16 minute read
The Season of Gratitude
from AE
by Design2Pro
Cheddar-Crusted Apple Pie
New Englanders have known the pleasures of combining apple pie and Cheddar cheese for a very long time — long enough to be quite opinionated about how the two should be eaten together. Some cooks include grated Cheddar in the filling itself. Others grate the cheese over the top of the pie, which is fine when the pie is warm but less so when it is cool and the cheese hardens. Old-timers lay a slab of Cheddar right on top of their pie slice and dig in. I wanted to integrate the cheese into the pie itself, so I baked grated cheese into the crust, which keeps the snappy Cheddar flavor front and center. This is one good pie.
Advertisement
Makes 8 servings
Cheddar Cheese Pie Dough (page 70)
Filling
• 8 cups peeled, cored, and sliced Granny
Smith or other apples • ½ cup sugar • 2 tablespoons lemon juice • ¾ cup chopped walnut halves, preferably toasted (page 453) • 2 ½–3 tablespoons all-purpose flour • 1 egg beaten with 1 tablespoon milk, for glaze
1. Prepare and refrigerate the pie dough. Roll the larger dough portion into a 12 ½- to 13-inch circle and line a 9- to 9 ½-inch deep-dish pie pan with it, letting the overhang drape over the edge. Refrigerate the shell until needed. 2. Combine the apples, sugar, lemon juice, and walnuts in a large bowl. Mix well. Let stand for 5 to 10 minutes. 3. Adjust the oven racks so one is in the lower position and another is in the middle of the oven. Preheat the oven to 400°F (200°C). Line a baking sheet with parchment paper. 4. Sprinkle the flour over the apples, using the larger amount of flour if the apples seem very juicy. Mix well. 5. Roll the other dough portion into an 11-inch circle. Turn the filling into the pie shell and smooth it over to level out the fruit. Lightly moisten the rim of the pie shell. Drape the top pastry over the filling, pressing along the edge to seal. Trim the overhang with scissors, leaving an even ½ to 3/4 inch all around, then sculpt the edge into an upstanding ridge. Flute or crimp the edge, as desired. Poke several steam vents in the top of the pie with a large fork or paring knife. Put a couple of the vents near the edge so you can check the juices. Brush the pie lightly with the egg wash glaze. 6. Put the pie on the prepared baking sheet and bake on the lower oven rack for 30 minutes. Reduce the oven temperature to 375°F (190°C) and move the pie up to the middle rack, rotating the pie 180 degrees. Bake for 30 to 40 minutes longer, until the pie is a rich, golden brown and juices bubble thickly up through the vents. 7. Transfer the pie to a rack and cool for about 1 hour before serving. Longer is fine, but you’ll bring out the flavor of the cheese if you serve this pie warmer than most.
Cheddar Cheese Pie Dough
Every true New Englander knows that nothing goes better with apples than sharp Cheddar cheese. My favorite way of combining these two is by baking the cheese right in the crust. The baked-in Cheddar flavor is out of this world, and it’s one of the prettiest crusts you’ll find, all golden and covered with crispy cheese freckles. It makes a great crust for savory pies, too, like quiches and pot pies.
One 9- to 9 1/2-inch standard or deep-dish double-crust piecrust or two pie shells
• 2 ½ cups all-purpose flour • ⅓ cup fine yellow cornmeal • 2 teaspoons cornstarch • ¾ teaspoon salt • 1 cup (2 sticks) cold unsalted butter, cut into ½-inch cubes • 1 ¼ cups cold grated sharp Cheddar cheese (white or yellow)* • ½ cup plus 2 tablespoons cold water
*Alternative:
Sharp and flavorful cheeses like Gouda or Gruyére work best.
1. Combine the flour, cornmeal, cornstarch, and salt in a large bowl. Scatter the butter around on a large flour-dusted plate. Measure the water into a 1-cup glass measuring cup. Refrigerate everything for 10 to 15 minutes. 2. Transfer the dry ingredients to a food processor. Pulse several times to mix. Scatter the butter over the dry mixture. Pulse the machine seven or eight times, until the pieces of butter are roughly the size of small peas. Remove the lid and scatter the cheese over the mixture. Replace the lid. Pulse three or four times, just long enough to mix in the cheese thoroughly. 3. Pour the water through the feed tube in a 8- to 10-second stream, pulsing the machine as you add it. Stop pulsing when the mixture begins to form large clumps. 4. Turn the dough out onto your work surface and divide it in two, making one part — for the bottom crust — slightly larger than the other. Pack the dough into balls, place on separate sheets of plastic wrap, and flatten into 3/4-inchthick disks. Wrap the disks and refrigerate for about 1 hour before rolling.
To Make this Dough by Hand
Combine the chilled dry ingredients in a large bowl. Add the butter and cut it in thoroughly. Mix in the cheese by hand. Mound the ingredients in the center of the bowl. Drizzle half of the water down the sides of the bowl, rotating the bowl as you pour. Mix well with a fork. Sprinkle half of the remaining water over the mixture; mix again. Pour most of the remaining water over the mixture; mix vigorously until the dough gathers in large clumps. If there are dry, floury areas remaining, stir in the last spoonfuls of water. Turn the dough out onto your work surface and proceed as in step 4.
North Carolina Sweet Potato Pie
My adoptive North Carolina ranks first in the nation in the production of sweet potatoes: more than 60,000 acres of them, about half of the total US production. In light of that, I came up with this recipe as a tribute to the farmers and their lovely sweet potatoes. Sweet potatoes have a wonderfully dense flesh and deep color that are in their full glory in this tasty pie.
Makes 8–10 servings
Old-Fashioned Shortening Pie Dough (page 62) or another single-crust dough
Filling
• 3 medium-large sweet potatoes • 3 large eggs plus 1 large egg yolk, at room temperature • ⅔ cup packed light brown sugar • ⅓ cup granulated sugar • 4 tablespoons unsalted butter, melted • ½ cup heavy cream • ½ cup half-and-half • ¾ teaspoon vanilla extract • 1 tablespoon all-purpose flour • ½ teaspoon ground cinnamon • ½ teaspoon ground nutmeg • ¼ teaspoon ground cloves • ½ teaspoon salt • Whipped Cream (page 447) (optional)
1. Prepare and refrigerate the pie dough. Roll the dough into a 12 ½- to 13-inch circle and line a 9- to 9 ½-inch deep-dish pie pan with it, shaping the edge into an upstanding ridge. Flute or crimp the edge, chill the shell, and partially prebake it according to the instructions on page 000. 2. Preheat the oven to 400°F (200°C). Scrub the potatoes and place them on a baking sheet. Pierce them several times with a paring knife. Bake for 60 to 75 minutes, until they feel tender all the way through when pierced with a paring knife. Cut the potatoes open to help them cool faster. 3. When the potatoes have cooled, scoop the flesh into a food processor. Process to a smooth purée. Measure out 1 ½ cups purée. (Save any extra purée for another use.) 4. Preheat the oven to 375°F (190°C). Whisk the eggs and egg yolk in a large bowl until frothy. Add the potato purée, sugars, melted butter, heavy cream, half-and-half, and vanilla. Using a handheld electric mixer, beat on medium-low speed until evenly blended. Mix the flour, cinnamon, nutmeg, cloves, and salt in a small bowl. Sprinkle over the liquid and blend it in on low speed. 5. Put the pie shell on a baking sheet, near the oven, and carefully pour the filling into the shell. Bake the pie, on the sheet, on the middle oven rack for 20 minutes. Reduce the heat to 350°F (180°C) and rotate the pie 180 degrees. Bake for 30 to 40 minutes longer, until the filling is set. When the pie is done, the filling will be wobbly and puff slightly around the edges. 6. Transfer the pie to a rack. Serve slightly warm, at room temperature, or chilled, garnished with whipped cream, if desired.
Boil or Bake?
In my sweet potato pie trials, I both boiled and baked the potatoes and found that I preferred the baked results. Baking takes longer, but it concentrates the flavor without adding excess moisture to the pie.
You get a creamier, fuller-bodied pie when the moisture comes from the cream and eggs. If you like, you can accelerate the pie-making process by baking the sweet potatoes the day before, perhaps when you have something else in the oven. Refrigerate them after they have cooled.
And by the way, since you’re baking sweet potatoes anyway, why not bake a couple of extras and use them to thicken soups or stews, or in muffins and quick breads. Or serve them as a simple side dish, mixed with butter and a drizzle of maple syrup.
Excerpted from “Pie Academy” by Ken Haedrich, photography by Emulsion Studio, used with permission from Storey Publishing.
Old-Fashioned Shortening Pie Dough
This is a pretty standard all-shortening piecrust, like the one my dad used when I was a youngster. A shortening piecrust won’t have the delicate flavor of a butter crust, and the texture is typically more crumbly, less flaky. Still, this yields a delicious, tender crust that many bakers believe makes the best pies.
One 9- to 9 1/2-inch standard or deep-dish pie shell
• 1 ½ cups all-purpose flour • 1 tablespoon confectioners’ sugar (optional for a sweet pie; omit for a savory pie) • ½ teaspoon salt • ½ cup cold vegetable shortening • ¼–⅓ cup cold water
1. Combine the flour, sugar (if using), and salt in a large bowl; refrigerate for 15 minutes. 2. Add the shortening to the dry ingredients and toss it with your hands to coat, then break it up into smaller pieces. Using a pastry blender, cut the shortening into the dry ingredients until the pieces of fat are roughly the size of small peas and everything looks like it has been touched by the fat. There should be no dry, floury areas. 3. Mound the ingredients in the center of the bowl. Drizzle about half of the water down the sides of the bowl, turning the bowl as you pour so the water doesn’t end up in one spot. Using a large fork, lightly mix the dough, tossing it from the perimeter toward the center of the bowl. Drizzle most of the remaining water here and there over the dough and toss again. 4. Mix the dough vigorously now. The dough should start to gather in large clumps, but if it is dry in places, stir in the rest of the water. 5. Turn the dough out onto a lightly floured work surface and pack it into a ball, then knead it several times to smooth it out. Put the dough on a sheet of plastic wrap and flatten it into a 3/4-inch-thick disk. Wrap the disk and refrigerate for about 1 hour before rolling.
Double-Crust Version
The softness of the shortening makes this an easy recipe to double. Simply double all of the ingredients and proceed as above. Divide the dough in two when it comes out of the bowl, making one part slightly larger than the other if you’re using it for a top and bottom crust. •
Back to Our Roots
At Athol Orchards, a graphic designer turned apple farmer rediscovered her love of nature and America’s agricultural heritage
The fundamentals of life at Athol Orchards are simple: a tight-knit family, a love for all things apple, and a deep appreciation for mountain air and American soil.
Located in the northern reaches of Idaho, Athol
Orchards is owned and operated by the Conley family: Erreck, Nikki, daughters Mackenzie (13) and Madelyn (10), and Nikki’s mother Carole. While it is most known to the public for its historical apple varieties, delectable apple cider syrup, and Idaho-harvested maple syrup, the Conley family looks at the orchard as a token of the American Dream: strong family foundations, plenty of hard work (oftentimes backbreaking, as Nikki said), and the traditional, family-owned farm life.
In the beginning, many told Nikki and Erreck they’d bitten off more than they could chew. But since moving to Idaho from the West
Coast in January of 2016, the family has been chipping away at their vision, little by little; just six years ago, Nikki was a professional graphic designer working in a Northern California metropolis, parked in front of a computer day in and day out, while memories of the quiet
Californian mountain town where she spent her childhood bloomed in her mind.
“When I was 3 years old, my family wanted to seek a quieter life for me and my siblings, so we moved to the eastern foothills of central California in a little town called Springfield. It was the ideal small town,” said Nikki. “The Sequoia National Forest was pretty much our backyard, and we had a lot of these multi-generational, commercial apple orchards that were being grown in high-elevation mountains there.”
Crisp apples and fresh mountain air are braided into Nikki’s childhood, so much so that she often asked her father if they could become apple farmers. The glow of a computer screen became a headache as the mother of two pictured the quality of life she wanted for her daughters.
Building an Orchard From Scratch
Nikki and Erreck didn’t have a lick of agricultural experience of their own—Nikki herself had cycled through graphic design, teaching, and the medical field, trying to find her lifelong career—but while the orchard dream was still far removed from reality, it remained within arms’ reach.
“We wanted to seek a quiet life for our kids. A slower life, away from the big population densities in California where we were. I don’t know if this happens to all parents, but our minds really started changing in the ways we thought about the world, after watching how things have changed and the world got so fast, unpredictable, scary.”
Northern Idaho checked all of Nikki’s boxes for climate, environment, safety. She, her high school sweetheart, and their kids headed east. And with the town of Athol nearly rhyming with the word
Nikki Conley chose a small town in Idaho to start her orchard, after years of toiling in front of a computer as a graphic designer.
Nikki with her husband, Erreck, and two daughters, Mackenzie and Madelyn.
apple, it just felt a universal sign to Nikki that it was time to make her childhood dream come true.
Crucial to this was her husband’s willingness to change his own career path, move states, and walk alongside his wife in her new endeavor; while apples alone may not have been a convincing-enough argument, Nikki finding her true calling surely would. Erreck is a 23-year Air Force veteran who remained in government work until joining Nikki in the full-time orchard venture. Carole lives on the orchard and assists in the operation as well, helping with gardening, watering, and tending the berry patches.
The apples and their byproducts are just a delicious bonus. “I’m the dreamer and Erreck is very much the doer. Everything we’ve done, we’ve done together right alongside our girls,” Nikki said.
What to most people is just a household kitchen staple is to Nikki a fruit with a rich, intricate history, which has fascinated her for years. There are multi-volume book series, historians, and national conventions dedicated to the apple, and the varieties grown at Athol are unlike those found on grocery store shelves. Some varieties were lost and found again when abandoned American homesteads, dating back to the 18th century, were rediscovered and explored—the ancient apple trees found on those homesteads were “gifts from our ancestors,” Nikki said.
“I learned about all of these lost, old, historical varieties that really tied in with my love of American history. All the pieces started to fall into place for me.” Nikki now delights in sharing her knowledge through her orchard, which she said also functions as a living history farm.
Back to Nature
Preserving history and providing agricultural education are important, Nikki explained. Agricultural exposure in public school is minimal, and, with
—NIKKI CONLEY the threshold to enter the commercial farming industry so high, she wants impressionable young children to learn the vital role that agriculture—not just commercial farming—can play for a person, a community, and America as a whole. “We want to change the way kids see agriculture, whether it be becoming beekeepers, having their own orchard, or raising Nigerian goats for cheese and raw milk. Public education doesn’t have the time to touch on agriculture anymore, and that’s why we need to hold on to the family farms in our country,” she said.
Nikki does not aspire to run a commercial apple farm. She sees herself as a curator of apples, and her farm a preservation orchard, with its 1.5 acres and 120 trees, holding space in the present for apple varieties that held so much significance in the past. She has plans to plant more trees on an additional 16 acres next spring.
Athol Orchards is perhaps most known for its signature apple cider syrup. A lover of natural and holistic ingredients harvested straight from the earth, Nikki didn’t like the thought of her family using artificial syrups, so she set out to create a syrup product from her apples. She did not expect that she would soon be selling out of the product at farmers markets—where customers gushed that the syrup was happiness in a bottle or like Christmas for the tastebuds—and shipping to all 50 states and internationally.
Nikki took a similar approach with maple syrup, the supermarket varieties of which can be loaded with additives, after a visit to New England where maple farms thrive. “The whole idea and tradition of maple syrup stuck in my heart just as fast as the apples did,” she said.
A Rewarding Dream
So, what is it like living in the shadow of the Rockies, where your nearest neighbors are apple trees? It is an “amazing silence,” Nikki said, free of the traffic, construction, and general cacophony that steals the quiet away from urban places. The morning of her American Essence interview, she rose early to find wild turkeys foraging the orchard for fallen apples while her Nigerian dwarf goats brayed to hail the morning; in the mountains, the nighttime often leaves a milky fog behind that casts the forest surrounding the orchard into haziness. Elk may emerge to try to sneak a few apples off the trees, and while the Conley family has not yet experienced any firsthand, moose, wolves, and cougars loom in this very much still wild and untamed land.
Metro California, choked and uncomfortable like a person pulling at a turtleneck, seemed a distant memory.
