Stone Lined
AQUA BOOSTER
V
aughn’s Aqua Booster hot water storage tank combines HydrastoneŽ, the most effective method of preventing corrosion, with foam, the most efficient material for preventing heat loss. The Vaughn Aqua Booster provides economical hot water storage. It is designed specifically for use with a tankless hot water system. The Aqua Booster storage system is connected directly through a circulator to the tankless heating coils in the heating boiler. As water is used, or thermostatic controls call for heat, water is circulated through the boiler coils and returned to the storage system. In this process, the system insures consistent water temperature. The Vaughn Aqua Booster hot water storage tank is an easy, economical solution to hot water shortages particularly where tankless coils in existing boilers lack the capacity to meet heavy draw requirements.
e on St ned Li
For three generations, Vaughn has built hot water storage tanks of heavy gauge steel with seamless one-half inch thick Hydrastone lining and bronze fittings at all water openings. Vaughn’s unique manufacturing process has continually combined this old fashioned quality with ongoing advanced technology in providing the longest lasting and most environmentally friendly heater available. Because of our manufacturing process, no anode rod is needed. This unequalled combination of quality, the latest technology, and continuous commitment to the industry has always set Vaughn apart from other tank manufacturers.
Features... Hydrastone Lining A seamless, one-half inch thick lining which has proven to be the most effective method of preventing tank failure due to corrosion.
New Plastic Jacket Rust-free, light weight all plastic outer jacket. Easy to clean and no maintenance.
Bronze Fittings at all water openings eliminates corrosion due to dissimilar metals. No dielectric unions or anode rod required.
Heat Trap Specially designed built-in hot water outlet pipe preventing unnecessary heat loss.
Dense Urethane Foam Insulation completely surrounds the tank to significantly reduce heat loss and increase energy savings (R-16 insulation value). This foam combined with heat-retaining stone allows less than one-third degree/hour heat loss. There is simply none better. Hand Hole Cleanout Option allows for easy inspection and cleaning of bottom of tank.
Wide Selection Models available from 30-120 gal. 10-Year Limited Warranty 30, 40, 65 and 80 gal. models. 5-Year Limited Warranty CD models.
Typical Installation
Internal Boiler Coil To Coil
Hot Water to Fixtures
T & P Relief Valve Immersion Well for Thermostat
Check Valve
From Coil Cold Water
Circulator Temperature Control TPI
115 VAC Wiring Diagram
3/4-inch Tappings
®
Hydrastone Lining
Phase 1
Phase 2
Phase 3 Protected steel surface
A seamless one-half inch thick stone lining impervious to any adverse water conditions, proven to be the most effective method of preventing tank failure due to corrosion. No anode necessary.
Oxygen Hydrastone absorbs water.
No oxygen
Aggressive water with oxygen attacks steel tank.
Inert water with no oxygen is held against steel by Hydrastone preventing further corrosion.
Specifications
A
MODEL CAPACITY GALLONS
HEIGHT OVERALL (inches)
B CASING DIAMETER
C
D
LOOR TO F DRAIN
FLOOR TO CIRCULATOR DISCHARGE
• IMMERSION THERMOSTAT WEIGHT
• INSULATION: 2 to 3 inches of non-CFC urethane foam • All tappings 3/4” except 120 gal. model has 1 1/2” fittings and separate 3/4” drains
S-30C
30
41 1/2
20
7 1/2
13 3/8 165 lbs
S-40C
40
58 3/4
20
7 1/2
13 3/8 218 lbs
S-65C
65
48
26 7 15/16
13 13/16 299 lbs
• Temperature and pressure relief valve required • Vacuum relief valve may be required
S-80C
80
58
26 7 15/16
13 13/16 325 lbs
S-120CD
115
69 1/2
28 8 3/16
16 3/16 410 lbs
• Hand hole clean out option
Standard 10-Year Limited Warranty A repair or replacement (excluding labor and freight) if the tank should leak within 10 years from the date of purchase. Commercial 120 CD model 5 year limited warranty.
A B
C
D
P.O. Box 5431, 26 Old Elm Street, Salisbury, MA 01952 (800) 282-8446 FAX: (978) 462-4683/6497 email:general@vaughncorp.com www.vaughncorp.com
Apr 2007/1000/Journeyman