Service tables
Page 1 of 7
Service tables The following chapter contains the well-known service tables with the service specifications of the Volkswagen brand. Since, in the past, individual service specifications were set up in various markets, mostly through severe operating conditions, these are listed in service tables with specific deviations. Service tables → Chapter Service tables with market-specific deviations → Chapter Note For combined kilometre and time display applies: whichever occurs first. Depending on conditions under which the vehicle is used → Chapter and vehicle equipment, extra service work must be performed in addition to the interval service, inspection service or interval service inspection. It is also possible, to perform additional work outside the service intervals with regard to the entries in the service schedule (or sticker: your next service).
Service tables Service intervals → Anchor. VW engine oil standards → Anchor Filter change intervals → Anchor Toothed belt change intervals → Anchor Spark plug change intervals → Anchor Other time or distance dependent additional work → Anchor Service intervals Caution Only applies to diesel engines:
In some countries the sulphur content in diesel fuel exceeds 2000 ppm. The high sulphur content leads to excessive wear of cylinders and it considerably reduces the cleanliness of pistons. Therefore, in countries with elevated sulphur content in diesel fuel, change engine oil and fuel filter every 7,500 km. Your importer will inform you about countries with elevated sulphur content in diesel fuel. Note
For extremely uneconomical driving style or use under extreme conditions → Chapter, the shortest interval for an oil change service or interval service is “15,000 km or 1 year”. However, other intervals apply for other countries. Your importer will inform you about this. PASSAT 3C
vw-wi://igg/V.en-GB.K00590214.wi::40352910.xml?xsl=3
04.03.2011
Service tables
Page 2 of 7
Service intervals ►2007 From - to
Since introduction
Since introduction ►2007
Engine/Engine code/ PR No./Remarks Diesel, in countries with elevated sulphur content in fuel
Service/intervals
Indicated on service interval display SID (includes oil change)
Oil change service every 7,500 km or 1 year
YES
Oil change service: QG0/QG2/QG3 or every 15,000 km or 1 year QG1 vehicles coded to non-flexible interval Interval service: every 30,000 km or 2 years
YES
Interval service: flexible from 15,000 to max. 30,000 km or max. 2 years
YES
QG1 vehicles
All vehicles
Interval service inspection: every 60,000 km or 4 years
YES
YES
PASSAT 3C, Passat CC ►2009 and CC 2010► Service intervals 2008► From - to
Since introduction
Engine/Engine code/ PR No./Remarks Diesel, in countries with elevated sulphur content in fuel
Service/intervals
Indicated on service interval display SID (includes oil change)
Oil change service every 7,500 km or 1 year
Oil change service QG0/QG2/QG3 or every 15,000 km or 1 year QG1 vehicles coded to non-flexible interval Interval service: every 30,000 km or 2 years 2008►
YES YES YES
Interval service: from 15,000 km or 1 year up to max. 30,000 km or 2 years
YES
QG1 vehicles
Inspection service: after 3 years or max 60,000 km, then every 2 years
NO
All vehicles
Note For combined kilometre and time display applies: whichever occurs first. VW engine oil standards Caution Only engine oils approved by VW may be used, up-to-date information → ServiceNet, Technical information, Inspections and Servicing, Approved oils, or ask your importer. PASSAT 3C, Passat CC ►2009 and CC 2010►
vw-wi://igg/V.en-GB.K00590214.wi::40352910.xml?xsl=3
04.03.2011
Service tables
Page 3 of 7
VW ENGINE OIL STANDARDS With LongLife service (QG1)
Without LongLife service (QG0, QG2)
PETROL ENGINES 4-cylinder engines incl. FSI ►2007
501 01/502 00
4-cylinder engines incl. FSI 2008►
502 00
VR6 FSI ►2007
502 00/505 01
503 01
VR6 FSI 2008►
502 00
504 001
4-cylinder TSI
502 00
507 001
4-cylinder engines with diesel particulate filter
507 001
507 001 alternative
4-cylinder engines without diesel particulate filter
505 01
504 001 alternative
4-cylinder engines incl. FSI
2 503 00
504 001 alternative
VR6 FSI 4-cylinder TSI DIESEL ENGINES 4-cylinder engines with diesel particulate filter 4-cylinder engines without diesel particulate filter
3 506 01
1) Combination product: 504 00/507 00 2) Combination product: 503 00/506 00 3) Combination product: 503 00/506 00/506 01
Note Vehicles with retrofitted diesel particulate filter are allocated in the table to diesel engines without diesel particulate filter. Vehicles with diesel particulate filter (factory-fitted) can be identified by PR No. 7GG or 7MB on the vehicle data sticker. Filter change intervals PASSAT 3C, Passat CC ►2009 and CC 2010► FILTER CHANGE INTERVALS Descriptions of work ENGINE OIL FILTER:1)2)
→ Chapter
Vehicles with LongLife service (QG1)
According to service interval display
All remaining vehicles
Every 15,000 km or 1 year
AIR FILTER:
→ Chapter
All engine types
Every 90,000 km or 6 years
FUEL FILTER:
→ Chapter Diesel conforming to EN 590
Diesel not conforming to EN 590
Diesel with sulphur content ≥2000 ppm
Every 90,000 km
Every 30,000 km
Every 7,500 km
All diesel engines
Draining water is deleted. → Chapter
DUST AND POLLEN FILTER: All engine types
Every 60,000 km or 2 years
vw-wi://igg/V.en-GB.K00590214.wi::40352910.xml?xsl=3
04.03.2011
Service tables
Page 4 of 7
OIL FILTER OF DUAL CLUTCH GEARBOX (DSG): All with gearbox type 02E 1)A
→ Chapter Every 60,000 km
new engine oil filter must be installed at every engine oil change.
2)Only
applies to diesel engines: In some countries the sulphur content in diesel fuel exceeds 2000 ppm. The high sulphur content leads to excessive wear of cylinders and it considerably reduces the cleanliness of pistons. Therefore, in countries with elevated sulphur content in diesel fuel, change engine oil and fuel filter every 7,500 km. Your importer will inform you about countries with elevated sulphur content in diesel fuel. Toothed belt change intervals
If the engine is fitted with toothed belt or timing chain can be found in the engine list. Note
The camshaft drive with timing chain is maintenance-free! PASSAT 3C, Passat CC ►2009 and CC 2010► TOOTHED BELT CHANGE / TENSIONING ROLLER CHANGE INTERVALS Diesel engines Engine type
Engine code
Model year
Toothed belt change interval
Tensioning roller change interval
TDI-PD
BKC, BKP ,BMA, BMP, BLS, BVE BMR, BUZ, BWV, BXE
►2006
Every 120,000 km → Chapter
Every 240,000 km → Chapter
TDI-PD
BKC, BKP ,BMA, BMP, BLS, BVE BMR, BUZ, BWV, BXE
2007►
Every 150,000 km → Chapter
Every 300,000 km → Chapter
2.0 l TDI CR
CBAA, CBAB, CBAC, CBBB, CBDC
Since introduction ►2009
Every 180,000 km → Chapter
360,000 km
All TDI CR
CBAA, CBAB,CBAC, CBBB, CBDC, CAYC
2010►
Every 210,000 km → Chapter
210,000 km
2.0 l
AXX, BLR, BLX, BLY, BPY, BWA BVX, BVY, BVZ
Since introduction
Every 180,000 km → Chapter
---
1.6 l
BSE, BSF
Since introduction
No prescribed change interval, toothed belt drive with test interval, see “other time or distance dependent additional work” → Anchor
Petrol engines
Spark plug change intervals
Spark plug designation and specified torque: Power unit → Rep. Gr.28 → Repairing ignition system → Test data. Note
For technical reasons it is possible that several cross references are not directed to the correct chapter. In this case select the procedure manually in the information.
vw-wi://igg/V.en-GB.K00590214.wi::40352910.xml?xsl=3
04.03.2011
Service tables
Page 5 of 7
PASSAT 3C, Passat CC ►2009 and CC 2010► Spark plug change intervals Engine type
Engine code
2.0l FSI 110 kW, 1.6l SRE and FSI 1.4l TSI engines
BLR, BLX, BLY, BVX, BVY, BVZ BLF, BLP, BSE, BSF CAXA, CDGA
Change intervals
2.0l TFSI V6 FSI 1.8l and 2.0l TSI
AXX, BPY, BWA AXZ, BLV BZB, CAWB, CBFA, CCTA, CCZA, CCTB, CDAA, CDAB, CGYA
Description of work
EVERY 60,000 km Mileage more than 60,000 km in 4 years EVERY 4 years Mileage less than 60,000 km in 4 years → Chapter
EVERY 90,000 km Mileage more than 90,000 km in 6 years EVERY 6 years Mileage less than 90,000 km in 6 years
Other time or distance dependent additional work Time or distance dependent additional work – Reducing agent (AdBlue®): Replenish
Interval
Description of work
At every service
→ Chapter
Every 60,000 km
→ Chapter
Every 60,000 km
→ Chapter
First at 90,000 km, then every 30,000 km
→ Chapter
First at 150,000 km, then every 30,000 km
→ Chapter
First at 180,000 km, then every 30,000 km
→ Chapter
every 12 months
→ Chapter
Every 2 years
→ Chapter
Only if customer requires and as a separate charge
– Haldex coupling: Change oil
Only applies to vehicles up to model year 2009 Applies to vehicles with 4MOTION
– ATF: Change
Applies to 1.8 l TSI with gearbox group 09G in 6-speed automatic gearbox Applies to 2.0 l TSI with gearbox group 09G in 6-speed automatic gearbox Applies to 2.0 l FSI from model year 2009 with gearbox group 09G in 6-speed automatic gearbox in countries with hot climate, China and USA
– Camshaft drive toothed belt: Check
Applies to 4-cylinder petrol engines without prescribed change interval
– Diesel particulate filter: Check
Only applies to vehicles up to model year 2009 Vehicles with factory-fitted diesel particulate filter
– Diesel particulate filter: Check
Only applies to vehicles from model year 2010 Vehicles with factory-fitted diesel particulate filter
– Exhaust emissions test (EET): Perform test
For vehicles with commercial passenger transport, e.g. taxis Only applies to Germany
– Brake and clutch system: Change brake fluid
Only applies to vehicles ►2007
vw-wi://igg/V.en-GB.K00590214.wi::40352910.xml?xsl=3
04.03.2011
Service tables
Page 6 of 7
– Haldex coupling: Change oil
Only applies to vehicles from model year 2010 Applies to vehicles with 4MOTION
– Brake and clutch system: Change brake fluid
Only applies to vehicles 2008►
– Gas system test (GAP): Perform test
Only applies to Passat EcoFuel
WARNING: Must only be carried out by authorized personnel! – Checking condition of natural gas filler neck and sealing cap, clean if necessary and check seal
Only applies to Passat EcoFuel
– Exhaust emissions test (EET): Perform test
Only applies to Germany
– Reducing agent (AdBlue®): Change
Applies to vehicles driving less than 15,000 km in 4 years
Every 3 years
→ Chapter
First after 3 years, then every 2 years
→ Chapter
First after 3 years, then every 2 years
→ Chapter
First after 3 years, then every 2 years
→ Chapter
First after 3 years, then every 2 years
→ Chapter
Every 4 years
→ Chapter
Every 6 years
→ Chapter
Every 20 years
→ Chapter
– Tyre pressure sensors: Change
Only applies to vehicles up to model year 2003 If fitted
– Natural gas tank: Renew
Only applies to Passat EcoFuel
WARNING: Must only be carried out by authorized personnel!
Service tables with market-specific deviations Note This chapter only provides information on market-specific deviations. This means that all maintenance points that are not shown here are to be found in the normal service tables. Russian market from model year 2010 Interval
Description of work
Interval service (QG0/QG2) (appears on service interval display)
Every 15,000 km or 1 year 1)
→ Maintenance tables
Inspection service (does not appears on service interval display)
Every 30,000 km or 2 years 1)
→ Maintenance tables
– Dust and pollen filter (cabin filter): Renew
Every 15,000 km or 1 year 1)
→ Chapter
– Spark plugs: Renew
Every 30,000 km or 2 years 1)
→ Chapter
– Fuel filter: Renew
Every 30,000 km
→ Chapter
vw-wi://igg/V.en-GB.K00590214.wi::40352910.xml?xsl=3
04.03.2011
Service tables
– Air filter element: Check and renew, if necessary, and clean housing
Page 7 of 7
Every 30,000 km or 2 years 1)
→ Chapter
Every 90,000 km
→ Chapter
Interval
Description of work
Every 60,000 km
→ Chapter
– Camshaft drive toothed belt: Renew
1)
Only valid for 2.0 l TFSI Whichever occurs first
North American market
– Sliding sunroof drains: Check flow and clean if necessary
vw-wi://igg/V.en-GB.K00590214.wi::40352910.xml?xsl=3
04.03.2011