Lazydays RV Service Booklet by LDRV

2024 SERVICE SPECIALS 866-495-3055

ROOFTOP & BODY SEALANT— Should be inspected for deterioration.

SLIDE GASKETS—Should be conditioned to maintain their pliability for proper flipping and sealing off of sliderooms.

SLIDE TOPPERS—Should be cleaned to prevent debris from damaging the material that protects your sliderooms from water intrusion.

APPLIANCES—Appliance burn chambers should be inspected and cleaned.

RECOMMENDED EVERY 3-6 MONTHS

866-495-3055 | Lazydays.com/RV-Service

RECOMMENDED EVERY 6-12 MONTHS*

CHASSIS—Generally, the rear chassis grease fittings are not lubricated during an oil change. A complete chassis lube should be performed.

GENERATOR—The fibers in generator air, fuel, and oil filters break down and should be replaced.

BATTERIES—Battery posts and terminals should be cleaned. Fluid levels in wet battery cells should be topped off.

ROOF AC—AC coils should be cleaned to help prevent debris and buildup, which if left, will negatively impact the quality of air and bog down the AC system.

ENGINE AIR DRYER—The air dryer in diesel motorhomes should be inspected to ensure it is still protecting the air system from moisture.

AQUA-HOT® The nozzle and fuel filter should be replaced.

MOTORHOME BRAKES—Annual brake inspection to ensure proper condition of pads, rotors and fluids.

TRAILER BRAKES AND AXLES—Annual brake inspection and wheel bearing repack (if necessary) to ensure proper operation. Our

Certified Technicians Can Help You Maintain Your RV

NOTE: Raycore and Diesel filters additional cost. Coolant Filter and Coolant at additional charge ENGINE

NOTE: Prices reflect up to 3 gallons of coolant for Gas coaches and up to 12 gallons of coolant for Diesel coaches. If extra coolant is required, it is $27.00 per gallon.

FILTER CHANGE SERVICE • Change hydraulic filters (3 Filters) • Change fuel filters • Top off coolant $550 FILTER-03

OIL & FILTER SERVICE

• Replace engine oil

Front end

Gas Up to 8 Qts $350 LOF-01 Diesel Up to 24 Qts $480 LOF-02 Mercedes/ Sprinter Up to 14 Qts Synthetic $400 LOF-04

Visual inspection of

Visual inspection

Drain

Fill

Gas $450 COOLANT-01 Diesel $550 COOLANT-02

• Replace engine oil filter •

Chassis lube

COOLANT SERVICE •

hoses •

clamps •

of heater hoses •

coolant •

with new coolant

Replace generator oil filter

Replace oil

Inspect exhaust Gas $210 LOF-03 Diesel $360 LOF-05

GENERATOR SERVICE**

Replace generator oil filter

Replace oil • Replace air filter

Replace fuel filter

Inspect exhaust Gas $340 GENERATOR-02 Diesel $540 GENERATOR-03

GENERATOR OIL SERVICE** •

•

PREMIUM

•

BATTERY SERVICE

• Clean battery tray

• Test batteries

• Top off fluid

•

• Check brakes for proper operation

• Test for amp draw on each wheel

• Remove tire, drum and hub and inspect hoses for excessive wear

• Check brake wiring

• Adjust brakes to proper settings

• Inspect wheel bearings and repack as necessary

• Check and adjust tire air pressures

SLIDE OUT & JACK MAINTENANCE

• Test slide out for proper operations

• Clean side walls of slides

• Lubricate exterior slide seals

• Lubricate all interior slide components

• Check applicable hydraulic lines

• Ensure proper operation of control board

• Clean all jacks, including footpads

• Lubricate jacks, rams and gears $410

SLIDE-OUTS-02

TRAVEL TRAILER BRAKE & AXLE SERVICE

Single Axle $420 TOWABLE-01 Double Axle $840 TOWABLE-06 Triple Axle $1,270 TOWABLE-07

Visual

lines

Visual inspection of

TRANSMISSION SERVICE •

inspection of transmission

•

transmission fittings

Drain

Gas $550 TRANSMISSION-02 Diesel $610 TRANSMISSION-03

transmission fluid

DRYER

Replace air dryer

$480 FILTER-02

Up to 6 house & chassis batteries Gas $420 BATTERY-02 AIR

SERVICE •

filter

AQUA-HOT® SERVICE

• Inspect Aqua-Hot System

• Replace nozzle

• Replace fuel filter

• Top off boiler fluid

• Check electrode alignment

• Clean burner chamber

• Check fuel lines

• Check fuel pressure

$430 AQUA-HOT-02

NOTE: Restricted access or hard line (fuel feed) add $40.00. Raycore Filter additional cost.

APPLIANCE SERVICE

• Check operation of water heater

• Clean compartment tube assembly (excludes diesel fuel heaters)

• Check operation of refrigerator

• Clean burner tube assembly

• Visually inspect roof AC

• Replace filters, as needed

• Check operation of stove

• Clean burner of debris

• Ensure proper air mixture

• Check operation of furnace

• Clean furnace of dirt and debris

$410 APPLIANCE-02

ROOF AC SERVICE

• Visually inspect AC unit

• Remove AC units and acid wash

• Clean AC coils

• Perform amp draw test

• Clean drains

• Replace AC gaskets and filters

$530 per unit AC-06

NOTE: Limited roof AC vent access could be an additional charge, estimate will be provided

DASH AC/HEAT INSPECTION

• Visually inspect AC unit

• Check fans

• Check for leaks

• Check for cooling

$190 per unit DASH-02

BODY RESEAL

• Clean and scrape all side – body seams

• Clean and scrape all windows (except windshield)

• Apply original equipment self-leveling sealer

• Rain bay unit and test for leaks

Pricing includes materials.

ROOF RESEAL

• Rain bay unit

• Inspect roof seams

$52 per ft. BODY-01

• Inspect roof clearance lights

• Inspect roof vent covers

• Inspect roof antenna

• Inspect ladder

• Remove old sealant from all abovementioned areas

• Reseal entire roof seams and components with factory-specified silicone

• Allow to cure overnight

• Rain bay unit to ensure no leaks are present

Pricing includes materials.

$50 per ft. ROOF-03

Prices do not include taxes, shop supplies or any applicable fees. Requested changes to service may result in additional charges. Some service locations may have limited offerings.

**Synthetic oil at additional cost.

MOTORIZED BRAKE AND AXLE SERVICE**

• Check brakes for proper operation

• Test for amp on each wheel

• Remove tire,drum and hub and inspect shoes

• Check brake wiring

• Adjusts brakes to proper settings

• Inspect wheel bearings and repack as necessary

• Check & adjust tire air pressures

Gas $950 MOTORIZED-01 Diesel $1,400 MOTORIZED-02

Certified RV Technicians: ASK YOUR SERVICE ADVISOR TO BUNDLE THE BEST PACKAGE FOR YOU 866-495-3055

866-495-3055 | Lazydays.com/RV-Service

TOWABLE PACKAGES *

A comprehensive check-up on your RV.

TOWABLE INSPECTION

• Slideouts (seals and operation)

• Furnace(s) LP & Electric

• AC Roof Unit Operation

• Converter Charging Operation

• Inverter Operation

• Microwave

• Stove/Oven

• TV/Radio(s)

• Refer—Gas and Electric

• Battery (water level, charge state, cables)

• Jacks

• Steps

• Shore Power

• Water Pump

• Water Heater

• Water System (faucets, etc.)

• LP System Check

• Awning(s)

• Rooftop

• Exterior Lights

$310* SEASONAL INSP TT

*Prices do not include taxes, shop supplies or any applicable fees. Inspection sheet provided.

SILVER TRAILER BUNDLES *

We’ve bundled a variety of services for a more economical maintenance solution. *Prices do not include taxes, shop supplies or

VISUAL INSPECTION OF:

• Slideouts (seals and operation)

• Outside lights – includes repairing 2 lights

• Roof membrane condition and sealant

• Body and window sealants

• Roof AC coil inspection

• Awnings

• Shackles and springs

• Check charging systems

• Check 110 polarity

• Check tires and adjust tire pressures per unit’s tag requirements

• Inspect breakaway switch and perform amp draw on brakes

LUBRICATE THE FOLLOWING:

• Antenna gears

• Locks & latches

• Entry steps

SERVICE THE FOLLOWING:

• Battery

• Slides and jacks

• Water heater

• Refrigerator

• Furnace

• Clean and lube coupler

• Flush and deodorize holding tanks

$1,020* TOWABLE-03

result in additional

Some service

may have limited offerings. For preventative standard maintenance recommendations refer to your owner’s manual. Inspection sheet provided. **Synthetic oil at additional cost.

any applicable fees. Requested changes to services may

charges.

locations

AXLE SERVICE:

• Slideouts (seals and operation)

• Outside lights – includes repairing 2 lights

• Roof membrane condition and sealant

• Body and window sealants

• Roof AC coil inspection

• Awnings

• Shackles and springs

• Check charging systems

• Check 110 polarity

• Check tires and adjust tire pressures per unit’s tag requirements

• Inspect breakaway switch and perform amp draw on brakes

ROOF RESEAL:

• Scrape off old and loose sealant

• Reseal with new sealant

ROOF RESEAL:

• Remove body sealant & reseal with new sealant

• Service rooftop AC units

• Cleaning coils

• Replacing gaskets

• Replacing filters

PLUS

$1,870* TOWABLE-04 GOLD Includes Silver

$3,370* TOWABLE-02 PLATINUM Includes Gold PLUS

$6,170* TOWABLE-05 TITANIUM Includes Platinum PLUS

• Run Generator and Verify Charging

• Windshield Washer Operation

• Wiper Blades

• Dash AC/Heat

• Inspect Belts

• Check Fluid Levels

• Slideouts (seals and operation)

• Furnace(s) LP & Electric

• AC Roof Unit Operation

• Converter Charging Operation

• Inverter Operation

• Microwave

• Stove/Oven

• TV/Radio(s)

• Refer—Gas and Electric

• Battery (water level, charge state, cables)

• Jacks

• Steps

• Shore Power

• Water Pump

• Water Heater

• Water System (faucets, etc.)

• LP System Check

• Awning(s)

• Rooftop

• Exterior Lights

*Prices do not include taxes, shop supplies or any applicable fees. Inspection sheet provided 866-495-3055 | Lazydays.com/RV-Service

$510* SEASONAL INSP MTR

MOTORIZED PACKAGES * A comprehensive check-up on your RV. MOTORIZED INSPECTION

We’ve bundled a variety of services for a more economical maintenance solution.

VISUAL INSPECTION OF:

• Fan belts

• Radiator and heater hoses

• Air filter (gas only)

• Air filter gauge (diesel only)

• Window seals and sealant

• Polarity and voltage

• Operation of exterior lights

• Directional signals

• Dump valve

• Visual inspection of dates and condition of tires

• Check house and converter charging system

SERVICE THE FOLLOWING:

• Clean and service house and chassis batteries

• Check and top off fluid levels (EXCLUDES DEF TANK)

• Lubricate entry steps

• Replace engine oil and filter** (up to 8 quarts gas; up to 24 quarts diesel)

• Replace generator oil and filter**

• Clean and lubricate slack adjusters (diesel only)

• Adjust tire pressure (NOTE: Tire pressures will be adjusted to the manufacturer’s placard.) GAS $680*

DIESEL

SVC-SPECIAL-03

SVC-SPECIAL-02

$1,370*

SILVER MOTORHOME BUNDLES *

*Prices do not include taxes, shop supplies or any applicable fees. Requested changes to services may result in additional charges. Some service locations may have limited offerings. For preventative standard maintenance recommendations refer to your owner’s manual. Inspection sheet provided. **Synthetic oil at additional cost.

REPLACEMENT OF:

• Generator air filter

• Generator fuel filter

• Engine fuel filter

• Water separator (diesel only)

SERVICE THE FOLLOWING:

• Water heater

• Refrigerator

• Stove

• Furnace

• Clean or replace AC filters

• Aqua-Hot service (diesel only)

• Inspect system

• Replace nozzle

• Replace filter

• Top off fluid

VISUAL INSPECTION OF:

• Test water pump and city water

• Clean and sanitize grey and black tanks

• Fill fresh water

• Replace air filter

• Clean and flush outside radiator coils

• Service slides and jacks

• Replace wiper blades (Note: Parts price will vary by model), clean washer nozzles

• Replace hydraulic filters (diesel only)

• Air tank system

• Air dryer service

• Complete lubrication of chassis

GAS $1,310* SVC-SPECIAL-04 DIESEL $2,240* SVC-SPECIAL-05

GAS $2,290* SVC-SPECIAL-06 DIESEL $4,160* SVC-SPECIAL-07 GOLD Includes Silver PLUS PLATINUM Includes Gold PLUS 866-495-3055 Certified RV Technicians:

VISUAL INSPECTION OF:

• Inspect and service pacbrake

• Charge air cooler inspection and cleaning

• Change transmission fluid and filter (if required by Allison)

• Remove, clean, repack and adjust wheel bearings

• Change axle lubricant (Freightliner axle only)

• Check and clean ground cables

LUBRICATE THE FOLLOWING:

• Throttle pedal pivot pin

• ZF IFS (independent front suspension)

• Camshaft bracket bushing

• Foot brake valve actuator

• Meritor roll pin

• Drag link

• Bosch brake caliper slide pin

CHECK & INSPECT:

• Engine support fasteners

• Alternator, battery and starter

• Transmission hose routing for chaffing and leaks

• Suspension

• Suspension height control valve

• Suspension U-bolt torque

• Oil level of oil-filled hubs

• Axle seals for leaks

• Axle breather

• Brake system valves

• Bendix hydromax brake system (front engine only)

• Air brakes

• Hydraulic disc or air brake lines

• Hydraulic disc brake lining for wear (front engine only)

• Fuel tank mounts and fuel lines

• Exhaust system

• AC components

DIESEL $7,130* SVC-SPECIAL-12 TITANIUM Includes Platinum PLUS Certified RV Technicians: 866-495-3055

DIAMOND

VISUAL INSPECTION OF:

• Fan belts

• Radiator and heater hoses

• Air filter

• Window seals and sealant

• Polarity and voltage

• Operation of exterior lights

• Directional signals

• Dump valve

SERVICE THE FOLLOWING:

• Water heater

• Refrigerator

• Stove

• Furnace

• Lubricate entry steps

• Check and top off fluid levels

• Test water pump and city water

• Clean washer nozzles

• Clean and service house and chassis batteries

• Check house and converter charging system

• Visual inspection of dates and condition of tires

• Adjust tire pressure (Note: Tire pressures will be adjusted to the manufacturer’s placard.)

• Clean or replace AC filters

• Service slides and jacks

• Complete lubrication of chassis

• Aqua-Hot service (diesel only)

• Inspect system

• Replace nozzle

• Replace filter

• Top off fluid

GAS $1,430* SVC-SPECIAL-11 DIESEL $1,600* SVC-SPECIAL-16

866-495-3055 | Lazydays.com/RV-Service

CHASSIS PACKAGES * We’ve bundled a variety of services for a more economical maintenance solution.

CHASSIS PACKAGES *

We’ve bundled a variety of services for a more economical maintenance solution.

SAPPHIRE Class A Diesel

VISUAL INSPECTION OF:

• Fan belts

• Radiator & heater hoses

• Air filter gauge

• Tires dates and condition adjust tire pressures

(NOTE: tire pressures will be adjusted to the specifications on the placard when fully loaded will require the coach to be weighed and adjusted.)

SERVICE THE FOLLOWING:

• Polarity & voltage

• Directional signals

• Air brakes

• Engine–support fasteners

• Alternator, battery & starter

• Suspension

• AC components

• Exhaust system

• Brake system valves

• Air cleaner

• Suspension

• Suspension u bolt torque

• Oil filled hubs oil level check axle seals for leaks

• Axle breather

• Fuel tank mounts and fuel lines

• Clean ground cables

• Air tank system–check for leaks

• Air dryer service

• Park brake

• Air cooler

MAINTENANCE:

• Pac brake (if needed)

• Air dryer (if needed)

• Transmission Service (As required by Allison Transmission)

REPLACE:

• Water separator

• Hydraulic filters

• Engine oil & filter (up to 24 quarts diesel)

• Generator oil & filter

• Wiper blades ($40 per blade), clean washer nozzles

• Generator air filter

• Generator fuel filter

• Engine fuel filter

• Air cleaner

CLEAN:

• Lubricate slack adjusters

• Flush outside radiator coils

• Service house & chassis batteries

• Ground cables

• Air cooler

LUBRICATE:

• Camshaft bracket bushing

• Slack adjuster

• Meritor roller pin

• Complete chassis

• Lubricate throttle pedal pivot pin

• Change axle lubricant (freightliner axle only)

CHARGE:

• Air cooler

• Hose routing

• Chafing and leaks

• Wheel bearings

• Remove, clean, repack & adjust

Certified RV Technicians: 866-495-3055

$3,790* CHROME-01

PACKAGES

We’ve bundled a variety of services for a more economical maintenance solution.

VISUAL INSPECTION OF:

• Fan belts

• Radiator & heater hoses

• Air filter gauge

• Tires dates and condition adjust tire pressures

(NOTE: tire pressures will be adjusted to the specifications on the placard when fully loaded will require the coach to be weighed and adjusted.)

SERVICE THE FOLLOWING:

• Polarity & voltage

• Directional signals

• Air brakes

• Engine–support fasteners

• Alternator, battery & starter

• Suspension

• AC components

• Exhaust system

• Brake system valves

• Air cleaner

• Suspension

• Suspension u bolt torque

• Oil filled hubs oil level check axle seals for leaks

• Axle breather

• Fuel tank mounts and fuel lines

• Clean ground cables

• Air tank system–check for leaks

• Air dryer service

• Park brake

• Air cooler EMERALD

Class A Gas CHASSIS

MAINTENANCE:

• Pac brake (if needed)

• Air dryer (if needed)

• Transmission Service (As required by Allison Transmission)

REPLACE:

• Engine oil & filter (up to 24 quarts diesel)

• Generator oil & filter

• Wiper blades ( $40 per blade), clean washer nozzles

• Generator air filter

• Generator fuel filter

• Engine fuel filter

• Air cleaner

CLEAN:

• Lubricate slack adjusters

• Flush outside radiator coils

• Service house & chassis batteries

• Ground cables

• Air cooler

LUBRICATE:

• Camshaft bracket bushing

• Slack adjuster

• Meritor roller pin

• Complete chassis

• Lubricate throttle pedal pivot pin

• Change axle lubricant (freightliner axle only)

CHARGE:

• Air cooler

• Hose routing

• Chafing and leaks

• Wheel bearings

• Remove, clean, repack & adjust

$3,080* CHROME-02

Certified RV Technicians:

866-495-3055

CHASSIS PACKAGES *

We’ve bundled a variety of services for a more economical maintenance solution.

RUBY Class C

VISUAL INSPECTION OF:

• Fan belts

• Radiator & heater hoses

• Tires dates and condition adjust tire pressures

(NOTE: tire pressures will be adjusted to the specifications on the placard when fully loaded will require the coach to be weighed and adjusted.)

INSPECT:

• Polarity & voltage

• Directional signals

• Engine-support fasteners

• Alternator, battery & starter

• Suspension

• AC components

• Exhaust system

• Brake system valves

• Suspension

• Suspension u bolt torque

• Fuel tank mounts and fuel lines

• Clean ground cables

• Brake system valves

REPLACE:

• Engine oil & filter (up to 24 quarts diesel)

• Generator oil & filter

• Wiper blades ($40 per blade), clean washer nozzles

• Generator air filter

• Generator fuel filter

• Engine fuel filter

CLEAN:

• Flush outside radiator coils

• Service house & chassis batteries

• Ground cables

• Air cooler

LUBRICATE:

• Air cooler

• Hose routing

• Chafing and leaks

LUBRICATE:

• Meritor roller pin

• Complete chassis

CHARGE:

• Meritor roller pin

• Complete chassis

$2,480 CHROME-03

Certified RV Technicians:

866-495-3055

CHASSIS PACKAGES *

We’ve bundled a variety of services for a more economical maintenance solution.

PEARL Class B

VISUAL INSPECTION OF:

• Fan belts

• Radiator & heater hoses

• Tires dates and condition adjust tire pressures

(NOTE: tire pressures will be adjusted to the specifications on the placard when fully loaded will require the coach to be weighed and adjusted.)

INSPECT:

• Polarity & voltage

• Directional signals

• Engine-support fasteners

• Alternator, battery & starter

• Suspension

• AC components

• Exhaust system

• Brake system valves

• Suspension

• Suspension u bolt torque

• Fuel tank mounts and fuel lines

• Clean ground cables

• Brake system valves

REPLACE:

• Engine oil & filter (up to 24 quarts diesel)

• Generator oil & filter

• Wiper blades ($40 per blade), clean washer nozzles

• Generator air filter

• Generator fuel filter

• Engine fuel filter

CLEAN:

• Flush outside radiator coils

• Service house & chassis batteries

• Ground cables

• Air cooler

LUBRICATE:

• Air cooler

• Hose routing

• Chafing and leaks

LUBRICATE:

• Meritor roller pin

• Complete chassis

CHARGE:

• Meritor roller pin

• Complete chassis

$2,080 CHROME-04

Certified RV Technicians:

866-495-3055

COLLISION Let our body and collision experts perform RV restoration and repair services needed to return your RV to its original appearance BEST IN THE BUSINESS FOR: • Leading RV Insurance Carriers • RV Roof & Door Repair • RV Fiberglass & Metalwork Experts Book your repair appointment today. 855-929-3992 Lazydays.com/RV-Service/RV-Collision-Repair

COLLISION CENTER

DID YOU KNOW?

We Offer Complimentary Sealant Inspection

Rooftop & body sealant should be inspected every 3 months for deterioration.

We Offer Chassis Lubrication Service

Generally, the rear chassis grease fittings are not lubricated during an engine oil change. A complete chassis lube should be performed every 12 months.

We Offer Aqua-Hot® Service

The AQUA-HOT® nozzle and fuel filter should be replaced every 12 months.

2024 SERVICE SPECIALS P: 866-495-3055

WE SERVICE ALL RV BRANDS WITH EXCLUSIVE OFFERS AND BUNDLES.

Trust our skilled technicians for comprehensive RV care, from diagnostics to installations.