemical Sciences
Journal of Alternative, Complementary & Integrative Medicine
Journal of Medicine: Study & Research
Journal of Alzheimer’s & Neurodegenerative Diseases Journal of Angiology & Vascular Surgery Journal of Animal Research & Veterinary Science Archives of Zoological Studies
Journal of Nanotechnology: Nanomedicine & Nanobiotechnology Journal of Neonatology & Clinical Pediatrics Journal of Nephrology & Renal Therapy Journal of Non Invasive Vascular Investigation Journal of Nuclear Medicine, Radiology & Radiation Therapy
Archives of Urology Journal of Atmospheric & Earth-Sciences Journal of Aquaculture & Fisheries Journal of Biotech Research & Biochemistry Journal of Brain & Neuroscience Research Journal of Cancer Biology & Treatment Journal of Cardiology: Study & Research Journal of Cell Biology & Cell Metabolism Journal of Clinical Dermatology & Therapy Journal of Clinical Immunology & Immunotherapy Journal of Clinical Studies & Medical Case Reports
Journal of Obesity & Weight Loss Journal of Orthopedic Research & Physiotherapy Journal of Otolaryngology, Head & Neck Surgery Journal of Protein Research & Bioinformatics Journal of Pathology Clinical & Medical Research Journal of Pharmacology, Pharmaceutics & Pharmacovigilance Journal of Physical Medicine, Rehabilitation & Disabilities Journal of Plant Science: Current Research Journal of Psychiatry, Depression & Anxiety Journal of Pulmonary Medicine & Respiratory Research Journal of Practical & Professional Nursing
Journal of Community Medicine & Public Health Care
Journal of Reproductive Medicine, Gynaecology & Obstetrics
Current Trends: Medical & Biological Engineering
Journal of Stem Cells Research, Development & Therapy
Journal of Cytology & Tissue Biology
Journal of Surgery: Current Trends & Innovations
Journal of Dentistry: Oral Health & Cosmesis
Journal of Toxicology: Current Research
Journal of Diabetes & Metabolic Disorders
Journal of Translational Science and Research
Journal of Dairy Research & Technology
Trends in Anatomy & Physiology
Journal of Emergency Medicine Trauma & Surgical Care
Journal of Vaccines Research & Vaccination
Journal of Environmental Science: Current Research
Journal of Virology & Antivirals
Journal of Food Science & Nutrition
Archives of Surgery and Surgical Education
Journal of Forensic, Legal & Investigative Sciences
Sports Medicine and Injury Care Journal
Journal of Gastroenterology & Hepatology Research
International Journal of Case Reports and Therapeutic Studies
Journal of Gerontology & Geriatric Medicine
Journal of Ecology Research and Conservation Biology
Submit Your Manuscript: http://www.heraldopenaccess.us/Online-Submission.php Herald Scholarly Open Access, 2561 Cornelia Rd, #205, Herndon, VA 20171, USA. Tel: +1 202-499-9679; E-mail: info@heraldsopenaccess.us http://www.heraldopenaccess.us/