Uofillinois AH Vol2 by Michal Najder

TEAM ILLINOISE VOLUME 2 UNIVERSITY OF ILLINOIS AT URBANA-CHAMPAIGN U.S. DEPARTMENT OF ENERGY 2017 RACE TO ZERO COMPETITION ATTACHED HOUSING

TABLE OF CONTENTS 01

Design Renderings

Construction Drawing Set

HRV Specifications/Commissioning Sheet

HVAC Ducted Minisplit Specifications/Commissioning Sheet

HVAC Ductless Minisplit Specification/Commissioning Sheet

Sunpower X22 series Photovoltaic Array Spec. sheet

Tesla Powerwall 2 Spec. sheet

RemRate Analysis - Without PV

RemRate Analysis - With PV

WUFI Hygrothermal Analysis

Financial Analysis

Volume 2 - Team Illinoize - Page 01

Volume 2 - Team Illinoize - Page 02

Volume 2 - Team Illinoize - Page 03

Volume 2 - Team Illinoize - Page 04

Volume 2 - Team Illinoize - Page 05

Volume 2 - Team Illinoize - Page 06

Volume 2 - Team Illinoize - Page 07

Volume 2 - Team Illinoize - Page 08

SITE PLAN NOTES:

21'-7" SETBACK

EXISTING 5 STORY RESIDENTIAL BUILDING. NOT IN CONSTRUCTION

PROPERTY LINE & EXTENT OF NEW CONSTRUCTION

WOOD AND STONE OUTDOOR FIREPLACE

23'-8"

24'-4"

EXISTING 5 STORY RESIDENTIAL BUILDING. NOT IN CONSTRUCTION

DRAINAGE PIPE FROM RAINWATER CISTERN TO RETENTION AND RAIN GARDEN AREA

10'-2" SETBACK

RECLAIMED WOOD PLANT CONTAINER

RECLAIMED WOOD SLAT PRIVACY FENCE

8'-8"

50' MAPLE

THE LOCATION OF EXISTING UNDERGROUND UTILITIES, SUCH AS WATER MAINS, SEWERS, GAS LINES, ETC. HAS NOT BEEN DETERMINED AND HAS NOT BEEN SHOWN ON THE PLANS. BEFORE CONSTRUCTION, OWNER SHOULD HIRE A LICENSED CIVIL ENGINEER TO DETERMINE LOCATION BASED ON THE BEST AVAILABLE INFORMATION. ALL INFORMATION SHOWN CONTRACTOR. THE OWNER IS GIVEN FOR THE CONVENIENCE OF THE AND THE ENGINEER DO NOT ASSUME RESPONSIBILITY IN THE EVENT THAT DURING CONSTRUCTION, UTILITIES OTHER THAN THOSE SHOWN MAY BE ENCOUNTERED AND THAT THE ACTUAL LOCATION OF THOSE WHICH EXIST MAY BE DIFFERENT FROM THE LOCATION ASSUMED.

CONTRACTOR SHALL NOTIFY THE OWNER, ENGINEER AND THE LOCAL PRESIDING MUNICIPALITY A MINIMUM OF 48 HOURS IN ADVANCE OF PERFORMING ANY WORK.

ALL AREAS, ON OR OFF SITE, DISTURBED DURING CONSTRUCTION OPERATIONS AND NOT PART OF THE WORK

AS SHOWN HERON SHALL BE RESTORED TO ORIGINAL CONDITION TO THE SATISFACTION OF THE OWNER AT NO ADDITIONAL COST TO THE OWNER. IT IS INCUMBENT UPON CONTRACTOR TO SHOW THAT DAMAGED AREAS WERE NOT DISTURBED BY CONSTRUCTION OPERATIONS

THESE DRAWINGS ASSUME THAT THE CONTRACTOR WILL UTILIZE AN ELECTRONIC DRAWING FILE AND STAKE ALL SITE IMPROVEMENTS USING COORDINATES TIED INTO THE CONTROL POINTS. THE DIMENSIONS INDICATED ON THE DRAWINGS ARE FOR THE CONVENIENCE OF THE CONTRACTOR ONLY

IN THE CASE OF CONFLICT BETWEEN THESE DRAWINGS, THE FOUNDATION DRAWINGS AND THE ARCHITECTURAL SITE PLAN, THE USER OF THIS INFORMATION SHALL CONTACT THE ARCHITECT IMMEDIATELY.

OWNER TO COORDINATE THE EXACT LOCATIONS OF ALL UTILITY SERVICE LINES WITH PLUMBING DRAWINGS. REFER TO PLUMBING DRAWINGS FOR CONTINUATION OF ALL UTILITIES WITHIN 5 FEET OF BUILDING AREA

CONTRACTOR SHALL FIELD VERIFY INVERT & LOCATIONS OF EXISTING UTILITY MAINS PRIOR TO INSTALLING ANY ON-SITE UTILITIES OR STRUCTURES

CLEAN OUT ALL EXISTING AND PROPOSED STORM INLETS AND CATCH BASINS AT THE COMPLETION OF CONSTRUCTION

10.

CONTRACTOR SHALL NOT DISTURB EXISTING UTILITIES, STRUCTURES, FIXTURES ON SITE DURING AND AFTER DURATION OF CONSTRUCTION.

PROPERTY LINE

13'-8"

WATER RETENTION AND RAIN GARDEN

14'-10"

LOCUST ST.

9'-6 1/2"

6'-0 1/2"

CONTRACTOR SHALL BE RESPONSIBLE FOR reviewing all plans and specifications, verifying all existing conditions prior to proceeding with construction, complying with all applicable building codes, and notifying architect immediately of any discrepancies or conflicts. contractor shall conduct work in conformance with all applicable building codes.

6'-0 1/2"

contractor is responsible for design and installation of properly sized and loaded systems. submit shop drawings to architect for approval on conformity to architectural design intent.

35' MAPLE

illinois solar decathlon shall retain all copyrights, statutory and common law right with regard to these plans, drawings and building design. reproduction, changes, or assignment to any third party shall not occur without obtaining expressed written permission and consent of illinois solar decathlon.

13-0" EQ.

[INSERT PROJECT NAME]

14'-10"

63 E. DANIEL ST. CHAMPAIGN, IL 61820

2017 U.S. DEPARTMENT OF ENERGY RACE TO ZERO DESIGN COMPETITION ISSUED FOR: INITIAL CONSTRUCTION SET

X/X/2017

60'-0"

PROPERTY LINE

10-0' UTILITY EASEMENT

PROPERTY LINE

10-0' UTILITY EASEMENT

14' OAK

60'-0"

DATE 1/21/2017

5'-0"

29'-2"

14'-0" V.I.F

10-0' UTILITY EASEMENT

10-2" SETBACK

90' OAK

EXISTING STREETSIDE PARKING TO REMAIN

ILLINOIS SOLAR DECATHLON TEAM ILLINOISE RACE TO ZERO 2017

DANIEL ST.

PROJ # 3

SCALE: AS INDICATED

DN. BY: Team ILLINOISE

CK. BY:

TITLE PAGE

G1.0 Volume 2 - Team Illinoize - Page 09

NORMAL LAYOUT

ADA LAYOUT

NORMAL LAYOUT

ADA LAYOUT

3' - 5 7/16"

11' - 6 13/16"

7' - 10 1/8"

10' - 0"

2' - 7 7/16" 20' - 5 9/16"

4' - 0 9/16"

4' - 0"

3' - 0"

6' - 5"

3' - 0"

4' - 0"

)

11' - 5"

15' - 11 7/8"

)

19' - 1 1/2"

Kitchen

KITCHEN

188 SF

)

HVAC 30 SF

LAUNDRY

42 SF

)

13' - 6 9/16"

)

6' - 11"

2' - 7 7/16" 7' - 10 1/16"

WATER

19 SF

PWDR RM

32 SF

DINING ROOM

81,9(56,7< 2) ,//,12,6 $7 85%$1$ &+$03$,*1

188 SF

$77$&+(' +286,1*

5(9(5%

( '$1,(/ 67 &+$03$,*1 ,/

8 6 '(3$570(17 2) (1(5*< 5$&( 72 =(52 '(6,*1 &203(7,7,21

Living Room

237 SF

'$7(

,668(' )25

,1,7,$/ &216758&7,21 6(7

),1$/ &216758&7,21 6(7

),1$/ 68%0,77$/6

$ -

188 SF

10' - 0 1/16"

5' - 0 9/16"

11' - 4 13/16"

2' - 7 7/16"

Dining Room

20' - 5 9/16"

7' - 10 1/16"

3' - 1" 3' - 8 13/16"

13' - 6 9/16"

20' - 5 9/16"

10' - 0 1/16"

)

2' - 7 3/4" 4' - 1"

13' - 11 7/8"

)

6' - 6"

3' - 8 13/16"

13' - 11 7/8"

14' - 2 9/32"

)

3' - 0"

4' - 1" 2' - 7 3/4"

)

6' - 0"

9' - 0 25/32"

HVAC 30 SF

)

4' - 8 3/8"

6' - 6" 58' - 10 3/4"

)

6' - 6"

74' - 10 13/16"

237 SF

)

3' - 1"

Room

63 SF

2' - 11 1/2"

8' - 0 1/16"

FAMILY ROOM

237 SF

83 )

)

6/23( 0$;

5' - 5 7/16"

4' - 6 1/2"

9' - 11 15/16"

5' - 6 11/16"

12' - 8" 23' - 11"

5' - 8 5/16"

,//,12,6 62/$5 '(&$7+/21 7($0 ,//,12,6( 5$&( 72 =(52

83 4' - 6 1/2"

3URMHFW 1XPEHU

6FDOH

'1 %< 7HDP ,//,12,6(

&. %<

5' - 5 7/16"

),567 )/225 3/$1

9' - 11 15/16"

43' - 10 7/8"

),567 )/225 $UFK 3ODQ

Family Room

3' - 0"

63 SF

2' - 7 7/16"

3' - 0"

MUDROOM

63 SF -

10' - 0"

MUDROOM $

11' - 6 13/16"

4' - 6 9/16"

6' - 7 13/16"

8' - 0"

),567 )/225 )851,785( 3/$1

$ Volume 2 - Team Illinoize - Page 10

NORMAL LAYOUT

ADA LAYOUT

NORMAL LAYOUT

ADA LAYOUT

50' - 0" 25' - 0"

25' - 0" 11' - 11 1/2"

10' - 0"

6' - 11"

)

2' - 0"

)

1' - 0"

15' - 3 15/16"

) )

)

10' - 5"

)

10' - 4 11/16"

12' - 10 3/4"

)

12' - 10 3/4"

9' - 6 7/16"

)

2' - 6"

)

10' - 0"

)

9' - 0 1/2"

9' - 11 1/8"

% 24' - 0 5/8"

57 SF

STUDY AREA 259 SF 81,9(56,7< 2) ,//,12,6 $7 85%$1$ &+$03$,*1

5' - 3 3/8"

( '$1,(/ 67 &+$03$,*1 ,/

BATHROOM

55 SF

57 SF

BEDROOM

ADA BEDROOM

146 SF

139 SF

BEDROOM

ADA BEDROOM

143 SF

147 SF

8 6 '(3$570(17 2) (1(5*< 5$&( 72 =(52 '(6,*1 &203(7,7,21 '$7(

,668(' )25

,1,7,$/ &216758&7,21 6(7

),1$/ &216758&7,21 6(7

),1$/ 68%0,77$/6

9' - 11 3/16"

43' - 10 15/16"

BATHROOM

55 SF

5(9(5%

)

BATHROOM

$77$&+(' +286,1*

2' - 11 1/2" 4' - 11 11/16"

)

1' - 0"

270 SF

12' - 7"

)

2' - 0"

)

STUDY AREA

4' - 0"

2' - 6"

2' - 0"

)

136 SF

15' - 3 15/16"

10' - 0"

22' - 5 3/8"

)

ADA BEDROOM

144 SF

20' - 7 3/8"

3' - 2 3/8"

20' - 7 3/8"

BEDROOM

)

3' - 2 3/8"

)

150 SF

)

22' - 5 3/8"

)

11' - 5"

)

ADA BEDROOM

146 SF

6' - 3 3/8"

BEDROOM

) %

74' - 10 7/8"

5' - 11 27/32"

)

4' - 7"

3' - 6"

)

9' - 0 1/2"

)

18' - 5 9/16"

2' - 6"

15' - 0 3/4"

10' - 11"

)

15' - 0 3/4"

)

2' - 6"

10' - 5"

3' - 6"

9' - 6 1/2"

6' - 6"

13' - 0 3/4"

8' - 0"

13' - 0 3/4"

3' - 0 1/2"

5' - 0 1/2" 2' - 11 1/2"

18' - 0 3/4"

7' - 10 23/32"

11' - 11 1/2"

7' - 11 3/16"

10' - 0"

2' - 0"

3' - 0 1/2"

,//,12,6 62/$5 '(&$7+/21 7($0 ,//,12,6( 5$&( 72 =(52 3URMHFW 1XPEHU

6FDOH

'1 %< 7HDP ,//,12,6(

&. %<

6(&21' )/225 3/$1

6(&21' )/225 $UFK 3ODQ

6(&21' )/225 )851,785( 3/$1

$ Volume 2 - Team Illinoize - Page 11

50' - 0" 3' - 0 3/4"

50' - 2"

46' - 11 1/4"

3' - 0 3/4"

47' - 1 1/4"

15' - 11 1/2"

2' - 5 17/32" 10' - 6 31/32"

5' - 5 7/8"

5' - 0"

5' - 5 5/8"

14' - 10 1/32"

13' - 0 1/2"

25' - 11 15/16"

20' - 3 5/8"

10' - 7 7/32"

16' - 11 1/16" 22' - 9"

74' - 11 7/8"

22' - 7"

4' - 5 7/8"

15' - 11 1/2"

4' - 6 11/16" 4' - 5 7/8"

74' - 10 7/8"

4' - 5 7/8" 4' - 6 11/16"

16' - 8 7/16"

$77$&+(' +286,1*

5(9(5%

( '$1,(/ 67 &+$03$,*1 ,/

26' - 3 15/16"

18' - 4 3/4"

8 6 '(3$570(17 2) (1(5*< 5$&( 72 =(52 '(6,*1 &203(7,7,21 '$7(

,668(' )25

,1,7,$/ &216758&7,21 6(7

),1$/ &216758&7,21 6(7

),1$/ 68%0,77$/6

7' - 11 3/16"

26' - 3 15/16"

81,9(56,7< 2) ,//,12,6 $7 85%$1$ &+$03$,*1

,//,12,6 62/$5 '(&$7+/21 7($0 ,//,12,6( 5$&( 72 =(52 3URMHFW 1XPEHU

6FDOH

'1 %< 7HDP ,//,12,6(

&. %<

522) '(&.

522) '(&. $UFK 3ODQ

833(5 522) $UFK 3ODQ

$ Volume 2 - Team Illinoize - Page 12

833(5 522)

522) '(&. 3$5$3(7

522) '(&.

6(&21' )/225

),567 )/225

*5281' /(9(/

% )281'$7,21

:(67 (/(9$7,21

833(5 522)

81,9(56,7< 2) ,//,12,6 $7 85%$1$ &+$03$,*1

833(5 522)

$77$&+(' +286,1*

5(9(5%

522) '(&. 3$5$3(7

522) '(&.

6(&21' )/225

),567 )/225

8 6 '(3$570(17 2) (1(5*< 5$&( 72 =(52 '(6,*1 &203(7,7,21 '$7(

,668(' )25

,1,7,$/ &216758&7,21 6(7

),1$/ &216758&7,21 6(7

),1$/ 68%0,77$/6

6(&21' )/225

),567 )/225

*5281' /(9(/

% )281'$7,21

($67 (/(9$7,21

( '$1,(/ 67 &+$03$,*1 ,/

,//,12,6 62/$5 '(&$7+/21 7($0 ,//,12,6( 5$&( 72 =(52 3URMHFW 1XPEHU

6FDOH

'1 %< 7HDP ,//,12,6(

&. %<

(;7(5,25 (/(9$7,216

$ Volume 2 - Team Illinoize - Page 13

833(5 522)

522) '(&. 3$5$3(7

522) '(&.

6(&21' )/225

),567 )/225

*5281' /(9(/

% )281'$7,21

6287+ (/(9$7,21

81,9(56,7< 2) ,//,12,6 $7 85%$1$ &+$03$,*1

833(5 522)

$77$&+(' +286,1*

5(9(5% ( '$1,(/ 67 &+$03$,*1 ,/

522) '(&. 3$5$3(7

522) '(&.

6(&21' )/225

),567 )/225

1257+ (/(9$7,21

8 6 '(3$570(17 2) (1(5*< 5$&( 72 =(52 '(6,*1 &203(7,7,21 '$7(

,668(' )25

,1,7,$/ &216758&7,21 6(7

),1$/ &216758&7,21 6(7

),1$/ 68%0,77$/6

6(&21' )/225

),567 )/225

*5281' /(9(/

% )281'$7,21

,//,12,6 62/$5 '(&$7+/21 7($0 ,//,12,6( 5$&( 72 =(52 3URMHFW 1XPEHU

6FDOH

'1 %< 7HDP ,//,12,6(

&. %<

(;7(5,25 (/(9$7,216 &217 '

Volume 2 - Team Illinoize - Page 14

833(5 522)

522) '(&. 3$5$3(7

522) '(&.

6(&21' )/225

),567 )/225

*5281' /(9(/

% )281'$7,21

6HFWLRQ

833(5 522)

81,9(56,7< 2) ,//,12,6 $7 85%$1$ &+$03$,*1

833(5 522)

$77$&+(' +286,1*

5(9(5%

522) '(&. 3$5$3(7

522) '(&.

6(&21' )/225

( '$1,(/ 67 &+$03$,*1 ,/

8 6 '(3$570(17 2) (1(5*< 5$&( 72 =(52 '(6,*1 &203(7,7,21 '$7(

,668(' )25

,1,7,$/ &216758&7,21 6(7

),1$/ &216758&7,21 6(7

),1$/ 68%0,77$/6

6(&21' )/225

),567 )/225

),567 )/225 *5281' /(9(/

% )281'$7,21

6HFWLRQ ),1

,//,12,6 62/$5 '(&$7+/21 7($0 ,//,12,6( 5$&( 72 =(52 3URMHFW 1XPEHU

6FDOH

'1 %< 7HDP ,//,12,6(

&. %<

6(&7,216

$ Volume 2 - Team Illinoize - Page 15

833(5 522)

522) '(&. 3$5$3(7

522) '(&.

6(&21' )/225

),567 )/225

*5281' /(9(/

% )281'$7,21

6HFWLRQ ),1

81,9(56,7< 2) ,//,12,6 $7 85%$1$ &+$03$,*1

833(5 522)

$77$&+(' +286,1*

833(5 522)

5(9(5% ( '$1,(/ 67 &+$03$,*1 ,/

522) '(&. 3$5$3(7

522) '(&.

6(&21' )/225

8 6 '(3$570(17 2) (1(5*< 5$&( 72 =(52 '(6,*1 &203(7,7,21 '$7(

,668(' )25

,1,7,$/ &216758&7,21 6(7

),1$/ &216758&7,21 6(7

),1$/ 68%0,77$/6

6(&21' )/225

,//,12,6 62/$5 '(&$7+/21 7($0 ,//,12,6( 5$&( 72 =(52

),567 )/225

),567 )/225 *5281' /(9(/

% )281'$7,21

6HFWLRQ

3URMHFW 1XPEHU

6FDOH

'1 %< 7HDP ,//,12,6(

&. %<

6(&7,216 &217 '

% )281'$7,21

$ Volume 2 - Team Illinoize - Page 16

833(5 522)

522) '(&. 3$5$3(7

522) '(&.

2' - 6"

6(&21' )/225

),567 )/225

*5281' /(9(/

% )281'$7,21

6HFWLRQ ),1

81,9(56,7< 2) ,//,12,6 $7 85%$1$ &+$03$,*1

833(5 522)

$77$&+(' +286,1*

833(5 522)

5(9(5% ( '$1,(/ 67 &+$03$,*1 ,/

522) '(&. 3$5$3(7

522) '(&.

6(&21' )/225

),567 )/225

6HFWLRQ

8 6 '(3$570(17 2) (1(5*< 5$&( 72 =(52 '(6,*1 &203(7,7,21 '$7(

,668(' )25

,1,7,$/ &216758&7,21 6(7

),1$/ &216758&7,21 6(7

),1$/ 68%0,77$/6

6(&21' )/225

),567 )/225

*5281' /(9(/

% )281'$7,21

,//,12,6 62/$5 '(&$7+/21 7($0 ,//,12,6( 5$&( 72 =(52 3URMHFW 1XPEHU

6FDOH

'1 %< 7HDP ,//,12,6(

&. %<

6(&7,216 &217 '

$ Volume 2 - Team Illinoize - Page 17

PRESSURE TREATED OSB PLYWOOD CANT STRIP PERMEABLE WRB, LAP OVER EDGE OF SIP WALL

SHEET METAL PARAPET FLASHING CAP, SLOPED TO ROOF

SIP SCREW, 1 1/2" LONGER THAN ROOF PANEL THICKNESS

FLASHING TO EXTEND MIN. 4" BELOW TOP OF PARAPET

5/8" SOUND ATTENUATING GYPSUM BOARD

2x4 FURRING STRIPS OR SLEEPERS FOR VENTILATION CHANNELS 16" O.C. PERMEABLE WEATHER BARRIER MEMBRANE, LAP OVER ROOF EDGE

JAMES HARDIE HARDIEPLANK LAP SIDING

2 1/2" METAL STUDS AT 24" O.C.

CONTINUOUS BEAD OF SEALANT, 1/4"

TPO ROOFING MEMBRANE 1/2" OSB PLYWOOD OVER VENTILATION CHANNELS

RING SHANK NAILS 6" O.C. STAGGERED TYP. BOTH SIDES

8" CMU

7/16" OSB PLYWOOD (PART OF SIP) 6 1/4" THERMOCORE SIP SUPER INSULATED ROOF

MORTAR JOINT

24" O.C.

ROOF SLOPED TO DRAIN

48" MIN. SPACING

2X LUMBER PARAPET SILL PLATE

RING SHANK NAILS 6" O.C. STAGGERED TYP. BOTH SIDES

2 1/2"

HIGH DENSITY CLOSED CELL SPRAY FOAM INSULATION 14" DEEP WOOD TRUSSES AT 19.2" O.C.

EXPANDING FOAM SEALANT, 3/8" CONTINUOUS BEAD OF SEALANT, XPS-TO-WOOD TYP. 7/16" OSB PLYWOOD

CLOSED CELL SPRAY FOAM INSULATION, WRAP TO TOP OF SIP WALL 2 LAYERS OF 5/8" GYPSUM BOARD CEILING WITH GREEN GLUE

3/4" FURRING STRIP SIP STRUCTURAL SPLINES. ATTACH USING SHANK NAILS SCHUCO TRIPLE PANE WINDOW WITH SI SYSTEM

CONTINUOUS FLASHING

7 3/4"

AIR BARRIER MEMBRANE

2X TREATED LUMBER TOP PLATE

POLYURETHANE FOAM BETWEEN HEADER AND SIP PANEL

2 1/2" EcoTouch™ QuietZone® PINK™ FIBERGLAS® Acoustic Batt Insulation

UNIT B

2 1/2"

INTERIOR PARTITION AT PARTY WALL SCALE = 1/2" = 1'-0"U.N.O

6" SIP TAPE, ATTACHED TO PREDOMINATELY WARM SIDE

LAP AND TAPE AWB DRIIP EDGE.

RESILIENT CHANNELS 3/4"

2 1/2" STEEL STUDS AT 24" O.C.

AIR BARRIER LAYER

PARAPET DETAIL

2 1/2" EcoTouch™ QuietZone® PINK™ FIBERGLAS® Acoustic Batt Insulation

SCALE = 1/2" = 1'-0"

UNIT A

UNIT B

BOTTOM PLATE 6 1/2" SIP WALL PANEL

6/17" OSB PLYWOOD (BOTH SIDES) 2 LAYERS OF 5/8" GYPSUM BOARD WITH WATER PERMEABLE PAINT 16D COMMON NAILS AT 16" O.C. WHEN USED AS BRACING

DRAIN AND VENTILATED 3/4" AIR GAP SCHUCO TRIPLE PANE WINDOW WITH SI SYSTEM

MASTIC SEAL

CLAPBOARD SELF ADHERED FLASHING MEMBRANE

POLYURETHANE FOAM BETWEEN SILL PLATE AND SIP PANEL

LAP WINDOW SILL FLASHING OVER WEATHER RESISTIVE BARRIER

FLOOR FINISH - HARDWOOD OR CAPRET - SEE FINISH PLANS

7/16" OSB PLYWOOD

HIGH DENSITY CLOSED CELL SPRAY FOAM INSULATION

WINDOW OPENING DETAIL

1'-6"

WOOD FLOOR TRUSS

2x LET-IN PLATE SIMPSON STRONG TIE METAL STRAP AS REQUIRED

SIPS SCREWS WITH MINIMUM 1" PENETRATION IN WOOD MEMBER IN SIP WALL PANEL CONNECTED TO AT 24" O.C. MAX

1-1/2"

CONTINUOUS SEALANT EACH SIDE OF FRAMING TYP. AS REQUIRED

6 1/2" XPS INSULATION AS PART OF SIP PANEL.

SIMPSON STRONG TIE DIRECT BEARING METAL FLOOR JOIST HANGER

METAL RESILIENT CHANNEL 24" O.C.

8D COMMON NAILS 4" O.C. ON SIMPSON STRONG TIE METAL JOIST HANGER

CONTINUOUS SEALANT ON EACH SIDE OF FRAMING TYP. AS REQURED

1-1/2"

1/2" GYPSUM BOARD

METAL RESILIENT CHANNEL 24" O.C.

HVAC DUCTWORK - SEE MECH DWGS FOR PRECISE LOCATION. METAL CONNECTOR PLATE, TYP.

PRESSURE TREATED CAP PLATE

2 1/2"

2ND FLOOR CONNECTION DETAIL (HANGING FLOOR)

SCALE = 1/2" = 1'-0"U.N.O

UNIVERSITY OF ILLINOIS AT URBANA-CHAMPAIGN

7 3/4"

5/8" GYPSUM WALL BOARD

2 LAYERS OF 5/8" SOUND ATTENUATING GYPSUM BOARD WITH GREEN GLUE

ATTACHED HOUSING 9' TYP. CEILING HEIGHT

SCALE = 1/2" = 1'-0"U.N.O

CONTINUOUS SEALANT

2ND FLOOR-TO-WALL CONNECTION DETAIL SCALE = 1/2" = 1'-0"U.N.O

COMMON 8D NAILS AT 6" O.C. EACH SIDE CONTINUOUS SEALANT EACH SIDE OF FRAMING TYP. AS REQUIRED

CONTINUOUS SEALANT AS REQUIRED

3/4" AIR GAP (WITH FURRING STRIPS)

WALL-TO-WALL PANEL CORNER CONNECTION HARDIEPLANK LAP SIDING. SEE MATERIAL SPECS.

SCALE = 1/2" = 1'-0"U.N.O

8 1/4" SIP WITH FILLED-IN XPS INSULATION

3/4" FURRING STRIP FOR VENTILATION AND DRAINAGE

7/8" OSB PLYWOOD SHEATHING (BUILT IN SIP)

HARDIEPLANK FIBER CEMENT SIDING

VAPOR PERMEABLE ALL WEATHER RESISTIVE BARRIER CONTINUOUS SEALANT ON EACH SIDE OF SIP

SIP TAPE ON ALL JOINTS AND SEAMS

FIELD INSTALLED PRESSURE- TREATED BOTTOM PLATE

16D NAILS INTO FLOOR TRUSS PLATE AT 16" O.C. WHEN USED AS BRACING (3) 16D NAILS AT 16" O.C. 8D COMMON NAILS AT 6" O.C. EACH SIDE

8" CMU

5/8" SOUND ATTENUATING GYPSUM WALL BOARD

CLOSED CELL HIGH DENSITY SPRAY FOAM INSULATION (GRADE I) SUBFLOOR OR COMBINED SUBFOOR AND UNDERLAYMENT, TYP.

CONTINUOUS BEAD OF SEALANT AT EACH SIDE OF FRAMING TYP. AS RECOMMENDED BY MANUFACTURER

2017 U.S. DEPARTMENT OF ENERGY RACE TO ZERO DESIGN COMPETITION

UNIT B

3" ECOTOUCH QUIETZONE PINK FIBERGLASS ACOUSTICAL BATT INSULATION

CONTINUOUS BEAD OF SEALANT

8D COMMON NAILS

8 1/4" XPS INSULATION CORE 3/4" FURRING STRIP

UNIT A

REVERB 63 E. DANIEL ST. CHAMPAIGN, IL 61820

2 1/2" METAL STUDS AT 24" O.C.

2 LAYERS 5/8" SOUND ATTENUATING GYPSUM BOARD WITH GREEN GLUE

DRAINED AND VENTILATED 3/4" AIR GAP

VAPOR PERMEABLE WEATHER BARRIER

1'-6"

5/8" GYPSUM BOARD

WOOD FLOOR TRUSS

1-1/2" FURRING STRIP, NAILED AT 16" O.C.

3" ECOTOUCH QUIETZONE PINK FIBERGLASS ACOUSTICAL BATT INSULATION

3/4" PLYWOOD FLOOR SHEATHING (GLUED AND NAILED) TO EXTEND OVER TOP OF SIP WALL

CONTINUOUS BEAD OF SEALANT

HARDIEPLANK SIDING 3/4" AIR GAP AND DRAINAGE PLANE

TRIM

2 x 8" FLOOR JOIST

CONTINUOUS SEALANT EACH SIDE OF FRAMING TYPE AS RECOMMENDED BY MANUFACTURER

3/4" FURRING STRIP, NAILED TO SIP PANEL 8D COMMON NAILS AT 6" O.C. BOTH SIDES

ANCHOR BOLT TO EXTEND MIN 1 1/2" BELOW

3/4" OSB PLYWOOD FLOOR SHEATHING

VAPOR BARRIER

VAPOR PERMEABLE ALL WEATHER RESISTIVE BARRIER

8" CMU

ACOUSTIBLOCK SOUNDPROOFING UNDERLAYMENT

STANDARD WIRE CHASE

HARDIEPLANK LAP SIDING. SEE MATERIAL SPECS.

INTERIOR FLOOR TRIM

CMU CAVITY FILL

DATE

ISSUED FOR:

1/21/2017

INITIAL CONSTRUCTION SET

3/28/2017

FINAL CONSTRUCTION SET

4/4/2017

FINAL SUBMITTALS

1'-6"

WOOD FLOOR TRUSS

USE NAILS PER MANUFACTURER'S RECOMMENDATIONS FOR SIZE AND SPACING BLOCK SUPPORTING TRIMMER

WOOD FLOOR TRUSS

CONTINUOUS POLYURETHANE FOAM AND CONTINUOUS SEALANT BETWEEN 2 SIP PANELS

MINIMUM 6" GAP FROM SIDING STOP TO GRADE POLYPROPYLENE MESH STRIP INSECT STOP AND SCREEN CONCRETE FOUNDATION WALL - 12" THICK

TREATED SILL PLATE

CAPILLARY BREAK. MIN 6 MM POLY OR MIN 3/4" PRESSURE-TREATED PLYWOOD UNDER SILL PLATE AND BOTH FACES

WATERPROOFING MEMBRANE - WRAP BELOW FOOTING

ANCHOR BOLTS AS REQUIRED BY CODE

CHASE FOR EXPANDED FOAM SEALANT

UNIT A

UNIT B

LIQUID APPLIED CAPILLARY BREAK APPLIED TO TOP OF FOOTING, BEFORE PLACING/POURING FOUNDATION WALL

20 MIL POLYETHYLENE VAPOR RETARDER 6 MIL POLYETHYLENE UNDER CONCRETE SLAB

ILLINOIS SOLAR DECATHLON TEAM ILLINOISE 5 1/4"

1'-0"

CONCRETE FOOTING

4" CONCRETE SLAB

SIP VERTICAL PANEL JOINT/SEAM DETAIL. SCALE = 1/2" = 1'-0"U.N.O

CRAWLSPACE DRAIN

LIQUID APPLIED CAPILLARY BREAK APPLIED TO TOP OF FOOTING, BEFORE PLACING/POURING FOUNDATION WALL

2'-0"

WATERPROOFING MEMBRANE - WRAP UP CMU FOOTING

4" CONCRETE SLAB

BOND BREAK

GROUND SLOPES AWAY FROM WALL AT 5% GRADING (6 IN PER 10 FT)

2x12 LEDGER

L-SHAPED ANGLE 3" x 3" x .25"

1'-8"

6" SIP TAPE, APPLIED TO PREDOMINATELY WARM SIDE OF ASSEMBLY

SIMPSON STRONG TIE DIRECT BEARING METAL FLOOR TRUSS HANGER

1/8" EXPANSION GAP

3'-0"

8D COMMON NAILS @ 6" O.C. EACH STRIP AND EACH SIDE

2 LAYERS OF SOUND ATTENUATING 5/8" GYPSUM BOARD WITH GREEN GLUE

1'-6"

END TRIMMER SIP TAPE ON ALL JOINTS AND SEAMS RESILIENT CHANNEL AR 24" O.C. VAPOR PERMEABLE PAINT AND PRIMER

REBAR - INSTALL ADHERING TO LOCAL CODES

2'-0"

6 MIL POLYETHYLENE UNDER CONCRETE SLAB

RACE TO ZERO 2017 PROJ # 3

SCALE: AS INDICATED

DN. BY: Team ILLINOISE

CK. BY:

WALL SECTION DETAILS

20 MIL VAPOR RETARDER CONTINUOUSLY SLOPING TOWARDS DRAIN. SEAMS LAPPED 6IN AND SEALED WITH DUCT MASTIC

FOUNDATION DETAIL SCALE = 1/2" = 1'-0"U.N.O

4" RIGID INSULATION, BELOW CONCRETE SLAB 4" GRAVEL (GAS PERMEABLE) 2" RIGID INSULATION

FOUNDATION DETAIL AT CMU PARTY WALL SCALE = 1/2" = 1'-0"U.N.O

A401 Volume 2 - Team Illinoize - Page 18

6' - 5 15/16"

0' - 2 3/32"

0' - 2 29/32"

7' - 10 3/32"

7' - 0 3/32" 0'0' - 2- 29/32" 2 3/32"

6' - 5 15/16"

0' - 2 3/32"

3' - 8 17/32"

0' - 3 11/16" 0' - 2 3/32" 0' - 2 3/32"

0' - 3 11/16" 0' - 2 3/32"

0'0'- -1 13/16" 3 3/16"

0' - 2 29/32"

0' - 2 3/32"

0' - 2 29/32" 6' - 0 1/8" 0' - 2 29/32"

0' - 2 29/32" 0' - 2 3/32"

5' - 2 7/32"

0' - 1 19/32" 0' - 2 1/8"

4' - 5 1/8"

2' - 0 1/16"

0' - 2 1/8" 0' - 1 19/32"

0' - 2 15/32" 0' - 1 19/32"

0' - 2 15/32"

0' - 1 15/16" 1' - 5 1/4"

3' - 4 3/16"

1' - 5 1/4"

0' - 2 1/8"

2' - 6 11/16" 0' - 2 13/32"

0' - 2 1/4" 0' - 2 1/8"

5' - 1 7/8"

4' - 11 1/2"

2' - 4 25/32" 0' - 2 3/32" 0' - 3 11/16" 0' - 2 3/32"

4' - 6 11/16"

3' - 2 19/32"

4' - 3 3/8"

1' - 3 9/16"

3' - 2 1/8"

6' - 11 1/2"

:,1'2:6 2' - 6"

2' - 8"

2' - 10"

3' - 0"

81,9(56,7< 2) ,//,12,6 $7 85%$1$ &+$03$,*1

$77$&+(' +286,1*

5(9(5%

( '$1,(/ 67 &+$03$,*1 ,/

6' - 9"

0' - 2 3/32"

4' - 4 7/32"

7' - 1"

0' - 3 5/32"

0' - 2 29/32"

0' - 2 3/32"

0' - 1 15/16" 0' - 2 1/4" 0' - 2 1/8"

1' - 5 3/4"

0' - 2 29/32"

0' - 1 23/32" 0' - 3 9/32"

0' - 2 13/32"

0' - 3 5/32"

3' - 2 19/32"

0' - 1 7/8"

5' - 2 7/32"

1' - 9 13/32"

0' - 1 3/16" 0' - 1 25/32"

1' - 9 13/32"

6' - 9"

4' - 10 5/32"

0'0' - 2- 29/32" 2 3/32" 2' - 4 19/32" 0' 0'--223/32" 29/32"

0' - 2 29/32"

0' - 2 3/32"

0' - 1 9/16"

0'0' - 2- 29/32" 2 3/32" 2' - 4 19/32" 0' 0'--223/32" 29/32"

6' - 9"

0' - 2 29/32"

2' - 2 11/32"

3' - 9 1/16"

0' - 3 11/16"

0' - 2 3/32"

1' - 10 5/32"

0' - 2 3/32"

5' - 7 15/16"

0' - 2 29/32"

4' - 2 9/16"

:LGWK

6' - 5 15/16"

6FKXHFR ,QWHUQDWLRQDO .* 6FKXHFR ,QWHUQDWLRQDO .* 6FKXHFR ,QWHUQDWLRQDO .* 6FKXHFR ,QWHUQDWLRQDO .* 6FKXHFR ,QWHUQDWLRQDO .* 9(/8; 9(/8; 9(/8; 9(/8; 6FKXHFR ,QWHUQDWLRQDO .* 6FKXHFR ,QWHUQDWLRQDO .* 6FKXHFR ,QWHUQDWLRQDO .* 6FKXHFR ,QWHUQDWLRQDO .* 6FKXHFR ,QWHUQDWLRQDO .* 6FKXHFR ,QWHUQDWLRQDO .* 6FKXHFR ,QWHUQDWLRQDO .* 6FKXHFR ,QWHUQDWLRQDO .* 6FKXHFR ,QWHUQDWLRQDO .* 6FKXHFR ,QWHUQDWLRQDO .* 6FKXHFR ,QWHUQDWLRQDO .* 6FKXHFR ,QWHUQDWLRQDO .* 6FKXHFR ,QWHUQDWLRQDO .* 6FKXHFR ,QWHUQDWLRQDO .* 6FKXHFR ,QWHUQDWLRQDO .* 6FKXHFR ,QWHUQDWLRQDO .* 6FKXHFR ,QWHUQDWLRQDO .* 6FKXHFR ,QWHUQDWLRQDO .* 6FKXHFR ,QWHUQDWLRQDO .* 6FKXHFR ,QWHUQDWLRQDO .* 6FKXHFR ,QWHUQDWLRQDO .* 6FKXHFR ,QWHUQDWLRQDO .* 6FKXHFR ,QWHUQDWLRQDO .* 6FKXHFR ,QWHUQDWLRQDO .* 6FKXHFR ,QWHUQDWLRQDO .* 6FKXHFR ,QWHUQDWLRQDO .* 6FKXHFR ,QWHUQDWLRQDO .* 9(/8; 9(/8; 9(/8; 9(/8;

0' - 2 3/32"

3' - 1 3/8" 0' - 3 11/32"

0' - 4 11/32"

1' - 3 9/16"

+HLJKW

0' - 2 3/32"

8 6 '(3$570(17 2) (1(5*< 5$&( 72 =(52 '(6,*1 &203(7,7,21

5' - 2"

2' - 10"

5' - 10"

3' - 2"

3' - 0"

'$7(

,668(' )25

,1,7,$/ &216758&7,21 6(7

),1$/ &216758&7,21 6(7

),1$/ 68%0,77$/6

3' - 0"

:DOO 6FKHGXOH

) * + -

7' - 3"

),1 6,36 ZLWK )LEHU&HPHQW VW )ORRU ),1 6,36 ZLWK )LEHU&HPHQW QG )ORRU ),1 ,QWHULRU :DOOV ),1 &08 SDUW\ ZDOO ),1 6,36 ZLWK 5HFODLPHG :RRG ),1 ,QWHULRU 3DUWLWLRQ KU

7' - 3"

&RXQW

7' - 1 3/16"

7\SH

6' - 10"

7\SH 0DUN

7' - 1"

0' - 2 1/4"

0DQXIDFWXUHU

1' - 11 1/8"

0DUN

0' - 11 5/8" 0' - 1 13/16" 0' - 3 3/16"

:LQGRZ 6FKHGXOH :LGWK

1' - 11 1/8"

+HLJKW

0' - 1 11/32" 0' - 4 21/32"

'RRU 6FKHGXOH 0DUN

5' - 10"

'2256

6' - 5 3/8"

3' - 4"

3' - 6"

,//,12,6 62/$5 '(&$7+/21 7($0 ,//,12,6( 5$&( 72 =(52 3URMHFW 1XPEHU

6FDOH

'1 %< 7HDP ,//,12,6(

&. %<

:1': '225 '(7/6 6&+(' 63(&6

Volume 2 - Team Illinoize - Page 19

FUME HOOD - SEE SPECS

STRUCTURAL WALL WITH RECLAIMED WOOD FINISH - SEE MATERIAL SPECS

7'-11 1/2"

3'-1 1/2"

1'-11"

5'-9 1/4" 3'-1 1/2"

1'-9"

4'-0 1/2"

HIGH PERFORMANCE WEATHERSTRIPPING

2'-10"

4'-2"

1'-8" 1'-8" 1'-8"

21'-1 1/2"

PATIO DOOR ELEVATION

KITCHEN INTERIOR ELEVATION SCALE = 1/2" = 1'-0"U.N.O

10'-6" 7'-4 3/4"

7'-0" 10'-6"

7'-0"

SCALE = 1/2" = 1'-0"U.N.O

10'-6"

1'-8" 1'-8" 1'-8"

10'-6" 7'-4 3/4"

4" VINYL BASEBOARD

UNIVERSITY OF ILLINOIS AT URBANA-CHAMPAIGN ATTACHED HOUSING

[INSERT PROJECT NAME]

2'-4 1/4"

3'-6"

1'-11 1/2"

3'-6 1/2"

9'-9 1/2"

63 E. DANIEL ST. CHAMPAIGN, IL 61820

3'-1 1/4"

1'-9 1/4" 1'-2"

3'-6"

10'-6"

4'-8 3/4"

3'-1 1/2" 1'-11"

10'-6" 8'-2"

2'-4"

BACKSLASH TILE - SEE MATERIAL SPECS

3'-4"

2'-11"

3'-6 1/2"

3'-4"

9'-9 1/2"

2017 U.S. DEPARTMENT OF ENERGY RACE TO ZERO DESIGN COMPETITION DATE

ISSUED FOR:

1/21/2017

INITIAL CONSTRUCTION SET

X/X/2017

KITCHEN ISLAND ELEVATIONS SCALE = 1/2" = 1'-0"U.N.O

DIMENSIONING NOTES: B.01

UNLESS NOTED OTHERWISE, PARTITIONS ARE DIMENSIONED TO THE FINISH FACE OF THE WALL.

B.02

ALL DIMENSIONS SHALL BE VERIFIED IN THE FIELD BEFORE PROCEEDING WITH THE WORK. THE ARCHITECT SHALL BE NOTIFIED OF ANY CORRECTION.

B.03

DOOR OPENINGS ARE GENERALLY DIMENSIONED TO CENTERLINE OF OPENING. DOOR OPENINGS THAT ARE NOT DIMENSIONALLY LOCATED ARE TO BE CENTERED BETWEEN WALLS OR POSITIONED WITH ONE JAMB AGAINST AN ADJACENT WALL OR COLUMN AS SHOWN ON THE PLANS. ALL DIMENSIONS SHALL BE VERIFIED AND COORDINATED WITH THE WORK OF ALL TRADES

B.04

ILLINOIS SOLAR DECATHLON TEAM ILLINOISE RACE TO ZERO 2017 PROJ # 3

SCALE: AS INDICATED

DN. BY: Team ILLINOISE

CK. BY:

INTERIOR KITCHEN ELEVATIONS

A601 Volume 2 - Team Illinoize - Page 20

9,000 kBTU DUCTLESS MINI-SPLIT UP

3/8"∅ COPPER REFRIGERANT GAS PIPES 1/4"∅ COPPER REFRIGERANT LIQUID PIPES

3/8"∅ COPPER REFRIGERANT GAS PIPES

DW D

REF.

1"∅ PVC CONDENSATE PIPES

DW REF.

1/4"∅ COPPER REFRIGERANT LIQUID PIPES

[1]

UNIVERSITY OF ILLINOIS AT URBANA-CHAMPAIGN ATTACHED HOUSING 9,000 kBTU DUCTLESS MINI-SPLIT

REVERB 63 E. DANIEL ST. CHAMPAIGN, IL 61820

2017 U.S. DEPARTMENT OF ENERGY RACE TO ZERO DESIGN COMPETITION

SLOPE: 1/12 MAX

DATE

ISSUED FOR:

1/21/2017

INITIAL CONSTRUCTION SET

X/X/2017

SLOPE: 1/12 MAX

DN SLOPE: 1/12 MAX

SLOPE: 1/12 MAX

ILLINOIS SOLAR DECATHLON TEAM ILLINOISE RACE TO ZERO 2017 UP

PROJ # 3

SCALE: AS INDICATED

DN. BY: Team ILLINOISE

FIRST FLOOR MECH. PIPING PLAN SCALE = 3/16" = 1'-0"

FIRST FLOOR DUCTWORK PLAN SCALE = 3/16" = 1'-0"

CK. BY:

MECHANICAL LAYOUT - 1ST FLOOR

M101 Volume 2 - Team Illinoize - Page 21

10"x6" WALL REGISTER

6"∅ DUCTS

9,000 BTU DUCTED MINI-SPLIT DN

CEILING GRILLE MINI-SPLIT

1/4"∅ COPPER REFRIGERANT LIQUID PIPES 3/8"∅ COPPER REFRIGERANT GAS PIPES [1]

1"∅ PVC CONDENSATE PIPES 1/4"∅ COPPER REFRIGERANT LIQUID PIPES 3/8"∅ COPPER REFRIGERANT GAS PIPES

[2]

UNIVERSITY OF ILLINOIS AT URBANA-CHAMPAIGN

1"∅ PVC CONDENSATE PIPES

ATTACHED HOUSING

REVERB [2]

63 E. DANIEL ST. CHAMPAIGN, IL 61820

CEILING GRILLE MINI-SPLIT

2017 U.S. DEPARTMENT OF ENERGY RACE TO ZERO DESIGN COMPETITION

9,000 BTU DUCTED MINI-SPLIT 6"∅ DUCTS 10"x6" WALL REGISTER

DATE

ISSUED FOR:

1/21/2017

INITIAL CONSTRUCTION SET

X/X/2017

ILLINOIS SOLAR DECATHLON TEAM ILLINOISE RACE TO ZERO 2017 PROJ # 3

SCALE: AS INDICATED

DN. BY: Team ILLINOISE

SECOND FLOOR MECH. PIPING PLAN SCALE = 3/16" = 1'-0"

SECOND FLOOR DUCTWORK PLAN SCALE = 3/16" = 1'-0"

CK. BY:

MECHANICAL LAYOUT - 2ND FLOOR

M102 Volume 2 - Team Illinoize - Page 22

UNIVERSITY OF ILLINOIS AT URBANA-CHAMPAIGN ATTACHED HOUSING

REVERB 63 E. DANIEL ST. CHAMPAIGN, IL 61820

2017 U.S. DEPARTMENT OF ENERGY RACE TO ZERO DESIGN COMPETITION DATE

ISSUED FOR:

1/21/2017

INITIAL CONSTRUCTION SET

X/X/2017

ILLINOIS SOLAR DECATHLON TEAM ILLINOISE RACE TO ZERO 2017 PROJ # 3

SCALE: AS INDICATED

DN. BY: Team ILLINOISE

ROOF MECHANICAL PLAN SCALE = 3/16" = 1'-0"

CK. BY:

MECHANICAL LAYOUT ROOFDECK

M103 Volume 2 - Team Illinoize - Page 23

ELECTRICAL GENERAL NOTES ELECTRICAL SUB-CONTRACTORS AND G.C. SHALL COORDINATE AND REVIEW THE ARCHITECTURAL RCPS AND ELECTRICAL PLANS TO FAMILIARIZE THEMSELVES WITH THE SCOPE OF WORK AND VERIFY EXACT LOCATIONS OF ALL CEILING MOUNTED FIXTURES AND DEVICES WITH MECHANICAL SYSTEMS PRIOR TO STARTING WORK. ANY VARIATIONS CONFLICTS OR UNCLEAR ITEMS SHALL BE SUBMITTED FOR REVIEW BY THE ARCHITECT AND G.C. EACH SERVICE DISCONNECT SHALL BE PERMANENTLY MARKED AND CLEAR TO IDENTIFY AS A SERVICE DISCONNECT. BRANCH CIRCUITS THAT SUPPLY 120 VOLTS SINGLE PHASE 15 AND 20 AMPERE OUTLETS INSTALLED IN BEDROOMS SHALL BE PROTECTED BY AN ARC-FAULT CIRCUIT INTERRUPTER LISTED TO PROVIDE PROTECTION FOR THE ENTIRE CIRCUIT. PROVIDE AFCI BREAKER IN PANEL. SMOKE AND CARBON MONOXIDE DETECTORS SHALL BE LINE VOLTAGE AND WIRED TOGETHER, RESPECTIVELY. SMOKE DETECTORS SHALL BE INSTALLED IN AND WITHIN 15 FEET OF ROOMS USED FOR SLEEPING PURPOSES, WITH NOT LESS THAN ONE PER LEVEL CONTAINING HABITABLE ROOMS OR UNENCLOSED HEATING PLANT SYSTEMS. CLOSETS HAVING A MINIMUM AREA OF 8 SQ FT SHALL HAVE A LIGHTING OUTLET INSTALLED. DN

ALL WALL SWITCHES NOT TO EXCEED 48" ABOVE FINISHED FLOOR, MEASURING TO CENTER OF SWITCH.

WIRE FOR LAN CABLE/SATELLITE, CAT 6 AND TELEPHONE SERVICE. BRING ALL HOME RUNS BACK TO DEDICATED LOW VOLTAGE PANEL BOARD. ALL COUNTERTOP OUTLETS IN KITCHENS, BATHROOMS AND WITHIN 4 FEET OF A WATER SOURCE SHALL BE GROUND-FAULT CIRCUIT INTERRUPTED TYPE OUTLETS.

ALL RECESSED CANS TO BE IC/AT RATED.

REF.

ALL EXTERIOR ELECTRICAL DEVICES SHALL BE WEATHER PROOF AND ALL EXTERIOR LIGHTING SHALL INCORPORATE FULL CUTOFF LIGHTING FIXTURES.

ALL 120-VOLT SINGLE PHASE, 15 AND 20 AMPERE â&#x20AC;&#x201D; OUTLETS, ELECTRICAL EQUIPMENT, LIGHT FIXTURES AND FANS IN ALL BATHROOMS SHALL BE INSTALLED WITH GFCI PROTECTION.

ALL ELECTRIC BOXES, RECESSED FIXTURES AND OTHER WALL PENETRATIONS ON EXTERIOR WALLS TO BE FIRMLY ATTACHED AND GASKETED AND/OR CAULKED TO BACKSIDE OF DRYWALL TO ENSURE COMPLETE AIR TIGHTNESS.

UNIVERSITY OF ILLINOIS AT URBANA-CHAMPAIGN

ALL FIXTURES AND SWITCHPLATES TO INCLUDE AIR TIGHT GASKET.

ATTACHED HOUSING

ALL SWITCHES, OUTLETS & COVERPLATES TO BE WHITE, U.N.O.

REVERB

LIGHTING & ELECTRICAL NOTES: 1) ALL RECESSED CANS TO BE IC/AT RATED. 2) 80% OF ALL LAMPS TO BE LED OR FLUORESCENT ENERGY STAR RATED. 3) 4) ALL ELECTRIC BOXES, RECESSED FIXTURES AND OTHER WALL PENETRATIONS ON EXTERIOR WALLS TO BE FIRMLY ATTACHED AND GASKETED AND/OR CAULKED TO BACKSIDE OF DRYWALL TO ENSURE COMPLETE AIR TIGHTNESS. 5) ALL FIXTURES AND SWITCHPLATES TO INCLUDE AIR TIGHT GASKET. 6) ALL SWITCH & COVERPLATES TO BE WHITE, U.N.O. ALL SWITCHES & DIMMERS TO BE DECORA SERIES. 7) 'WP' LIGHT FIXTURES TO RECEIVE WATER PROOF TRIM KIT

63 E. DANIEL ST. CHAMPAIGN, IL 61820

2017 U.S. DEPARTMENT OF ENERGY RACE TO ZERO DESIGN COMPETITION

WALL SWITCH, +48" AFF, UON SUBSCRIPT INDICATES SWITCH CONTROL "D" - DIMMER SWITCH "3" - THREE WAY TOGGLE SWITCH "4" - FOUR WAY TOGGLE SWITCH "T" - TIME DELAY SWITCH

DATE

ISSUED FOR:

1/21/2017

INITIAL CONSTRUCTION SET

X/X/2017

SLOPE: 1/12 MAX

DUPLEX RECEPTACLE, +15" AFF, UON SUBSCRIPT INDICATES FUNCTION "WP" - WATERPROOF "AFCI" - ARC FAULT CIRCUIT INTERRUPTER "GFI" - GROUND FAULT INTERRUPTER

DN SLOPE: 1/12 MAX

ILLINOIS SOLAR DECATHLON TEAM ILLINOISE RACE TO ZERO 2017

PROJ # 3

SCALE: AS INDICATED

DN. BY: Team ILLINOISE

FIRST FLOOR ELECTRICAL PLAN SCALE = 1/4" = 1'-0"U.N.O

SECOND FLOOR ELECTRICAL PLAN SCALE = 1/4" = 1'-0"U.N.O

CK. BY:

ELECTRICAL PLAN

E101 Volume 2 - Team Illinoize - Page 24

[1 ] [2 ]

- HW & CW LINES RUN UNDER FLOOR SEE P-602 - WATERLESS URINAL U-1 DOES NOT REQUIRE SUPPLY

GENERAL NOTES A. ALL PLUMBING SHALL BE IN ACCORDANCE WITH 2014 INTERNATIONAL RESIDENTIAL CODE B. REFER TO ARCHITECTURAL DRAWINGS FOR EXACT HEIGHTS AND LOCATIONS OF WATER FIXTURES AND APPLIANCES C. ALL PIPING ABOVE GRADE SHALL BE SUPPORTED FROM BUILDING STRUCTURE. D. WATER PIPING SHALL BE LOCATED IN DROPPED CEILING OR WITHIN FURRED OUT SPACE AT EXTERIOR WALL LOCATIONS. SEE P101 FOR EXTERIOR WALL LOCATIONS.

F. FLOOR DRAINS, SHOWER DRAINS AND CLEANOUTS SHALL BE FLUSH WITH THE FLOOR. G. CONTRACTOR SHALL FOLLOW BUILDING CODE H. CONTRACTOR SHALL FOLLOW THE MANUFACTURES HANDLING AND INSTALLATION INSTRUCTIONS I. NOT ALL CONNECTIONS AND COMPONENTS ARE SHOWN ON DRAWINGS, CONTRACTOR SHALL PERFORM ALL NECESSARY MODIFICATIONS IN ORDER TO COMPLY WITH BUILDING CODES J. ALL VENT PIPING SHALL CONVERGE ABOVE HIGHEST WATER LEVEL OF RELEVANT FIXTURES

1/2" HW & CW TO KS-1 K. THE AREA OF COMBINED GREYWATER AND WASTE DISCHARGE MUST BE SIMILAR TO EXITING VENT AREA

1/2" HW & CW TO S-1

[1]

DW REF.

1/2" HW FROM KS-1

1/2" HW & CW TO W/D

1/2" CW TO REF.

1/2" HW & CW TO SH-1

1/2" CW TO WC-1

24 PORT PEX MANIFOLD

UNIVERSITY OF ILLINOIS AT URBANA-CHAMPAIGN

1/2" CW TO WC-1 1/2" HW UP TO 2ND FL.

1/2" CW UP TO 2ND FL.

ATTACHED HOUSING

ABBREVIATIONS

REVERB 1/2" HW & CW TO S-1

1/2" HW & CW TO SH-1

1/2" CW TO WC-1

CD - CONDENSATE

1/2" HW & CW TO S-1

63 E. DANIEL ST. CHAMPAIGN, IL 61820

CW - DOMESTIC COLD WATER FCO - FLOOR CLEAN OUT

2017 U.S. DEPARTMENT OF ENERGY RACE TO ZERO DESIGN COMPETITION

FD - FLOOR DRAIN

[2]

GW - GREYWATER HW - DOMESTIC HOT WATER V - VENT VTR - VENT TO ROOF

DATE

ISSUED FOR:

1/21/2017

INITIAL CONSTRUCTION SET

X/X/2017

W - WASTE

SLOPE: 1/12 MAX

DN SLOPE: 1/12 MAX

ILLINOIS SOLAR DECATHLON TEAM ILLINOISE RACE TO ZERO 2017 PROJ # 3

FIRST FLOOR PLUMBING SUPPLY SCALE = 3/16" = 1'-0"

SCALE: AS INDICATED

DN. BY: Team ILLINOISE

SECOND FLOOR PLUMBING SUPPLY SCALE = 3/16" = 1'-0"

CK. BY:

PLUMBING SUPPLY

P101 Volume 2 - Team Illinoize - Page 25

UNIVERSITY OF ILLINOIS AT URBANA-CHAMPAIGN ATTACHED HOUSING

REVERB 63 E. DANIEL ST. CHAMPAIGN, IL 61820

2017 U.S. DEPARTMENT OF ENERGY RACE TO ZERO DESIGN COMPETITION DATE

ISSUED FOR:

1/21/2017

INITIAL CONSTRUCTION SET

X/X/2017

ILLINOIS SOLAR DECATHLON TEAM ILLINOISE RACE TO ZERO 2017 PROJ # 3

SCALE: AS INDICATED

DN. BY: Team ILLINOISE

SECOND FLOOR PLUMBING RETURN SCALE = 3/16" = 1'-0"

CK. BY:

PLUMBING SUPPLY

P102 Volume 2 - Team Illinoize - Page 26

SUPPLY RISER DIAGRAM SCALE = N.T.S

UNIVERSITY OF ILLINOIS AT URBANA-CHAMPAIGN ATTACHED HOUSING

REVERB 63 E. DANIEL ST. CHAMPAIGN, IL 61820

2017 U.S. DEPARTMENT OF ENERGY RACE TO ZERO DESIGN COMPETITION DATE

ISSUED FOR:

1/21/2017

INITIAL CONSTRUCTION SET

X/X/2017

ILLINOIS SOLAR DECATHLON TEAM ILLINOISE RACE TO ZERO 2017 PROJ # 3

RETURN RISER DIAGRAM SCALE = N.T.S

SCALE: AS INDICATED

DN. BY: Team ILLINOISE

CK. BY:

SUPPLY AND RETURN RISER

P602 Volume 2 - Team Illinoize - Page 27

11' - 6"

10' - 0"

8' - 0"

10' - 0"

7' - 1 13/16"

14' - 4 3/16"

58' - 0 1/2"

14' - 4 3/16"

81,9(56,7< 2) ,//,12,6 $7 85%$1$ &+$03$,*1 $77$&+(' +286,1*

5(9(5% ( '$1,(/ 67 &+$03$,*1 ,/

8 6 '(3$570(17 2) (1(5*< 5$&( 72 =(52 '(6,*1 &203(7,7,21 '$7(

,668(' )25

,1,7,$/ &216758&7,21 6(7

),1$/ &216758&7,21 6(7

),1$/ 68%0,77$/6

7' - 11 3/8"

7-/ :22' 23(1 :(% -2,67 # 2 &

,//,12,6 62/$5 '(&$7+/21 7($0 ,//,12,6( 5$&( 72 =(52 83 3URMHFW 1XPEHU

6FDOH

'1 %< 7HDP ,//,12,6(

&. %<

)281'$7,21 $1' ),567 )/225

% )281'$7,21

),567 )/225

6 Volume 2 - Team Illinoize - Page 28

18' - 0" 2' - 0"

7-/ :22' 23(1 :(% -2,67 # 2 &

7-/ :22' 23(1 :(% -2,67 # 2 & 72 $//2: &/($5$1&( )25 0(&+$1,&$/ (48,30(17

81,9(56,7< 2) ,//,12,6 $7 85%$1$ &+$03$,*1

52' - 6"

$77$&+(' +286,1* 7-/ :22' 23(1 :(% -2,67 # 2 &

5(9(5% ( '$1,(/ 67 &+$03$,*1 ,/

8 6 '(3$570(17 2) (1(5*< 5$&( 72 =(52 '(6,*1 &203(7,7,21 7-/ :22' 23(1 :(% -2,67 # 2 &

'$7(

,668(' )25

,1,7,$/ &216758&7,21 6(7

),1$/ &216758&7,21 6(7

),1$/ 68%0,77$/6

,//,12,6 62/$5 '(&$7+/21 7($0 ,//,12,6( 5$&( 72 =(52 3URMHFW 1XPEHU

6FDOH

'1 %< 7HDP ,//,12,6(

&. %<

6(&21' )/225 $1' 522) '(&.

6(&21' )/225

522) '(&.

6 Volume 2 - Team Illinoize - Page 29

INDOOR AIR QUALITY

HRV / ERV

HEALTHY CLIMATE

ÂŽ

Heat / Energy Recovery Ventilator Bulletin No. 210528 March 2017

P R O D U C T S P E C I F I C AT I O N S

Supersedes May 2016

FEATURES CONTENTS Application Map ........................................................... 7 Blower Data ............................................................... 13 Dimensions - Accessories.......................................... 15 Dimensions - Unit ...................................................... 14 Electrical Data............................................................ 10 Features....................................................................... 2 0RGHO 1XPEHU ,GHQWLÂżFDWLRQ ........................................ 1 Optional Accessories ................................................. 12 6SHFLÂżFDWLRQV ERV .................................................. 11 6SHFLÂżFDWLRQV HRV ................................................. 10 System Sizing .............................................................. 8 Typical System Applications ...................................... 16

HRV5-150

ERV3-150, -200

WARRANTY

HRV3-195, -300

Certain models have earned the (ŕś&#x2013;ŕś?ŕś&#x161;ŕś?ŕśĄ 6ŕś&#x153;ŕś&#x2030;ŕś&#x161;ÂŽ PDUN E\ PHHWLQJ VWULFW HQHUJ\ HIÂżFLHQF\ guidelines set by Natural Resources Canada and the US EPA. These models meet ENERGY STAR requirements only when used in Canada.

MODEL NUMBER IDENTIFICATION

HRV 5 - 200 - TPD Unit Type HRV = Heat Recovery Ventilator ERV = Energy Recovery Ventilator

Defrost Type (Certain Models) TPD = Top Port Damper Defrost TPF = Top Port Fan Defrost

Generation 3 = 3rd Generation 5 = 5th Generation

HRV Heat Recovery Ventilators (HRV) provide fresh, clean outdoor air with an energy saving temperature recovery of up to 90%. HRVâ&#x20AC;&#x2122;s are recommended in regions where normal humidity levels occur. See Application Map on page 7.

ERV Enthalpic Core - Limited ten year warranty in residential applications, one-year in non-residential.

Intake and exhaust air passes through a patented thermally conductive aluminum core where heat is transferred from exhaust air to incoming air.

APPROVALS $OO XQLWV DUH &6$ FHUWLÂżHG WR 8/ DQG &6$ 3HUIRUPDQFH LV FHUWLÂżHG E\ WKH +RPH 9HQWLODWLQJ Institute (HVI).

HRV3-095

APPLICATIONS See System Sizing section on page 8 to determine the right model for the desired application. If use of +59 (59 ZLWK D GHKXPLGLÂżHU DQG +(3$ &DUERQ Filtration for optimal Indoor Air Quality (IAQ) is desired, see Lennox Service & Application Notes â&#x20AC;&#x153;HEPA )LOWUDWLRQ ZLWK 2XWGRRU $LU DQG D 'HKXPLGLÂżHUÂ´

HRV Aluminum Core - Limited lifetime warranty in residential applications, one-year in non-residential.

All other covered components - /LPLWHG ÂżYH \HDU warranty in residential applications, one-year in nonresidential. 5HIHU WR /LPLWHG :DUUDQW\ &HUWLÂżFDWH LQFOXGHG ZLWK WKH equipment for more details. HRV3-150-TPD/TPF, HRV5-200-TPD

INSTALLATION GUIDELINES Lennox recommends that the HRV/ERV unit be installed in a conditioned space. If the unit is installed above a ceiling a separate, secondary drain pan should also be installed under the unit. If the unit is installed in an unconditioned area condensate lines must be protected against freezing temperatures.

Units conform to the Canadian Home Buildersâ&#x20AC;&#x2122; Association R-2000 Standard and meet Heating, Refrigeration and Air Conditioning Institute of Canada (HRAI) standards. All units conform to CAN/ULC-S110-M1986 for non FRPEXVWLEOH PDWHULDO DQG &$1 8/& 6 0 IRU Ă&#x20AC;DPH VSUHDG UDWLQJ DQG VPRNH GHYHORSHG FODVVLÂżFDWLRQ Certain models have earned the ENERGY STARÂŽ E\ PHHWLQJ VWULFW HQHUJ\ HIÂżFLHQF\ JXLGHOLQHV VHW E\ Natural Resources Canada and the US EPA. These models meet ENERGY STAR requirements only when XVHG LQ &DQDGD 6HH 6SHFLÂżFDWLRQV WDEOH IRU TXDOLÂżHG models. ISO 9001 Registered Manufacturing Quality System. 8QLWV DUH FRPSOHWHO\ ZLUHG DQG LQFOXGH ÂżOWHUV

NOTE - HRV3-150-TPD, HRV3-150-TFP and HRV5200-TPD are top port models with four oval collars. TPD models have a top port damper defrost, TPF models have a top port fan defrost. See dimension drawings for additional information. ERV Energy Recovery Ventilators (ERV) provide fresh clean outdoor air while reducing humidity levels at the same time. ERVâ&#x20AC;&#x2122;s are recommended in regions where high outdoor humidity levels occur. Not recommended where outdoor temperatures fall below 25Â°F continuously for more than ÂżYH GD\V 6HH $SSOLFDWLRQ 0DS RQ page 7. Intake and exhaust air passes through an enthalpic core where heat is transferred from exhaust air to incoming air and moisture is reduced. HRV / ERV Centrifugal blowers bring in fresh outdoor air while at the same time exhausting an equal amount of stale indoor air. A duct system distributes the fresh air and collects the stale air for removal from the building. 6\VWHP DLUĂ&#x20AC;RZ PXVW EH EDODQFHG IRU PD[LPXP HIÂżFLHQF\ 5HIHU WR ,QVWDOODWLRQ ,QVWUXFWLRQV IRU V\VWHP DLU Ă&#x20AC;RZ EDODQFLQJ GHWDLOV

Number of Cores 095 = Single Core 150 = Single Core 195 = Dual Core 200 = Single Core 300 = Dual Core ERV / HRV Recovery Ventilators / Page 2

FEATURES CORE ASSEMBLY HRV Patented Aluminum Core Aluminum plates have excellent heat transfer FKDUDFWHULVWLFV DUH QRQĂ&#x20AC;DPPDEOH FRUURVLRQ UHVLVWDQW and durable. Plates are mounted in plastic frame and are easily removable for cleaning. Opposed dimples pressed into each plate ensure proper separation within each core. Modular design ensures ease of service. ERV Enthalpic Core Enthalpic core has excellent latent and sensible heat WUDQVIHU FKDUDFWHULVWLFV DUH QRQĂ&#x20AC;DPPDEOH FRUURVLRQ resistant and durable. UL recognized component. Plates are mounted in a frame and are easily removable for cleaning. Modular design ensures ease of service. BLOWER Dual centrifugal type with single motor. Rubber insulated mounts furnished on all models. Blower motor housing design allows easy access for servicing. Multi-speed direct drive PSC motor (up to 5 speed settings with optional control). DEFROST (HRV ONLY) The HRV has an electronically controlled defrost mechanism. The defrost cycle is activated when the outdoor temperature drops below 27Â°F. Three recirculating defrost modes are available. Defrost run times vary based on incoming fresh air temperature. 1. At 27Â°F HRV runs in defrost for 3 minutes and runs in ventilation for 25 minutes 2. At -4Â°F HRV runs in defrost for 4.5 minutes and runs in ventilation for 17 minutes 3. At -31Â°F HRV runs in defrost for 7 minutes and runs in ventilation for 15 minutes No remote device can override this defrost mode or selected speed until the cycle is complete. After the defrost cycle is complete the HRV defaults to previous settings. If the cycle is complete and the thermistor continues to measure defrost temperature the defrost cycle is repeated.

FEATURES Damper Defrost (HRV3-195, HRV3-300 Models) During defrost a motor driven damper door mechanism FORVHV RII WKH VXSSO\ DLU IURP RXWVLGH DOORZLQJ WKH ÂżIWK port to open, enabling warm room air to be drawn in from around the unit. During defrost cycle stale air exhaust is still occurring. After the defrost period, the damper operates in the opposite direction to reopen the fresh air port. Defrost cycle repeats until the temperature rises above 27Â°F. The defrost port can also be ducted to another location. Fan Defrost (HRV3-150-TPF) During the defrost cycle, the supply air motor shuts off, allowing the unit to operate in exhaust only mode. The warm exhaust air will defrost the core. After the defrost cycle has ended, the unit will resume normal operation. Defrost cycle repeats until the outdoor temperature rises above 27Â°F. CABINET Constructed of 20 gauge pre-painted quartz gray steel. Interior is lined with foil-faced polystyrene to eliminate noise, condensation and air loss. Cabinet is designed for structural strength and long life. Access panels are hinged, have quick release latches and can be completely removed for easy access to ÂżOWHUV DQG FRUH V IRU VHUYLFLQJ Safety interlock switch automatically shuts off power to unit when access panel is opened. Threaded inserts with screws are furnished on cabinet for hanging unit with furnished PVC reinforced polyester rubber straps. Condensate drain pans have drain connection (HRV models). System Balancing HRV3-150-TPD, HRV3-150-TPF, HRV5-150, HRV5200-TPD, ERV3-150 and ERV3-200 models include a patented, balancing damper located in the intake and exhaust air stream collar. HRV3-150-TPD, HRV3-150-TPF, HRV5-150 and HRV5200-TPD models include door port balancing capability. See installation instructions. HRV3-095, HRV3-195, HRV3-300 models requires DQ RSWLRQDO ÂżHOG LQVWDOOHG EXWWHUĂ&#x20AC;\ GDPSHU IRU V\VWHP balancing. See Optional Accessories.

AIR FILTER 0(59 DLU ÂżOWHUV DUH IXUQLVKHG LQ ERWK H[KDXVW DQG intake air streams. )RDP ÂżOWHUV DUH HDVLO\ UHPRYHG IRU FOHDQLQJ 'HVLJQ DQG ORFDWLRQ RI ÂżOWHUV DOORZV PD[LPXP ÂżOWUDWLRQ with minimum air resistance. ELECTRICAL Control Box Contains control circuit board and auto-transformer. Plug-in Electrical Connection Convenient 36 inch (approx. length) power cord with 3-prong 120VAC plug provided for easy electrical connection. CONTROLS Circuit Board Circuit board controls unit operation. Two jumpers furnished on control board. One jumper enables/disables recirculating mode. One jumper overrides normal defrost settings (setting: 27Â°F /3 min. recirculate, 25 min. ventilation). 8S WR ÂżYH EORZHU VSHHGV DQG IRXU PRGHV RI RSHUDWLRQ are available with optional wall mount controls. Self-Test When unit is energized, the HRV/ERV cycles through all speeds available, tests damper motor operation, and returns to the previous operational mode and speed selection.

Terminal Block Control Board is wired to external terminal block located on side of unit. Terminal block allows connection to various wall mount controls. See Optional Accessories for complete listing. Terminal block also allows interlock control connection to furnace or air handler. Healthy ClimateÂŽ Wall Mount 2 Speed Dehumidistat/ Ventilation Control Furnished with HRV/ERV units (non-GDX models only). NOTE - All GDX models (Canada only) include the Digital 5 Speed / 4 Mode Control furnished as standard. See next page for description. â&#x20AC;˘ ON/OFF button with indicator LED â&#x20AC;˘ Dehumidistat with graduated LED indicators (20 to 60% relative humidity) â&#x20AC;˘ Fan Speed button for High, Low and Standby â&#x20AC;˘ Compatible with Wireless 20 / 40 / 60 Minute Timer â&#x20AC;˘ 3-wire, 20-gauge (min.), low-voltage wire connection â&#x20AC;˘ Designed to be mounted in a standard 2 x 4 in. electrical box or surface mounted to a wall

Dehumidistat Disable Feature The dehumidistat function will be disabled if the outdoor temperature exceeds 59Â°F for a 24-hour period. The dehumidistat function will be re-enabled if the unit is unplugged for 3 minutes or if the outdoor temperature drops below 59Â°F for a 24-hour period. Permanently enabled on ERV units. Furnace/Air Handler Interlock Capability Built-in function on circuit board allows unit to operate whenever furnace or air handler is operating. Refer to Installation Instructions for interlocking unit to furnace or air handler.

Recirculating Damper Defrost (HRV3-095, HRV3-150TPD, HRV5-150, HRV5-200-TPD) During defrost a motor driven damper door mechanism closes off the supply air from outside allowing exhaust air to recirculate through the unitâ&#x20AC;&#x2122;s core. During defrost cycle no ventilation is occurring. After the defrost period, the damper operates in the opposite direction to reopen the fresh air port. Defrost cycle repeats until the temperature rises above 27Â°F. ERV / HRV Recovery Ventilators / Page 3

ERV / HRV Recovery Ventilators / Page 4

Volume 2 - Team Illinoize - Page 30

OPTIONAL ACCESSORIES (MUST BE ORDERED SEPARATELY)

OPTIONAL ACCESSORIES (MUST BE ORDERED SEPARATELY) CONTROLS Healthy ClimateÂ® Digital 5 Speed / 4 Mode Dehumidistat/Ventilation Control Fully digital control determines when and how much fresh air will enter the home.

â&#x20AC;¢ 5-speed blower setting â&#x20AC;¢ Standby setting (blower speed 0) â&#x20AC;¢ Electronic dehumidistat â&#x20AC;¢ Five selectable modes of operation: 1. Continuous Ventilation 2. 2 20 min. Ventilation / 40 min. Recirculation 3. 20 min. Ventilation / 40 min. Off 4. 10 min. Ventilation / 50 min. Off 5. 2 Continuous Recirculation â&#x20AC;¢ 20 / 40 / 60 high speed override button â&#x20AC;¢ Compatible with Wireless 20 / 40 / 60 Minute Timer â&#x20AC;¢ Instruction card inserted in control â&#x20AC;¢ Easy-to-read backlit LCD screen â&#x20AC;¢ Service Indicator â&#x20AC;¢ 3-wire, 20-gauge (min.), low-voltage wire connection â&#x20AC;¢ Slim-line design 1

Furnished as standard with all GDX (Canada only) models.

NOTE - Recirculation mode not available on all models.

Healthy ClimateÂ® Wired 20 / 40 / 60 Minute Timer Remotely located timer allows 20, 40 or 60 minute operation. â&#x20AC;¢ One-touch button activates high speed â&#x20AC;¢ 3 indicator LEDâ&#x20AC;&#x2122;s show timer status â&#x20AC;¢ Lockout feature eliminates tampering â&#x20AC;¢ 3-wire, 20-gauge (min.), low-voltage wire connection â&#x20AC;¢ Installs in a standard 2 x 4 in. electrical box

Healthy ClimateÂ® Wireless 20 / 40 / 60 Minute Timer Remotely located timer allows 20, 40 or 60 minute wireless operation when paired with the Wall Mount Dehumidistat/Ventilation Control or the Digital 5 Speed / 4 Mode Control. â&#x20AC;¢ 40 ft. range â&#x20AC;¢ One-touch button activates high speed â&#x20AC;¢ 3 indicator LEDâ&#x20AC;&#x2122;s show timer status â&#x20AC;¢ No wiring, timer is paired with the main control â&#x20AC;¢ Multiple timers can be paired to a single main control â&#x20AC;¢ Designed to be mounted in a standard 2 x 4 in.electrical box or surface mounted to a wall â&#x20AC;¢ Battery (CR2450) lithium button type is furnished. Healthy ClimateÂ® Wireless Repeater The Wireless Repeater is used to extend range of the Wireless Timer. â&#x20AC;¢ Installed halfway in-between the Wireless Timer and the main control if the timer is out of range â&#x20AC;¢ Plugs directly into a 120V power outlet â&#x20AC;¢ LED indicates connection status: â&#x20AC;¢ Green = Connected to the wall control â&#x20AC;¢ Flashing = Moderate connection to the wall control â&#x20AC;¢ Red = No connection to the wall control â&#x20AC;¢ Multiple Repeaters can be paired to a single main control AIR BALANCING TOOLS Optional Accessories %XWWHUÃ&#x20AC;\ %DODQFLQJ 'DPSHU 6 or 7 in. diameter.

Backdraft Damper 5 or 6 in. diameter. Spring-loaded damper is installed on the Stale Air to Outside ducting. See System Applications.

Door Port Gauge Tube Set (HRV3-150-TPD/TPF, HRV5-150, HRV5-200-TPD Models Only) Includes two connection hoses and WZR UXEEHU Â¿WWLQJV and instructions. Magnehelic gauge or digital manometer (reading down to 0 with resolution RI LQ Z J LV QRW IXUQLVKHG DQG PXVW EH Â¿HOG supplied.

ERV / HRV Recovery Ventilators / Page 5

APPLICATION MAP

AIR BALANCING TOOLS (continued)

Round Diffusers White molded plastic grilles are available for room air distribution. Grilles are adjustable for room to room system balancing. Compression spring tab clips into round duct. Available in 4, 5, 6 and 8 inch diameters.

Digital Manometer Measures positive, negative or differential SUHVVXUHV RI DLU DQG JDVVHV 5DQJH Â´ w.c., max. pressure 5 psig. Large easy to read LCD display. Lightweight, extruded aluminum case. Standard 9-volt battery operation (furnished). Low battery indicator. Piezoresistive pressure sensor Standard dual size connectors (1/8 in. or 3/16 in.)

Weatherhood Kit Two furnished per kit, one for intake air and one for exhaust air. /DEHOHG IRU HDV\ LGHQWLÂ¿FDWLRQ

DUCTWORK

Fully adjustable for different wall thickness. Complete with 1/4 in. mesh bird screen, two 12 in. sleeves with insulating duct collars. Hinged hood allows easy cleaning of screen. :KLWH Â¿QLVK $YDLODEOH LQ DQG LQFK GLDPHWHUV

Optional Accessories Duct Heaters Duct heaters are available to temper incoming fresh air after heat recovery. Heaters have built-in electronic modulating controller DQG DLU Ã&#x20AC;RZ WHPSHUDWXUH VHQVRU WR proportionally adjust the heating load to match the exact capacity required while minimizing operating costs. Available in 6 inch (1 or 2 kW) and 7 inch (2 kW) diameter sizes.

Dual Hood Dual Hood only requires a single 6 inch diameter penetration in the exterior wall for the fresh air intake and stale air exhaust connections. Stale air is exhausted from the front of the hood while fresh air intake is from the bottom of the hood. See dimension drawing on page 15.

Voltage/Phase - 120/1. H x W x L - 8-1/2 x 11-1/2 x 12-1/2 in.

See pressure drop charts on page 12.

Flexible Ducts - Insulated or Non-Insulated Non-insulated ducts are available for connection to optional circular grilles. Constructed of aluminum foil/ polyester laminate and metalized SRO\HVWHU Â¿OP DURXQG D VWHHO ZLUH helix. )XOO\ LQVXODWHG Â¿EHUJODVV GXFWV KDYH DQ Â³5Â´ YDOXH RI 5.8 and are available for connection to optional outside weatherhoods. Available for inside use in standard 3 to 10 in. diameters and 25 ft. lengths. Underwriterâ&#x20AC;&#x2122;s Laboratories Canada (ULC) listed Class 1 Duct. Hinged Kitchen Exhaust Grille Louvered panel is hinged for easy access to washable aluminum grease Â¿OWHU Size - 6 x 10 in. in white.

ERV / HRV Recovery Ventilators / Page 6

SYSTEM SIZING SIZING A CENTRAL VENTILATION SYSTEM The HRV and ERV is part of a central ventilation system. The system can include multiple fans such as kitchen range hoods and bathroom exhaust fans in addition to the HRV or ERV. An HRV can be used in place of a bathroom exhaust fan and provide supplemental ventilation in the kitchen (it cannot be used as a range hood). Therefore determining the required Ventilation CFM will depend on the application and standard/method used for calculation. Method #1

Severe Conditions

Size the HRV/ERV to provide 1/3 air change per hour - International Residential Code (IRC) 2006 7KLV PHWKRG UHTXLUHV GHWHUPLQLQJ WKH YROXPH RI WKH KRPH DQG WKHQ SURYLGLQJ HQRXJK DLU Ã&#x20AC;RZ WR KDYH RQH FRPSOHWH DLU change every 3 hours. ([DPSOH $ KRPH KDV VTXDUH IHHW RI FRQGLWLRQHG Ã&#x20AC;RRU VSDFH DQG IW FHLOLQJV 7KH YROXPH LV [ FXELF IHHW 7R REWDLQ UHTXLUHG DLUÃ&#x20AC;RZ LQ &)0 PXOWLSO\ E\ DQG GLYLGH E\ PLQXWHV KRXU 5HTXLUHG DLUÃ&#x20AC;RZ FIP FX IW ; $&+ PLQXWHV KU FIP Method #2 8VH D 5RRP &RXQW WR Â¿QG WKH UHTXLUHG DLUÃ&#x20AC;RZ &6$ ) Determine the number of bedrooms and add 1. Multiply this by 10 cfm. An additional 10 cfm is required for every other URRP LQ WKH KRXVH $Q XQLÂ¿VKHG EDVHPHQW UHTXLUHV FIP Example: A home with 4 bedrooms, 2 bathrooms, living room, kitchen, dining room and basement requires 110 cfm.

Moderate Conditions

Method #3 ASHRAE (American Society of Heating Refrigeration and Air Conditioning Engineers) Standard 62.2 -2013 This standard describes the minimum ventilation required based on the ASHRAE 4.1a Quick Reference Chart. Example a 2000 square foot home with 4 bedrooms from ASHRAE 4.1 a quick reference chart predicts 98 CFM.

Pacific Conditions Extreme Areas of High Humidity Arid Zone â&#x2C6;&#x2019; Dry Climate

Method #4 Home Ventilating Institute (HVI): +9, UHFRPPHQGV XVLQJ WKH PLQLPXP YHQWLODWLRQ UDWH DV VSHFLÂ¿HG E\ $6+5$( DQG DGGLQJ FIP VT IW RI Ã&#x20AC;RRU DUHD Example a 2000 square foot home with 4 bedrooms from ASHRAE 4.1a Quick Reference Chart predicts 98 CFM + 40 CFM = 138 CFM.

Severe Conditions HRV Required

Moderate Conditions HRV Recommended

WHOLE BUILDING VENTILATION AIR REQUIREMENTS ASHRAE 4.1a (I-P) Quick Reference Chart Floor Area VT IW

Pacific Conditions HRV Recommended ERV Optional

Arid Zone â&#x2C6;&#x2019; Dry Climate HRV Recommended

* Extreme Areas of High Humidity ERV Recommended

<500 501 - 1000

No. of Bedrooms 1

cfm

1001 - 1500

1501 - 2000

105

2001- 2500

105

113

120

2501 - 3000

105

113

120

128

135

3001 - 3500

120

128

135

143

150

3501 - 4000

135

143

150

158

165

NOTE - ERV is not recommended where temperatures fall below 25Â°F continuously for more than 5 days.

4001 - 4500

150

158

165

173

180

*ERV is not recommended in regions where high outdoor humidity causes air conditioning operation for GHKXPLGLÂ¿FDWLRQ PRUH IUHTXHQWO\ WKDQ KHDWLQJ V\VWHP RSHUDWLRQ

4501 - 5000

165

173

180

188

195

ERV / HRV Recovery Ventilators / Page 7

ERV / HRV Recovery Ventilators / Page 8

Volume 2 - Team Illinoize - Page 31

SYSTEM SIZING

SPECIFICATIONS - HRV Model No.

Method #5

Custom method to achieve a target VOCâ&#x20AC;&#x2122;s level in homes 9HQWLODWLRQ RU VRXUFH FRQWURO PD\ EH UHTXLUHG DERYH WKH $6+5$( UDWHV LI WKHUH DUH VLJQLÂ¿FDQW VRXUFHV RU WR DFKLHYH VSHFLÂ¿F FRQFHQWUDWLRQ OHYHO V RI FKHPLFDO V RI LQWHUHVW >IRU LQVWDQFH DFKLHYLQJ uJ P3 of formaldehyde (HCHO) as recommended by the CDC/HUD and NIOSH for occupied trailers]. If ventilation rates other than mentioned above DUH GHVLUHG GHDOHUV PD\ ZLVK WR REWDLQ WKH VHUYLFHV RI D FHUWLÂ¿HG ,$4 FRQVXOWDQW WR REWDLQ JXLGDQFH DQG ODERUDWRU\ measurements of chemical(s) of concern both before and after installation and operation of additional ventilation to insure that the target concentration(s) of chemical(s) of concern are achieved. Dealers and homeowner need to be DZDUH WKDW UHDFKLQJ VSHFLÂ¿F FRQFHQWUDWLRQ WDUJHW V PD\ EH DQ LWHUDWLYH SURFHVV )RU LQVWDQFH LI WKHUH DUH PXOWLSOH furnace/air handlers in the home, ventilation may be added to one or more of the indoor units to start with, and if the desired level(s) of chemical(s) of concern are not obtained, additional ventilation can be added to the additional indoor units or more rigorous source control measures implemented (i.e. removing contaminant sources from the home). One option is to size the HRV/ERV based on low speed fan operation or 20 minute/hour operation to one of the above methods which will allow ventilation to be easily increased by changing a controller setting if desired. NOTE - Dealer should always calculate increased load requirement due to ventilation and insure that HVAC system is sized appropriately to handle both sensible (temperature) and latent (humidity) loads. 1RWH ,Q VRPH ORFDWLRQV D VWDQGDORQH GHKXPLGLÂ¿HU PD\ EH UHTXLUHG WR KDQGOH WKH LQFUHDVHG ODWHQW KXPLGLW\ ORDG WR prevent increased humidity in the home. SIZING A CENTRAL VENTILATION SYSTEM

No. of Cores ENERGY STARÂ® 4XDOLÂ¿HG &DQDGD 2QO\

Performance Sensible effectiveness @ 32Â°F 6HQVLEOH HIÂ¿FLHQF\ WKHUPDO # Â&#x192;) 6HQVLEOH HIÂ¿FLHQF\ WKHUPDO # Â&#x192;) Blower Air Flow (cfm) 0.1 in. w.g. 0.2 in. w.g. vs. Static Pressure 0.3 in. w.g. (high speed) 0.4 in. w.g. +9, &HUWLÂ¿HG

0.5 in. w.g. 0.6 in. w.g. 0.7 in. w.g. 0.8 in. w.g. Number of Speeds Available (with furnished control) Number of Speeds Available (with optional control) Defrost type Door Port Balancing Balancing Damper in Intake and Exhaust Collar Duct Connections (No.) & diameter - inch Ports Condensate drain (o.d.) - in. (includes tee) Shipping weight - lbs.

HRV5-150 HRV3-150-TPD HRV3-150-TPF HRV3-095 HRV3-095-GDX 1 HRV5-150-GDX 1 HRV3-150-TPD-GDX 1 HRV3-150-TPF-GDX Single Single Single Single Yes Yes No No 88% (60 cfm) 84% (59 cfm) 74% (66 cfm) 75% (66 cfm) 75% (60 cfm) 75% (59 cfm) 61% (66 cfm) 66% (66 cfm) 68% (61 cfm) 72% (64 cfm) 63% (76 cfm) 56% (76 cfm) 76 184 169 174 73 163 156 165 70 146 149 154 66 132 136 143 60 115 126 132 --92 116 120 --60 103 107 ----89 95 2 2 2 2 5 5 5 5 Recirculating Recirculating Recirculating Fan No Yes Yes Yes No Yes Yes Yes (2) 5 outside (2) 6 outside (2) 5 outside (2) 5 outside (2) 6 inside (2) 6 inside (2) 5 inside (2) 5 inside (2) 1/2 (2) 1/2 (2) 1/2 (2) 1/2 56 73 54 54

ELECTRICAL DATA

SUMMARY OF THE ABOVE CALCULATIONS USING VARIOUS METHODS

Voltage Blower HP (PSC type) Fan Watts - high speed @ 0.3 in. w.g. Fan Watts - low speed @ 0.3 in. w.g. Amp Rating

Method 1 - Cubic Volume - 88 CFM Method 2 - Room Count - 110 CFM Method 3 - ASHRAE 62.2 - 98 CFM

120 volts - 60 hertz - 1 phase 1/10 1/20 118 110 66 57 1.4 1.3

1/20 150 60 0.9

1/20 118 66 1.4

127( (IIHFWLYHQHVV LV EDVHG RQ WHPSHUDWXUH GLIIHUHQFH EHWZHHQ WKH DLUVWUHDPV (IÂ¿FLHQF\ LQFOXGHV SDUDVLWLF ORVVHV IURP IDQ RSHUDWLRQ 1 Canada ony.

Method 4 - HVI Recommendation - 1138 CFM Method 5 - Custom calculation. Size on one of above methods on low speed fan or 20 minute/hour operation. After measuring chemical(s) of concern, adjust operation accordingly. All methods were calculated using the same 2,000 sq. ft. with 8 ft. ceiling house as an example. Choose the CFM ZKLFK VDWLVÂ¿HV WKH FRGH UHTXLUHPHQW RI \RXU DUHD DQG DSSOLFDWLRQ All sizing is done based on HIGH fan speed data but normal operation is constant LOW fan speed with times of HIGH fan speed from a timer, dehumidistat or wall control Typically a 0.4 in. w.g. static is used for choosing the correct model (however your duct design would negate the static \RX ZDQW WR XVH IRU WKH FDOFXODWHG &)0 IRU \RXU LQVWDOODWLRQ GHVLJQ VHH H[DFW PRGHO VSHFLÂ¿FDWLRQV IRU GHWDLOV +9, FHUWLÂ¿HG GDWD IRU WKH XQLW ,W LV DOZD\V UHFRPPHQGHG D SURSHU GXFW GHVLJQ LV GRQH 127( 'HDOHU VKRXOG DOZD\V FDOFXODWH LQFUHDVHG ORDG UHTXLUHPHQW GXH WR YHQWLODWLRQ DQG LQVXUH WKDW +9$& system is sized appropriately to handle both sensible (temperature) and latent (humidity) loads. 127( ,Q VRPH ORFDWLRQV D VWDQGDORQH GHKXPLGLÂ¿HU PD\ EH UHTXLUHG WR KDQGOH WKH LQFUHDVHG ODWHQW (humidity) load to prevent increased humidity in the home.

SPECIFICATIONS - HRV Model No. 1

No. of Cores ENERGY STAR 4XDOLÂ¿HG &DQDGD 2QO\

HRV5-200-TPD HRV5-200-TPD-GDX Single Yes 77% (100 cfm) 68% (100 cfm) 68% (100 cfm) 222 207 193 179 165 150 135 119 2 5 Recirculating Yes Yes (2) 6 outside (2) 6 inside

Condensate drain (o.d.) - in. (includes tee) Shipping weight - lbs.

HRV3-195

HRV3-300

(2) 1/2 67

Dual Yes 86% (114 cfm) 78% (114 cfm) 72% (112 cfm) 216 195 181 158 144 125 107 72 2 5 Damper No No (2) 6 outside (2) 7 inside (1) 6 defrost (2) 1/2 108

Dual Yes 90% (117 cfm) 79% (117 cfm) 70% (132 cfm) 232 212 202 183 163 144 123 92 2 5 Damper No No (2) 6 outside (2) 7 inside (1) 6 defrost (2) 1/2 108

1/10 96 64 1.4

120 volts - 60 hertz - 1 phase 1/10 173 64 1.5

1/4 333 150 2.9

ELECTRICAL DATA Voltage Blower HP (PSC type) Fan Watts - high speed @ 0.3 in. w.g. Fan Watts - low speed @ 0.3 in. w.g. Amp Rating

127( (IIHFWLYHQHVV LV EDVHG RQ WHPSHUDWXUH GLIIHUHQFH EHWZHHQ WKH DLUVWUHDPV (IÂ¿FLHQF\ LQFOXGHV SDUDVLWLF ORVVHV IURP IDQ RSHUDWLRQ 1 Canada ony.

ERV / HRV Recovery Ventilators / Page 9

ERV / HRV Recovery Ventilators / Page 10

OPTIONAL ACCESSORIES - ORDER SEPARATELY

SPECIFICATIONS - ERV Model No. Number of Cores Performance Sensible effectiveness @ 32Â°F 6HQVLEOH HIÂ¿FLHQF\ WKHUPDO # Â&#x192;) /DWHQW HIÂ¿FLHQF\ PRLVWXUH Â&#x192;) 7RWDO HIÂ¿FLHQF\ Â&#x192;) 0.1 in. w.g. Blower Air Flow (cfm) vs. Static Pressure 0.2 in. w.g. (high speed) 0.3 in. w.g. 0.4 in. w.g. 0.5 in. w.g. 0.6 in. w.g. 0.7 in. w.g. 0.8 in. w.g. Number of Speeds Available (with furnished control) Number of Speeds Available (with optional control) Door Port Balancing Balancing Damper in Intake and Exhaust Collar Duct Ports Connections (No.) & diameter - inch

ERV3-150 Single 81% (63 cfm) 69% (63 cfm) 37% (65 cfm) 47% (65 cfm) 151 141 132 124 107 98 81 60 1 5 No Yes (2) 6 outside, (2) 6 inside

ERV3-200 Single 76% (116 cfm) 69% (116 cfm) 41% (117 cfm) 50% (117 cfm) 180 169 157 146 132 118 101 82 1 5 No Yes (2) 6 outside, (2) 6 inside

Door Port Gauge Tube Set Digital Handheld Manometer Backdraft Damper

6 in. diameter 6 inch diameter 7 inch diameter

1/10 182 70 1.4 70 (32)

NOTE - Effectiveness is based on temperature difference between the 2 airstreams. (IÂ¿FLHQF\ LQFOXGHV SDUDVLWLF ORVVHV IURP IDQ RSHUDWLRQ

N/A

Y2207

N/A

Y6484

Y3728

---

Y3727

---

--91X09

Furnished Furnished Furnished

Furnished Furnished

---

Field Provided

---

Y8250

Wired 20/40/60 Minute Fan Timer

Y2169

Wireless 20/40/60 Minute Fan Timer

Y8251

Y8251 Y8252

Wireless Repeater 2

Y2207

Y6484 Y3728

5 Speed/4 Mode Controller

Controls

Y8252

Y3813

N/A

Y3813

6 in. diameter (1 kW)

97E73

6 in. diameter (2 kW)

20N16

7 in. diameter (2 kW)

97E74

Voltage/Phase (60 Hz)

120/1

Amps - 1 kW Heater

8.3

Amps - 2 kW Heaters

16.7

Dual Hood

Duct Heaters

120 volts - 60 hertz - 1 phase

(2) 5

(2) 6

Hinged Kitchen Exhaust Grille

18N48

Round Diffusers

92E54

Flexible Ducts - No. & dia. - in. 4 in. diameter 5 in. diameter

Weatherhood Kit (2 per kit)

92E55

6 in. diameter

92E56

8 in. diameter

56N81

5 in. diameter

92E66

6 in. diameter

95P07

7 in. diameter

17N11

92E66

Furnished as standard with GDX models (Canada only). Optional for other models. 2 See Pressure Drop Charts below for application. 3 Contact your Territory Manager for additional information. 4 Two Required, one for fresh air intake, one for stale air exhaust. 1

DUAL HOOD PRESSURE DROP/AIRFLOW CHARTS Exhaust Airflow Chart

Intake Airflow Chart

0.40

Static Pressure (in w.g.)

0.40 Static Pressure (in w.g.)

1/20 173 63 1.4 70 (32)

5 in. diameter

%XWWHUÃ&#x20AC;\ 'DPSHU

ELECTRICAL DATA Voltage Blower HP (PSC type) Fan Watts - high speed @ 0.3 in. w.g. Fan Watts - low speed @ 0.3 in. w.g. Amp Rating Shipping weight - lbs. (kg)

Model No. HRV3-095 HRV3-150- HRV5-150 HRV5-200- HRV3-195 HRV3-300 ERV3-150 ERV3-200 TPD/TPF TPD

Air Balancing Tools

0.35 0.30 0.25 0.20 0.15 0.10 0.05

0.30 0.25 0.20 0.15 0.10 0.05 0

0 20

ERV / HRV Recovery Ventilators / Page 11

0.35

80 100 Air Flow (cfm)

120

14 0

100

120

140

Air Flow (cfm)

ERV / HRV Recovery Ventilators / Page 12

Volume 2 - Team Illinoize - Page 32

DIMENSIONS - UNIT - INCHES (MM)

BLOWER DATA FOR OPTIONAL CONTROLS (Factory Tested)

HRV3-095 HEAT RECOVERY VENTILATOR

Speed 4 Air Flow (cfm) 0.1 in. w.g. Medium-High vs. Static 0.2 in. w.g. Pressure 0.3 in. w.g.

---

153

189

167

220

120

180

---

141

170

159

202

111

169

---

131

153

150

186

103

157

0.4 in. w.g.

101

117

136

140

169

146

0.5 in. w.g.

---

120

124

158

132

0.6 in. w.g.

---

106

110

134

118

0.7 in. w.g.

---

108

101

0.8 in. w.g.

---

Air Flow (cfm) 0.1 in. w.g. vs. Static 0.2 in. w.g. Pressure 0.3 in. w.g.

---

144

161

142

194

133

---

130

141

136

178

130

120

123

127

170

124

0.4 in. w.g.

106

108

118

154

114

0.5 in. w.g.

---

103

139

104

0.6 in. w.g.

---

118

0.7 in. w.g.

---

127

115

170

112

116

108

107

163

107

106

100

151

101

0.4 in. w.g.

136

Speed 1 Low

129

---

107

---

0.7 in. w.g.

---

Air Flow (cfm) 0.1 in. w.g. vs. Static 0.2 in. w.g. Pressure 0.3 in. w.g.

---

108

100

144

100

137

134

0.4 in. w.g.

121

0.5 in. w.g.

---

110

---

0.6 in. w.g.

---

THREADED INSERTS (4) at corners

FILTER (in back chamber)

FILTER (in front chamber) 18 in. (457 mm) (min.) required for service access

DRAIN PAN DRAIN SPOUT

18-1/2 (470)

FRESH AIR TO INSIDE (Supply) 6 in. (178 mm) round (converted to oval collar)

BALANCING DAMPER

NOTE - All Duct Connections 6 in. (152 mm)

STALE AIR TO OUTSIDE

CORE

NOTE - Front clearance of 25 in. (635 mm) is recommended for servicing unit

FRESH AIR TO INSIDE

BLOWER

CONDENSATE DRAINS

BALANCING DAMPER

33-5/8 (854)

14-3/4 (375)

HRV3-195, HRV3-300 HEAT RECOVERY VENTILATORS FILTER STALE AIR TO OUTSIDE Duct Connections 6 in. (152 mm) FRESH AIR FROM OUT SIDE

STALE AIR FROM INSIDE

BLOWER

CORE

Blower Duct Connections 7 in. (178 mm)

MOTOR (SEE NOTE BELOW) FILTER

NOTE - Front clearance of 25 in. (635 mm) is recommended for servicing unit

FRESH AIR TO INSIDE

CORE BLOWER

14-3/4 (375)

CONDENSATE DRAINS DEFROST AIR FROM INSIDE

NOTE: DRAWING DEPICTS HRV3-300; MODEL HRV3-195 MOTOR IS AT TOP BLOWER

49 (1245)

HRV3-150-TPD/TPF HEAT RECOVERY VENTILATORS

Description

STALE AIR TO OUTSIDE

0.4

0.5

N/A

HRV3-150-TPD

115

104

$LUÀRZ :LWK 'XDO +RRG

HRV3-150-TPF

120

107

100

$LUÀRZ :LWK 'XDO +RRG

HRV5-150

115

103

$LUÀRZ :LWK 'XDO +RRG

HRV5-200-TPD

128

120

110

$LUÀRZ :LWK 'XDO +RRG

HRV3-195

125

114

107

$LUÀRZ :LWK 'XDO +RRG

HRV3-300

N/A

Not Available

ERV3-150

107

$LUÀRZ :LWK 'XDO +RRG

ERV3-200

125

118

101

$LUÀRZ :LWK 'XDO +RRG

FRESH AIR FROM OUTSIDE

STALE AIR FROM INSIDE

FRESH AIR TO INSIDE

$LUÀRZ :LWK 'XDO +RRG All duct connections are elliptical collars for use with 5 in. (125 mm) ductwork. Balancing Dampers are located on all collars. DEFROST DAMPER (TPD Model Only)

17-1/4 (438)

BLOWER

NOTE − Front clearance of 25 inches (635 mm) is recommended for servicing unit

BLOWER

14 (356)

22-3/4 (578)

ERV / HRV Recovery Ventilators / Page 13

DIMENSIONS - UNIT - INCHES (MM)

ERV / HRV Recovery Ventilators / Page 14

TYPICAL SYSTEM APPLICATIONS

HRV5-200-TPD HEAT RECOVERY VENTILATORS STALE AIR FROM INSIDE

SIMPLIFIED INSTALLATION (Return/Return Method) Return Air

FRESH AIR TO INSIDE

(Direct connection of both supply and exhaust air streams to the air handler cold air return) Return Air 40 in. (1016 mm) Minimum

All ducts use 6 in. (150 mm) oval collars, balancing dampers are located on all collars.

FILTERS

RECIRCULATING DEFROST DAMPER 18-3/4 (476) BLOWER

CORE

CONDENSATE DRAINS

Backdraft Damper

NOTE − Front clearance of 25 in. (635 mm) is recommended for servicing unit

Cool Air Return

Furnace/ Air Handler

Leaf Hinge

14 (356)

33-5/8 (854)

36 in. (914 mm) Min. Recommended

Dampers for balancing airflows

Outdoors

BLOWER

19 (483)

MOTOR

0.3

FRESH AIR FROM OUTSIDE

STALE AIR FROM INSIDE (Exhaust) 6 in. (178 mm) round (converted to oval) collar supplied

STALE AIR FROM INSIDE

FRESH AIR FROM OUTSIDE

NOTE - Perform all calculations for duct sizing in the usual manner (taking into account measured and equivalent lengths).

STALE AIR TO OUTSIDE

STALE AIR TO OUTSIDE (Exhaust) 5 in. (127 mm) round collar

16 (406)

DEFROST DAMPER

HRV3-095

TOP VIEW FRESH AIR FROM OUTSIDE (Supply) 5 in. (127 mm) round collar

DIVIDER PANEL (each side)

CORE

BLOWER DATA WITH OPTIONAL DUAL HOOD $LUÀRZ FIP DW 1RPLQDO ([WHUQDO 6WDWLF 3UHVVXUH LQ Z J

BLOWER

127( 6HH 6SHFL¿FDWLRQV WDEOHV IRU VWDQGDUG KLJK VSHHG GDWD

Model No.

STALE AIR FROM INSIDE

FILTERS

---

RECIRCULATING DEFROST DAMPER

---

HRV5-150 HEAT RECOVERY VENTILATORS

0.8 in. w.g.

0.6 in. w.g.

CORE

Speed 2 Air Flow (cfm) 0.1 in. w.g. Medium-Low vs. Static 0.2 in. w.g. Pressure 0.3 in. w.g. 0.5 in. w.g.

HANGING STRAPS (4)

19 (483)

Speed 3 Medium

FRESH AIR TO INSIDE

FRESH STALE AIR AIR TO FROM OUTSIDE OUTSIDE

24-1/2 (622)

Model No. HRV3-095 HRV3-150 HRV5-150 HRV5-200- HRV3-195 HRV3-300 ERV3-150 ERV3-200 -TPD/TPF TPD

ERV3-150, ERV3-200 ENERGY RECOVERY VENTILATORS PARTIALLY DEDICATED SYSTEM INSTALLATION

BALANCING DAMPER

(Direct connection of supply air stream to the air handler cold air return) (Stale air drawn from key areas of home)

FILTER FRESH AIR TO INSIDE All Duct Connections 6 in. (152 mm)

MOTOR FRESH AIR FROM OUTSIDE

CORE BLOWER

19 (483)

BLOWER

STALE AIR FROM INSIDE

NOTE - Front clearance of 25 in. (635 mm) is recommended for servicing unit

STALE AIR TO OUTSIDE

EXHAUST AIR from various parts of home. (i.e. bathrooms, kitchens, utility areas)

Return Air

Outdoors

Dampers for balancing airflows

FILTER 33-5/8 (854)

36 in. (914 mm) Min. Recommended

14-3/4 (375)

Backdraft Damper

Cool Air Return

DIMENSIONS - ACCESSORIES - INCHES (MM) DUAL HOODS

Furnace/ Air Handler

6 (152)

8 (203)

leaf hinge

13 (330)

FULLY DEDICATED SYSTEM INSTALLATION (Fresh air supplied to main living areas of house. Stale air drawn from key areas of home) Stale air from various parts of home (i.e. bathrooms, kitchens, utility areas)

TOP VIEW

Fresh air to house - main living areas, bedrooms, living room, rec. room, etc.

Outdoors

6 (152)

Dampers for Balancing Airflows

5 (127)

8-1/4 (210)

6 (152)

25 (635) 21-1/2 (546)

SIDE VIEW ERV / HRV Recovery Ventilators / Page 15

ERV / HRV Recovery Ventilators / Page 16

Volume 2 - Team Illinoize - Page 33

REVISIONS Sections

Description of Change

Optional Accessories

New control options added.

6,1*/(

7HFKQLFDO 'DWD %RRN >7'%@ 6OLP 'XFW IRU 86$ ,19 5 $ +] +3

0RGHO $& .1/'&+ $$ $& .;$'&+ $$

Visit us at www.lennox.com For the latest technical information, www.LennoxPROs.com Contact us at 1-800-4-LENNOX 127( 'XH WR /HQQR[Â¶ RQJRLQJ FRPPLWPHQW WR TXDOLW\ 6SHFLÂ¿FDWLRQV 5DWLQJV DQG 'LPHQVLRQV VXEMHFW WR FKDQJH ZLWKRXW QRWLFH DQG ZLWKRXW LQFXUULQJ OLDELOLW\ Improper installation, adjustment, alteration, service or maintenance can cause property damage or personal injury. ,QVWDOODWLRQ DQG VHUYLFH PXVW EH SHUIRUPHG E\ D TXDOLÂ¿HG LQVWDOOHU DQG VHUYLFLQJ DJHQF\ Â&#x2039; /HQQR[ ,QGXVWULHV ,QF

+LVWRU\

9HUVLRQ 9HU

0RGLILFDWLRQ 5HOHDVHG

9HU 0RGLI\ 6OLP 'XFW 'UDZLQJ NB N

'DWH

5HPDUN

9HU 0RGLI\ +HDWLQJ &DSDFLW\ NB N &KDQJH 8QLW 34 &DSD &RUUHFWLRQ 9HU

0RGLILHG 6SHFLIFDWLRQ IRU (QHUJ\ HIILFLHQF\ &DSDFLW\ WDEOH &\FOH GLDJUDP

,QGH[

1RPHQFODWXUH 6SHFLILFDWLRQV

9HU

0RGLI\ 2XWGRRU XQLW 6SHF ZHLJKW GLPHQVLRQ 3

&DSDFLW\ WDEOH

9HU

0RGLI\ 34 FXUYH GDWD

'LPHQVLRQDO GUDZLQJ (OHFWULFDO ZLULQJ GLDJUDP 6RXQG SUHVVXUH OHYHO 34 &XUYH &\FOH GLDJUDP &DSDFLW\ FRUUHFWLRQ

Volume 2 - Team Illinoize - Page 34

1 1RPHQFODWXUH

1 Nomenclature

Indoor Units

Outdoor Units Model Names

Model Names

%X\HU

(1) Classification

(5) Product Notation

CAC

(2) Capacity x 1,000 Btu/h (3 digits)

1Way Cassette 4Way Cassette (600 X 600)

4Way Cassette

InY Side LoZ Temp

6OLP Duct

Non InY Side LoZ Temp

MSP Duct

Ceiling

Console

Wall-Mounted

(6) Feature (4) Product Type Indoor Unit

;

Outdoor Unit

. Flagship

Standard

Deluxe

Standrad Tropical Non Module

Standard

Deluxe

2016

(7) Rating Voltage &

(4) Product Type N

Indoor Unit

Outdoor Unit

1Ã&#x2DC;, 20 ~2 0V, 0Hz

(8) Mode

(7) Rating Voltage &

InY Side *eneral Temp Non InY Side *eneral Temp

(6) Feature2 (3) Version

A B

x 1,000 Btu/h (3 digits)

201

CAC

(2) Capacity

(3) Version .

(5) Feature1

(1) Classification

1 N

1Ã&#x2DC;, 20 ~2 0V, 0Hz

Heat Pump(R410A)

(8) Mode H

Heat Pump(R410A)

2 Specifications

3 Capacity taEle

Slim Duct

Type Indoor Unit Outdoor Unit

Model Name Mode

Cooling(Min/Std/Max) Capacity Heating(Min/Std/Max)

PoZer

System

PoZer Input Cooling(Min/Std/Max (Nominal) Heating(Min/Std/Max Current Input Cooling(Min/Std/Max (Nominal) Heating(Min/Std/Max MCA M23 ((R (Nominal Cooling) ((R (Nominal Cooling, US) COP (Nominal Heating)

NW Btu/h US RT NW Btu/h US RT NW A

A A Btu/Wh (nergy (fficiency (nergy (nergy *rade (nergy Ã&#x2DC;, mm LiTuid Pipe Ã&#x2DC;, inch Ã&#x2DC;, mm *as Pipe Piping Ã&#x2DC;, inch Connection m s Max Length ft Installation Limitation m Max Height ft PoZer Source Wire Ã&#x2DC;, mm Field Wiring Transmission CaEle Ã&#x2DC;, mm Type Control Method Refrigerant Ng Factory Charging lEs PoZer Supply Ã&#x2DC;, , V, Hz Type Motor Output W Fan Air FloZ Rate High/Mid/LoZ CFM Pa (xternal Static Min/Std/Max Pressure In Wg Drain Drain Pipe Ã&#x2DC;,mm Sound

Pressure

High/Mid/LoZ

PoZer

Cooling

dB(A)

Ng lEs Ng lEs mm inch mm Shipping Dimensions (WxHxD) inch Panel model Ng Panel Net Weight lEs Ng Shipping Weight lEs Panel Size mm Net Dimensions (WxHxD) inch mm Shipping Dimensions (WxHxD) inch Drain pump ,QFOXGHG

Drain pump Accessories Max Lifting mm/h Air Filter PoZer Supply Ã&#x2DC;, , V, Hz Type Model Compressor Output NW Oil Type Fan Air FloZ Rate Cooling CFM Net Weight

Indoor Unit

(xternal Dimension

Sound Outdoor Unit

Shipping Weight

Net Dimensions (WxHxD)

Pressure

Cooling/Heating

PoZer

Cooling

Net Weight (xternal Dimension

Shipping Weight Net Dimensions (WxHxD) Shipping Dimensions (WxHxD)

Operating Temp

Cooling Heating

dB(A) Ng lEs Ng lEs mm inch mm inch Â&#x17E;F Â&#x17E;F

AC00 .NLDCH/AA AC00 .XADCH/AA

Slim Duct AC00 .NLDCH/AA AC00 .XADCH/AA Heat Pump 0 4 / 2 64 / 3 52 3,200 / ,000 / 12,000 0 27 / 0 75 / 1 00 0 85 / 3 52 / 4 10 2, 00 / 12,000 / 14,000 0 24 / 1 00 / 1 17 0 23 / 0 64 / 1 15 0 20 / 1 18 / 1 50 1 50 / 3 10 / 5 20 1 40 / 5 30 / 6 10 10 70 15 00 4 0 1 2 8 S((R 21 HSPF 10 5 6 35 1/4 52 3/8 20 (25) 66 (82) 15 (15) 4 (4 ) 2 50 0 75 ~ 1 25 R410A 1 05 2 31 1,2,208-230,60 Sirocco 6 x 1 353 16 / 317 84 / 282 53 0 00 / 24 50 / 58 80 0 00 / 0 10 / 0 24 VP25 (OD 32,ID 25)

Slim Duct AC012.NLDCH/AA AC012.XADCH/AA Heat Pump 1 00 / 3 52 / 4 48 3,400 / 12,000 / 15,300 0 28 / 1 00 / 1 28 0 88 / 4 10 / 4 3,000 / 14,000 / 1 , 00 0 25 / 1 17 / 1 28 0 24 / 1 00 / 1 70 0 20 / 1 30 / 1 60 1 60 / 4 70 / 7 10 1 40 / 6 00 / 6 80 10 70 15 00 3 52 12 00 3 16 S((R 20 HSPF 10 5 6 35 1/4 52 3/8 20 (25) 66 (82) 15 (15) 4 (4 ) 2 50 0 75 ~ 1 25 R410A 1 05 2 31 1,2,208-230,60 Sirocco 6 x 1 423 7 / 370 82 / 317 84 0 00 / 24 50 / 58 80 0 00 / 0 10 / 0 24 VP25 (OD 32,ID 25)

Slim Duct AC018.NLDCH/AA AC018.XADCH/AA Heat Pump 1 47 / 5 28 / 6 15 5,000 / 18,000 / 21,000 0 42 / 1 50 / 1 75 1 11 / 5 86 / 6 5 3,800 / 20,000 / 2 ,000 0 32 / 1 67 / 1 75 0 31 / 1 68 / 2 20 0 30 / 1 8 / 2 70 1 0 / 7 70 / 50 1 70 / 8 80 / 12 00 12 70 20 00 3 14 10 7 2 6 S((R 1 5 HSPF 8 6 35 1/4 12 70 1/2 30 (35) 8 (115) 20 (20) 66 (66) 2 50 0 75 ~ 1 25 R410A 1 30 2 87 1,2,208-230,60 Sirocco 84 x 1 4 4 42 / 423 7 / 353 16 0 00 / 24 50 / 58 80 0 00 / 0 10 / 0 24 VP25 (OD 32,ID 25)

33 / 30 / 26

34 / 31 / 27

35 / 32 / 28

1 7 44 03 1 7 44 03 700 x 1 x 600 27 56 x 7 83 x 23 62 51 x 280 x 70 37 44 x 11 02 x 27 1 MDP-(075S((3D 3UH 1,2,208-230,60 7ZLQ BLDC Rotary U* T115FUA(4 PO( -

23 60 52 03 23 60 52 03 00 x 1 x 600 35 43 x 7 83 x 23 62 1,151 x 280 x 70 45 31 x 11 02 x 27 1 MDP-(075S((3D 3UH 1,2,208-230,60 TZin BLDC Rotary U*4T150LNB(4 1 42 PO( -

46 / 47

47 / 48

4 / 50

7 0 x 548 x 2 5 x 21 57 x 1 x 6 x 3 3 x 2 x 1 -0 4 ~ 114 8 -4 0 ~ 75 2

Specifications may Ee suEMect to change Zithout prior notice 1) Nominal capacity are Eased on (Refrigerant Piping 24 6ft , LeYel Differences 0ft)

00 x x x 2 x 1 x x x 2 x 1 -0 4 ~ 114 8 -4 0 ~ 75 2

Cooling

TC(Total Capacity), SHC(SensiEle Heat Capacity), PI(PoZer Input)

2XWGRRU 7HPSHUDWXUH È&#x2022; '%

7& 0%+

2) Sound pressure OHYHO LV acTuired in a DQHFKRLF room Thus actual noise leYel may Ee different depending on the installation conditions

,QGRRU 7HPSHUDWXUH È&#x2022; '% :%

3, N:

7& 0%+

6+& 0%+

3, N:

7& 0%+

6+& 0%+

3, N:

7& 0%+

6+& 0%+

3, N:

7& 0%+

6+& 0%+

3, N:

7& 0%+

6+& 0%+

3, N:

Heating

7& 0%+

6+& 0%+

3, N:

TC Total Capacity, PI PoZer Input

2XWGRRU 7HPSHUDWXUH È&#x2022; '%

7& 0%+

,QGRRU 7HPSHUDWXUH È&#x2022; '%

3, N:

7& 0%+

3, N:

7& 0%+

3, N:

7& 0%+

3, N:

7& 0%+

3, N:

7& 0%+

3, N:

AC012.NLDCH/AA AC012.XADCH/AA

Cooling

TC(Total Capacity), SHC(SensiEle Heat Capacity), PI(PoZer Input)

2XWGRRU 7HPSHUDWXUH È&#x2022; '%

7& 0%+

6+& 0%+

3, N:

7& 0%+

6+& 0%+

3, N:

7& 0%+

6+& 0%+

,QGRRU 7HPSHUDWXUH È&#x2022; '% :%

3, N:

7& 0%+

6+& 0%+

3, N:

7& 0%+

6+& 0%+

3, N:

7& 0%+

6+& 0%+

Heating

3, N:

7& 0%+

6+& 0%+

3, N:

TC Total Capacity PI PoZer Input

2XWGRRU 7HPSHUDWXUH È&#x2022; '%

7& 0%+

,QGRRU 7HPSHUDWXUH È&#x2022; '%

3, N:

7& 0%+

3, N:

7& 0%+

3, N:

7& 0%+

3, N:

7& 0%+

3, N:

7& 0%+

3, N:

AC018.NLDCH/AA AC018.XADCH/AA

Cooling

TC(Total Capacity), SHC(SensiEle Heat Capacity), PI(PoZer Input)

2XWGRRU 7HPSHUDWXUH È&#x2022; '%

7& 0%+

6+& 0%+

3, N:

7& 0%+

6+& 0%+

3, N:

7& 0%+

6+& 0%+

,QGRRU 7HPSHUDWXUH È&#x2022; '% :%

3, N:

7& 0%+

6+& 0%+

3, N:

7& 0%+

6+& 0%+

3, N:

7& 0%+

6+& 0%+

Heating

3, N:

7& 0%+

6+& 0%+

3, N:

TC Total Capacity, PI PoZer Input

2XWGRRU 7HPSHUDWXUH È&#x2022; '%

Cooling Indoor temperature 80Â&#x192;F DB, 67Â&#x192;F WB / Outdoor temperature 5Â&#x192;F DB, 75Â&#x192;F WB Heating Indoor temperature 70Â&#x192;F DB, 60Â&#x192;F WB / Outdoor temperature 47Â&#x192;F DB, 43Â&#x192;F WB

6+& 0%+

7& 0%+

,QGRRU 7HPSHUDWXUH È&#x2022; '%

3, N:

7& 0%+

3, N:

7& 0%+

3, N:

7& 0%+

3, N:

7& 0%+

3, N:

7& 0%+

3, N:

Capacities are Eased on folloZing conditions Refrigerant pipe length 24 6ft / LeYel difference 0ft

Volume 2 - Team Illinoize - Page 35

'LPHQVLRQDO GUDZLQJ

4 Dimensional draZing

,QGRRU 6OLP 'XFW

Indoor Slim Duct

$& .1/'&+ $$ $& .1/'&+ $$

AC018.NLDCH/AA

6OJU JODI NN

3x10.08=30.24(3x256=768)

2.80 3.94 0.39 (71) (100) (10)

0.47(11.9)

36.94(938.4) 4VTQFOTJPO QPTJUJPO

1.1(28) 1.1(28)

23.62(600)

18.78(477) 4VTQFOTJPO QPTJUJPO

8x3.937=31.50(8x100=800) 33.86(860) "JS PVUMFU EVDU GMBOHF

22-Ã¸0.13(3.2) hole

35.43(900)

"JS BSPVOE

23.62(600)

Inspection hole

35.43(900) 19.69(500)

3.94(100)

7.83(199) 5.97(151.6)

4.55(115.5) 5.73(145.5)

1.20(30.5)

0.71(18)

39.37(1000)

7.17(182) 9.69(246) 13.11(333) Discharge side

Suction side

TaEle of descriptions Refrigerant liquid pipe

Air filter

Refrigerant gas pipe

HooN

Drain Connection

PoZer Comm Ziring conduits

Air discharge flange

4 Dimensional draZing

Outdoor

AC00 .XADCH/AA $& .;$'&+ $$

AC01 .XADCH/AA

Units mm / inches

880 >2 -10 3/4 @ 660 >2 -2 @

110 >4 1/4 @

364 >1 -2 1/4 @ 340 >1 -1 1/2 @

12 >1/2 @

4 Dimensional draZing

1 2

560 >1 -10 @

310 >1 -0 1/4 @

318 >1 -0 1/2 @

648 >2 -1 1/2 @

50 >2 @

TaEle of descriptions 1

Refrigerant gas pipe

Refrigerant liTuid pipe

PoZer Comm Ziring conduits

Volume 2 - Team Illinoize - Page 36

5 (lectrical Ziring diagram

Indoor Slim Duct

Outdoor

AC00 .NLDCH/AA, AC012.NLDCH/AA, AC018.NLDCH/AA

AC00 .XADCH/AA, AC012.XADCH/AA, AC018.XADCH/AA

6 Sound pressure level

] z G G

Indoor : Slim Duct

v Unit: dB(A)

| aG iOhP

Model

High

Low

AC009KNLDCH/AA (ODU : AC009KXADCH/AA)

hjWW`r hkjoVhhGOpk|GaGhjWW`ruskjoVhhP

[]

AC012KNLDCH/AA (ODU : AC012KXADCH/AA)

hjWXYr hkjoVhhGOpk|GaGhjWXYruskjoVhhP

AC018KNLDCH/AA (ODU : AC018KXADCH/AA)

hjWX_r hkjoVhhGOpk|GaGhjWX_ruskjoVhhP

Note

u Q 6SHFLILFDWLRQV PD\ EH VXEMHFW WR FKDQJH ZLWKRXW SULRU QRWLFH

* Specifications may be subject to change without prior notice 1) 7KHVH RSHUDWLRQ YDOXHV DUH REWDLQHG LQ DQ DQHFKRLF URRP

XP 7KHVH RSHUDWLRQ YDOXHV DUH REWDLQHG LQ DQ DQHFKRLF URRP

2) 6RXQG SUHVVXUH OHYHO LV D UHODWLYH YDOXH GHSHQGLQJ RQ WKH GLVWDQFH DQG DFRXVWLF HQYLURQPHQW

YP 6RXQG SUHVVXUH OHYHO LV D UHODWLYH YDOXH GHSHQGLQJ RQ WKH GLVWDQFH DQG DFRXVWLF HQYLURQPHQW

3) 6RXQG SUHVVXUH OHYHO PD\ GLIIHU GHSHQGLQJ RQ RSHUDWLRQ FRQGLWLRQ

ZP 6RXQG SUHVVXUH OHYHO PD\ GLIIHU GHSHQGLQJ RQ RSHUDWLRQ FRQGLWLRQ

NC curve

ujG

Sound pressure level(dB)

0% *KIJ

.QY

0% 20

0% 15

0% 0%

0% 15

j o

ujG[\

ujG[W

ujGZ\

ujGZW

ujG\\

j \W

ujG\W

ujG]W

ujG\\

\W 0%

YP hjWXYr hkjoVhhGOpk|GaGhjWXYruskjoVhhP

ujG]W

.QY

]W \\

XP hjWW`r hkjoVhhGOpk|GaGhjWW`ruskjoVhhP

*KIJ 40

Sound pressure level(dB)

z G G O iP

2) AC012KNLDCH/AA (ODU : AC012KXADCH/AA)

z G G O iP

1) AC009KNLDCH/AA (ODU : AC009KXADCH/AA)

ujG\W

ujG[\

ujG[W

ujGZ\

ujGZW

ujGY\ YW

ujGYW X\

ujGX\ 0

125

250

500

1000

2000

4000

8000

Octave band center frequency(Hz)

125

250

500

1000

2000

4000

8000

XY\

XWWW

YWWW

[WWW

0% 20

0% 15

0% 10

z G G O iP

XY\

Y\W

\WW

XWWW

YWWW

[WWW

_WWW

ujG]W

o j

ujG\\

_WWW

v G G G Oo¡P

.QY

\WW

ZP hjWX_r hkjoVhhGOpk|GaGhjWX_ruskjoVhhP

Y\W

v G G G Oo¡P

*KIJ

ujGX\ XW

Octave band center frequency(Hz)

3) AC018KNLDCH/AA (ODU : AC018KXADCH/AA)

Sound pressure level(dB)

XW 63

ujG\W

ujG[\

ujG[W

ujGZ\

ujGZW

Y\ ujGY\ YW ujGYW

X\ ujGX\

XW 63

125

250

500

1000

2000

Octave band center frequency(Hz)

4000

8000

XY\

Y\W

\WW

XWWW

YWWW

[WWW

_WWW

v G G G Oo¡P

Volume 2 - Team Illinoize - Page 37

7 P4 Curve

Indoor : Slim Duct

1) AC009KNLDCH/AA (ODU : AC009KXADCH/AA)

2) AC012KNLDCH/AA (ODU : AC012KXADCH/AA)

0.5 0.4 0.3 ²Ã ² đÃU

0.1

LOW 0 200 300

ƸΧΧʪθ ̷͔̈̈ϩ ͱ˙ external static pressure 1

External Static Pressure(InAq) 0.098

øͱиʪθ ̷͔̈̈ϩ ͱ˙ external static pressure

400 500 Air Flow rate [CFM]

External Static Pressure(InAq) 0.197

600

0.7 0.6 0.5 0.4 0.3

Option Code 01C06C-1C5AF0-271A21-370000

0 200

ƸΧΧʪθ ̷͔̈̈ϩ ͱ˙ external static pressure 2

²Ã ² đÃU LOW

0.1

700

300

0.7

0.4 0.3

400 500 Air Flow rate [CFM]

External Static Pressure(InAq) 0.236

600

0.4 0.3 ²Ã ²

0.2

ƸΧΧʪθ ̷͔̈̈ϩ ͱ˙ external static pressure

đÃU

øͱиʪθ ̷͔̈̈ϩ ͱ˙ external static pressure

LOW

0.1

0 200

0.1

Option Code 01C06C-1C5E24-271A21-370000

400 500 Air Flow rate [CFM]

600

400

øͱиʪθ ̷͔̈̈ϩ ͱ˙ external static pressure

500 600 Air Flow rate [CFM]

External Static Pressure(InAq) 0.197

0.7 0.6 0.5 0.4 0.3

²Ã ²

0.2

đÃU

ƸΧΧʪθ ̷͔̈̈ϩ ͱ˙ external static pressure 4

LOW

øͱиʪθ ̷͔̈̈ϩ ͱ˙ external static pressure

400 500 Air Flow rate [CFM]

600

Option Code 01C06C-1C5E24-272328-370000

Note

ƸΧΧʪθ ̷͔̈̈ϩ ͱ˙ external static pressure øͱиʪθ ̷͔̈̈ϩ ͱ˙ external 2 static pressure

²Ã ² đÃU

400

500 600 Air Flow rate [CFM]

External Static Pressure(InAq) 0.236

700

Option Code 01C06C-1C5E47-272328-370000

0.8

0.7

0.4 ƸΧΧʪθ ̷͔̈̈ϩ ͱ˙ external static pressure 3

0.3 ²Ã ² đÃU

øͱиʪθ ̷͔̈̈ϩ ͱ˙ external static pressure

LOW

0 300

700

0.4 0.3

LOW 0 300

700

0.5

0.1

300

0.5

0.1

0.6

0.2

0.7 0.6

0.2 1

0.8

0 200

700

²Ã ² đÃU

0 LOW 300

700

0.1

300

ƸΧΧʪθ ̷͔̈̈ϩ ͱ˙ external static pressure

0.2

øͱиʪθ ̷͔̈̈ϩ ͱ˙ external static pressure

Option Code 01C06C-1C5AF1-272328-370000

0.8

0.5

External Static Pressure [InAq]

0.7

0.5

External Static Pressure(InAq) 0.157

0.6

0.8

0.6

Option Code 01C06C-1C7968-272328-370000

0.8

0.2

0.8 External Static Pressure [InAq]

Option Code 01C06C-1C59CC-271A21-370000

External Static Pressure [InAq]

0.7 0.6

0.2

External Static Pressure(InAq) 0.157 0.8

External Static Pressure [InAq]

Option Code 01C06C-1C6933-271A21-370000

0.8

External Static Pressure [InAq]

External Static Pressure(InAq) 0.098

400

500 600 Air Flow rate [CFM]

0.7 0.6 0.5 0.4 0.3

²Ã ²

0.2

đÃU

0.1

LOW

0 300

700

ƸΧΧʪθ ̷͔̈̈ϩ ͱ˙ external static pressure 4

400

øͱиʪθ ̷͔̈̈ϩ ͱ˙ external static pressure

500 600 Air Flow rate [CFM]

700

Note

Adjust option code according to the actual installation condition (external static pressure)

The graphs display the available external static pressure range of installed indoor units Therefore, they do not reflect the actual change

of external static pressure and airflow rate according to adjusted airflow (High-Mid-Low) of installed indoor units

7 P4 Curve

8 Cycle diagram Outdoor

Indoor : Slim Duct

AC009KXADCH/AA, AC012KXADCH/AA, AC018KXADCH/AA

3) AC018KNLDCH/AA (ODU : AC018KXADCH/AA)

External Static Pressure(InAq) 0.098

Option Code 01C06C-1C7944-27343C-370000

0.7 0.6 0.5 0.4 0.3 0.2 0.1

ƸΧΧʪθ ̷͔̈̈ϩ ͱ˙ external static pressure

HIGH MID

LOW 0 300 400

500 600 Air Flow rate [CFM]

External Static Pressure(InAq) 0.197

700

Option Code 01C06C-1C59AB-27343C-370000

7KHUPLVWRU ,'8 +HDW ([FKDQJHU 2XW 7B,2

7KHUPLVWRU $PELHQW 7B$

0.4

+HDW ([FKDQJHU ,QGRRU 8QLW +;B,'

7KHUPLVWRU ,'8 +HDW ([FKDQJHU ,Q 7B,,

*DV SLSH FRQQHFWLRQ SRUW

0.3

ƸΧΧʪθ ̷͔̈̈ϩ ͱ˙ external static pressure 2

HIGH

LOW 0 300 400

øͱиʪθ ̷͔̈̈ϩ ͱ˙ external static pressure

500 600 Air Flow rate [CFM]

External Static Pressure(InAq) 0.236

700

+HDW ([FKDQJHU 0DLQ +;B0

800

7KHUPLVWRU ,QGRRU 5RRP 7B,5

2XWGRRU )DQ 0RWRU 2)0

7KHUPLVWRU &RQG 2XW 7B&2

Option Code 01C06C-1C59DF-27343C-370000

,QGRRU )DQ 0RWRU ,)0

/LTXLG SLSH FRQQHFWLRQ SRUW

0.8

0.7

External Static Pressure [InAq]

0.7

0.5

0.1

800

0.5 0.4

0.1

,QGRRU 8QLW 6HUYLFH 9DOYH *DV SLSH 69B*

MID

øͱиʪθ ̷͔̈̈ϩ ͱ˙ external static pressure

0.6

0.2

2XWGRRU 8QLW

Option Code 01C06C-1C5978-27343C-370000

0.6

0.2

0.8

0.3

External Static Pressure(InAq) 0.157 0.8

External Static Pressure [InAq]

0.8

ƸΧΧʪθ ̷͔̈̈ϩ ͱ˙ external static pressure øͱиʪθ ̷͔̈̈ϩ ͱ˙ 3 external static pressure

HIGH MID LOW

0 300

400

500 600 Air Flow rate [CFM]

700

800

)LOWHU

0.7

6ROHQRLG YDOYH :D\ 9B :

0.6 0.5 0.4 0.3

HIGH

0.2

MID

0.1

LOW

0 300

(OHFWURQLF ([SDQVLRQ 9DOYH 0DLQ (B0

)LOWHU

6HUYLFH 9DOYH /LTXLG SLSH 69B/

ƸΧΧʪθ ̷͔̈̈ϩ ͱ˙ external static pressure øͱиʪθ ̷͔̈̈ϩ ͱ˙ 4 external static pressure

400

500 600 Air Flow rate [CFM]

700

800

7KHUPLVWRU &RPSUHVVRU 7RS 7B&7

7KHUPLVWRU 'LVFKDUJH SLSH 7B'

&RPSUHVVRU &203

Note Adjust option code according to the actual installation condition (external static pressure) The graphs display the available external static pressure range of installed indoor units Therefore, they do not reflect the actual change of external static pressure and airflow rate according to adjusted airflow (High-Mid-Low) of installed indoor units

Volume 2 - Team Illinoize - Page 38

9 Capacity correction Outdoor AC009KNLDCH/AA AC009KXADCH/AA

Level Difference (IW)

Cooling 0

1 00 1 00 1 00 -

Pipe Length (IW) 0 96 0 96 0 96 0 96 0 96 0 95 0 95

0 98 0 98 0 98 0 97 0 96 -

0 95 0 95 0 95 0 95 0 94 0 94 0 93

0 93 0 93 0 93 0 93 0 92 0 92 0 91

0 95 0 95 0 95 0 95 0 94 0 94 0 93

0 93 0 93 0 93 0 93 0 92 0 92 0 91

AC012KNLDCH/AA AC012KXADCH/AA

Level Difference (IW)

Cooling 0

1 00 1 00 1 00 -

Pipe Length (IW) 0 96 0 96 0 96 0 96 0 96 0 95 0 95

0 98 0 98 0 98 0 97 0 96 -

AC018KNLDCH/AA AC018KXADCH/AA

Level Difference (IW)

Cooling 0

1 00 1 00 1 00 -

0 99 0 99 0 99 0 98 0 97 -

Pipe Length (IW) 0 97 0 97 0 97 0 97 0 97 0 96 0 96 -

0 96 0 96 0 96 0 96 0 96 0 95 0 95 0 94 0 94

0 94 0 94 0 94 0 94 0 94 0 94 0 93 0 93 0 92

0 93 0 93 0 93 0 93 0 93 0 92 0 92 0 92 0 91

201 . Ver.1.

Samsung Electronics Co., LTD. B2B PM / SE Head Office (Suwon Korea) 129, Samsung-Ro, Yeongtong-Gu, Suwon City, Gyeonggi-Do, Korea 443-742 Website : www.samsung.com Email : airconditioner@samsung.com Images and data in this book may subject to change without prior notice.

5$&

7HFKQLFDO 'DWD %RRN

+LVWRU\ 9HUVLRQ

0RGLILFDWLRQ

'DWH

5HOHDVH WKH QHZ 7'%

0RGLI\ &DSDFLW\ FRUUHFWLRQ GDWD

5HPDUN

5$& IRU 1RUWK $PHULFD ,QY 5 $ +] +3

0RGHO $5 .6:6-:.1 :KLVSHU

Volume 2 - Team Illinoize - Page 39

6SHFLILFDWLRQV

,QGH[

,QYHUWHU +3

7\SH ,QGRRU 8QLW 2XWGRRU 8QLW

0RGHO 1DPH

6SHFLILFDWLRQV

0RGHO

N: %WX K 86 57 N: %WX K 86 57

&RROLQJ 0LQ 6WG 0D[

&DSDFLW\

&DSDFLW\ WDEOH

+HDWLQJ 0LQ 6WG 0D[

'LPHQVLRQDO GUDZLQJ

3RZHU

(OHFWULFDO ZLULQJ GLDJUDP

3RZHU ,QSXW &RROLQJ 0LQ 6WG 0D[ 1RPLQDO

+HDWLQJ 0LQ 6WG 0D[ &XUUHQW ,QSXW &RROLQJ 0LQ 6WG 0D[ 1RPLQDO

+HDWLQJ 0LQ 6WG 0D[ 0&$ 0)$ ((5 1RPLQDO &RROLQJ

((5 1RPLQDO &RROLQJ 86

&23 1RPLQDO +HDWLQJ

N: $

$ $ %WX :K (QHUJ\ (IILFLHQF\ (QHUJ\ (QHUJ\ *UDGH (QHUJ\ Â&#x2018; PP /LTXLG 3LSH Â&#x2018; LQFK Â&#x2018; PP *DV 3LSH 3LSLQJ Â&#x2018; LQFK &RQQHFWLRQV P 0D[ /HQJWK IW ,QVWDOODWLRQ /LPLWDWLRQ P 0D[ +HLJKW IW 3RZHU 6RXUFH :LUH Â&#x2018; PP )LHOG :LULQJ 7UDQVPLVVLRQ &DEOH Â&#x2018; PP 7\SH &RQWURO 0HWKRG 5HIULJHUDQW NJ )DFWRU\ &KDUJLQJ OEV 3RZHU 6XSSO\ Â&#x2018; 9 +] 7\SH 2XWSXW : 0RWRU &)0 $LU )ORZ 5DWH 7XUER +LJK 0LG /RZ )DQ 3D ([WHUQDO 6WDWLF 0LQ 6WG 0D[ 3UHVVXUH ,Q :J 'UDLQ 'UDLQ 3LSH Â&#x2018; PP

6\VWHP

6RXQG SUHVVXUH OHYHO 7HPSHUDWXUH DQG DLU IORZ GLVWULEXWLRQ &\FOH GLDJUDP 2SHUDWLRQ OLPLW &DSDFLW\ FRUUHFWLRQ

6RXQG

3UHVVXUH

+LJK /RZ

3RZHU

&RROLQJ

([WHUQDO 'LPHQVLRQ

6KLSSLQJ :HLJKW 1HW 'LPHQVLRQV :[+['

3DQHO PRGHO 3DQHO 1HW :HLJKW 6KLSSLQJ :HLJKW 1HW 'LPHQVLRQV :[+['

6KLSSLQJ 'LPHQVLRQV :[+['

'UDLQ SXPS $GGLWLRQDO 'UDLQ SXPS 0D[ /LIWLQJ $FFHVVRULHV $LU )LOWHU 3RZHU 6XSSO\ 7\SH 0RGHO &RPSUHVVRU 2XWSXW 2LO 7\SH )DQ $LU )ORZ 5DWH &RROLQJ 6RXQG 2XWGRRU 8QLW

3UHVVXUH

&RROLQJ +HDWLQJ

3RZHU

&RROLQJ

[ [ [ [ [ [ [ [ %/'& 5RWDU\ 8* 7 )8$(4 32(

NJ OEV NJ OEV PP LQFK PP LQFK Â&#x17E;) Â&#x17E;)

6KLSSLQJ :HLJKW 1HW 'LPHQVLRQV :[+['

6KLSSLQJ 'LPHQVLRQV :[+['

2SHUDWLQJ 7HPS

[ [ [ [ [ [ [ [ %/'& 5RWDU\ 8* 7 )8$(4 32(

[ [ [ [ [ [ [ [ a a

G% $

1HW :HLJKW ([WHUQDO 'LPHQVLRQ

NJ OEV NJ OEV PP LQFK PP LQFK NJ OEV NJ OEV PP LQFK PP LQFK PP OLWHU K Â&#x2018; 9 +] N: &)0

6KLSSLQJ 'LPHQVLRQV :[+['

3DQHO 6L]H

,QYHUWHU +3 $5 .6:6-:.1&9 $5 .6:6-:.;&9 :KLVSHU 0&$

6((5 +63) 5 $ &URVV )ORZ )DQ [ ,' +26(

G% $

1HW :HLJKW

,QGRRU 8QLW

,QYHUWHU +3 $5 .6:6-:.1&9 $5 .6:6-:.;&9 :KLVSHU 0&$

6((5 +63) 5 $ &URVV )ORZ )DQ [ ,' +26(

&RROLQJ +HDWLQJ

6SHFLILFDWLRQV PD\ EH VXEMHFW WR FKDQJH ZLWKRXW SULRU QRWLFH 1RPLQDO FDSDFLW\ DUH EDVHG RQ 5HIULJHUDQW 3LSLQJ IW P /HYHO 'LIIHUHQFHV IW &RROLQJ ,QGRRU WHPSHUDWXUH Â&#x192;) '% Â&#x192;) :% 2XWGRRU WHPSHUDWXUH Â&#x192;) '% Â&#x192;) :% +HDWLQJ ,QGRRU WHPSHUDWXUH Â&#x192;) '% Â&#x192;) :% 2XWGRRU WHPSHUDWXUH Â&#x192;) '% Â&#x192;) :% 6RXQG SUHVVXUH ZDV DFTXLUHG LQ D GHDG URRP 7KXV DFWXDO QRLVH OHYHO PD\ EH GLIIHUHQW GHSHQGLQJ RQ WKH LQVWDOODWLRQ FRQGLWLRQV

6SHFLILFDWLRQV

&DSDFLW\ WDEOH

,QYHUWHU +3

7\SH ,QGRRU 8QLW 2XWGRRU 8QLW

0RGHO 1DPH 0RGH

&RROLQJ 0LQ 6WG 0D[

&DSDFLW\ +HDWLQJ 0LQ 6WG 0D[

3RZHU

6\VWHP

3RZHU ,QSXW &RROLQJ 0LQ 6WG 0D[ 1RPLQDO

+HDWLQJ 0LQ 6WG 0D[ &XUUHQW ,QSXW &RROLQJ 0LQ 6WG 0D[ 1RPLQDO

+HDWLQJ 0LQ 6WG 0D[ 0&$ 0)$ ((5 1RPLQDO &RROLQJ

((5 1RPLQDO &RROLQJ 86

&23 1RPLQDO +HDWLQJ

N: $

$ $ %WX :K (QHUJ\ (QHUJ\ *UDGH (QHUJ\ Â&#x2018; PP /LTXLG 3LSH Â&#x2018; LQFK Â&#x2018; PP *DV 3LSH 3LSLQJ Â&#x2018; LQFK &RQQHFWLRQV P 0D[ /HQJWK IW ,QVWDOODWLRQ /LPLWDWLRQ P 0D[ +HLJKW IW 3RZHU 6RXUFH :LUH Â&#x2018; PP )LHOG :LULQJ 7UDQVPLVVLRQ &DEOH Â&#x2018; PP 7\SH &RQWURO 0HWKRG 5HIULJHUDQW NJ )DFWRU\ &KDUJLQJ OEV 3RZHU 6XSSO\ Â&#x2018; 9 +] 7\SH 2XWSXW : 0RWRU &)0 )DQ $LU )ORZ 5DWH 7XUER +LJK 0LG /RZ 3D ([WHUQDO 6WDWLF 0LQ 6WG 0D[ 3UHVVXUH ,Q :J 'UDLQ 'UDLQ 3LSH Â&#x2018; PP (QHUJ\ (IILFLHQF\

6RXQG

3UHVVXUH

+LJK /RZ

3RZHU

&RROLQJ

1HW :HLJKW

,QGRRU 8QLW

N: %WX K 86 57 N: %WX K 86 57

([WHUQDO 'LPHQVLRQ

6KLSSLQJ :HLJKW 1HW 'LPHQVLRQV :[+['

6KLSSLQJ 'LPHQVLRQV :[+['

3DQHO PRGHO 3DQHO 1HW :HLJKW

3DQHO 6L]H

6KLSSLQJ :HLJKW 1HW 'LPHQVLRQV :[+['

6KLSSLQJ 'LPHQVLRQV :[+['

'UDLQ SXPS $GGLWLRQDO 'UDLQ SXPS 0D[ /LIWLQJ $FFHVVRULHV $LU )LOWHU 3RZHU 6XSSO\ 7\SH 0RGHO &RPSUHVVRU 2XWSXW 2LO 7\SH )DQ $LU )ORZ 5DWH &RROLQJ 6RXQG 2XWGRRU 8QLW

3UHVVXUH

&RROLQJ +HDWLQJ

3RZHU

&RROLQJ

1HW :HLJKW ([WHUQDO 'LPHQVLRQ

6KLSSLQJ :HLJKW 1HW 'LPHQVLRQV :[+['

6KLSSLQJ 'LPHQVLRQV :[+['

2SHUDWLQJ 7HPS

&RROLQJ +HDWLQJ

,QYHUWHU +3 $5 .6:6-:.1&9 $5 .6:6-:.;&9 :KLVSHU 0&$

6((5 +63) 5 $ &URVV )ORZ )DQ [ ,' +26(

,QYHUWHU +3 $5 .6:6-:.1&9 $5 .6:6-:.;&9 :KLVSHU 0&$

6((5 +63) 5 $ &URVV )ORZ )DQ [ ,' +26(

[ [ [ [ [ [ [ [ %/'& 5RWDU\ 8* 7 )8$( 32(

[ [ [ [ [ [ [ [ 7ZLQ %/'& 5RWDU\ 8* 7+ )(: 32(

G% $

NJ OEV NJ OEV PP LQFK PP LQFK NJ OEV NJ OEV PP LQFK PP LQFK PP OLWHU K Â&#x2018; 9 +] N: &)0

[ [ [ [ [ [ [ [ a a

G% $

NJ OEV NJ OEV PP LQFK PP LQFK Â&#x17E;) Â&#x17E;)

$5 .6:6-:.1&9 $5 .6:6-:.;&9

&RROLQJ È&#x2022; '%

7& 7RWDO &DSDFLW\ 6+& 6HQVLEOH +HDW &DSDFLW\ 3, 3RZHU ,QSXW

,QGRRU 7HPSHUDWXUH È&#x2022;

2XWGRRU

$LU 7HPS

7& 0%+ 6+& 0%+

3, N:

7& 0%+ 6+& 0%+

3, N:

7& 0%+ 6+& 0%+

3, N:

7& 0%+ 6+& 0%+

3, N:

7& 0%+ 6+& 0%+

3, N:

7& 0%+ 6+& 0%+

3, N:

7& 0%+ 6+& 0%+

3, N:

+HDWLQJ

7& 7RWDO &DSDFLW\ 3, 3RZHU ,QSXW ,QGRRU 7HPSHUDWXUH È&#x2022;

2XWGRRU $LU 7HPS È&#x2022; '%

0%+

$5 .6:6-:.1&9 $5 .6:6-:.;&9

&RROLQJ È&#x2022; '%

7& 7RWDO &DSDFLW\ 6+& 6HQVLEOH +HDW &DSDFLW\ 3, 3RZHU ,QSXW

,QGRRU 7HPSHUDWXUH È&#x2022;

2XWGRRU $LU 7HPS

7& 0%+ 6+& 0%+

3, N:

7& 0%+ 6+& 0%+

3, N:

7& 0%+ 6+& 0%+

3, N:

7& 0%+ 6+& 0%+

3, N:

7& 0%+ 6+& 0%+

3, N:

7& 0%+ 6+& 0%+

3, N:

7& 0%+ 6+& 0%+

3, N:

+HDWLQJ

7& 7RWDO &DSDFLW\ 3, 3RZHU ,QSXW ,QGRRU 7HPSHUDWXUH È&#x2022;

2XWGRRU $LU 7HPS È&#x2022; '%

0%+

&DSDFLWLHV DUH EDVHG RQ IROORZLQJ FRQGLWLRQV &RROLQJ PRGH LQGRRU DLU WHPSHUDWXUH â&#x201E;&#x2030; '% :% +HDWLQJ PRGH RXWGRRU DLU 5+ +RZHYHU WKH FRQGLWLRQ UDWHG FDSDFLW\ LV '% :% 5HIULJHUDQW SLSLQJ OHQJWK P IW /HYHO GLIIHUHQFH P ,Q FDVH RI ,QYHUWHU PRGHOV WKH FRROLQJ FDSDFLW\ RQ WKH FDSDFLW\ WDEOH FDQ EH KLJKHU WKDQ QRPLQDO FDSDFLW\ DV LQYHUWHU FRPSUHVVRUV RSHUDWH ZLWK GLIIHUHQW +] GHSHQGLQJ RQ RXWGRRU DQG LQGRRU WHPSHUDWXUHV 7KH VSHFLILFDWLRQV GHVLJQV DQG LQIRUPDWLRQ LQ WKLV 'DWDERRN LV VXEMHFW WR FKDQJH ZLWKRXW QRWLFH

Volume 2 - Team Illinoize - Page 40

&DSDFLW\ WDEOH

'LPHQVLRQDO GUDZLQJ ,QGRRU ,QYHUWHU +3

,QYHUWHU +3

$5 .6:6-:.1&9 $5 .6:6-:.1&9

$5 .6:6-:.1&9 $5 .6:6-:.;&9

&RROLQJ È&#x2022; '%

7& 7RWDO &DSDFLW\ 6+& 6HQVLEOH +HDW &DSDFLW\ 3, 3RZHU ,QSXW

,QGRRU 7HPSHUDWXUH È&#x2022;

2XWGRRU $LU 7HPS

7& 0%+ 6+& 0%+

3, N:

7& 0%+ 6+& 0%+

3, N:

7& 0%+ 6+& 0%+

3, N:

7& 0%+ 6+& 0%+

3, N:

7& 0%+ 6+& 0%+

3, N:

7& 0%+ 6+& 0%+

3, N:

7& 0%+ 6+& 0%+

3, N:

+HDWLQJ

7& 7RWDO &DSDFLW\ 3, 3RZHU ,QSXW ,QGRRU 7HPSHUDWXUH È&#x2022;

2XWGRRU $LU 7HPS È&#x2022; '%

0%+

$5 .6:6-:.1&9 $5 .6:6-:.;&9

&RROLQJ È&#x2022; '%

7& 7RWDO &DSDFLW\ 6+& 6HQVLEOH +HDW &DSDFLW\ 3, 3RZHU ,QSXW

,QGRRU 7HPSHUDWXUH È&#x2022;

2XWGRRU $LU 7HPS

7& 0%+ 6+& 0%+

3, N:

7& 0%+ 6+& 0%+

3, N:

7& 0%+ 6+& 0%+

3, N:

7& 0%+ 6+& 0%+

3, N:

7& 0%+ 6+& 0%+

3, N:

7& 0%+ 6+& 0%+

3, N:

7& 0%+ 6+& 0%+

3, N:

+HDWLQJ

7& 7RWDO &DSDFLW\ 3, 3RZHU ,QSXW ,QGRRU 7HPSHUDWXUH È&#x2022;

2XWGRRU $LU 7HPS È&#x2022; '%

0%+

'LPHQVLRQDO GUDZLQJ

,QGRRU ,QYHUWHU +3

2XWGRRU

$5 .6:6-:.1&9 $5 .6:6-:.1&9

$5 .6:6-:.;&9 $5 .6:6-:.;&9

8QLWV PP LQFKHV

> @ > @ > @

> @

'LPHQVLRQDO GUDZLQJ

> @ > @ > @

> @

à¾&#x203A; à¾&#x161;

à¾&#x2122; 7DEOH RI GHVFULSWLRQV

5HIULJHUDQW JDV SLSH

5HIULJHUDQW OLTXLG SLSH

3RZHU &RPP ZLULQJ FRQGXLWV

Â&#x2018; )ODUH Â&#x2018; )ODUH

Volume 2 - Team Illinoize - Page 41

'LPHQVLRQDO GUDZLQJ

2XWGRRU

$5 .6:6-:.;&9

8QLWV PP LQFKHV

> @

à¾&#x203A; à¾&#x161; > @

> @

> @ > @

> @

à¾&#x2122; 7DEOH RI GHVFULSWLRQV

5HIULJHUDQW JDV SLSH

5HIULJHUDQW OLTXLG SLSH

3RZHU &RPP ZLULQJ FRQGXLWV

Â&#x2018; )ODUH Â&#x2018; )ODUH

(OHFWULFDO ZLULQJ GLDJUDP

,QGRRU ,QYHUWHU +3

2XWGRRU

$5 .6:6-:.1&9 $5 .6:6-:.1&9 $5 .6:6-:.1&9 $5 .6:6-:.1&9

$5 .6:6-:.;&9 $5 .6:6-:.;&9

Volume 2 - Team Illinoize - Page 42

(OHFWULFDO ZLULQJ GLDJUDP

6RXQG SUHVVXUH OHYHO

2XWGRRU

,QGRRU ,QYHUWHU +3

$5 .6:6-:.;&9 $5 .6:6-:.;&9

8QLW G% $

jÂ&#x152;Â&#x2022;Â&#x203A;Â&#x152;Â&#x2122; WU_Â&#x201D;

XÂ&#x201D;

0RGHO

+LJK

/RZ

$5 .6:6-:.1&9 2'8 $5 .6:6-:.;&9

tÂ?Â&#x160;Â&#x2122;Â&#x2013;Â&#x2014;Â?Â&#x2013;Â&#x2022;Â&#x152; 1RWH 6SHFLILFDWLRQV PD\ EH VXEMHFW WR FKDQJH ZLWKRXW SULRU QRWLFH 7KHVH RSHUDWLRQ YDOXHV ZHUH REWDLQHG LQ DQ DQHFKRLF URRP 6RXQG SUHVVXUH OHYHO ZLOO YDU\ GHSHQGLQJ RQ D UDQJH RI IDFWRUV VXFK DV WKH FRQVWUXFWLRQ RI WKH SDUWLFXODU URRP ZKHUH WKH HTXLSPHQW LV LQVWDOOHG 2SHUDWLRQ VRXQG OHYHO PD\ GLIIHU GHSHQGLQJ RQ RSHUDWLRQ DQG DPELHQW FRQGLWLRQV

1& FXUYH $5 .6:6-:.1&9 2'8 $5 .6:6-:.;&9

$5 .6:6-:.1&9 2'8 $5 .6:6-:.;&9

0% 50 *KIJ

*KIJ

0% 0%

.QY

0% 0%

0% Sound pressure level(dB)

Sound pressure level(dB)

0% 40

0% 0%

.QY

0% 0%

0 63

125

250

500

1000

2000

4000

8000

125

Octave band center frequency(Hz)

6RXQG SUHVVXUH OHYHO

250

500

1000

2000

4000

6RXQG SUHVVXUH OHYHO

,QGRRU ,QYHUWHU +3

2XWGRRU 8QLW G% $

jÂ&#x152;Â&#x2022;Â&#x203A;Â&#x152;Â&#x2122; WU_Â&#x201D;

8000

Octave band center frequency(Hz)

XÂ&#x201D;

0RGHO

+LJK

/RZ

$5 .6:6-:.1&9 2'8 $5 .6:6-:.;&9

8QLW G% $

jÂ&#x152;Â&#x2022;Â&#x203A;Â&#x152;Â&#x2122;

XUWÂ&#x201D;

0RGHO

&RROLQJ

$5 .6:6-:.;&9 ,'8 $5 .6:6-:.1&9

tÂ?Â&#x160;Â&#x2122;Â&#x2013;Â&#x2014;Â?Â&#x2013;Â&#x2022;Â&#x152;

tÂ?Â&#x160;Â&#x2122;Â&#x2013;Â&#x2014;Â?Â&#x2013;Â&#x2022;Â&#x152; 1RWH

1RWH

6SHFLILFDWLRQV PD\ EH VXEMHFW WR FKDQJH ZLWKRXW SULRU QRWLFH

7KHVH RSHUDWLRQ YDOXHV ZHUH REWDLQHG LQ DQ DQHFKRLF URRP

6RXQG SUHVVXUH OHYHO ZLOO YDU\ GHSHQGLQJ RQ D UDQJH RI IDFWRUV VXFK DV WKH FRQVWUXFWLRQ RI WKH SDUWLFXODU URRP ZKHUH WKH HTXLSPHQW LV LQVWDOOHG

2SHUDWLRQ VRXQG OHYHO PD\ GLIIHU GHSHQGLQJ RQ RSHUDWLRQ DQG DPELHQW FRQGLWLRQV

1& FXUYH

$5 .6:6-:.1&9 2'8 $5 .6:6-:.;&9

0% 0%

0% .QY

0% 0%

0% .QY

0% 0%

0% 10

125

250

500

1000

2000

Octave band center frequency(Hz)

4000

8000

%QQNKPI

0% 0%

125

250

500

1000

2000

Octave band center frequency(Hz)

4000

8000

0% 0%

0 63

%QQNKPI

0% 10

0% 60

0% 10

0% Sound pressure level(dB)

Sound pressure level(dB)

70 0%

$5 .6:6-:.;&9 ,'8 $5 .6:6-:.1&9

*KIJ

$5 .6:6-:.;&9 ,'8 $5 .6:6-:.1&9

0% *KIJ

Sound pressure level(dB)

$5 .6:6-:.1&9 2'8 $5 .6:6-:.;&9

Sound pressure level(dB)

1& FXUYH

0 63

125

250

500

1000

2000

Octave band center frequency(Hz)

4000

8000

125

250

500

1000

2000

4000

8000

Octave band center frequency(Hz)

Volume 2 - Team Illinoize - Page 43

6RXQG SUHVVXUH OHYHO

7HPSHUDWXUH DQG DLU IORZ GLVWULEXWLRQ

2XWGRRU

,QGRRU ,QYHUWHU +3

8QLW G% $

XUW

0RGHO

&RROLQJ

$5 .6:6-:.;&9 ,'8 $5 .6:6-:.1&9

$5 .6:6-:.1&9 &RROLQJ DLU YHORFLW\ GLVWULEXWLRQ

1RWH 6SHFLILFDWLRQV PD\ EH VXEMHFW WR FKDQJH ZLWKRXW SULRU QRWLFH 7KHVH RSHUDWLRQ YDOXHV ZHUH REWDLQHG LQ DQ DQHFKRLF URRP 6RXQG SUHVVXUH OHYHO ZLOO YDU\ GHSHQGLQJ RQ D UDQJH RI IDFWRUV VXFK DV WKH FRQVWUXFWLRQ RI WKH SDUWLFXODU URRP ZKHUH WKH HTXLSPHQW LV LQVWDOOHG

&RROLQJ WHPSHUDWXUH GLVWULEXWLRQ

2SHUDWLRQ VRXQG OHYHO PD\ GLIIHU GHSHQGLQJ RQ RSHUDWLRQ DQG DPELHQW FRQGLWLRQV

1& FXUYH $5 .6:6-:.;&9 ,'8 $5 .6:6-:.1&9

$5 .6:6-:.;&9 ,'8 $5 .6:6-:.1&9

%QQNKPI

0% 60

0% 0%

0% Sound pressure level(dB)

Sound pressure level(dB)

0% 50

0% 0%

125

250

500

1000

2000

4000

Octave band center frequency(Hz)

8000

+HDWLQJ DLU YHORFLW\ GLVWULEXWLRQ

125

250

500

1000

2000

4000

8000

Octave band center frequency(Hz)

+HDWLQJ WHPSHUDWXUH GLVWULEXWLRQ

7HPSHUDWXUH DQG DLU IORZ GLVWULEXWLRQ

,QGRRU ,QYHUWHU +3

$5 .6:6-:.1&9

&RROLQJ DLU YHORFLW\ GLVWULEXWLRQ

&RROLQJ WHPSHUDWXUH GLVWULEXWLRQ

+HDWLQJ DLU YHORFLW\ GLVWULEXWLRQ

+HDWLQJ WHPSHUDWXUH GLVWULEXWLRQ

Volume 2 - Team Illinoize - Page 44

7HPSHUDWXUH DQG DLU IORZ GLVWULEXWLRQ

&\FOH GLDJUDP

,QGRRU ,QYHUWHU +3

2XWGRRU $5 .6:6-:.;&9 $5 .6:6-:.;&9 $5 .6:6-:.;&9 $5 .6:6-:.;&9

$5 .6:6-:.1&9 &RROLQJ DLU YHORFLW\ GLVWULEXWLRQ

2XWGRRU 8QLW

,QGRRU 8QLW

((9 9DOYH

&RROLQJ WHPSHUDWXUH GLVWULEXWLRQ +HDWLQJ &RROLQJ

$FFXPXODWRU

&RPSUHVVRU

+HDWLQJ DLU YHORFLW\ GLVWULEXWLRQ &DWHJRU\

6\PERO

'HVFULSWLRQ

&RPSUHVVRU

5RWDU\ &RPSUHVVRU

$FFXPXODWRU

+HDW ([FKDQJHU

&RQGHQVLQJ (YDSRUDWLQJ XQLW

%ORZHU

&URVV )DQ 3URSHOOHU )DQ

+HDWLQJ WHPSHUDWXUH GLVWULEXWLRQ ([SDQVLRQ

((9 9DOYH 6HUYLFH YDOYH

9DOYH ZD\ YDOYH 6HQVRU

2SHUDWLRQ OLPLW +HDWLQJ

2XWGRRU

80 75 70

120 115 110

$5 .6:6-:.1&9 $5 .6:6-:.;&9

&RROLQJ 3LSH /HQJWK IW

Operation Range

50 40 30 20 14 10

50 Warming Up Operation Range

Operation Range

/HYHO 'LIIHUHQFH IW

Outdoor Temperature (à¶&#x2018; DB)

+HDWLQJ

3LSH /HQJWK IW

20 10 5 0 61

Indoor Temperature (à¶&#x2018; DB)

$5 .6:6-:.1&9 $5 .6:6-:.;&9

&RROLQJ 3LSH /HQJWK IW

/HYHO 'LIIHUHQFH IW

-10

/HYHO 'LIIHUHQFH IW

Outdoor Temperature (à¶&#x2018; DB)

100

3LSH $LU 7HPSHUDWXUH VHQVRU

&DSDFLW\ FRUUHFWLRQ

&RROLQJ

7HPSHUDWXUH

+HDWLQJ 3LSH /HQJWK IW

Volume 2 - Team Illinoize - Page 45

&DSDFLW\ FRUUHFWLRQ 2XWGRRU $5 .6:6-:.1&9 $5 .6:6-:.;&9

/HYHO 'LIIHUHQFH IW

3LSH /HQJWK IW

/HYHO 'LIIHUHQFH IW

&RROLQJ

3LSH /HQJWK IW

+HDWLQJ

$5 .6:6-:.1&9 $5 .6:6-:.;&9

/HYHO 'LIIHUHQFH IW

3LSH /HQJWK IW

/HYHO 'LIIHUHQFH IW

&RROLQJ

3LSH /HQJWK IW

+HDWLQJ

9HU

6DPVXQJ (OHFWURQLFV &R /7' % % 30 6( +HDG 2IILFH 6XZRQ .RUHD 6DPVXQJ 5R <HRQJWRQJ *X 6XZRQ &LW\ *\HRQJJL 'R .RUHD :HEVLWH ZZZ VDPVXQJ FRP (PDLO DLUFRQGLWLRQHU#VDPVXQJ FRP ,PDJHV DQG GDWD LQ WKLV ERRN PD\ VXEMHFW WR FKDQJH ZLWKRXW SULRU QRWLFH

VENTING METHODS

Wall-Mount Canopy Range Hood CABINET DIMENSIONS

PRODUCT MODEL NUMBERS KVWB400D

This canopy hood is factory set for venting through the roof or wall. A 6" (15.2 cm) round vent system is needed for installation (not included). The hood exhaust opening is 6" (15.2 cm) round. NOTE: Flexible vent is not recommended. Flexible vent creates back pressure and air turbulence that greatly reduce performance. Vent system can terminate either through the roof or wall. To vent through a wall, a 90Â° elbow is needed. Rear discharge A 90Â° elbow may be installed immediately above the hood. For Non-Vented (recirculating) Installations If it is not possible to vent cooking fumes and vapors to the outside, the hood can be used in the non-vented (recirculating) version, using a Recirculation Kit (which includes charcoal filters and a deflector). To order, see the â&#x20AC;&#x153;Assistance or Serviceâ&#x20AC;? section.

KVWB406B

7Âšâ &#x201E;â&#x201A;&#x201E;" (18.4 cm) 2" (5.1 cm) min. 6" (15.2 cm) min.*

Electrical: A 120-volt, 60 Hz, AC only, 15-amp, fused electrical circuit is required.

6â ľâ &#x201E;â&#x201A;&#x2C6;" (16.8 cm)

PRODUCT DIMENSIONS 7Âšâ &#x201E;â&#x201A;&#x201E;" (18.3 cm)

Vent and power supply cable entry location

7Âłâ &#x201E;â&#x201A;&#x2C6;" (18.8 cm)

8Âšâ &#x201E;â&#x201A;&#x2C6;" (20.7 cm)

15" (38.1 cm)

*28â ˇâ &#x201E;â&#x201A;&#x2C6;" (72.6 cm) min. 42Âšâ &#x201E;â&#x201A; â&#x201A;&#x2020;" (106.9 cm) max.

Side cabinet

Roof Venting

Wall Venting

Non-vented (recirculating)

**28Âłâ &#x201E;â&#x201A;&#x2C6;" (72.0 cm) min. 38" (96.6 cm) max.

â&#x20AC;&#x153;Xâ&#x20AC;? bottom of canopy to cooking surface

B B

90Â° elbow

5.0 ft (1.5 m)

Maximum equivalent vent length is 35 ft (10.7 m). Example vent system 6 ft (1.8 m)

Wall cap

2 ft (0.6 m)

Cooking surface

The following example falls within the maximum recommended vent length of 35 ft (10.7 m).

IMPORTANT: Minimum distance â&#x20AC;&#x153;Xâ&#x20AC;?: 24" (61.0 cm) from electric cooking surface. Minimum distance â&#x20AC;&#x153;Xâ&#x20AC;?: 27" (68.6 cm) from gas cooking surfaces. Suggested maximum distance â&#x20AC;&#x153;Xâ&#x20AC;?: 36" (91.4 cm)

*For non-vented (recirculating) installations **For vented installations

2.5 ft (0.8 m)

Centerline

20" (50.8 cm) 1 " (4.0 cm)

45Â° elbow

90 elbow

Side cabinet

*For non-vented (recirculating) installations

30" (76.2 cm) or 36" (91.4 cm)

To calculate the length of the system you need, add the equivalent feet (meters) for each vent piece used in the system. Vent Piece 6" (15.2 cm)

30" (76.2 cm) or 36" (91.4 CM)

14Âšâ &#x201E;â&#x201A;&#x2C6;" (35.9 cm)

10" (25.4 cm)

Calculating Vent System Length

The chimneys can be adjusted for different ceiling heights. See the following chart.

A. Roof cap B. 6" (15.2 cm) round vent

A. Wall cap B. 6" (15.2 cm) round vent

1 - 90Â° elbow

= 5.0 ft (1.5 m)

1 - wall cap

= 0.0 ft (0.0 m)

8 ft (2.4 m) straight

= 8.0 ft (2.4 m)

Length of system

= 13.0 ft (3.9 m)

A. Deflector B. 6" (15.2 cm) round vent

Vented Installations Electric cooking surface Gas cooking surface

Min. ceiling height

Max. ceiling height

7' 5" (2.26 m) 7' 8" (2.34 m)

9' 2" (2.79 m) 9' 2" (2.79 m)

Non-vented (recirculating) Installations Min. ceiling height

Max. ceiling height

Electric cooking surface

7' 5" (2.26 m)

9' 6" (2.9 m)

Gas cooking surface

7' 8" (2.34 m)

9' 6" (2.9 m)

*NOTE: The range hood chimneys are adjustable and designed to meet varying ceiling or soffit heights depending on the distance â&#x20AC;&#x153;Xâ&#x20AC;? between the bottom of the range hood and the cooking surface. For higher ceilings, a Stainless Steel Chimney Extension Kit Part Number W10337357 is available from your dealer or an authorized parts distributor. The chimney extension replaces the upper chimney shipped with the range hood.

Page 1 of 2 Because Whirlpool Corporation policy includes a continuous commitment to improve our products, we reserve the right to change materials and specifications without notice.

Dimensions are for planning purposes only. For complete details, see Installation Instructions packed with product. Specifications subject to change without notice.

Ref. W10674121 12-14

Page 2 of 2 Because Whirlpool Corporation policy includes a continuous commitment to improve our products, we reserve the right to change materials and specifications without notice.

Dimensions are for planning purposes only. For complete details, see Installation Instructions packed with product. Specifications subject to change without notice.

Ref. W10674121 12-14

Volume 2 - Team Illinoize - Page 46

4827$7,21 12

48,(76,'( //&

+(15,(77$ &5((. 5' 68,7( 52$12.( 7; 3KRQH )D[ ::: 6$0681*+9$& &20

4827$7,21

7+,6 4827( :$6 35(3$5(' 86,1* $ /,67 2) 0$7(5,$/6 $1' 25 63(&,),(' (48,30(17 0$18)$&785(' %< $ &203$1< 27+(5 7+$1 48,(76,'( &25325$7,21 48,(76,'( $1' 25 6$0681* :+,&+ ,1)250$7,21 :$6 3529,'(' 72 $ 48,(76,'( 5(35(6(17$7,9( %< ,//&2 ,1& 7+,6 4827( :$6 127 35(3$5(' 86,1* 7(&+1,&$/ 25 (1*,1((5,1* '$7$ 5(/$7(' 72 7+( 352-(&7 $1' 48,(76,'( ,6 127 $ /,&(16(' (1*,1((5,1* ),50 48,(76,'( +$6 127 $33529(' 7+,6 6$0681* '90 6<67(0 '(6,*1 $1' '2(6 127 *8$5$17(( 7+$7 7+,6 6$0681* '90 6<67(0 '(6,*1 :,// 3529,'( 237,0$/ 3(5)250$1&( 2) 7+( (48,30(17 D /,&(16(' 352)(66,21$/ (1*,1((5 0867 5(9,(: $1' $33529( 7+( 6$0681* '90 6<67(0 '(6,*1 72 (1685( 237,0$/ '(6,*1 $1' 3(5)250$1&( )25 7+( %8,/',1* 6

$7 :+,&+ 7+( (48,30(17 :,// %( ,167$//(' $1' 25 7+( *(2*5$3+,&$/ /2&$7,21 2) 7+( 352-(&7 7+( ,167$//,1* &2175$&725 0867 $77(1' ,167$//$7,21 75$,1,1* 3529,'(' %< $1 (03/2<(( 2) 48,(76,'( %()25( 7+( (48,30(17 4827(' +(5(,1 :,// %( 6+,33(' 81/(66 27+(5:,6( ',6&866(' 7+,6 4827( '2(6 127 *8$5$17(( 25 (1685( (48,30(17 3(5)250$1&( 5(/,$%,/,7< $1' 25 /21*(9,7<

&RQWDFW ,QIR

$&&(6625,(6 '906 0RGHO 3DUW 1R 05 (+ 8 05. $ 05. $ 1 05: $ 0:5 :+

3URMHFW ,QIR

&RPSDQ\ ,//&2 ,1&

'HVFULSWLRQ :,5(/(66 5(027( )25 '906 :,5(/(66 6,*1$/ 5(&(,9(5 )25 '8&7(' 81,7 '8&7 6,*1$/ 5(&(,9(5 :,5( :,5( '8&7(' 81,7 :,5(/(66 5(&(,9(5 67$1'$5' :,5(' ,1',9,'8$/ &21752//(5 '90 +5 '90 )-0

$WWHQWDWLRQ 6HDQ 3HGRWD

0RGHO 3DUW 1R 3URMHFW $GGUHVV ,/

)D[

%' %/8(

3KRQH

( 0DLO VSHGRWD#LOOFR FRP

/LVW 3ULFH 86

6HOO 3ULFH 86

7RWDO $PRXQW 86

4W\

/LVW 3ULFH 86

6HOO 3ULFH 86

7RWDO $PRXQW 86

4W\

/LVW 3ULFH 86

6HOO 3ULFH 86

7RWDO $PRXQW 86

4W\

/LVW 3ULFH 86

6HOO 3ULFH 86

7RWDO $PRXQW 86

4W\

/LVW 3ULFH 86

6HOO 3ULFH 86

7RWDO $PRXQW 86

4W\

/LVW 3ULFH 86

6HOO 3ULFH 86

7RWDO $PRXQW 86

$&&(6625,(6 )-0 &$& 5$&

3URMHFW 1DPH 8 RI , 6RODU 'HFDWKORQ

3KRQH

4W\

,/6

4XRWH ,QIR

'HVFULSWLRQ %/8( ',$021' 9$& &21'(16$7( 3803 .a .

; ; /,1( 6(7 3/86

0,1, 63/,7 &$&

4XRWH 'DWH 30

4XRWH 6WDWXV 2SHQ

([SLUDWLRQ 'DWH 30 5HT 6KLS 'DWH 1 $

0RGHO 3DUW 1R

&DWHJRU\ 6$0681* &$& 5$& )-0 /HDG 7LPH

&UHGLW 7HUP 'D\V 1HW

$& .1/'&+ $$ $& .;$'&+ $$

&UHDWHG %\ 3HWHU 4XLQQ

)UHLJKW 7HUP &XVWRPHU ,//&2 ,1& 32 %2; $8525$ ,/ 3KRQH )D[ ( 0DLO &RPPHQW

'HVFULSWLRQ &$& 6OLP 'XFW 0%+ 3K 9 &$& 6OLP 'XFW 2XWGRRU 0%+ 3K 9

0,1, 63/,7 )-0

$VVLJQHG 7R (GLWHG %\ 3HWHU 4XLQQ

0RGHO 3DUW 1R $- -1$'&+ $$ $- -1/'&+ $$ $- -&- &+ $$

'HVFULSWLRQ )-0 :DOO 0RXQWHG ,QGRRU 8QLW . %WX 3K +] 9$& )-0 6OLP 'XFWHG ,QGRRU 8QLW . %WX 3K +] 9$& )-0 3RUW 2XWGRRU 8QLW . %WX 3K +] 9$&

0,1, 63/,7 5$& 0RGHO 3DUW 1R

'HVFULSWLRQ

. %78 :+,63(5 60$57 :,), ,1 :$// $5 .6:6-:.1&9 3K . %78 :+,63(5 60$57 :,), 287 :$// $5 .6:6-:.;&9 3K

63$5( 3$576 )-0 &$& 5$& 0RGHO 3DUW 1R

:HGQHVGD\ 0DUFK

4827$7,21 12 4

48,(76,'( //& +(15,(77$ &5((. 5' 68,7( 52$12.( 7; 3KRQH )D[ ::: 6$0681*+9$& &20

4827$7,21 '% $

$66< &211(&725 :,5( 68% &200 )-0 0$/',9( +$1(66 :,5( )25 :,5(/(66 5(02&21

'% $

$66< 3&% 68% &200 )-0 )-0 0$/',9( 68% 3%

7RWDO /LVW 3ULFH 7RWDO ,WHP $PRXQW )UHLJKW (VWLPDWH

)UHLJKW (VWLPDWH 3OHDVH EH DZDUH WKLV LV RQO\ HVWLPDWH

'HVFULSWLRQ

0LVF 6XUFKDUJH

7RWDO $PRXQW

Â® SunPower X22-360-C-AC | Design-Driven Advantages aesthetics and Â&#x2DC; #1 module efficiencyÂ¹ 2 module reliability Â&#x2DC; Unmatched capacitors Â&#x2DC; No electrolytic Â&#x2DC; 25-year Combined Power and Product Warranty Maximize Value for Roof for roof, not string inverter Â&#x2DC; Size system Â&#x2DC; Optimize performance of each module Expand Deployment Options Â&#x2DC; Complex roofs and partial shading Â&#x2DC; Small systems Â&#x2DC; System expandability Simplify & Speed Installation Â&#x2DC; Factory-integrated microinverter AC Â&#x2DC; Robust, double-locking connectors Â&#x2DC; Design flexibility offsite and onsite Â&#x2DC; No DC string sizing process Â&#x2DC; Fewer installation steps than competing systems Â&#x2DC; Intuitive commissioning of Complete Component System Â® InvisiMountâ&#x201E;¢ Â&#x2DC; Built for use with SunPower and the SunPower Monitoring System Â&#x2DC; Superior system reliability and aesthetics

Residential AC

Module Series

Optimize System and Installation Efficiency

SunPowerÂ® AC Modules, which include a factory-integrated SunPower microinverter, provide a revolutionary combination of high efficiency, high reliability, and module-level DC-to-AC power conversion. Designed specifically for use with SunPower InvisiMountâ&#x201E;¢ and the SunPower Monitoring System, SunPower AC Modules enable rapid installation, best-in-class system aesthetics, and intuitive visibility into system performance. All this comes with the best Combined Power and Product Warranty in the industry.

sunpower.com

:HGQHVGD\ 0DUFK

Datasheet

Volume 2 - Team Illinoize - Page 47

SunPowerÂŽ X22-360-C-AC | Residential AC Module Series

Tested Operating Conditions

SPR-X22-360-C-AC Nominal Power (Pnom)

360 W

Power Tolerance

+5/-0%

Avg. Panel Efficiency4

22.2%

Temp. Coef. (Power) Shade Tolerance

Operating Temp.

â&#x20AC;&#x201C;40Â° F to +185Â° F (â&#x20AC;&#x201C;40Â° C to +85Â° C)

Max. Ambient Temp.

122Â° F (50Â° C)

Max. Load

Wind: 62 psf, 3000 Pa, 305 kg/mÂ˛ front & back Snow: 125 psf, 6000 Pa, 611 kg/mÂ˛ front

Impact Resistance

1 inch (25 mm) diameter hail at 52 mph (23 m/s)

â&#x20AC;&#x201C;0.29%/o C â&#x20AC;˘ Three bypass diodes â&#x20AC;˘ Integrated module-level maximum power point tracking

AC Electrical Data Output @ 240 V (min./nom./max.) Output @ 208 V (min./nom./max.) Operating Frequency (min./nom./max.)

Warranties 211/240/264 V 183/208/229 V 0.99

AC Max. Continuous Output Current @ 240 V AC Max. Continuous Output Current @ 208 V

1.33 A 1.54 A

AC Max. Cont. Output Power

320 W

DC/AC CEC Conversion Efficiency Max. Units Per 20 A Branch Circuit @ 240 V Max. Units Per 20 A Branch Circuit @ 208 V No active phase balancing for 3 phase installations

UL listed to UL 1741, including: Â&#x2DC; IEEE1547/1547a and IEEE1547.1/1547.1a Utility Interactive Â&#x2DC; PV Rapid Shutdown Equipment Â&#x2DC; Equipment Grounding Â&#x2DC; UL 6703, UL 9703 Connectors and cables (load break disconnection) Â&#x2DC; UL 1703 PV Modules (Type 2 fire rating)

59.3/60.0/60.5 Hz

Output Power Factor (min.)

96.0% 12 (single phase) 10 (two pole)

Certifications

96 Monocrystalline Maxeon Gen III

Front Glass

High-transmission tempered glass with anti-reflective coating

Environmental Rating

Outdoor rated

Frame

Class 1 black anodized (highest AAMA rating)

Weight

45.5 lbs (20.6 kg)

Recommended Max. Module Spacing

1.3 in. (33 mm)

Enables installation in accordance with: Â&#x2DC; NEC 690.6 Â&#x2DC; NEC 690.12 Rapid Shutdown (inside and outside the array) Â&#x2DC; NEC 690.15 AC Connectors, 690.33(A) â&#x20AC;&#x201C; (E)(1) FCC and ICES-003 Class B

Mechanical Data Solar Cells

Warranties and Certifications Â&#x2DC; 25-year limited power warranty Â&#x2DC; 25-year limited product warranty

When used with InvisiMount racking (UL 2703): Â&#x2DC; Integrated grounding and bonding Â&#x2DC; Class A fire rated PID Test

Potential-induced degradation free

280 mm [11.02 in]

1107 mm [43.6 in]

1046 mm [41.2 in]

46 mm [1.8 in]

Power Data 3

30 mm [1.2 in]

ÂšHighest of over 3,200 silicon solar panels, Photon Module Survey, Feb. 2014 2#1

rank in "PV Module Durability Initiative Public Report," Fraunhofer CSE, Feb 2013. Five out of the top eight largest manufacturers were tested. Campeau, Z. et al. "SunPower Module Degradation Rate," SunPower white paper, Feb 2013. See www.sunpower.com/facts for details.

1558 mm [61.3 in]

3Standard

Test Conditions (1000 W/mÂ˛ irradiance, AM 1.5, 25Â° C). NREL calibration standard: SOMS current, LACCS FF and voltage. All DC voltage is fully contained within the module.

4Based

on average of measured power values during production.

Please read the safety and installation instructions for details.

See www.sunpower.com/facts for more reference information. For more details, see extended datasheet: www.sunpower.com/datasheets.

Document # 516046 Rev D /LTR_US

ÂŠDecember 2016 SunPower Corporation. All rights reserved. SUNPOWER, the SUNPOWER logo, MAXEON and InvisiMount are trademarks or registered trademarks of SunPower Corporation in the U.S. and other countries as well. Specifications included in this datasheet are subject to change without notice.

" " % !% '3/+1 !8 .'25'/-3 $+'8.+6 .'25'/-3 '3/+1 !8 & & 9/1*/3- 3'1<7/7&$/8. 6'*+ 3791'8/43&$/8.498 # (1-

& ! 11/34/7 !41'6 +)'8.143 11/34/7 !41'6 +)'8.143 " 11/34/7 !41'6 +)'8.143

640+)8+* '8/3 '8+6

!% " ! 9/1*/3- '2+

'3/+1 !8

;3+6 7 '2+ 645+68< **6+77

'3/+1 !8

/8< !8 %/5

.'25'/-3

.43+ 92(+6

9/1*+6 7 '2+

11/34/7 !41'6 +)'8.143

.43+ 92(+6

43+

2'/1 **6+77

43+

1'3 4*+1 '2+

+:+6(

42293/8< +:+1452+38 +62/8 '8+ 92(+6

& ! ! 6-'3/='8/43 '2+ **6+77 /8< !8 %/5 .43+ 92(+6 $+(7/8+

11/34/7 !41'6 +)'8.143 46'*4 "',8 6/:+

.'25'/-3

! ! 64:/*+6

!'251+ !+8

+-/786< '8+6 7 '2+

11/34/7 !41'6 +)'8.143

'8+6 7

'8+6 7 2'/1

'8+6 '8/3- /+1* 375+)846 '8+6 '8/3- /+1* 375+)846

4(+68 4<

'8/3- '8+

'8/3- "<5+

640+)8+* '8/3-

+'743 ,46 '8/3-

+; 42+ ! ! % % ! !$ # "./7 /3,462'8/43 *4+7 348 )4378/898+ '3< ;'66'38< 4, +3+6-< )478 46 7':/3-7 > 46+7)4 491*+6 4146'*4

Volume 2 - Team Illinoize - Page 48

" " % !% !-)%+ 2 (!,/!)'- %!2(%0 (!,/!)'- !-)%+ 2 3)+$)-' -!+61)1 )2( 0!$% -13+!2).- )2(.32 "+'

) ! # )"" &, 0.*%#2%$ !2)-' !2%0

& ! ++)-.)1 .+!0 %#!2(+. ++)-.)1 .+!0 %#!2(+. " ++)-.)1 .+!0 %#!2(+.-

&$% &(, +83/6 $> 2+7:+318 (/+>2/< 2+7:+318 +83/6 $> # * * ?36.381 8+6C=3=*(3>2 <+./ 8=?6+>398*(3>29?>"' ,61

"<94/->/. #+>381 #+>/<

& # - ( $# 663893= $96+< /-+>2698 663893= $96+< /-+>2698

) ! & 663893= $96+< /-+>2698

! !

# & ! ) ! # # $&" ( $#

!2)-' 3,"%0

</+ 90 98.3>398/. $:+-/ =; 0>

'96?7/ 90 98.3>398/. $:+-/

)/+< ?36>

9?=381 %C:/

?:6/B =3816/ ?83>

/@/6 %C:/ :+<>7/8>= !86C

98/

699<= 98 9< ,9@/ <+./

?7,/< 90 /.<997=

9?8.+>398 %C:/

&8-98.3>398/. ,+=/7/8>

8-69=/. <+A6 $:+-/ %C:/

?7,/< 90 $>9<3/= 8-6?.381 98.3>398/. +=/7/8>

# %

%2/<7+6 9?8.+<C 9-+>398

# /0+?6>

$)# ( $# !! # $&" ( $# +7/

+=> (/=> $9?>2 9<>2

3,<+<C 8><C

9-+>398

/81>2 0>

%9>+6 /312> 0>

/:>2 /69A <+./ 0>

/312> ,9@/ <+./ 0>

&9 '+6?/ &9 '+6?/ 97,9 A+66 986C

# <+:/. ?66

&8-98. ,=7> +7, 1<8.

# <+:/. ?66

&8-98. ,=7> +7, 1<8.

# <+:/. ?66

&8-98. ,=7> +7, 1<8.

# <+:/. ?66

&8-98. ,=7> +7, 1<8.

&9 '+6?/ 97,9 -97,38/= A+66 +3<0367 +8. =936 :+>2

$)# ( $# !! & &, '( $)# ( $# !! & % )!!

%C:/

$963. -98-</>/ 9< =>98/

%23-58/== 38

$>?.=

98/

8>/<39< 8=?6+>398

98>38?9?= # '+6?/

<+7/ +@3>C # '+6?/

+@3>C 8=?6+>398 <+./ ! ! % % ! !$ # ()1 )-&.0,!2).- $.%1 -.2 #.-12)232% !-6 5!00!-26 .& %-%0'6 #.12 .0 1!4)-'1 7 .0%1#. .3+$%0 .+.0!$.

!'% .&

$ $ !' ! !#' (50,3 "; /(47(0.5 &,(;/,9 /(47(0.5 (50,3 "; ! ' ' <03+05. 5(3@:0:'&0;/ 9(+, 5:<3(;065'&0;/6<; % )3.

( ' #( ! # & , # !,' ' # ( # $ (+ & * %23= 3809<7+>398 .9/= 89> -98=>3>?>/ +8C A+<<+8>C 90 /8/<1C -9=> 9< =+@381= D 9</=-9 9?6./< 969<+.9

) ! # )"" &,

! ( # 330560: "63(9 ,*(;/365 330560: "63(9 ,*(;/365 $ ! 330560: "63(9 ,*(;/365

961,*;,+ !(;05. !(;,9

&$% &(, ,9407 &? 3,8;,429 *0,?30= 3,8;,429 ,9407 &? % + + @47/492 9,7D>4>+*4?3 =,/0 9>@7,?4:9+*4?3:@?#) -72

$ # ! !' "#

& # - ( $# 7749:4> &:7,= 0.,?37:9 7749:4> &:7,= 0.,?37:9 ) ! & 7749:4> &:7,= 0.,?37:9

#=:50.?0/ %,?492 %,?0= !

& " !$$& & &, '(

5: ;67

-; -964 ;67 6- >(33

:4>? &;,.492 49 :.

5: 6;;64

-; -964 )6;;64 6- >(33

=,8492 ,.?:= /01,@7?

%# '

?;,9069 5:<3(;065

7::= :A0=492

! %(3<,

!:?0

5: ;67

-; -964 ;67 6- >(33

5: )6;;64

-; ),36> .9(+,

$* & !!

6;,

! ! ! # (4, 5+ 3669

:; 3669

0)9(9@ 5;9@

6*(;065

9,( :8 -;

$6 %(3<,

! # $505:<3(;,+

;>5 *65+ *65+ (+0()(;0*

;>5 *65+ <5*65+ ):4;

3669 $505:<3(;,+

5-694(;065 964 <0*2 033 "*9,,5 65;056<: 5:<3(;065 ! %(3<,

(=0;@ 5:<3(;065 ! %(3<,

(=0;@ 5:<3(;065 #/0*25,:: 05

(=0;@ 5:<3(;065 9(+,

9(405. (*;69 +,-(<3;

3669 6=,905.

! #

4-=,=D 9?=D

*0>? *,77

& #

:9/ ,8-409?

0/4@8

&:@?3 *,77

& #

:9/ ,8-409?

:.,?4:9

0/4@8

!:=?3 *,77

& #

:9/ ,8-409?

0/4@8

C?0=4:= :7:=

% '

*,77 :9>?=@.?4:9 'D;0

&?=@.?@=,7 9>@7,?0/ #,907

:9?49@:@> 9>@7,?4:9 % ),7@0

=,80 ,A4?D 9>@7,?4:9 % ),7@0

=,80 ,A4?D 9>@7,?4:9 '34.690>> 49

&?@/ &4E0 B C / 49

&?@/ &;,.492 49 : .

=,8492 ,.?:= /01,@7?

D;>@8 '34.690>> 49

# $+ # $&" ( $# "A0=3,92

3669 ! 5-694(;065 964 <0*2 033 "*9,,5

!,80

*,77 >>429809?

"=409?

!* 0/=::8

*,77

(=0;@ 5:<3(;065 ! %(3<,

(=0;@ 5:<3(;065 #/0*25,:: 05

(=0;@ 5:<3(;065 9(+,

!* 0/=::8

60:; "0A, > ? / 05

&?@/D =0,

# " # ! ' '" " # #& ! % #/0: 05-694(;065 +6,: 56; *65:;0;<;, (5@ >(99(5;@ 6- ,5,9.@ *6:; 69 :(=05.: B 69,:*6 6<3+,9 6369(+6

(: ),7@0

!:?0

6;,

65;056<: 5:<3(;065 ! %(3<,

=0, >< 1?

$* & !! & &, '(

$* & !!

=,80 ,A4?D 9>@7,?4:9 =,/0

60:; "7(*05. 05 6*

!,80

91:=8,?4:9 =:8 $@4.6 477 &.=009

! ! ! !' "#

60:; "0A, > ? / 05

"+1/ 90

(., 6-

( ),7@0

=0, ><1?

*0>?

*,77

*0>?

*,77

*0>?

9?0=4:=

0;?3 ': ':; ': ?8 1? 1? 1?

/5,.09?

*49?0= &3,/492

&@880= &3,/492

*49?0= &3,/492

&@880= &3,/492

!:90

( ' #( ! # & , # !,' ' # ( # $ (+ & * '34> 491:=8,?4:9 /:0> 9:? .:9>?4?@?0 ,9D B,==,9?D :1 090=2D .:>? := >,A492> F !:=0>.: :@7/0= :7:=,/:

#,20 :1

Volume 2 - Team Illinoize - Page 49

" " % !% )61-4 "< 0)58)1/6 &-)<0-: 0)58)1/6 )61-4 "< ! ( ( =14,16/ 6)4A;1;(&1<0 :),- 6;=4)<176(&1<07=< % *4/

) ! # )"" &,

:72-+<-, !)<16/

!)<-:

& ! 441671; "74): -+)<0476 441671; "74): -+)<0476 " 441671; "74): -+)<0476

&$% &(, +83/6 #> 2+7:+318 '/+>2/< 2+7:+318 +83/6 #> " * * ?36.381 8+6C=3=*'3>2 <+./ 8=?6+>398*'3>29?> & ,61

$ ! >-:0)6/ )5-

&)44 ;;1/65-6<

:1-6<

$ %)4=-

:-) ;9.<

"<=,A :-)

&)44

&-;<

"& -,:775

&)44

&-;<

"& -,:775

&)44

&-;<

)514A !775

&)44

&-;<

1<+0-6

&)44

&-;<

1<+0-6

&)44

&-;<

1>16/ !775

&)44

&-;<

6<-:17:

-8<0 #7 #78 #7 <5 .< .< .<

<94/->/. "+>381

"+>/<

& # - ( $# 663893= #96+< /-+>2698 663893= #96+< /-+>2698

) ! & 663893= #96+< /-+>2698

$$ & &, '( ! # !$+# ((

,2)+-6<

&16<-: "0),16/

"=55-: "0),16/

&16<-: "0),16/

"=55-: "0),16/

76-

8=?6+>/. <+7381 #:+-381 38 9 -

76-

<+7381 +->9< ./0+?6>

76-

/36381 $C:/

>>3-

76-

9>/

,! ( # $&" ( $#

! #

1>16/ !775

&)44

"7=<0

76-

" -,:775

&)44

"7=<0

76-

" -,:775

&)44

"7=<0

76-

)514A !775

&)44

7:<0

76-

-,:775

&)44

7:<0

-,:775

&)44

7:<0

1*:):A 6<:A

&)44 ;;1/65-6<

"7=<0 77:

"<--4 =:<0 ? *:3

7:<0 &)44

"<--4 =:<0 ? *:3

98>389?= 8=?6+>398 " &+6?/

+@3>C 8=?6+>398 " &+6?/

+@3>C 8=?6+>398 $23-58/== 38

+@3>C 8=?6+>398 <+./

C:=?7 $23-58/== 38

8=?6+>/. <+7381 #3D/ A B 2 38

" $

+7/

"990 ==3187/8>

<3/8>+>398

% &+6?/

</+ =; 0>

'38>/< #2+.381

#?77/< #2+.381

3>-2( )

76-

&/6?B #5C6312>=

"990

'/=>

76-

&/6?B #5C6312>=

"990

'/=>

76-

&/6?B #5C6312>=

"990

'/=>

&/6?B #5C6312>=

"990

'/=>

! )5-

809<7+>398 <97 !?3-5 366 #-<//8

8)9= :-) ;9 .<

$7 %)4=-

! %)4=- 7. 8)9=- :-)

"<7:5 77:

&)44

! )5-

1*:):A 6<:A

!77.

! 47?6 <<1+

-1416/ :-) ;9 .<

!77. :-) ;9 .<

@<-:17: 747:

!),1)6< )::1-:

#A8-

$7 %)4=-

-5-6< 7: 4)A #14-;

!77. #14%-6<14)<176

!-.4-+<1>-

<<1+

'-;

! ! % % ! !$ # #01; 16.7:5)<176 ,7-; 67< +76;<1<=<- )6A ?)::)6<A 7. -6-:/A +7;< 7: ;)>16/; B 7:-;+7 7=4,-: 747:),7

( ! (

%"# %'+ (50,3 ": /(47(0.5 &,(:/,8 /(47(0.5 (50,3 ": ! ' ' ;03+05. 5(3?909'&0:/ 8(+, 59;3(:065'&0:/6;: % )3.

% ! , ' "! 3305609 "63(8 ,*(:/365 3305609 "63(8 ,*(:/365

( % 3305609 "63(8 ,*(:/365

861,*:,+ !(:05.

!(:,8

! !#' -9517 (> 4-8;-539 " +1->41< 4-8;-539 " -9517 (> ' , , ?570593 9-7C=5=,+5>4 <-01 9=?7->5:9,+5>4:?>&* .73

! ( # 7759:5= (:7-< 1/->47:9 7759:5= (:7-< 1/->47:9 $ ! 7759:5= (:7-< 1/->47:9

&<:61/>10 '->593 '->1< $

$ #

;4),8 6- ,*/(50*(3 "?9:,49

,(:05. ",: 605:

,(:05. ",:)(*2 #/,8469:(:

&1</19> ":-0 (1<@10

8,9,5:

66305. ",:;7 #/,8469:(:

8,9,5:

77 .->4 2-?/1>= =4:A1<= 3;8

><?1

77 + ;5;1= 2?77C 59=?7->10 '

><?1

'1/5</?7->5:9 >C;1

$:91 =>-90-<0 =C=>18

-<>41=> 25B>?<1 >: + 41->1<

;,3 #?7,

3,*:80*

)%) " &5;17193>4 2:< 7:931=> + <?9

,(:05. ",(965(3 --0*0,5*?

+ ' ?95> ;<1=19>

><?1

6478,9968 ,(:05. ;:7;: (7(*0:? (: 2 :;/

+ ' ?95> 1225/519/C ;1< (

6478,9968 ,(:05. ;:7;: (7(*0:? (: 2 :;/

+ ' ;<141->= /:70 =?;;7C 2:< =4:A1<

3,*:80* !,909:(5*, (*2;7 (7(*0:? 2&

+ ' ;<141->= 4:> =?;;7C 2:< =4:A1<

><?1

66305. ;:7;: (7(*0:? 2 :;/

$?8.1< =4:A1<41-0= 59 4:81

66305. ",(965(3 --0*0,5*?

" !

$?8.1< =4:A1<= /:991/>10 >: + '

,9;7,8/,(:,8

6:,

! #

;4),8 - $50:9 6*(:065

,8-684(5*, +1;9:4,5:

' ) ><?1

+ 5-39:=>5/=

04A ;0

65+0:065,+ (8,(

;1'->5:

05=4A-=41< ;0

,8*,5: ,(:05. 6(+ ",8<,+

/7:>41=+-=41< :>+->1< &

,8*,5: 66305. 6(+ ",8<,+

122

1A-=>1

>8-59=

0A4<+4 971>)18; 06

' % ' '%

+1/ 90

$ $ !'

! $( # !'

66305. ",: 605:

( ' #( ! # & , # !,' ' # ( # $ (+ & * $23= 3809<7+>398 .9/= 89> -98=>3>?>/ +8C A+<<+8>C 90 /8/<1C -9=> 9< =+@381= E 9</=-9 9?6./< 969<+.9

)/- 7.

&(:,8 ,(:,8 #?7,

,(: 7;47

;,3 #?7,

3,*:80*

5,8.? (*:68

!,*6<,8? --0*0,5*?

&(:,8 #(52 "0@, .(33659

>:8( #(52 59;3(:065 ! %(3;,

;?8; :9=!A4

;?8; :9=#8.>?

6:, ;4),8 - $50:9 6*(:065 ,8-684(5*, +1;9:4,5:

65+0:065,+ (8,( ' & !' ! % + ! +& & ! ' ! " '* % ) #/09 05-684(:065 +6,9 56: *659:0:;:, (5? =(88(5:? 6- ,5,8.? *69: 68 9(<05.9 A 68,9*6 6;3+,8 6368(+6

(., 6-

# " # ! ' '" " # #& ! % )45= 592:<8->5:9 0:1= 9:> /:9=>5>?>1 -9C A-<<-9>C :2 191<3C /:=> :< =-@593= D $:<1=/: :?701< :7:<-0:

&-31 :2

Volume 2 - Team Illinoize - Page 50

% % "( " ! "$( *72.5 %= 1*69*207

(.*=1.; 1*69*207 *72.5 %= $

)

) >25-270 7*5A<2<)(2=1 ;*-. 7<>5*=287)(2=18>="' +50

$ $ !'

";83.,=.- $*=270

$*=.;

" ) $ 552782< %85*; .,*=1587 552782< %85*; .,*=1587 % " 552782< %85*; .,*=1587

! !#' #0+'. 5 *#/2#+)0 !'#5*'3 *#/2#+)0 #0+'. 5 " " 6+.&+0) 0#.94+4"!+5* 3#&' 046.#5+10"!+5*165 $.)

% $ (#$ #

31,'%5'& #5+0) #5'3

! ( # ..+01+4 1.#3 '%#5*.10 ..+01+4 1.#3 '%#5*.10 $ ! ..+01+4 1.#3 '%#5*.10

$ # '"# "

15#. 6%5 '#-#)'

#4%#.4

% $

6%5 +)*50'44 '45

145%104536%5+10 '45

87-2=287.- 588; ;.* <: /=

8/ $.=>;7<

.*=270 %A<=.6

) % "

622.9

10&+5+10'& 42#%'

885270 %A<=.6

) % "

'5630

10&+5+10'& 42#%'

! # #

%>995A >,= %>;/*,. ;.* <: /= $.=>;7 >,= %>;/*,. ;.* <: /=

>,= .*4*0. #>*52=*=2?. <<.<<6.7=

8= 9952,*+5.

$ &

>,= .*4*0. =8 !>=<2-. %>995A !75A $.=>;7 !75A

8= 9952,*+5.

"*<,*5<

&8=*5 >,= .*4*0.

"*<,*5<

>,= &201=7.<< &.<=

"8<=,87<=;>,=287 &.<=

(! %>995A $.=>;7

%>995A $.=>;7

" $ $

87-2=287.- <9*,.

% $ #$ "

87-2=287.- 588; ;.* <: /=

8/ $.=>;7<

.*=270 %A<=.6

) % "

885270 %A<=.6

) % "

%>995A >,= %>;/*,. ;.* <: /=

$.=>;7 >,= %>;/*,. ;.* <: /=

>,= .*4*0. #>*52=*=2?. <<.<<6.7=

8= 9952,*+5.

>,= .*4*0. =8 !>=<2-.

%>995A $.=>;7

8= 9952,*+5.

%>995A !75A

"*<,*5<

$.=>;7 !75A

"*<,*5< $ # $ " ( (# # $ $' " & &12< 27/8;6*=287 -8.< 78= ,87<=2=>=. *7A @*;;*7=A 8/ .7.;0A ,8<= 8; <*?270< B

8;.<,8 8>5-.; 858;*-8

# # & "& (40,2 #9 /(36(0.4 &,(9/,7 /(36(0.4 (40,2 #9 " ' ' :02+04. 4(2=808'&09/ 7(+, 48:2(9054'&09/5:9 % )2.

# " # ! ' '" " # #& ! % *+4 +0(13/#5+10 &1'4 015 %1045+565' #09 8#33#059 1( '0'3)9 %145 13 4#7+0)4 : 13'4%1 16.&'3 1.13#&1

"*0. 8/

" " %

' " 2204508 #52(7 ,*(9/254 2204508 #52(7 ,*(9/254 # 2204508 #52(7 ,*(9/254

751,*9,+ "(904. "(9,7

!% (50,3 !: /(47(0.5 %,(:/,8 /(47(0.5 (50,3 !:

' ' ;03+05. 5(3?909'%0:/ 8(+, 59;3(:065'%0:/6;: $ )3.

" " " "

& ! 3305609 !63(8 ,*(:/365 3305609 !63(8 ,*(:/365 " 3305609 !63(8 ,*(:/365

861,*:,+ (:05.

(:,8

&/52, 5:8, 4-0297(9054

,:(03,+ (;+0:

,(8:7,3,49 $=6,

25<,7 +557 9,89

0./: 0>:;8, 9

2%/ ;9, #9,9 &,(8 & !"

,(904. #,(854 4-0297(9054 %(2:,

(9:7(2

>:,8068 0./: 0>:;8, 9

2%/ ;9, #9,9 &,(8 !:(5+(8+

55204. #,(854 4-0297(9054 %(2:,

(9:7(2

,-80.,8(:68

2%/ ;9, #9,9 &,(8 & !"

#/,29,7 2(88

09/=(9/,8

5+, %,70-0*(9054

$,89,+

<,5 (5.,

2%/ ;9, #9,9 &,(8 & !"

36:/,9 8?,8

2%/ ;9, #9,9 &,(8 & !"

,*/(40*(2 %,4902(9054 -57 !

36:/,9 %(9/,8

2%/ ;9, #9,9 &,(8 & !"

$=6,

(2(4*,+

!/6=,8 (:/

(33659 ;9, #9,9 &,(8 !:(5+(8+

"(9, *-3

3;. 6(+ 9

2%/ ;9, #9,9 &,(8 !:(5+(8+

" $

#,480)2, ",*5;,7= --0*0,4*=

$59(2 ",*5;,7= --0*0,4*=

5:78 6,7 (=

(4 5<,7 <(998

(4 5957

-(28,

#)' 1(

%,4902(9054 #97(9,.= -57 55204.

55204. #,(854 %,4902(9054

&/52, 5:8, (4

" ! " & &! ! " "% $ $/08 04-573(9054 +5,8 459 *548909:9, (4= <(77(49= 5- ,4,7.= *589 57 8(;04.8 > 57,8*5 5:2+,7 5257(+5

(., 5-

2%/ ;9, #9,9 &,(8 !:(5+(8+

" ! ! % % ! !$ # "/09 05-684(:065 +6,9 56: *659:0:;:, (5? =(88(5:? 6- ,5,8.? *69: 68 9(<05.9 @ 68,9*6 6;3+,8 6368(+6

(., 6-

Volume 2 - Team Illinoize - Page 51

# # (50,3 "; /(47(0.5 %,(;/,9 /(47(0.5 (50,3 "; ! ' ' <03+05. 5(3@:0:'%0;/ 9(+, 5:<3(;065'%0;/6<; $ )3.

" " % 961,*;,+ !(;05. !(;,9

$ 330560: "63(9 ,*(;/365 330560: "63(9 ,*(;/365 330560: "63(9 ,*(;/365

!% )51-3 "; 0)47)1/5 &-);0-9 0)47)1/5 )51-3 "; ! ( ( <13,15/ 5)3?:1:(&1;0 9),- 5:<3);165(&1;06<; % *3/

962-+;-, !);15/

!);-9

& ! 331561: "63)9 -+);0365 331561: "63)9 -+);0365 " 331561: "63)9 -+);0365

% %

!,8<09,4,5;:

64- <13,-9 <4*-9

$,90-0,+

;9<,

331561: "63)9 -+);0365

$,90-0,+

;9<,

)5,);69? !-8<19-4-5;:

$,90-0,+

;9<,

%-91.1-, -5-:;9);165

;9<-

%-91.1-, 5:<3);165

;9<-

$,90-0,+

;9<,

%-91.1-, <+; 6+);165

;9<-

$,90-0,+ &

$,90-0,+

-(3:,

;9<,

%-91.1-, 7731)5+-

;9<-

$,90-0,+

-(3:,

;9<-

%-91.1-, 1/0;15/

%-91.1-, )5 ..1+1-5+?

;9<-

!,8<09,4,5;:

%-91.1-, &);-9 ..1+1-5+?

;9<-

!(;,9 *,9;0-0,: ;/(; ;/, /64, *64730,: >0;/ ;/, -6336>05.

! #

%-91.1-, 5,669 )19 $"

;9<-

9,8<09,4,5;: -69

! & "# ! $

%-91.1-, !-5->)*3- 5-9/? !-),? "63)9 3-+;91+

;9<-

!(;,9 ,:0.5 !,=0,> /,*230:;

!(;,9 0,3+ /,*230:;

7;165)3 64- <13,-9 6441;4-5;: .69 !-+6/51;165

$ ,:0.5 !,769;

-9;1.1-, <5,-9 ;0- &);-9"-5:- .69 -> 64-: 96/9)4

$ 6440::06505. /,*230:; 67;065(3

! & "# ! $,9:065 7730(5*,: !,-90.,9(;69:

-9;1.1-, <5,-9 ;0- " .69;1.1-, .69 ").-9 1=15/ 96/9)4

6336>-, ;0- '-96 5-9/? !-),? 64- <)31;? )5)/-4-5; <1,-315-:

46<5;

0:/>(:/,9:

! & "# ! $,9:065 (:,4,5;:

(:,4,5; %(33 9,( ,36> 9(+

-(3:,

(:,4,5; 3669 9,(

9,:*907;0=, !,8<09,4,5;: -69 ! & "# ! =

-(3:,

"3() 5:<3(;065 ?,47;065

-(3:,

5+669 (09 3<: $,90-0*(;065 /,*230:;

;9<,

,0305. (5: ?/(<:; (5:

0,3+ 77

#0- *<?-9 6. ;01: 064- :1/5-, ) >)1=-9 /1=15/ '-96 5-9/? 6 !-),? 64- )++-:: ;6 <;131;? *133 ,);) .69 65- ?-)9

! # "?:;-4 #?7-

?*91,

633-+;69 667 #?7-

);+0 0-);-9

633-+;69 #?7-

65-

633-+;69 91-5;);165

65-

9-) :8 .;

#13; ,-/9--:

%63<4- +< .; /)3

# # " ! #/0: 05-694(;065 +6,: 56; *65:;0;<;, (5@ >(99(5;@ 6- ,5,9.@ *6:; 69 :(=05.: A 69,:*6 6<3+,9 6369(+6

42543*39 438:259.43 745*79= 4A<8? ,G

;4@C4<:A #&

084G;8E ;4@C4<:A #& 4A<8? ,G

+ 3 3 H<?7<A: A4?LF<F30<G;! E478#AFH?4G<BA30<G;BHG*/ 5?:

)/- 6.

42543*39 438:259.43

!" *EB=86G87 +4G<A:

# (

7,'3.>'9.43 #??<AB<F ,B?4E 864G;?BA #??<AB<F ,B?4E 864G;?BA :.1)*7 #??<AB<F ,B?4E 864G;?BA

! ! % % ! !$ # #01: 15.694);165 ,6-: 56; +65:;1;<;- )5? >)99)5;? 6. -5-9/? +6:; 69 :)=15/: @ 69-:+6 6<3,-9 6369),6

(., 6-

+ *'9.3, "*'843

+ -

9: =7

8<?<A:F +BB9F

+<@ 4A7 $B<FGF

5BI8 !E478 04??F

BHA74G<BA 04??F

BBEF

0<A7BJF ,>L?<:;GF

?BBEF

!" *EB=86G87 +4G<A:

# (

7,'3.>'9.43 #??<AB<F ,B?4E 864G;?BA #??<AB<F ,B?4E 864G;?BA :.1)*7 #??<AB<F ,B?4E 864G;?BA

745*79= 4A<8? ,G

;4@C4<:A #&

084G;8E ;4@C4<:A #& 4A<8? ,G

+ 3 3 H<?7<A: A4?LF<F30<G;! E478#AFH?4G<BA30<G;BHG*/ 5?:

441.3, "*'843

9: =7

8<?<A:F +BB9F

+<@ 4A7 $B<FGF

5BI8 !E478 04??F

BHA74G<BA 04??F

BBEF

0<A7BJF ,>L?<:;GF

?BBEF

E4J? ,C468 .A;G F@G

,?45 ?BBEF

#A9<?GE4G<BA

'86;4A<64? /8AG<?4G<BA

H6GF

6G<I8 ,B?4E

,HAFC468

#AG8EA4? !4<AF

-BG4?

#AG8EA4? !4<AF

0;B?8 "BHF8 /8AG<?4G<BA

-BG4?

"84G<A: ,84FBA '' GH LE BB?<A: ,84FBA '' GH LE

,HAFC468

H6GF

6G<I8 ,B?4E

#A9<?GE4G<BA

'86;4A<64? /8AG<?4G<BA

,?45 ?BBEF

E4J? ,C468 .A;G F@G

?BBEF

BBEF

BHA74G<BA 04??F

'' GH LE

5BI8 !E478 04??F

+<@ 4A7 $B<FGF

! !'9* !*8.)*39.'1 3*7,= 3'1=8.8 '3) !'9.3, "4+9<'7* ;

-;<F <A9BE@4G<BA 7B8F ABG 6BAFG<GHG8 4AL J4EE4AGL B9 8A8E:L 6BFG BE F4I<A:F

N (BE8F6B BH?78E B?BE47B

*4:8 B9

! !'9* !*8.)*39.'1 3*7,= 3'1=8.8 '3) !'9.3, "4+9<'7* ;

-;<F <A9BE@4G<BA 7B8F ABG 6BAFG<GHG8 4AL J4EE4AGL B9 8A8E:L 6BFG BE F4I<A:F

N (BE8F6B BH?78E B?BE47B

0;B?8 "BHF8 /8AG<?4G<BA

#AG8EA4? !4<AF

0<A7BJF ,>L?<:;GF

#AG8EA4? !4<AF

,HAFC468

6G<I8 ,B?4E

H6GF

#A9<?GE4G<BA

'86;4A<64? /8AG<?4G<BA

,?45 ?BBEF

?BBEF

E4J? ,C468 .A;G F@G

0<A7BJF ,>L?<:;GF

BBEF

5BI8 !E478 04??F

+<@ 4A7 $B<FGF

BHA74G<BA 04??F

8<?<A:F +BB9F

'' GH LE

8<?<A:F +BB9F

*4:8 B9

Volume 2 - Team Illinoize - Page 52

42543*39 *8.,3 4')8

745*79= 4A<8? ,G

;4@C4<:A #&

084G;8E ;4@C4<:A #& 4A<8? ,G

+ 3 3 H<?7<A: A4?LF<F30<G;! E478#AFH?4G<BA30<G;BHG*/ 5?:

745*79= 4A<8? ,G

;4@C4<:A #&

084G;8E ;4@C4<:A #& 4A<8? ,G

+ 3 3 H<?7<A: A4?LF<F30<G;! E478#AFH?4G<BA30<G;BHG*/ 5?:

7,'3.>'9.43 #??<AB<F ,B?4E 864G;?BA #??<AB<F ,B?4E 864G;?BA :.1)*7 #??<AB<F ,B?4E 864G;?BA

!" *EB=86G87 +4G<A:

# (

+ *'9.3,

+<@ 4A7 $B<FGF

5BI8 !E478 04??F

BHA74G<BA 04??F

BBEF

0<A7BJF ,>L?<:;GF

?BBEF

!" *EB=86G87 +4G<A:

# (

+ -

0 9: -7

8<?<A:F +BB9F

7,'3.>'9.43 #??<AB<F ,B?4E 864G;?BA #??<AB<F ,B?4E 864G;?BA :.1)*7 #??<AB<F ,B?4E 864G;?BA

441.3,

0 9: -7

8<?<A:F +BB9F

+<@ 4A7 $B<FGF

5BI8 !E478 04??F

BHA74G<BA 04??F

BBEF

0<A7BJF ,>L?<:;GF

?BBEF

E4J? ,C468 .A;G F@G

,?45 ?BBEF

#A9<?GE4G<BA

'86;4A<64? /8AG<?4G<BA

H6GF

6G<I8 ,B?4E

,HAFC468

#AG8EA4? !4<AF

0;B?8 "BHF8 /8AG<?4G<BA

#AG8EA4? !4<AF -BG4?

-BG4?

"84G<A: % GH "E BB?<A: % GH "E

% GH "E

,HAFC468

#AG8EA4? !4<AF

745*79= 4A<8? ,G

;4@C4<:A #&

084G;8E ;4@C4<:A #& 4A<8? ,G

+ 3 3 H<?7<A: A4?LF<F30<G;! E478#AFH?4G<BA30<G;BHG*/ 5?:

*4:8 B9

*;BGBIB?G4<6F

#49'1

"84G<A:

BB?<A:

04G8E "84G<A:

&<:;GF CC?<4A68F

+ -

! !'9* !*8.)*39.'1 3*7,= 3'1=8.8 '3) !'9.3, "4+9<'7* ;

-;<F <A9BE@4G<BA 7B8F ABG 6BAFG<GHG8 4AL J4EE4AGL B9 8A8E:L 6BFG BE F4I<A:F

N (BE8F6B BH?78E B?BE47B

! !'9* !*8.)*39.'1 3*7,= 3'1=8.8 '3) !'9.3, "4+9<'7* ;

-;<F <A9BE@4G<BA 7B8F ABG 6BAFG<GHG8 4AL J4EE4AGL B9 8A8E:L 6BFG BE F4I<A:F

N (BE8F6B BH?78E B?BE47B

*;BGBIB?G4<6F

,8EI<68 ;4E:8F

#49'1

0 9: -7

,C468 "84G<A:

,C468 BB?<A:

$9.1.9= !'9*8 ?86GE<6<GL

894H?G ?86GE<6 *EBI<78E

-BG4?

*;BGBIB?G4<6F

&<:;GF CC?<4A68F

04G8E "84G<A:

BB?<A:

&<:;GF CC?<4A68F

"84G<A: 04G8E "84G<A:

"84G<A:

9: =7

'' GH LE

33:'1 438:259.43

04G8E "84G<A: J BHG -4A> &BFF

33:'1 4')

04G8E "84G<A:

!" *EB=86G87 +4G<A:

+4G8E # (

7,'3.>'9.43 #??<AB<F ,B?4E 864G;?BA #??<AB<F ,B?4E 864G;?BA :.1)*7 #??<AB<F ,B?4E 864G;?BA

BB?<A:

"84G<A:

BB?<A:

*8.,3 4')8

0;B?8 "BHF8 /8AG<?4G<BA

6G<I8 ,B?4E

'86;4A<64? /8AG<?4G<BA

#A9<?GE4G<BA

H6GF

,?45 ?BBEF

?BBEF

E4J? ,C468 .A;G F@G

BBEF

*7+472'3(* !*5479 !" *EB=86G87 +4G<A:

+4G8E # (

9: =7

33:'1 3*7,= 489

! !'9* !*8.)*39.'1 3*7,= 3'1=8.8 '3) !'9.3, "4+9<'7* ;

-;<F <A9BE@4G<BA 7B8F ABG 6BAFG<GHG8 4AL J4EE4AGL B9 8A8E:L 6BFG BE F4I<A:F

N (BE8F6B BH?78E B?BE47B

*4:8 B9

"84G<A:

33:'1 438:259.43

0<A7BJF ,>L?<:;GF

BHA74G<BA 04??F

5BI8 !E478 04??F

8<?<A:F +BB9F

'' GH LE

33:'1 4')

#AG8EA4? !4<AF

6G<I8 ,B?4E

H6GF

'86;4A<64? /8AG<?4G<BA

,?45 ?BBEF

*7+472'3(* !*5479 7,'3.>'9.43 #??<AB<F ,B?4E 864G;?BA #??<AB<F ,B?4E 864G;?BA :.1)*7 #??<AB<F ,B?4E 864G;?BA

! !'9* !*8.)*39.'1 3*7,= 3'1=8.8 '3) !'9.3, "4+9<'7* ;

-;<F <A9BE@4G<BA 7B8F ABG 6BAFG<GHG8 4AL J4EE4AGL B9 8A8E:L 6BFG BE F4I<A:F

N (BE8F6B BH?78E B?BE47B

745*79= 4A<8? ,G

;4@C4<:A #&

084G;8E ;4@C4<:A #& 4A<8? ,G

+ 3 3 H<?7<A: A4?LF<F30<G;! E478#AFH?4G<BA30<G;BHG*/ 5?:

E4J? ,C468 .A;G F@G

?BBEF

BHA74G<BA 04??F

5BI8 !E478 04??F

8<?<A:F +BB9F

+<@ 4A7 $B<FGF

,HAFC468

#A9<?GE4G<BA

+<@ 4A7 $B<FGF

BBEF

0<A7BJF ,>L?<:;GF

% GH "E

*4:8 B9

Volume 2 - Team Illinoize - Page 53

*7+472'3(* !*5479 745*79= 4A<8? ,G

;4@C4<:A #&

084G;8E ;4@C4<:A #& 4A<8? ,G

+ 3 3 H<?7<A: A4?LF<F30<G;! E478#AFH?4G<BA30<G;BHG*/ 5?:

7,'3.>'9.43 #??<AB<F ,B?4E 864G;?BA #??<AB<F ,B?4E 864G;?BA :.1)*7 #??<AB<F ,B?4E 864G;?BA

!" *EB=86G87 +4G<A:

+4G8E # (

33:'1 3*7,= 489

*8.,3 4')8

74/*(9*) !'9.3, '8*) 43 1'38 .*1) 43+.72'9.43 !*6:.7*)

> GH ;E

4A<8? ,G

#??<AB<F ,B?4E 864G;?BA

+ -

#??<AB<F ,B?4E 864G;?BA

-BG4?

*;BGBIB?G4<6F

,8EI<68 ;4E:8F

&<:;GF CC?<4A68F

04G8E "84G<A:

"84G<A:

BB?<A:

+ ,C468 "84G<A:

,C468 BB?<A:

+ ' +4G8 +8F<78AG<4? A8E:L A4?LF<F 4A7 +4G<A: ,B9GJ4E8 I

! !'9* !*8.)*39.'1 3*7,= 3'1=8.8 '3) !'9.3, "4+9<'7* ;

-;<F <A9BE@4G<BA 7B8F ABG 6BAFG<GHG8 4AL J4EE4AGL B9 8A8E:L 6BFG BE F4I<A:F

N (BE8F6B BH?78E B?BE47B

*4:8 B9

! & "# ! ; 42* %*7.+.('9.43 ":22'7= 745*79= 4A<8? ,G

;4@C4<:A #&

084G;8E ;4@C4<:A #& 4A<8? ,G

+ 3 3 H<?7<A: A4?LF<F30<G;! E478#AFH?4G<BA30<G;BHG*/ 5?:

!" *EB=86G87 +4G<A:

+4G8E # (

7,'3.>'9.43 #??<AB<F ,B?4E 864G;?BA #??<AB<F ,B?4E 864G;?BA :.1)*7 #??<AB<F ,B?4E 864G;?BA

Illinois Solar Decathlon 2/28/2017 63 E. Daniel St. Champaign, IL 61820

Illinois Solar Decathlon N/A 2017-02-10 3.1

74/*(9*) !'9.3, '8*) 43 1'38 .*1) 43+.72'9.43 !*6:.7*) :.1).3, 3+472'9.43

!'9.3,

BA7<G<BA87 E84 FD 9G

" +, #A78K

BA7<G<BA87 /B?H@8 6H5<6 9G

" +, #A78K J B */

#AFH?4G87 ,;8?? E84 FD 9G

" +, #A78K -4E:8G , 7=HFG87

(H@58E B9 87EBB@F

" +, #A78K B9 +898E8A68 8F<:A "B@8

HC?8K F<A:?8 HA<G

,<M8 7=HFG@8AG 46GBE

"BHF<A: -LC8 BHA74G<BA -LC8

.A6BA7<G<BA87 54F8@8AG

-;<F ;B@8 ' -, )+ 1 , G;8 * F E8DH<E8@8AGF 9BE 4A ( +!2 ,- + "B@8

" +, #A78K J B */ " +, #A78K B9 +898E8A68 8F<:A "B@8 ( " +, #A78K " +, #A78K -4E:8G GB 6B@C?L

+ -

:.1).3, "-*11

8<?<A: J GG<6 + ?BJA GG<6 .

0<A7BJ -LC8 ,6;H6B 0,

,84?87 GG<6 (BA8

0<A7BJ . /4?H8

,"!

/4H?G87 8<?<A: (BA8

0<A7BJ 04?? +4G<B

5BI8 !E478 04??F ,#* .

#A9<?GE4G<BA -LC8 ?BJ8E 7BBE G8FG

BHA7 04??F BA7 (BA8

#A9<?GE4G<BA "G:

"A4G

BHA7 04??F .A6BA7 + E4C87 H?? +

H6G &84>4:8 GB )HGF<78

' *4F64?F

?BBEF + .

-BG4? H6G &84>4:8

' *4F64?F

,?45 ?BBEF (BA8

*(-'3.('1 "=89*28 ,"*

"G: > GH;

",* ?:

> GH;

, +

04G8E "84G<A:

"84G CH@C ?86

+ JE4C

*EB:E4@@45?8 -;8E@BFG4G

"84G 28F BB? 28F

/8AG<?4G<BA ,LFG8@

4?4A687 +/ 69@

J4GGF

Htg: 0.03 Clg: 0.03 ACHnat Ceiling: R-73.0

FndWall: R-19.0

AGWall: R-40.0

Floor: R-40.0

U-Value: 0.170, SHGC: 0.190

4.10 CFM25.

Refrigerators: 1

Dishwashers: 1

8.00 CFM25.

Ceiling Fans: 0

Exhaust Fans: 1

Electric, Htg: 10.0 HSPF. Clg: 19.0 SEER.

Heat pump, Electric, 0.95 EF, 30.0 Gal, R-8 wrap.

Electric, Htg: 10.0 HSPF. Clg: 19.0 SEER.

.,-98 '3) 551.'3(*8 *8E68AG #AG8E<BE &<:;G<A:

?BG;8F EL8E H8?

?86GE<6

*8E68AG KG8E<BE &<:;G<A:

?BG;8F EL8E

+89E<:8E4GBE >0; LE

?BG;8F 04F;8E & +

<F;J4F;8E A8E:L 46GBE

?BG;8F 04F;8E 4C46<GL

8<?<A: 4A 69@ 04GG

+4A:8 )I8A H8?

?86GE<6

The certificate provides a summary of the major energy efficiency and other construction features that contribute to this home earning the ENERGY STAR, including its Home Energy Rating System(HERS) score, as determined through independent inspection and verification performed by a trained professional. The home Energy Rating System is a nationally-recognized uniform measurement of the energy efficiency of homes. Note that when a home contains multiple performance levels for a particular feature (e.g., window efficiency or insulation levels), the predominant value is shown. Also, homes may be certified to earn the ENERGY STAR using a sampling protocol, whereby one home is randomly selected from a set of homes for representative inspections and testing. In such cases, the features found in each home within the set are intended to meet or exceed the values presented on this certificate. The actual values for your home may differ, but offer equivalent or better performance. This certificate was printed using REM/Rate - v15.3. Â© 1985-2016 Noresco, Boulder, Colorado.

(BG8 0;8E8 984GHE8 ?8I8? I4E<8F <A ;B@8 G;8 7B@<A4AG I4?H8 <F F;BJA

31 ! !'9* !*8.)*39.'1 3*7,= 3'1=8.8 '3) !'9.3, "4+9<'7* ;

-;<F <A9BE@4G<BA 7B8F ABG 6BAFG<GHG8 4AL J4EE4AGL B9 8A8E:L 6BFG BE F4I<A:F

N (BE8F6B BH?78E B?BE47B

Volume 2 - Team Illinoize - Page 54

+47 " 745*79= 4A<8? ,G

;4@C4<:A #&

084G;8E ;4@C4<:A #& 4A<8? ,G

+ 3 3 H<?7<A: A4?LF<F30<G;! E478#AFH?4G<BA30<G;BHG*/ 5?:

0&'!&)$ *(+'& ) " -*+"-/3 (50,3 "; /(47(0.5 &,(;/,9 /(47(0.5 (50,3 "; ! ' ' <03+05. 5(3@:0:'&0;/ 9(+, 5:<3(;065'&0;/6<; % )3.

!" *EB=86G87 +4G<A:

+4G8E # (

7,'3.>'9.43 #??<AB<F ,B?4E 864G;?BA #??<AB<F ,B?4E 864G;?BA :.1)*7 #??<AB<F ,B?4E 864G;?BA

#-.8 -42* :8*8 1*88 *3*7,= 9-'3 9-* !*+*7*3(* 42*

"4:7(* 3*7,= 438:259.43 9: =7

-$ )&4 /&*) 330560: "63(9 ,*(;/365 330560: "63(9 ,*(;/365 0&'!" 330560: "63(9 ,*(;/365

'"(")/.

).0' /&*) "1"'.

"/,33 $ /,*2

: ,:0.5,+

,0305.:

"2@30./;:

8 *8.,3*)

)6=, 9(+, &(33:

&05+6>: (5+ 669:

3669: =,9 $5*65+ (:,4,5;

04G8E "84G<A:

=,9(33 $ ,:0.5 4<:; ), ,8<(3 69 36>,9

&<:;GF CC?<4A68F

*;BGBIB?G4<6F

BB?<A:

+ -

-BG4?

#-.8 -42* #" 9-* 7*6:.7*2*398 +47 )*8.,3'9.43 '8 '3 ! & "# ! :'1.+.*) 42* :3)*7 ;*78.43

8F<:A 6BAFH@CG<BA <F 54F87 BA G;8 9B??BJ<A: 7B@<A4AG 984GHE8F

(H@58E B9 87EBB@F

8<?<A: ?4G +

/4H?G87 8<?<A: (

,84?87 8<?<A: (

5BI8 !E478 04??F +

BHA74G<BA 04??F +

!*+*7*3(* "84G<A:

961,*;,+ !(;05.

!(;,9

)! /*-3 ",0&-"(")/.

! #

"/,33 $ /,*2

"" "

<*; 5:<3(;065 ! %(3<, /,*2 7,9 ",*;065

"" "

&05+6> $ %(3<, (5+ " /,*2 7,9 ",*;065

"" "

64, 5-03;9(;065 ",*;065

"" "

<*; #,:;05. ",*;065

,*/(50*(3 %,5;03(;065 ",*;065

"" "

,*/(50*(3 %,5;03(;065 (5 --0*(*@ ",*;065

"" "

(5+(;69@ !,8<09,4,5;: /,*2 6?

"" "

%&. %*(" /%" *1"- '' /%"-( ' +"-#*-( ) " -",0&-"(")/. )! 1"-&#& /&*). *# /%" )/"-) /&*) ' )"-$3 *)."-1 /&*) *!" ."! *) '&( /" 4*)" *# " /&*) )/"-) /&*) ' )"-$3 *)."-1 /&*) *!" "!&/&*) ) # / /%&. %*(" .0-+ ..". /%" -",0&-"(")/. 3 (4, 330560: "63(9 ,*(;/365

"0.5(;<9,

9.(50A(;065 330560: "63(9 ,*(;/365

KCBF87 ?BBE +

,?45 (

0<A7BJ -LC8 . /4?H8

,"!

#A9<?GE4G<BA ?BJ8E 7BBE G8FG "G:

"A4G

"84G<A: ?86GE<6 "G:

",* ?:

, +

BB?<A: ?86GE<6 "G:

",* ?:

, +

04G8E "84G<A: "84G CH@C ?86GE<6

!4? + JE4C

H6G &84>4:8 GB )HGF<78

/8AG<?4G<BA ,LFG8@ 4?4A687 +/ 69@

J4GGF

*EB:E4@@45?8 -;8E@BFG4G "84G 28F BB? 28F

(;, (9*/

! !'9* !*8.)*39.'1 3*7,= 3'1=8.8 '3) !'9.3, "4+9<'7* ;

-;<F <A9BE@4G<BA 7B8F ABG 6BAFG<GHG8 4AL J4EE4AGL B9 8A8E:L 6BFG BE F4I<A:F

N (BE8F6B BH?78E B?BE47B

/" ".&!")/& ' )"-$3 ) '3.&. )! /&)$ *#/2 -" 1

#/0: 05-694(;065 +6,: 56; *65:;0;<;, (5@ >(99(5;@ 6- ,5,9.@ *6:; 69 :(=05.: B 69,:*6 6<3+,9 6369(+6

*#.%4 +/0 +),(' *!# .+,#.04 )61-4 #< 0)58)1/6 '-)<0-: 0)58)1/6 )61-4 #< " ( ( =14,16/ 6)4A;1;('1<0 :),- 6;=4)<176('1<07=<!& *4/

.% *'5 0'+* 441671; #74): -+)<0476 441671; #74): -+)<0476 1'("#. 441671; #74): -+)<0476

!:72-+<-, ")<16/ ")<-:

**1 ( *#.%4 +/0

/ #/'%*#"

-)<16/

77416/

')<-: -)<16/

1 +0 ( /#" 0+ #0#.)'*# +),(' *!#

1/0<; 8841)6+-;

!07<7>74<)1+;

#-:>1+- 0):/-

+0 (

*" 0+.4 #-1'.#)#*0/

" $

!# # # # ! % " " #

# ! # ! ' " !% # #/09 /53, );02: (: (40,2 ": /(36(0.4 )? 2204509 "52(8 ,*(:/254 ,>*,,+9 :/, 30403;3 8,7;08,3,4:9 -58 :/, 4:,84(:054(2 4,8.? 549,8<(:054 5+,

! #

# "# !

66=)4 6-:/A 7;< 0-+3

! ## #

=+< 6;=4)<176 " &)4=- 0-+3 8-: #-+<176

! ## #

'16,7? % &)4=- )6, # 0-+3 8-: #-+<176

! ## #

",(2,+ ::0*

;*: ,(1(., :5 ;:90+, (9*(29

%(;2:,+ ,0204.

#5:(2 ;*: ,(1(., (9*(29

75- 6.14<:)<176 #-+<176

! ## #

)5<, 8(+, &(229 !

=+< $-;<16/ #-+<176

! ## #

5;4+(:054 &(229 !

-+0)61+)4 &-6<14)<176 #-+<176

! ## #

-+0)61+)4 &-6<14)<176 )6 ..1+)+A #-+<176

! ## #

)6,)<7:A "-9=1:-5-6<; 0-+3 7@

! ## #

&'/ &+)# 0&# **1 ( #*#.%4 !+/0 .#-1'.#)#*0/ +$ #!0'+* +$ 0&# *0#.* 0'+* ( *#.%4 +*/#.2 0'+* +"# /#" +* !(') 0# 5+*# +$ * $ !0 0&'/ &+)# /1., //#/ 0&# .#-1'.#)#*0/ 4 )5- 441671; #74): -+)<0476 :/)61B)<176 441671; #74): -+)<0476

#1/6)<=: )<- ):+0

,0204. 2(: !

>659,+ 2558 ! "2() 54,

;*:

4-02:8(:054 :. 2. 4(:

&04+5= $ %(2;, "

08 "5;8*,

2,*:80* :. " 2. " !

&(:,8 ,(:04. ,(: 6;36 2,*:80* (2 ! =8(6

& " $ " ! " " " ! # ! ! ! ! !" " $ " " # ! ! " ! " # " ! !# "" $ " " " " ! # ! ! " " " # "! $ " " ! " $ " " % # "! (3, 2204509 "52(8 ,*(:/254 8.(40@(:054 2204509 "52(8 ,*(:/254

"0.4(:;8, (:, (8*/

#/, 4:,84(:054(2 4,8.? 549,8<(:054 5+, 09 ( 8,.09:,8,+ :8(+,3(81 5- :/, 4:,84(:054(2 5+, 5;4*02 4* A B 5 <,89054 5- :/09 95-:=(8, /(9 ),,4 8,<0,=,+ 58 (6685<,+ )? 58 0:9 (--020(:,9 ! !(:, !,90+,4:0(2 4,8.? 4(2?909 (4+ !(:04. "5-:=(8, <

6 )++7:,)6+- ?1<0 *=14,16/ 168=<; ;=+0 ); ;-<8716<; 16.14<:)<176 :)<-; )6, ?16,7? ;0),16/ 5)A 0)>- *--6 +0)6/-, 8:17: <7 +)4+=4)<16/ )66=)4 -6-:/A +7;< =:<0-:57:- <0- ;<)6,):, :-.-:-6+- ,-;1/6 & ;A;<-5 -..1+1-6+1-; ):- ;-< -9=)4 <7 <07;- 16 <0,-;1/6 075- ); ;8-+1.1-, 16 <0- $0-;- ;<)6,):,; ):- ;=*2-+< <7 +0)6/- )6, ;7.<?):- =8,)<-; ;07=4, *- 7*<)16-, 8-:17,1+)44A <7 -6;=:- <0- +75841)6+- +)4+=4)<176; :-.4-+< +=::-6< .-,-:)4 51615=5 ;<)6,):,;

0# #/'"#*0' ( *#.%4 * (4/'/ *" 0'*% +$03 .# 2 $01; 16.7:5)<176 ,7-; 67< +76;<1<=<- )6A ?)::)6<A 7. -6-:/A +7;< 7: ;)>16/; C 7:-;+7 7=4,-: 747:),7

Volume 2 - Team Illinoize - Page 55

30,'%5'& /'3): #5+/) /&'9 '1035 301'35: <14,-9 441671: %74*9 -+*;0476 ,,9-:: *61-4 %;

0*58*1/6

3)#/+;#5+0/ 758*6@ 441671: %74*9 -+*;0476 #076- $*;-9 441671: %74*9 -+*;0476

(%! * $ ( / * $ $ . &%(*

/'3): #5+/) /&'9 /(03.#5+0/ #972-+;-, $*;16/ $*;-9 ! *;- $*;-,

" # * %$

45+.#5'& //6#- /'3): 0/46.15+0/ #5'& 0.' #-%6-#5'& /'3): !4' ! -*;16/

#5'& 0.' 045 :3

77416/

'*;-9 -*;16/

1/0;: 8841*6+-: #07;7=74;*1+: 05#-

*:-, 76 :;*6,*9, 78-9*;16/ +76,1;176:

8+5* " 8+5*065 "

$ & 4-+;91+ 3'0

51::176: &76:

6-9/@ %*=16/:

*:-, 76 ;0- 6-9/@ $*;16/ 6,-? $-.-9-6+- -:1/6 75-

#9+.6. /'3): #5+/) /&'9

*+4 0.' 4 /'3): #5+/) /&'9

!*5- 441671: %74*9 -+*;0476 "9/*61A*;176 441671: %74*9 -+*;0476

%1/6*;<9-

;02+04. :/,83(2 ,4<,256, 30403;3 049;2(:054 2,<,29 (4+ 3(>03;3 -,4,9:8(:054 ! ## % -(*:58 (4+ #

!59: ( 6,83(4,4: *,8:0-0*(:, 209:04. :/, 2,<,2 5- ,--0*0,4*,0,9 049:(22,+ 04 :/, /5;9,

,8:0-0*(:, 8,7;08,+ -58

4<,256, (08 2,(1(., 3(>03;3 2,(1(., 8(:,

-58 & ! ##

$()2, "

5362? =0:/ (08 9,(204. (4+ 049;2(:054 8,7;08,3,4:9 04 $()2, "

/,*1209: 8,7;08,+ -58

"5539 *54:(0404. -;,2 );8404. (6620(4*,9

'''''''''''''''

(>03;3 -,4,9:8(:054 % -(*:58 (4+ #

! ##

,(: 6;36 *54:8529

'''''''''''''''

;*:9 5;:90+, 5- *54+0:054,+ 96(*, :5 ), 049;2(:,+ :5 ( 30403;3 5- "

%#&" $ ) %$

! ##

" $

" " "

*+4 *0.' 5*' /'3): #5+/) /&'9 %03' 3'26+3'.'/54 0( '%5+0/ 0( 5*'

/5'3/#5+0/ /'3): 0/4'37#5+0/ 0&' $#4'& 0/ # %-+.#5' ;0/' 0( / #&&+5+0/ 50 5*' /'3): #5+/) /&'9 05*'3 .#/&#503: .'#463'4 .645 $' .'5 '' #/&#503: '26+3'.'/54 0/ 4'%0/& 1#)'

$()2,

//6#- 45+.#5'4

$ *%(/ '+ ( # $*) '+ ( ) " %$ (# * %$

(%, ) %$ +# (

" "

;*: 9,(204. 54 (22 +;*:9

'''''''''''''''

;*: :,9:04. -58 +;*:9 04 ;4*54+0:054,+ 96(*,

;02+04. *(<0:0,9 45: ;9,+ (9 +;*:9

'''''''''''''''

,(:,+ =(:,8 *08*;2(:054 (4+ :,36,8(:;8, 3(04:,4(4*, 9?9:,39 *5362?

'''''''''''''''

5: =(:,8 606, 049;2(:,+ :5 "

! ##

,*/(40*(2 <,4:02(:054 3,,:04. :/, 8,7;08,3,4:9 5- :/, " 58 ;:+558 (08 ''''''''''''''' (4+ ,>/(;9: +(36,89 049:(22,+

(4;(2 (4+ # *54+;*:,+ -58 (22 /,(:04. (4+ *55204. 9?9:,39

*;- *9+0

5839 ",7;08,+ -58 6,830:

#?9:,39 9,8<04. 3;2:062, +=,2204. ;40:9 :5 3,,: :/, 3,*/(40*(2 8,7;08,3,4:9 5- 5,9 5: 662? :/, *533,8*0(2

307+&'3 #5# #/& '#-

#45= 3,2: (4+ 0*, 9?9:,3 *54:8529 049:(22,+ =/,8, (6620*()2,

'''''''''''''''

!5529 (4+ 6,83(4,4: 96( ,4,8.? *549;36:054 3,,: 8,7;08,3,4:9 -58 /,(:,89 :03, *25*19 (4+ *5<,89

'''''''''''''''

& & 758*6@ ,,9-:: 1;@ %;*;- (18

!58:()2, 96(9 3,,: :/, 8,7;08,3,4:9 5- !#!

'''''''''''''''

0./ ,--0*(*? 20./:9 049:(22,+ 04 5- 6,83(4,4:2? 049:(22,+ -0>:;8,9

! ##

"(:,8 /(9 <,80-0,+ :/(: (22 9?9:,39 (8, 04 *53620(4*, =0:/ 8;2,9

#076-

&7 ,-;-9516- 1. * 897=1,-9 1: 8978-94@ *++9-,1;-, /7 ;7 >>> 9-:6-; <: 897.-::176*4 897/9*5: :-*9+0),19-+;79@ #5' '4+&'/5+#- /'3): /#-:4+4 #/& #5+/) 0(58#3' 7 &01: 16.795*;176 ,7-: 67; +76:;1;<;- *6@ >*99*6;@ 7. -6-9/@ +7:; 79 :*=16/:

B !79-:+7 7<4,-9 7479*,7

* ) $* " $ ( / $ "/) ) $ * $ % *- ( , $/09 04-583(:054 +5,9 45: *549:0:;:, (4? =(88(4:? 5- ,4,8.? *59: 58 9(<04.9 @

58,9*5 5;2+,8 5258(+5

!(., 5-

" " % !% &2.*0 !7 -&14&.,2 #*&7-*5 -&14&.,2 &2.*0 !7 % % 8.0).2, 2&0;6.6%#.7- 5&)* 2680&7.32 '0,

& ! 00.23.6 !30&5 *(&7-032 00.23.6 !30&5 *(&7-032 " 00.23.6 !30&5 *(&7-032

53/*(7*) &7.2, &7*5

!% " ! 8.0).2, &1*

&2.*0 !7

:2*5 6 &1* 534*57; ))5*66

&2.*0 !7

.7; !7 $.4

-&14&.,2

-32* 81'*5

8.0)*5 6 &1*

00.23.6 !30&5 *(&7-032

-32* 81'*5

32*

1&.0 ))5*66

32*

0&2 3)*0 &1*

*9*5'

31182.7; *9*0341*27 *51.7 &7* 81'*5

& ! ! 5,&2.<&7.32 &1* ))5*66 .7; !7 $.4 -32* 81'*5 #*'6.7*

00.23.6 !30&5 *(&7-032 35&)3 "&+7 5.9*

-&14&.,2

! ! 539.)*5

!&140* !*7

*,.675;

&7*5 6 &1*

00.23.6 !30&5 *(&7-032

&7*5 6

&7*5 6 1&.0

&7*5 &7.2, .*0) 264*(735 &7*5 &7.2, .*0) 264*(735

3'*57 3;

&7.2, &7*

&7.2, ";4*

53/*(7*) &7.2,

*&632 +35 &7.2,

*: 31* ! ! % % ! !$ # "-.6 .2+351&7.32 )3*6 237 (3267.787* &2; :&55&27; 3+ *2*5,; (367 35 6&9.2,6 = 35*6(3 380)*5 3035&)3

Volume 2 - Team Illinoize - Page 56

" " % !% ,($* 1 ' +. (&, $ 1'$/ ' +. (&, ,($* 1 2(*#(,& , *50(0 (1' / #$ ,02* 1(-, !*&

) ! # )"" &, /-)$"1$# 1(,& 1$/

& ! **(,-(0 -* / $" 1'*-, **(,-(0 -* / $" 1'*-, " **(,-(0 -* / $" 1'*-,

&$% &(, +83/6 $> 2+7:+318 (/+>2/< 2+7:+318 +83/6 $> # * * ?36.381 8+6C=3=*(3>2 <+./ 8=?6+>398 ,61

"<94/->/. #+>381 #+>/<

& # - ( $# 663893= $96+< /-+>2698 663893= $96+< /-+>2698

) ! & 663893= $96+< /-+>2698

! !

# & ! ) ! # # $&" ( $#

1(,& 2+!$/

</+ 90 98.3>398/. $:+-/ =; 0>

'96?7/ 90 98.3>398/. $:+-/

)/+< ?36>

9?=381 %C:/

?:6/B =3816/ ?83>

/@/6 %C:/ :+<>7/8>= !86C

98/

699<= 98 9< ,9@/ <+./

?7,/< 90 /.<997=

9?8.+>398 %C:/

&8-98.3>398/. ,+=/7/8>

8-69=/. <+A6 $:+-/ %C:/

?7,/< 90 $>9<3/= 8-6?.381 98.3>398/. +=/7/8>

# %

%2/<7+6 9?8.+<C 9-+>398

# /0+?6>

$)# ( $# !! # $&" ( $# +7/

+=> (/=> $9?>2 9<>2

3,<+<C 8><C

9-+>398

/81>2 0>

%9>+6 /312> 0>

/:>2 /69A <+./ 0>

/312> ,9@/ <+./ 0>

&9 '+6?/ &9 '+6?/ 97,9 A+66 986C

# <+:/. ?66

&8-98. ,=7> +7, 1<8.

# <+:/. ?66

&8-98. ,=7> +7, 1<8.

# <+:/. ?66

&8-98. ,=7> +7, 1<8.

# <+:/. ?66

&8-98. ,=7> +7, 1<8.

&9 '+6?/ 97,9 -97,38/= A+66 +3<0367 +8. =936 :+>2

$)# ( $# !! & &, '( $)# ( $# !! & % )!!

%C:/

$963. -98-</>/ 9< =>98/

%23-58/== 38

$>?.=

98/

8>/<39< 8=?6+>398

98>38?9?= # '+6?/

<+7/ +@3>C # '+6?/

+@3>C 8=?6+>398 <+./ ! ! % % ! !$ # '(0 (,%-/+ 1(-, #-$0 ,-1 "-,01(121$ ,5 4 // ,15 -% $,$/&5 "-01 -/ 0 3(,&0 6 -/$0"- -2*#$/ -*-/ #-

&$ -%

$ $ !' ! !#' (50,3 "; /(47(0.5 &,(;/,9 /(47(0.5 (50,3 "; ! ' ' <03+05. 5(3@:0:'&0;/ 9(+, 5:<3(;065 )3.

( ' #( ! # & , # !,' ' # ( # $ (+ & * %23= 3809<7+>398 .9/= 89> -98=>3>?>/ +8C A+<<+8>C 90 /8/<1C -9=> 9< =+@381= D 9</=-9 9?6./< 969<+.9

) ! # )"" &,

! ( # 330560: "63(9 ,*(;/365 330560: "63(9 ,*(;/365 $ ! 330560: "63(9 ,*(;/365

961,*;,+ !(;05. !(;,9

&$% &(, ,9407 &? 3,8;,429 *0,?30= 3,8;,429 ,9407 &? % + + @47/492 9,7D>4>+*4?3 =,/0 9>@7,?4:9 -72

$ # ! !' "#

& # - ( $# 7749:4> &:7,= 0.,?37:9 7749:4> &:7,= 0.,?37:9 ) ! & 7749:4> &:7,= 0.,?37:9

#=:50.?0/ %,?492 %,?0= !

& " !$$& & &, '(

5: ;67

-; -964 ;67 6- >(33

:4>? &;,.492 49 :.

5: 6;;64

-; -964 )6;;64 6- >(33

=,8492 ,.?:= /01,@7?

%# '

?;,9069 5:<3(;065

7::= :A0=492

! %(3<,

!:?0

5: ;67

-; -964 ;67 6- >(33

5: )6;;64

-; ),36> .9(+,

$* & !!

6;,

! ! ! # (4, 5+ 3669

:; 3669

0)9(9@ 5;9@

6*(;065

9,( :8 -;

$6 %(3<,

! # $505:<3(;,+

;>5 *65+ *65+ (+0()(;0*

;>5 *65+ <5*65+ ):4;

3669 $505:<3(;,+

5-694(;065 964 <0*2 033 "*9,,5 65;056<: 5:<3(;065 ! %(3<,

(=0;@ 5:<3(;065 ! %(3<,

(=0;@ 5:<3(;065 #/0*25,:: 05

(=0;@ 5:<3(;065 9(+,

9(405. (*;69 +,-(<3;

3669 6=,905.

! #

4-=,=D 9?=D

*0>? *,77

& #

:9/ ,8-409?

0/4@8

&:@?3 *,77

& #

:9/ ,8-409?

:.,?4:9

0/4@8

!:=?3 *,77

& #

:9/ ,8-409?

0/4@8

C?0=4:= :7:=

% '

*,77 :9>?=@.?4:9 'D;0

&?=@.?@=,7 9>@7,?0/ #,907

:9?49@:@> 9>@7,?4:9 % ),7@0

=,80 ,A4?D 9>@7,?4:9 % ),7@0

=,80 ,A4?D 9>@7,?4:9 '34.690>> 49

&?@/ &4E0 B C / 49

&?@/ &;,.492 49 : .

=,8492 ,.?:= /01,@7?

D;>@8 '34.690>> 49

# $+ # $&" ( $# "A0=3,92

3669 ! 5-694(;065 964 <0*2 033 "*9,,5

!,80

*,77 >>429809?

"=409?

!* 0/=::8

*,77

(=0;@ 5:<3(;065 ! %(3<,

(=0;@ 5:<3(;065 #/0*25,:: 05

(=0;@ 5:<3(;065 9(+,

!* 0/=::8

60:; "0A, > ? / 05

&?@/D =0,

# " # ! ' '" " # #& ! % #/0: 05-694(;065 +6,: 56; *65:;0;<;, (5@ >(99(5;@ 6- ,5,9.@ *6:; 69 :(=05.: B 69,:*6 6<3+,9 6369(+6

(: ),7@0

!:?0

6;,

65;056<: 5:<3(;065 ! %(3<,

=0, >< 1?

$* & !! & &, '(

$* & !!

=,80 ,A4?D 9>@7,?4:9 =,/0

60:; "7(*05. 05 6*

!,80

91:=8,?4:9 =:8 $@4.6 477 &.=009

! ! ! !' "#

60:; "0A, > ? / 05

"+1/ 90

(., 6-

( ),7@0

=0, ><1?

*0>?

*,77

*0>?

*,77

*0>?

9?0=4:=

0;?3 ': ':; ': ?8 1? 1? 1?

/5,.09?

*49?0= &3,/492

&@880= &3,/492

*49?0= &3,/492

&@880= &3,/492

!:90

( ' #( ! # & , # !,' ' # ( # $ (+ & * '34> 491:=8,?4:9 /:0> 9:? .:9>?4?@?0 ,9D B,==,9?D :1 090=2D .:>? := >,A492> F !:=0>.: :@7/0= :7:=,/:

#,20 :1

Volume 2 - Team Illinoize - Page 57

" " % !% )61-4 "< 0)58)1/6 &-)<0-: 0)58)1/6 )61-4 "< ! ( ( =14,16/ 6)4A;1;(&1<0 :),- 6;=4)<176 *4/

) ! # )"" &,

:72-+<-, !)<16/

!)<-:

& ! 441671; "74): -+)<0476 441671; "74): -+)<0476 " 441671; "74): -+)<0476

&$% &(, +83/6 #> 2+7:+318 '/+>2/< 2+7:+318 +83/6 #> " * * ?36.381 8+6C=3=*'3>2 <+./ 8=?6+>398 ,61

$ ! >-:0)6/ )5-

&)44 ;;1/65-6<

:1-6<

$ %)4=-

:-) ;9.<

"<=,A :-)

&)44

&-;<

"& -,:775

&)44

&-;<

"& -,:775

&)44

&-;<

)514A !775

&)44

&-;<

1<+0-6

&)44

&-;<

1<+0-6

&)44

&-;<

1>16/ !775

&)44

&-;<

6<-:17:

-8<0 #7 #78 #7 <5 .< .< .<

<94/->/. "+>381

"+>/<

& # - ( $# 663893= #96+< /-+>2698 663893= #96+< /-+>2698

) ! & 663893= #96+< /-+>2698

$$ & &, '( ! # !$+# ((

,2)+-6<

&16<-: "0),16/

"=55-: "0),16/

&16<-: "0),16/

"=55-: "0),16/

76-

8=?6+>/. <+7381 #:+-381 38 9 -

76-

<+7381 +->9< ./0+?6>

76-

/36381 $C:/

>>3-

76-

9>/

,! ( # $&" ( $#

! #

1>16/ !775

&)44

"7=<0

76-

" -,:775

&)44

"7=<0

76-

" -,:775

&)44

"7=<0

76-

)514A !775

&)44

7:<0

76-

-,:775

&)44

7:<0

-,:775

&)44

7:<0

1*:):A 6<:A

&)44 ;;1/65-6<

"7=<0 77:

"<--4 =:<0 ? *:3

7:<0 &)44

"<--4 =:<0 ? *:3

98>389?= 8=?6+>398 " &+6?/

+@3>C 8=?6+>398 " &+6?/

+@3>C 8=?6+>398 $23-58/== 38

+@3>C 8=?6+>398 <+./

C:=?7 $23-58/== 38

8=?6+>/. <+7381 #3D/ A B 2 38

" $

+7/

"990 ==3187/8>

<3/8>+>398

% &+6?/

</+ =; 0>

'38>/< #2+.381

#?77/< #2+.381

3>-2( )

76-

&/6?B #5C6312>=

"990

'/=>

76-

&/6?B #5C6312>=

"990

'/=>

76-

&/6?B #5C6312>=

"990

'/=>

&/6?B #5C6312>=

"990

'/=>

! )5-

809<7+>398 <97 !?3-5 366 #-<//8

8)9= :-) ;9 .<

$7 %)4=-

! %)4=- 7. 8)9=- :-)

"<7:5 77:

&)44

! )5-

1*:):A 6<:A

!77.

! 47?6 <<1+

-1416/ :-) ;9 .<

!77. :-) ;9 .<

@<-:17: 747:

!),1)6< )::1-:

#A8-

$7 %)4=-

-5-6< 7: 4)A #14-;

!77. #14%-6<14)<176

!-.4-+<1>-

<<1+

'-;

! ! % % ! !$ # #01; 16.7:5)<176 ,7-; 67< +76;<1<=<- )6A ?)::)6<A 7. -6-:/A +7;< 7: ;)>16/; B 7:-;+7 7=4,-: 747:),7

( ! (

%"# %'+ (50,3 ": /(47(0.5 &,(:/,8 /(47(0.5 (50,3 ": ! ' ' ;03+05. 5(3?909'&0:/ 8(+, 59;3(:065 )3.

% ! , ' "! 3305609 "63(8 ,*(:/365 3305609 "63(8 ,*(:/365

( % 3305609 "63(8 ,*(:/365

861,*:,+ !(:05.

!(:,8

! !#' ,8406 (= 3,7:,428 " *0,=30; 3,7:,428 " ,8406 (= ' + + >46/482 8,6B<4<+*4=3 ;,/0 8<>6,=498 -62

! ( # 664894< (96,; 0.,=3698 664894< (96,; 0.,=3698 $ ! 664894< (96,; 0.,=3698

&;950.=0/ ',=482 ',=0; $

$ #

;4),8 6- ,*/(50*(3 "?9:,49

,(:05. ",: 605:

,(:05. ",:)(*2 #/,8469:(:

&0;.08= "9,/ (0;?0/

8,9,5:

66305. ",:;7 #/,8469:(:

8,9,5:

66 -,=3 1,>.0=< <39@0;< 2:7

=;>0

66 * :4:0< 1>66B 48<>6,=0/ '

=;>0

'0.4;.>6,=498 =B:0

$980 <=,8/,;/ <B<=07

,;=30<= 14A=>;0 =9 * 30,=0;

;,3 #?7,

3,*:80*

)%) " &4:06082=3 19; 69820<= * ;>8

,(:05. ",(965(3 --0*0,5*?

* ' >84= :;0<08=

=;>0

6478,9968 ,(:05. ;:7;: (7(*0:? (: 2 :;/

* ' >84= 0114.408.B :0; (

6478,9968 ,(:05. ;:7;: (7(*0:? (: 2 :;/

* ' :;030,=< .96/ <>::6B 19; <39@0;

3,*:80* !,909:(5*, (*2;7 (7(*0:? 2&

* ' :;030,=< 39= <>::6B 19; <39@0;

=;>0

66305. ;:7;: (7(*0:? 2 :;/

$>7-0; <39@0;30,/< 48 3970

66305. ",(965(3 --0*0,5*?

" !

$>7-0; <39@0;< .9880.=0/ =9 * '

,9;7,8/,(:,8

6:,

! #

;4),8 - $50:9 6*(:065

,8-684(5*, +1;9:4,5:

' ) =;>0

* 4,289<=4.<

/3@ :/

65+0:065,+ (8,(

:0',=49

/4<3@,<30; :/

,8*,5: ,(:05. 6(+ ",8<,+

.69=30<*,<30; 9=*,=0; &

,8*,5: 66305. 6(+ ",8<,+

011

0@,<=0

=7,48<

/@3;*3 860=)07: /5

' % ' '%

+1/ 90

$ $ !'

! $( # !'

66305. ",: 605:

( ' #( ! # & , # !,' ' # ( # $ (+ & * $23= 3809<7+>398 .9/= 89> -98=>3>?>/ +8C A+<<+8>C 90 /8/<1C -9=> 9< =+@381= E 9</=-9 9?6./< 969<+.9

)/- 7.

&(:,8 ,(:,8 #?7,

,(: 7;47

;,3 #?7,

3,*:80*

5,8.? (*:68

!,*6<,8? --0*0,5*?

&(:,8 #(52 "0@, .(33659

>:8( #(52 59;3(:065 ! %(3;,

:>7: 98<!@3

:>7: 98<#7-=>

6:, ;4),8 - $50:9 6*(:065 ,8-684(5*, +1;9:4,5:

65+0:065,+ (8,( ' & !' ! % + ! +& & ! ' ! " '* % ) #/09 05-684(:065 +6,9 56: *659:0:;:, (5? =(88(5:? 6- ,5,8.? *69: 68 9(<05.9 A 68,9*6 6;3+,8 6368(+6

(., 6-

# " # ! ' '" " # #& ! % )34< 4819;7,=498 /90< 89= .98<=4=>=0 ,8B @,;;,8=B 91 080;2B .9<= 9; <,?482< C $9;0<.9 9>6/0; 969;,/9

&,20 91

Volume 2 - Team Illinoize - Page 58

% % "( " ! "$( )61-4 %< 0)58)1/6

'-)<0-: 0)58)1/6 )61-4 %< $

(

( =14,16/ 6)4@;1;('1<0 :),- 6;=4)<176 *4/

$ $ !'

":72-+<-, $)<16/

$)<-:

" ) $ 441671; %74): -+)<0476 441671; %74): -+)<0476 % " 441671; %74): -+)<0476

! !#' "/*&- 4 )".1"*(/ &"4)&2 )".1"*(/ "/*&- 4 ! ! 5*-%*/( /"-83*3! *4) 2"%& /35-"4*0/ #-(

% $ (#$ #

20+&$4&% "4*/( "4&2

! ( # --*/0*3 0-"2 &$"4)-0/ --*/0*3 0-"2 &$"4)-0/ $ ! --*/0*3 0-"2 &$"4)-0/

$ # '"# "

04"- 5$4 &","(&

"3$"-3

% $

5$4 *()4/&33 &34

034$0/3425$4*0/ &34

76,1<176-, 477: :-) ;9 .<

7. $-<=:6;

-)<16/ %@;<-5

( % "

511-8

0/%*4*0/&% 31"$&

77416/ %@;<-5

( % "

&452/

0/%*4*0/&% 31"$&

! # #

%=884@ =+< %=:.)+- :-) ;9 .< $-<=:6 =+< %=:.)+- :-) ;9 .<

=+< -)3)/#=)41<)<1>- ;;-;;5-6<

7< 8841+)*4-

$ &

=+< -)3)/- <7 !=<;1, %=884@ !64@ $-<=:6 !64@

7< 8841+)*4-

");+)4;

&7<)4 =+< -)3)/-

");+)4;

=+< &1/0<6-;; &-;<

"7;<+76;<:=+<176 &-;<

(! %=884@ $-<=:6

%=884@ $-<=:6

" $ $

76,1<176-, ;8)+-

% $ #$ "

76,1<176-, 477: :-) ;9 .<

7. $-<=:6;

-)<16/ %@;<-5

( % "

77416/ %@;<-5

( % "

%=884@ =+< %=:.)+- :-) ;9 .<

$-<=:6 =+< %=:.)+- :-) ;9 .<

=+< -)3)/#=)41<)<1>- ;;-;;5-6<

7< 8841+)*4-

=+< -)3)/- <7 !=<;1,-

%=884@ $-<=:6

7< 8841+)*4-

%=884@ !64@

");+)4;

$-<=:6 !64@

");+)4; $ # $ " ( (# # $ $' " & &01; 16.7:5)<176 ,7-; 67< +76;<1<=<- )6@ ?)::)6<@ 7. -6-:/@ +7;< 7: ;)>16/; A

7:-;+7 7=4,-: 747:),7

# # & "& (40,2 #9 /(36(0.4 &,(9/,7 /(36(0.4 (40,2 #9 " ' ' :02+04. 4(2=808'&09/ 7(+, 48:2(9054 )2.

# " # ! ' '" " # #& ! % )*3 */'02."4*0/ %0&3 /04 $0/34*454& "/8 7"22"/48 0' &/&2(8 $034 02 3"6*/(3 9 02&3$0 05-%&2 0-02"%0

")/- 7.

" " %

' " 2204508 #52(7 ,*(9/254 2204508 #52(7 ,*(9/254 # 2204508 #52(7 ,*(9/254

751,*9,+ "(904. "(9,7

!% '4/+2 !9 .'36'/-4 $+'9.+7 .'36'/-4 '4/+2 !9

& & :/2*/4- 4'2>8/8&$/9. 7'*+ 48:2'9/54 (2-

" " " "

& ! 22/45/8 !52'7 +)'9.254 22/45/8 !52'7 +)'9.254 " 22/45/8 !52'7 +)'9.254

750+)9+* '9/4 '9+7

&/52, 5:8, 4-0297(9054

+9'/2+* ':*/9

,(8:7,3,49 $=6,

25<,7 +557 9,89

/-.9 /=9:7+ 8

1$. :8+ #8+8 %+'7 % !"

,(904. #,(854 4-0297(9054 %(2:,

(9:7(2

=9+7/57 /-.9 /=9:7+ 8

1$. :8+ #8+8 %+'7 !9'4*'7*

55204. #,(854 4-0297(9054 %(2:,

(9:7(2

+,7/-+7'957

1$. :8+ #8+8 %+'7 % !"

#/,29,7 2(88

/8.<'8.+7

5+, %,70-0*(9054

$,89,+

;+4 '4-+

1$. :8+ #8+8 %+'7 % !"

259.+8 7>+7

1$. :8+ #8+8 %+'7 % !"

,*/(40*(2 %,4902(9054 -57 !

259.+8 $'8.+7

1$. :8+ #8+8 %+'7 % !"

$=6,

(2(4*,+

!.5<+7 '9.

'22548 :8+ #8+8 %+'7 !9'4*'7*

"(9, *-3

2:- 5'* 8

1$. :8+ #8+8 %+'7 !9'4*'7*

" $

#,480)2, ",*5;,7= --0*0,4*=

$59(2 ",*5;,7= --0*0,4*=

5:78 6,7 (=

(4 5<,7 <(998

(4 5957

-(28,

"(& 0'

%,4902(9054 #97(9,.= -57 55204.

55204. #,(854 %,4902(9054

&/52, 5:8, (4

" ! " & &! ! " "% $ $/08 04-573(9054 +5,8 459 *548909:9, (4= <(77(49= 5- ,4,7.= *589 57 8(;04.8 > 57,8*5 5:2+,7 5257(+5

(., 5-

1$. :8+ #8+8 %+'7 !9'4*'7*

" ! ! % % ! !$ # "./8 /4,573'9/54 *5+8 459 )5489/9:9+ '4> <'77'49> 5, +4+7-> )589 57 8';/4-8 ? 57+8)5 5:2*+7 5257'*5

'-+ 5,

Volume 2 - Team Illinoize - Page 59

# # (50,3 "; /(47(0.5 %,(;/,9 /(47(0.5 (50,3 "; ! ' ' <03+05. 5(3@:0:'%0;/ 9(+, 5:<3(;065 )3.

# # & 961,*;,+ !(;05. !(;,9

$ 330560: "63(9 ,*(;/365 330560: "63(9 ,*(;/365 330560: "63(9 ,*(;/365

"& +83/6 $> 2+7:+318 (/+>2/< 2+7:+318 +83/6 $> # * * ?36.381 8+6B=3=*(3>2 <+./ 8=?6+>398 ,61

!<94/->/. #+>381 #+>/<

' " 663893= $96+< /-+>2698 663893= $96+< /-+>2698 # 663893= $96+< /-+>2698

& &

!,8<09,4,5;:

97/ ?36./< ?7,/<

$,90-0,+

;9<,

663893= $96+< /-+>2698

$,90-0,+

;9<,

+8.+>9<B #/;?3</7/8>=

$,90-0,+

;9<,

'/<303/. /8/=><+>398

><?/

'/<303/. 8=?6+>398

><?/

$,90-0,+

;9<,

'/<303/. ?-> 9-+>398

><?/

$,90-0,+ &

$,90-0,+

-(3:,

;9<,

'/<303/. ::63+8-/

><?/

$,90-0,+

-(3:,

><?/

'/<303/. 312>381

'/<303/. +8 003-3/8-B

><?/

!,8<09,4,5;:

'/<303/. (+>/< 003-3/8-B

><?/

!(;,9 *,9;0-0,: ;/(; ;/, /64, *64730,: >0;/ ;/, -6336>05.

! #

# %

'/<303/. ! 8.99< +3<! &$

><?/

9,8<09,4,5;: -69

! & "# ! $

'/<303/. #/8/A+,6/ 8/<1B #/+.B $96+< 6/-><3-

><?/

!(;,9 ,:0.5 !,=0,> /,*230:;

!(;,9 0,3+ /,*230:;

$ ,:0.5 !,769;

/<>303/. ?8./< >2/ ! (+>/<$/8=/ 09< /A 97/= !<91<+7

$ 6440::06505. /,*230:; 67;065(3

! & "# ! $,9:065 7730(5*,: !,-90.,9(;69:

/<>303/. ?8./< >2/ $ 09<>303/. 09< $+0/< 3@381 !<91<+7

9669A/. >2/ )/<9 8/<1B #/+.B 97/ "?+63>B +8+1/7/8> ?3./638/=

0:/>(:/,9:

! & "# ! $,9:065 (:,4,5;:

(:,4,5; %(33 9,( ,36> 9(+

-(3:,

(:,4,5; 3669 9,(

9,:*907;0=, !,8<09,4,5;: -69 ! & "# ! =

-(3:,

"3() 5:<3(;065 ?,47;065

-(3:,

5+669 (09 3<: $,90-0*(;065 /,*230:;

;9<,

?/(<:; (5:

0,3+ 77

%2/ ,?B/< 90 >23= 297/ =318/. + A+3@/< 13@381 )/<9 8/<1B 9 #/+.B 97/ +--/== >9 ?>363>B ,366 .+>+ 09< 98/ B/+<

" $

# # " ! #/0: 05-694(;065 +6,: 56; *65:;0;<;, (5@ >(99(5;@ 6- ,5,9.@ *6:; 69 :(=05.: A 69,:*6 6<3+,9 6369(+6

B,<3.

966/->9< 99: %B:/

+>-2 2/+>/<

966/->9< %B:/

98/

966/->9< <3/8>+>398

98/

</+ =; 0>

%36> ./1<//=

'96?7/ -? 0> 1+6

+7/

966/->9< <3/8>+>398

#990>9: !' +<<+B

$9?>2

966/->9< </+ =; 0>

!' !+8/6 !/+5 !9A/< (+>>=

966/->9< %36> ./1<//=

8@/<>/< 003-3/8-B

" ! " & &! ! " "% $ %23= 3809<7+>398 .9/= 89> -98=>3>?>/ +8B A+<<+8>B 90 /8/<1B -9=> 9< =+@381= C 9</=-9 9?6./< 969<+.9

(., 6-

31432)28 3279148-32

!+1/ 90

31432)28 3279148-32

! *EB=86G87 +4G<A:

# (

6+&2-=&8-32 #??<AB<F ,B?4E 864G;?BA #??<AB<F ,B?4E 864G;?BA 9-0()6 #??<AB<F ,B?4E 864G;?BA

$B=>/7 %B:/

" $ " !

634)68< 4A<8? ,G

;4@C4<:A #&

084G;8E ;4@C4<:A #& 4A<8? ,G

+ 3 3 H<?7<A: A4?LF<F30<G;! E478#AFH?4G<BA 5?:

46<5;

,0305. (5:

:>398+6 97/ ?36./< 9773>7/8>= 09< #/-9183>398

+ )&8-2+ !)&732

+ -

89 <6

8<?<A:F +BB9F

+<@ 4A7 $B<FGF

5BI8 !E478 04??F

BHA74G<BA 04??F

BBEF

0<A7BJF ,>L?<:;GF

?BBEF

! *EB=86G87 +4G<A:

# (

6+&2-=&8-32 #??<AB<F ,B?4E 864G;?BA #??<AB<F ,B?4E 864G;?BA 9-0()6 #??<AB<F ,B?4E 864G;?BA

634)68< 4A<8? ,G

;4@C4<:A #&

084G;8E ;4@C4<:A #& 4A<8? ,G

+ 3 3 H<?7<A: A4?LF<F30<G;! E478#AFH?4G<BA 5?:

330-2+ !)&732

89 <6

8<?<A:F +BB9F

+<@ 4A7 $B<FGF

5BI8 !E478 04??F

BHA74G<BA 04??F

BBEF

0<A7BJF ,>L?<:;GF

?BBEF

E4J? ,C468 .A;G F@G

,?45 ?BBEF

#A9<?GE4G<BA

'86;4A<64? /8AG<?4G<BA

H6GF

6G<I8 ,B?4E

,HAFC468

#AG8EA4? !4<AF

-BG4?

#AG8EA4? !4<AF

0;B?8 "BHF8 /8AG<?4G<BA

-BG4?

"84G<A: ,84FBA '' GH LE BB?<A: ,84FBA '' GH LE

,HAFC468

H6GF

6G<I8 ,B?4E

#A9<?GE4G<BA

'86;4A<64? /8AG<?4G<BA

,?45 ?BBEF

E4J? ,C468 .A;G F@G

?BBEF

BBEF

BHA74G<BA 04??F

'' GH LE

5BI8 !E478 04??F

+<@ 4A7 $B<FGF

&8) )7-()28-&0 2)6+< 2&0<7-7 &2( &8-2+ !3*8;&6) :

-;<F <A9BE@4G<BA 7B8F ABG 6BAFG<GHG8 4AL J4EE4AGL B9 8A8E:L 6BFG BE F4I<A:F

N (BE8F6B BH?78E B?BE47B

*4:8 B9

&8) )7-()28-&0 2)6+< 2&0<7-7 &2( &8-2+ !3*8;&6) :

-;<F <A9BE@4G<BA 7B8F ABG 6BAFG<GHG8 4AL J4EE4AGL B9 8A8E:L 6BFG BE F4I<A:F

N (BE8F6B BH?78E B?BE47B

0;B?8 "BHF8 /8AG<?4G<BA

#AG8EA4? !4<AF

0<A7BJF ,>L?<:;GF

#AG8EA4? !4<AF

,HAFC468

6G<I8 ,B?4E

H6GF

#A9<?GE4G<BA

'86;4A<64? /8AG<?4G<BA

,?45 ?BBEF

?BBEF

E4J? ,C468 .A;G F@G

0<A7BJF ,>L?<:;GF

BBEF

5BI8 !E478 04??F

+<@ 4A7 $B<FGF

BHA74G<BA 04??F

8<?<A:F +BB9F

'' GH LE

8<?<A:F +BB9F

*4:8 B9

Volume 2 - Team Illinoize - Page 60

31432)28 )7-+2 3&(7

634)68< 4A<8? ,G

;4@C4<:A #&

084G;8E ;4@C4<:A #& 4A<8? ,G

+ 3 3 H<?7<A: A4?LF<F30<G;! E478#AFH?4G<BA 5?:

634)68< 4A<8? ,G

;4@C4<:A #&

084G;8E ;4@C4<:A #& 4A<8? ,G

+ 3 3 H<?7<A: A4?LF<F30<G;! E478#AFH?4G<BA 5?:

6+&2-=&8-32 #??<AB<F ,B?4E 864G;?BA #??<AB<F ,B?4E 864G;?BA 9-0()6 #??<AB<F ,B?4E 864G;?BA

! *EB=86G87 +4G<A:

# (

+ )&8-2+

+<@ 4A7 $B<FGF

5BI8 !E478 04??F

BHA74G<BA 04??F

BBEF

0<A7BJF ,>L?<:;GF

?BBEF

! *EB=86G87 +4G<A:

# (

+ -

/ 89 ,6

8<?<A:F +BB9F

6+&2-=&8-32 #??<AB<F ,B?4E 864G;?BA #??<AB<F ,B?4E 864G;?BA 9-0()6 #??<AB<F ,B?4E 864G;?BA

330-2+

/ 89 ,6

8<?<A:F +BB9F

+<@ 4A7 $B<FGF

5BI8 !E478 04??F

BHA74G<BA 04??F

BBEF

0<A7BJF ,>L?<:;GF

?BBEF

E4J? ,C468 .A;G F@G

,?45 ?BBEF

#A9<?GE4G<BA

'86;4A<64? /8AG<?4G<BA

H6GF

6G<I8 ,B?4E

,HAFC468

#AG8EA4? !4<AF

0;B?8 "BHF8 /8AG<?4G<BA

#AG8EA4? !4<AF -BG4?

-BG4?

"84G<A: % GH "E BB?<A: % GH "E

% GH "E

,HAFC468

#AG8EA4? !4<AF

634)68< 4A<8? ,G

;4@C4<:A #&

084G;8E ;4@C4<:A #& 4A<8? ,G

+ 3 3 H<?7<A: A4?LF<F30<G;! E478#AFH?4G<BA 5?:

*4:8 B9

*;BGBIB?G4<6F

"38&0

"84G<A:

BB?<A:

04G8E "84G<A:

+ -

&8) )7-()28-&0 2)6+< 2&0<7-7 &2( &8-2+ !3*8;&6) :

-;<F <A9BE@4G<BA 7B8F ABG 6BAFG<GHG8 4AL J4EE4AGL B9 8A8E:L 6BFG BE F4I<A:F

N (BE8F6B BH?78E B?BE47B

&8) )7-()28-&0 2)6+< 2&0<7-7 &2( &8-2+ !3*8;&6) :

-;<F <A9BE@4G<BA 7B8F ABG 6BAFG<GHG8 4AL J4EE4AGL B9 8A8E:L 6BFG BE F4I<A:F

N (BE8F6B BH?78E B?BE47B

&<:;GF CC?<4A68F

*;BGBIB?G4<6F

,8EI<68 ;4E:8F

"38&0

/ 89 ,6

,C468 "84G<A:

,C468 BB?<A:

#8-0-8< &8)7 ?86GE<6<GL

894H?G ?86GE<6 *EBI<78E

-BG4?

*;BGBIB?G4<6F

&<:;GF CC?<4A68F

04G8E "84G<A:

BB?<A:

"84G<A:

89 <6

"84G<A:

'' GH LE

229&0 3279148-32

04G8E "84G<A: J BHG -4A> &BFF

229&0 3&(

04G8E "84G<A:

! *EB=86G87 +4G<A:

+4G8E # (

6+&2-=&8-32 #??<AB<F ,B?4E 864G;?BA #??<AB<F ,B?4E 864G;?BA 9-0()6 #??<AB<F ,B?4E 864G;?BA

BB?<A:

"84G<A:

BB?<A:

)7-+2 3&(7

0;B?8 "BHF8 /8AG<?4G<BA

6G<I8 ,B?4E

'86;4A<64? /8AG<?4G<BA

#A9<?GE4G<BA

H6GF

,?45 ?BBEF

?BBEF

E4J? ,C468 .A;G F@G

BBEF

)6*361&2') )4368 ! *EB=86G87 +4G<A:

+4G8E # (

89 <6

229&0 2)6+< 378

&8) )7-()28-&0 2)6+< 2&0<7-7 &2( &8-2+ !3*8;&6) :

-;<F <A9BE@4G<BA 7B8F ABG 6BAFG<GHG8 4AL J4EE4AGL B9 8A8E:L 6BFG BE F4I<A:F

N (BE8F6B BH?78E B?BE47B

*4:8 B9

"84G<A:

229&0 3279148-32

0<A7BJF ,>L?<:;GF

BHA74G<BA 04??F

5BI8 !E478 04??F

8<?<A:F +BB9F

'' GH LE

229&0 3&(

#AG8EA4? !4<AF

6G<I8 ,B?4E

H6GF

'86;4A<64? /8AG<?4G<BA

,?45 ?BBEF

)6*361&2') )4368 6+&2-=&8-32 #??<AB<F ,B?4E 864G;?BA #??<AB<F ,B?4E 864G;?BA 9-0()6 #??<AB<F ,B?4E 864G;?BA

&8) )7-()28-&0 2)6+< 2&0<7-7 &2( &8-2+ !3*8;&6) :

-;<F <A9BE@4G<BA 7B8F ABG 6BAFG<GHG8 4AL J4EE4AGL B9 8A8E:L 6BFG BE F4I<A:F

N (BE8F6B BH?78E B?BE47B

634)68< 4A<8? ,G

;4@C4<:A #&

084G;8E ;4@C4<:A #& 4A<8? ,G

+ 3 3 H<?7<A: A4?LF<F30<G;! E478#AFH?4G<BA 5?:

E4J? ,C468 .A;G F@G

?BBEF

BHA74G<BA 04??F

5BI8 !E478 04??F

8<?<A:F +BB9F

+<@ 4A7 $B<FGF

,HAFC468

#A9<?GE4G<BA

+<@ 4A7 $B<FGF

BBEF

0<A7BJF ,>L?<:;GF

% GH "E

*4:8 B9

Volume 2 - Team Illinoize - Page 61

)6*361&2') )4368 634)68< 4A<8? ,G

;4@C4<:A #&

084G;8E ;4@C4<:A #& 4A<8? ,G

+ 3 3 H<?7<A: A4?LF<F30<G;! E478#AFH?4G<BA 5?:

6+&2-=&8-32 #??<AB<F ,B?4E 864G;?BA #??<AB<F ,B?4E 864G;?BA 9-0()6 #??<AB<F ,B?4E 864G;?BA

! *EB=86G87 +4G<A:

+4G8E # (

229&0 2)6+< 378

)7-+2 3&(7

63.)'8)( &8-2+ &7)( 32 0&27 -)0( 32*-61&8-32 )59-6)(

> GH ;E

4A<8? ,G

#??<AB<F ,B?4E 864G;?BA

+ #??<AB<F ,B?4E 864G;?BA

-BG4?

*;BGBIB?G4<6F

04G8E "84G<A:

&<:;GF CC?<4A68F

BB?<A:

"84G<A:

,8EI<68 ;4E:8F

+ ,C468 "84G<A:

,C468 BB?<A:

+ ' +4G8 +8F<78AG<4? A8E:L A4?LF<F 4A7 +4G<A: ,B9GJ4E8 I

&8) )7-()28-&0 2)6+< 2&0<7-7 &2( &8-2+ !3*8;&6) :

-;<F <A9BE@4G<BA 7B8F ABG 6BAFG<GHG8 4AL J4EE4AGL B9 8A8E:L 6BFG BE F4I<A:F

N (BE8F6B BH?78E B?BE47B

*4:8 B9

% !" : 31) $)6-*-'&8-32 !911&6< 634)68< 4A<8? ,G

;4@C4<:A #&

084G;8E ;4@C4<:A #& 4A<8? ,G

+ 3 3 H<?7<A: A4?LF<F30<G;! E478#AFH?4G<BA 5?:

! *EB=86G87 +4G<A:

+4G8E # (

6+&2-=&8-32 #??<AB<F ,B?4E 864G;?BA #??<AB<F ,B?4E 864G;?BA 9-0()6 #??<AB<F ,B?4E 864G;?BA

Illinois Solar Decathlon 2/28/2017 63 E. Daniel St. Champaign, IL 61820

Illinois Solar Decathlon N/A 2017-02-10 3.1

63.)'8)( &8-2+ &7)( 32 0&27 -)0( 32*-61&8-32 )59-6)( 9-0(-2+ 2*361&8-32

&8-2+

BA7<G<BA87 E84 FD 9G

" +, #A78K

BA7<G<BA87 /B?H@8 6H5<6 9G

" +, #A78K J B */

#AFH?4G87 ,;8?? E84 FD 9G

" +, #A78K -4E:8G , 7=HFG87

(H@58E B9 87EBB@F "BHF<A: -LC8 BHA74G<BA -LC8

" +, #A78K B9 +898E8A68 8F<:A "B@8

HC?8K F<A:?8 HA<G

,<M8 7=HFG@8AG 46GBE

.A6BA7<G<BA87 54F8@8AG

-;<F ;B@8 ' -, )+ 1 , G;8 * F E8DH<E8@8AGF 9BE 4A ( +!2 ,- + "B@8

" +, #A78K J B */ " +, #A78K B9 +898E8A68 8F<:A "B@8 ( " +, #A78K " +, #A78K -4E:8G GB 6B@C?L

+ -

9-0(-2+ !,)00

8<?<A: J GG<6 + ?BJA GG<6 .

0<A7BJ -LC8 ,6;H6B 0,

,84?87 GG<6 (BA8

0<A7BJ . /4?H8

,"!

/4H?G87 8<?<A: (BA8

0<A7BJ 04?? +4G<B

5BI8 !E478 04??F ,#* .

#A9<?GE4G<BA -LC8 ?BJ8E 7BBE G8FG

BHA7 04??F BA7 (BA8

#A9<?GE4G<BA "G:

"A4G

BHA7 04??F .A6BA7 + E4C87 H?? +

H6G &84>4:8 GB )HGF<78

' *4F64?F

?BBEF + .

-BG4? H6G &84>4:8

' *4F64?F

,?45 ?BBEF (BA8

)',&2-'&0 !<78)17 ,"*

"G: > GH;

",* ?:

> GH;

, +

04G8E "84G<A:

"84G CH@C ?86

+ JE4C

*EB:E4@@45?8 -;8E@BFG4G

"84G 28F BB? 28F

/8AG<?4G<BA ,LFG8@

4?4A687 +/ 69@

J4GGF

Htg: 0.03 Clg: 0.03 ACHnat Ceiling: R-73.0

FndWall: R-19.0

AGWall: R-40.0

Floor: R-40.0

U-Value: 0.170, SHGC: 0.190

4.10 CFM25.

Refrigerators: 1

Dishwashers: 1

8.00 CFM25.

Ceiling Fans: 0

Exhaust Fans: 1

Electric, Htg: 10.0 HSPF. Clg: 19.0 SEER.

Heat pump, Electric, 0.95 EF, 30.0 Gal, R-8 wrap.

Electric, Htg: 10.0 HSPF. Clg: 19.0 SEER.

-+,87 &2( 440-&2')7 *8E68AG #AG8E<BE &<:;G<A:

?BG;8F EL8E H8?

?86GE<6

*8E68AG KG8E<BE &<:;G<A:

?BG;8F EL8E

+89E<:8E4GBE >0; LE

?BG;8F 04F;8E & +

<F;J4F;8E A8E:L 46GBE

?BG;8F 04F;8E 4C46<GL

8<?<A: 4A 69@ 04GG

+4A:8 )I8A H8?

?86GE<6

(BG8 0;8E8 984GHE8 ?8I8? I4E<8F <A ;B@8 G;8 7B@<A4AG I4?H8 <F F;BJA

-1 &8) )7-()28-&0 2)6+< 2&0<7-7 &2( &8-2+ !3*8;&6) :

-;<F <A9BE@4G<BA 7B8F ABG 6BAFG<GHG8 4AL J4EE4AGL B9 8A8E:L 6BFG BE F4I<A:F

N (BE8F6B BH?78E B?BE47B

Volume 2 - Team Illinoize - Page 62

*36 ! 634)68< 4A<8? ,G

;4@C4<:A #&

084G;8E ;4@C4<:A #& 4A<8? ,G

+ 3 3 H<?7<A: A4?LF<F30<G;! E478#AFH?4G<BA 5?:

0&'!&)$ *(+'& ) " -*+"-/3 (50,3 "; /(47(0.5 &,(;/,9 /(47(0.5 (50,3 "; ! ' ' <03+05. 5(3@:0:'&0;/ 9(+, 5:<3(;065 )3.

! *EB=86G87 +4G<A:

+4G8E # (

6+&2-=&8-32 #??<AB<F ,B?4E 864G;?BA #??<AB<F ,B?4E 864G;?BA 9-0()6 #??<AB<F ,B?4E 864G;?BA

",-7 ,31) 97)7 0)77 )2)6+< 8,&2 8,) )*)6)2') 31)

!396') 2)6+< 3279148-32 89 <6

-$ )&4 /&*) 330560: "63(9 ,*(;/365 330560: "63(9 ,*(;/365 0&'!" 330560: "63(9 ,*(;/365

'"(")/.

).0' /&*) "1"'.

"/,33 $ /,*2

: ,:0.5,+

,0305.:

"2@30./;:

7 )7-+2)(

)6=, 9(+, &(33:

&05+6>: (5+ 669:

3669: =,9 $5*65+ (:,4,5;

04G8E "84G<A:

=,9(33 $ ,:0.5 4<:; ), ,8<(3 69 36>,9

&<:;GF CC?<4A68F

*;BGBIB?G4<6F

BB?<A:

+ -

-BG4?

",-7 ,31) "! 8,) 6)59-6)1)287 *36 ()7-+2&8-32 &7 &2 % !" 9&0-*-)( 31) 92()6 :)67-32

8F<:A 6BAFH@CG<BA <F 54F87 BA G;8 9B??BJ<A: 7B@<A4AG 984GHE8F

(H@58E B9 87EBB@F

8<?<A: ?4G +

/4H?G87 8<?<A: (

,84?87 8<?<A: (

5BI8 !E478 04??F +

BHA74G<BA 04??F +

)*)6)2') "84G<A:

961,*;,+ !(;05.

!(;,9

)! /*-3 ",0&-"(")/.

! #

"/,33 $ /,*2

"" "

<*; 5:<3(;065 ! %(3<, /,*2 7,9 ",*;065

"" "

&05+6> $ %(3<, (5+ " /,*2 7,9 ",*;065

"" "

64, 5-03;9(;065 ",*;065

"" "

<*; #,:;05. ",*;065

,*/(50*(3 %,5;03(;065 ",*;065

"" "

,*/(50*(3 %,5;03(;065 (5 --0*(*@ ",*;065

"" "

(5+(;69@ !,8<09,4,5;: /,*2 6?

"" "

"0.5(;<9,

9.(50A(;065 330560: "63(9 ,*(;/365

KCBF87 ?BBE +

,?45 (

0<A7BJ -LC8 . /4?H8

,"!

#A9<?GE4G<BA ?BJ8E 7BBE G8FG "G:

"A4G

"84G<A: ?86GE<6 "G:

",* ?:

, +

BB?<A: ?86GE<6 "G:

",* ?:

, +

04G8E "84G<A: "84G CH@C ?86GE<6

!4? + JE4C

H6G &84>4:8 GB )HGF<78

/8AG<?4G<BA ,LFG8@ 4?4A687 +/ 69@

J4GGF

*EB:E4@@45?8 -;8E@BFG4G "84G 28F BB? 28F

(;, (9*/

&8) )7-()28-&0 2)6+< 2&0<7-7 &2( &8-2+ !3*8;&6) :

-;<F <A9BE@4G<BA 7B8F ABG 6BAFG<GHG8 4AL J4EE4AGL B9 8A8E:L 6BFG BE F4I<A:F

N (BE8F6B BH?78E B?BE47B

/" ".&!")/& ' )"-$3 ) '3.&. )! /&)$ *#/2 -" 1

#/0: 05-694(;065 +6,: 56; *65:;0;<;, (5@ >(99(5;@ 6- ,5,9.@ *6:; 69 :(=05.: B 69,:*6 6<3+,9 6369(+6

*#.%4 +/0 +),(' *!# .+,#.04 )61-4 #< 0)58)1/6 '-)<0-: 0)58)1/6 )61-4 #< " ( ( =14,16/ 6)4A;1;('1<0 :),- 6;=4)<176 *4/

.% *'5 0'+* 441671; #74): -+)<0476 441671; #74): -+)<0476 1'("#. 441671; #74): -+)<0476

!:72-+<-, ")<16/ ")<-:

**1 ( *#.%4 +/0

/ #/'%*#"

-)<16/

77416/

')<-: -)<16/

1 +0 ( /#" 0+ #0#.)'*# +),(' *!#

1/0<; 8841)6+-;

!07<7>74<)1+;

#-:>1+- 0):/-

+0 (

*" 0+.4 #-1'.#)#*0/

" $

!# # # # ! % " " #

# ! # ! ' " !% # #/09 /53, );02: (: (40,2 ": /(36(0.4 )? 2204509 "52(8 ,*(:/254 ,>*,,+9 :/, 30403;3 8,7;08,3,4:9 -58 :/, 4:,84(:054(2 4,8.? 549,8<(:054 5+,

! #

# "# !

66=)4 6-:/A 7;< 0-+3

! ## #

=+< 6;=4)<176 " &)4=- 0-+3 8-: #-+<176

! ## #

'16,7? % &)4=- )6, # 0-+3 8-: #-+<176

! ## #

",(2,+ ::0*

;*: ,(1(., :5 ;:90+, (9*(29

%(;2:,+ ,0204.

#5:(2 ;*: ,(1(., (9*(29

75- 6.14<:)<176 #-+<176

! ## #

)5<, 8(+, &(229 !

=+< $-;<16/ #-+<176

! ## #

5;4+(:054 &(229 !

-+0)61+)4 &-6<14)<176 #-+<176

! ## #

-+0)61+)4 &-6<14)<176 )6 ..1+)+A #-+<176

! ## #

)6,)<7:A "-9=1:-5-6<; 0-+3 7@

! ## #

#1/6)<=: )<- ):+0

,0204. 2(: !

>659,+ 2558 ! "2() 54,

;*:

4-02:8(:054 :. 2. 4(:

&04+5= $ %(2;, "

08 "5;8*,

2,*:80* :. " 2. " !

&(:,8 ,(:04. ,(: 6;36 2,*:80* (2 ! =8(6

& " $ " ! " " " ! # ! ! ! ! !" " $ " " # ! ! " ! " # " ! !# "" $ " " " " ! # ! ! " " " # "! $ " " ! " $ " " % # "! (3, 2204509 "52(8 ,*(:/254 8.(40@(:054 2204509 "52(8 ,*(:/254

"0.4(:;8, (:, (8*/

0# #/'"#*0' ( *#.%4 * (4/'/ *" 0'*% +$03 .# 2 $01; 16.7:5)<176 ,7-; 67< +76;<1<=<- )6A ?)::)6<A 7. -6-:/A +7;< 7: ;)>16/; C 7:-;+7 7=4,-: 747:),7

Volume 2 - Team Illinoize - Page 63

2/+&$4&% .&2(9 "4*.( .%&8 &0/24 2/0&249 ;13,-8 3315619 %63*8 -+*:0365 ,,8-99 *51-3 %:

0*47*1/5

2(".*:"4*/. 647*5? 3315619 %63*8 -+*:0365 #065- $*:-8 3315619 %63*8 -+*:0365

(%! * $ ( / * $ $ . &%(*

.&2(9 "4*.( .%&8 .'/2-"4*/. #862-+:-, $*:15/ $*:-8 ! *:- $*:-,

" # * %$

34*-"4&% ..5", .&2(9 /.35-04*/. "4&% /-& ",$5,"4&% .&2(9 3& -*:15/

"4&% /-& /34 92

66315/

'*:-8 -*:15/

1/0:9 7731*5+-9 #06:6<63:*1+9 /4", *9-, 65 9:*5,*8, 67-8*:15/ +65,1:1659

7*4) ! 7*4)/54 !

$ & 41991659 &659

5-8/? %*<15/9

*9-, 65 :0- 5-8/? $*:15/ 5,-> $-.-8-5+- -91/5 64-

"8*-5- .&2(9 "4*.( .%&8

)*3 /-& 3 .&2(9 "4*.( .%&8

!*4- 3315619 %63*8 -+*:0365 "8/*51@*:165 3315619 %63*8 -+*:0365

%1/5*:;8-

;02+04. :/,83(2 ,4<,256, 30403;3 049;2(:054 2,<,29 (4+ 3(>03;3 -,4,9:8(:054 ! ## % -(*:58 (4+ #

!59: ( 6,83(4,4: *,8:0-0*(:, 209:04. :/, 2,<,2 5- ,--0*0,4*,0,9 049:(22,+ 04 :/, /5;9,

,8:0-0*(:, 8,7;08,+ -58

4<,256, (08 2,(1(., 3(>03;3 2,(1(., 8(:,

-58 & ! ##

$()2, "

5362? =0:/ (08 9,(204. (4+ 049;2(:054 8,7;08,3,4:9 04 $()2, "

/,*1209: 8,7;08,+ -58

"5539 *54:(0404. -;,2 );8404. (6620(4*,9

'''''''''''''''

(>03;3 -,4,9:8(:054 % -(*:58 (4+ #

! ##

,(: 6;36 *54:8529

'''''''''''''''

;*:9 5;:90+, 5- *54+0:054,+ 96(*, :5 ), 049;2(:,+ :5 ( 30403;3 5- "

%#&" $ ) %$

! ##

" $

" " "

)*3 )/-& 4)& .&2(9 "4*.( .%&8 $/2& 2&15*2&-&.43 /' &$4*/. /' 4)&

.4&2."4*/. .&2(9 /.3&26"4*/. /%& #"3&% /. " $,*-"4& :/.& /' . "%%*4*/. 4/ 4)& .&2(9 "4*.( .%&8 /4)&2 -".%"4/29 -&"352&3 -534 #& -&4 && ".%"4/29 &15*2&-&.43 /. 3&$/.% 0"(&

$()2,

..5", 34*-"4&3

$ *%(/ '+ ( # $*) '+ ( ) " %$ (# * %$

(%, ) %$ +# (

" "

;*: 9,(204. 54 (22 +;*:9

'''''''''''''''

;*: :,9:04. -58 +;*:9 04 ;4*54+0:054,+ 96(*,

;02+04. *(<0:0,9 45: ;9,+ (9 +;*:9

'''''''''''''''

,(:,+ =(:,8 *08*;2(:054 (4+ :,36,8(:;8, 3(04:,4(4*, 9?9:,39 *5362?

'''''''''''''''

5: =(:,8 606, 049;2(:,+ :5 "

! ##

,*/(40*(2 <,4:02(:054 3,,:04. :/, 8,7;08,3,4:9 5- :/, " 58 ;:+558 (08 ''''''''''''''' (4+ ,>/(;9: +(36,89 049:(22,+

(4;(2 (4+ # *54+;*:,+ -58 (22 /,(:04. (4+ *55204. 9?9:,39

*:- *8+0

5839 ",7;08,+ -58 6,830:

#?9:,39 9,8<04. 3;2:062, +=,2204. ;40:9 :5 3,,: :/, 3,*/(40*(2 8,7;08,3,4:9 5- 5,9 5: 662? :/, *533,8*0(2

2/6*%&2 "4" ".% &",

#45= 3,2: (4+ 0*, 9?9:,3 *54:8529 049:(22,+ =/,8, (6620*()2,

'''''''''''''''

!5529 (4+ 6,83(4,4: 96( ,4,8.? *549;36:054 3,,: 8,7;08,3,4:9 -58 /,(:,89 :03, *25*19 (4+ *5<,89

'''''''''''''''

& & 647*5? ,,8-99 1:? %:*:- (17

!58:()2, 96(9 3,,: :/, 8,7;08,3,4:9 5- !#!

'''''''''''''''

0./ ,--0*(*? 20./:9 049:(22,+ 04 5- 6,83(4,4:2? 049:(22,+ -0>:;8,9

! ##

"(:,8 /(9 <,80-0,+ :/(: (22 9?9:,39 (8, 04 *53620(4*, =0:/ 8;2,9

#065-

&6 ,-:-8415- 1. * 786<1,-8 19 7867-83? *++8-,1:-, /6 :6 === 8-95-: ;9 786.-99165*3 786/8*49 9-*8+0),18-+:68? "4& &3*%&.4*", .&2(9 .",93*3 ".% "4*.( /'47"2& 6 &019 15.684*:165 ,6-9 56: +659:1:;:- *5? =*88*5:? 6. -5-8/? +69: 68 9*<15/9

A !68-9+6 6;3,-8 6368*,6

* ) $* " $ ( / $ "/) ) $ * $ % *- ( , $/09 04-583(:054 +5,9 45: *549:0:;:, (4? =(88(4:? 5- ,4,8.? *59: 58 9(<04.9 @

58,9*5 5;2+,8 5258(+5

!(., 5-

WUFIÂ® Pro 6.0 NonCommercial Project Data

Project Name Project Number

SIP with HardiePlank

Client Contact Person City/Zip Street

U.S. Department of Energy Robert Moy

Phone Fax e-mail Responsible Remarks Date

3/3/2017

WUFIÂ® Pro 6.0 NonCommercial; SIP_HardiePlank.w6p; Case 1: #1; 4/2/2017

Page : 1

Volume 2 - Team Illinoize - Page 64

WUFI® Pro 6.0 NonCommercial

WUFI® Pro 6.0 NonCommercial Material: Composite Wood Siding

Component Assembly

Property

Case: #1

Bulk density

Exterior

Interior

Porosity

[ft³/ft³]

0.666

[Btu/lb°F]

0.44903

Thermal Conductivity, Dry, 50°F

[Btu/h ft°F]

0.0543122

[perm in]

2.42561

Reference Water Content

[lb/ft³]

4.71331

Free Water Saturation

[lb/ft³]

21.6625

Water Absorption Coefficient

[lb/in²s^0.5]

1.02408E-6

Temp-dep. Thermal Cond. Supplement

[Btu/h ft°F²]

6.41988E-5

Thermal Conductivity, Design Value

[Btu/h ft°F]

-0.577789

Materials:

- Composite Wood Siding

0.413 in

- Air Layer 40 mm

0.75 in

- vapor retarder (10perm)

0.039 in

- weather resistive barrier (sd=0,1m)

0.039 in

- Oriented Strand Board high

0.438 in

- Extruded Polystyrene Insulation

8.25 in

- Oriented Strand Board high

0.438 in 0.039 in

- Air Layer 40 mm

Thermal Conductivity [Btu/h ft°F]

- vapor retarder (0.1perm)

0.75 in

- Gypsum Board (USA)

0.5 in

- Gypsum Board (USA)

0.5 in

Total Thickness: 12.157 in R-Value: 51.26 h ft² °F/Btu U-Value: 0.019 Btu/h ft²°F WUFI® Pro 6.0 NonCommercial; SIP_HardiePlank.w6p; Case 1: #1; 4/2/2017

Page : 2

WUFI® Pro 6.0 NonCommercial

100.55

Permeability [perm in]

Thickness [in] - Monitor positions

100.60

0.10

100.50

0.05

100.45 100.40 100.35

0.00

25 Suction Redist.

10-10

Moisture Range:

Water Content [lb/ft³]

0.438 0.039 0.75 0.5 0.5

Liquid Transport Coefficient [ft²/s] Thermal Conductivity [Btu/h ft°F]

8.25

Value 46.1967

Specific Heat Capacity, Dry Permeability

0.4130.75 0.039 0.039 0.438

Unit [lb/ft³]

10-11 10-12 10-13

0.2 0.4 0.6 0.8 Normalized Water Content [ - ]

0.0 - 1.0 RH 0.95 - 1.0 RH

15 10 5 0

1.0

0 0.95

0.2 0.96

W/Wmax

0.10

0.4 0.6 0.8 0.97 0.98 0.99 Relative Humidity [ - ]

1.0 1.0

0.05

0.00 -20

20 40 Temperature [°F]

WUFI® Pro 6.0 NonCommercial; SIP_HardiePlank.w6p; Case 1: #1; 4/2/2017

Page : 3

WUFI® Pro 6.0 NonCommercial

Material: Air Layer 40 mm

Material: vapor retarder (10perm)

Property Bulk density

Value 0.0811563

Property Bulk density

Value 8.11563

[ft³/ft³]

0.999

[ft³/ft³]

0.001

[Btu/lb°F]

0.238846

Specific Heat Capacity, Dry

[Btu/lb°F]

0.549346

Thermal Conductivity, Dry, 50°F

[Btu/h ft°F]

0.132892

Thermal Conductivity, Dry, 50°F

[Btu/h ft°F]

1.32892

[perm in]

338.947

Permeability

[perm in]

0.392683

[Btu/h ft°F]

-0.577789

Temp-dep. Thermal Cond. Supplement

[Btu/h ft°F²]

6.41988E-5

Thermal Conductivity, Design Value

[Btu/h ft°F]

-0.577789

Permeability [perm in]

103.50

0.10

103.25 103.00

0.05

102.75

0.00

102.50

10-4

5 Suction Redist.

Moisture Range:

Water Content [lb/ft³]

10-6

Suction not defined

10-8

Redistribution not defined

10-10 10-12

0.15

0.2 0.4 0.6 0.8 Normalized Water Content [ - ]

1.0

W/Wmax

0.5 - 1.0 RH 0.95 - 1.0 RH

3 2 1 0 0.5 0.95

0.6 0.96

0.7 0.8 0.9 0.97 0.98 0.99 Relative Humidity [ - ]

1.0 1.0

0.10

0.05

0.00 50 Temperature [°F]

WUFI® Pro 6.0 NonCommercial; SIP_HardiePlank.w6p; Case 1: #1; 4/2/2017

Page : 4

100.75

1.6 Permeability [perm in]

103.75

0.15

Thermal Conductivity [Btu/h ft°F]

Liquid Transport Coefficient [ft²/s] Thermal Conductivity [Btu/h ft°F]

Thermal Conductivity, Design Value

1.2 0.8 0.4

100.25 100.00

10-0.25 10-0.50

0.0 10-4

0.010 Suction Redist.

10-6

Moisture Range:

Suction not defined

10-8

Redistribution not defined

10-10 10-12

100.50

Water Content [lb/ft³]

Permeability

Porosity

Unit [lb/ft³]

Specific Heat Capacity, Dry

Liquid Transport Coefficient [ft²/s] Thermal Conductivity [Btu/h ft°F]

Porosity

Unit [lb/ft³]

0.2 0.4 0.6 0.8 Normalized Water Content [ - ]

1.0

W/Wmax

1.6

0.008

0.5 - 1.0 RH 0.95 - 1.0 RH

0.006 0.004 0.002 0.000 0.5 0.95

0.6 0.96

0.7 0.8 0.9 0.97 0.98 0.99 Relative Humidity [ - ]

1.0 1.0

1.2 0.8 0.4 0.0 -20

20 40 Temperature [°F]

WUFI® Pro 6.0 NonCommercial; SIP_HardiePlank.w6p; Case 1: #1; 4/2/2017

Page : 5

Volume 2 - Team Illinoize - Page 65

WUFI® Pro 6.0 NonCommercial

Material: weather resistive barrier (sd=0,1m)

Material: Oriented Strand Board high

Property Bulk density

Value 8.11563

Property Bulk density

Value 45.2603

[ft³/ft³]

0.001

[ft³/ft³]

0.95

[Btu/lb°F]

0.549346

Specific Heat Capacity, Dry

[Btu/lb°F]

0.44903

Thermal Conductivity, Dry, 50°F

[Btu/h ft°F]

1.32892

Thermal Conductivity, Dry, 50°F

[Btu/h ft°F]

0.0664458

[perm in]

1.288

[perm in]

0.126884

Temp-dep. Thermal Cond. Supplement

[Btu/h ft°F²]

6.41988E-5

Reference Water Content

[lb/ft³]

5.61227

Thermal Conductivity, Design Value

[Btu/h ft°F]

-0.577789

Free Water Saturation

[lb/ft³]

26.251

Water Absorption Coefficient

[lb/in²s^0.5]

3.12914E-6

Temp-dep. Thermal Cond. Supplement

[Btu/h ft°F²]

6.41988E-5

Thermal Conductivity, Design Value

[Btu/h ft°F]

-0.577789

Permeability

100.75

0.8

100.50

0.4

100.25

0.0

100.00

10-4

0.010 Suction Redist.

Moisture Range:

Water Content [lb/ft³]

10-6

Suction not defined

10-8

Redistribution not defined

10-10 10-12

0.2 0.4 0.6 0.8 Normalized Water Content [ - ]

0.008

0.5 - 1.0 RH 0.95 - 1.0 RH

0.006 0.004 0.002 0.000 0.5 0.95

1.0

0.6 0.96

W/Wmax

1.6

0.7 0.8 0.9 0.97 0.98 0.99 Relative Humidity [ - ]

1.0 1.0

0.4 0.0 -20

20 40 Temperature [°F]

WUFI® Pro 6.0 NonCommercial; SIP_HardiePlank.w6p; Case 1: #1; 4/2/2017

Page : 6

WUFI® Pro 6.0 NonCommercial

100.4

10-0.0

0.05

10-0.4 10-0.8 10-1.2

0.00

30 Suction Redist.

10-9

Moisture Range:

10-10 10-11 10-12

1.2 0.8

100.8

0.10 Permeability [perm in]

Permeability [perm in]

101.00

1.2

Water Content [lb/ft³]

101.25

1.6

Thermal Conductivity [Btu/h ft°F]

Liquid Transport Coefficient [ft²/s] Thermal Conductivity [Btu/h ft°F]

Permeability

Porosity

Unit [lb/ft³]

Specific Heat Capacity, Dry

Liquid Transport Coefficient [ft²/s] Thermal Conductivity [Btu/h ft°F]

Porosity

Unit [lb/ft³]

0.2 0.4 0.6 0.8 Normalized Water Content [ - ]

0.0 - 1.0 RH 0.95 - 1.0 RH

18 12 6 0

1.0

0 0.95

0.2 0.96

W/Wmax

0.10

0.4 0.6 0.8 0.97 0.98 0.99 Relative Humidity [ - ]

1.0 1.0

0.05

0.00 -20

20 40 Temperature [°F]

WUFI® Pro 6.0 NonCommercial; SIP_HardiePlank.w6p; Case 1: #1; 4/2/2017

Page : 7

WUFI® Pro 6.0 NonCommercial

Material: Extruded Polystyrene Insulation

Material: Oriented Strand Board high

Property Bulk density

Value 1.7854

Property Bulk density

Value 45.2603

[ft³/ft³]

0.99

[ft³/ft³]

0.95

[Btu/lb°F]

0.3511

Specific Heat Capacity, Dry

[Btu/lb°F]

0.44903

Thermal Conductivity, Dry, 50°F

[Btu/h ft°F]

0.0144

Thermal Conductivity, Dry, 50°F

[Btu/h ft°F]

0.0664458

[perm in]

0.7552

Permeability

[perm in]

0.126884

[Btu/h ft°F²]

0.0000642

Reference Water Content

[lb/ft³]

5.61227

Free Water Saturation

[lb/ft³]

26.251

Water Absorption Coefficient

[lb/in²s^0.5]

3.12914E-6

Temp-dep. Thermal Cond. Supplement

[Btu/h ft°F²]

6.41988E-5

Thermal Conductivity, Design Value

[Btu/h ft°F]

-0.577789

Permeability [perm in]

0.010

0.005

100.50 100.25 100.00

10-0.25

0.000 10-4

0.5 Suction Redist.

Moisture Range:

Water Content [lb/ft³]

10-6

Suction not defined

10-8

Redistribution not defined

10-10 10-12

100.75

0.2 0.4 0.6 0.8 Normalized Water Content [ - ]

1.0

W/Wmax

0.025

0.4

0.0 - 1.0 RH 0.95 - 1.0 RH

0.3 0.2 0.1 0.0

0 0.95

0.2 0.96

0.4 0.6 0.8 0.97 0.98 0.99 Relative Humidity [ - ]

1.0 1.0

0.020

0.005 0.000 -20

20 40 Temperature [°F]

WUFI® Pro 6.0 NonCommercial; SIP_HardiePlank.w6p; Case 1: #1; 4/2/2017

Page : 8

100.4

10-0.0

0.05

10-0.4 10-0.8 10-1.2

0.00

30 Suction Redist.

10-9

Moisture Range:

10-10 10-11 10-12

0.015 0.010

100.8

0.10 Permeability [perm in]

101.00

0.015

Thermal Conductivity [Btu/h ft°F]

Liquid Transport Coefficient [ft²/s] Thermal Conductivity [Btu/h ft°F]

Temp-dep. Thermal Cond. Supplement

Water Content [lb/ft³]

Permeability

Porosity

Unit [lb/ft³]

Specific Heat Capacity, Dry

Liquid Transport Coefficient [ft²/s] Thermal Conductivity [Btu/h ft°F]

Porosity

Unit [lb/ft³]

0.2 0.4 0.6 0.8 Normalized Water Content [ - ]

1.0

W/Wmax

0.10

0.0 - 1.0 RH 0.95 - 1.0 RH

18 12 6 0

0 0.95

0.2 0.96

0.4 0.6 0.8 0.97 0.98 0.99 Relative Humidity [ - ]

1.0 1.0

0.05

0.00 -20

20 40 Temperature [°F]

WUFI® Pro 6.0 NonCommercial; SIP_HardiePlank.w6p; Case 1: #1; 4/2/2017

Page : 9

Volume 2 - Team Illinoize - Page 66

WUFI® Pro 6.0 NonCommercial

Material: vapor retarder (0.1perm)

Material: Air Layer 40 mm

Property Bulk density

Value 8.11563

Property Bulk density

Value 0.0811563

0.001

[ft³/ft³]

0.999

0.549346

Specific Heat Capacity, Dry

[Btu/lb°F]

0.238846

Thermal Conductivity, Dry, 50°F

[Btu/h ft°F]

1.32892

Thermal Conductivity, Dry, 50°F

[Btu/h ft°F]

0.132892

[perm in]

0.00392683

Permeability

[Btu/h ft°F²]

6.41988E-5

Thermal Conductivity, Design Value

[Btu/h ft°F]

-0.577789

Thermal Conductivity [Btu/h ft°F]

Permeability [perm in]

10-1.50

1.2

10-1.75

0.8

10-2.00

0.4

10-2.25 10-2.50

0.0 10-4

0.010 Suction Redist.

10-6

Moisture Range:

Suction not defined

10-8

Redistribution not defined

10-10 10-12

0.2 0.4 0.6 0.8 Normalized Water Content [ - ]

0.008

0.5 - 1.0 RH 0.95 - 1.0 RH

0.006 0.004 0.002 0.000 0.5 0.95

1.0

0.6 0.96

W/Wmax

1.6

0.7 0.8 0.9 0.97 0.98 0.99 Relative Humidity [ - ]

1.0 1.0

1.2 0.8 0.4 0.0 -10 10 30 50 70 90 110 130 150 170 Temperature [°F]

[perm in]

338.947

[Btu/h ft°F]

-0.577789

103.75

0.15

103.50

Permeability [perm in]

10-1.25

1.6

Water Content [lb/ft³]

Liquid Transport Coefficient [ft²/s] Thermal Conductivity [Btu/h ft°F]

Thermal Conductivity, Design Value

0.10

103.25 103.00

0.05

102.75 102.50

0.00 10-4

5 Suction Redist.

10-6

Moisture Range:

Water Content [lb/ft³]

Temp-dep. Thermal Cond. Supplement

Liquid Transport Coefficient [ft²/s] Thermal Conductivity [Btu/h ft°F]

[ft³/ft³] [Btu/lb°F]

Permeability

Porosity

Unit [lb/ft³]

Specific Heat Capacity, Dry

Thermal Conductivity [Btu/h ft°F]

Porosity

Unit [lb/ft³]

Suction not defined

10-8

Redistribution not defined

10-10 10-12

0.2 0.4 0.6 0.8 Normalized Water Content [ - ]

0.5 - 1.0 RH 0.95 - 1.0 RH

3 2 1 0 0.5 0.95

1.0

0.6 0.96

W/Wmax

0.15

0.7 0.8 0.9 0.97 0.98 0.99 Relative Humidity [ - ]

0.10

0.05

0.00 50 Temperature [°F]

WUFI® Pro 6.0 NonCommercial; SIP_HardiePlank.w6p; Case 1: #1; 4/2/2017

Page : 10

WUFI® Pro 6.0 NonCommercial

WUFI® Pro 6.0 NonCommercial; SIP_HardiePlank.w6p; Case 1: #1; 4/2/2017

Page : 11

WUFI® Pro 6.0 NonCommercial

Material: Gypsum Board (USA)

Property Bulk density

Unit

Value

[lb/ft³]

53.0638

Property Bulk density Porosity

Unit

Value

[lb/ft³]

53.0638

[ft³/ft³]

0.65

[ft³/ft³]

0.65

Specific Heat Capacity, Dry

[Btu/lb°F]

0.207796

Specific Heat Capacity, Dry

[Btu/lb°F]

0.207796

Thermal Conductivity, Dry, 50°F

21.4667

Moisture-dep. Thermal Cond. Supplement

[%/M.-%]

[Btu/h ft°F²]

6.41988E-5

[Btu/h ft°F]

-0.577789

Temp-dep. Thermal Cond. Supplement

Permeability [perm in]

0.6 0.4 0.2

101.6 101.5 101.4

25 Suction Redist.

Water Content [lb/ft³]

Moisture Range:

10-6 10-7 10-8

0.2 0.4 0.6 0.8 Normalized Water Content [ - ]

1.0

W/Wmax

0.15

0.0 - 1.0 RH 0.95 - 1.0 RH

15 10 5 0

0 0.95

0.2 0.96

0.4 0.6 0.8 0.97 0.98 0.99 Relative Humidity [ - ]

1.0 1.0

0.10

0.05

0.00 -20

20 40 Temperature [°F]

WUFI® Pro 6.0 NonCommercial; SIP_HardiePlank.w6p; Case 1: #1; 4/2/2017

[%/M.-%]

[Btu/h ft°F²]

6.41988E-5

[Btu/h ft°F]

-0.577789

Thermal Conductivity, Design Value

101.3

0.0

21.4667

Moisture-dep. Thermal Cond. Supplement Temp-dep. Thermal Cond. Supplement

101.7

0.8

0.0941797

[perm in]

Thermal Conductivity [Btu/h ft°F]

Liquid Transport Coefficient [ft²/s] Thermal Conductivity [Btu/h ft°F]

Thermal Conductivity, Design Value

[Btu/h ft°F]

Permeability

Page : 12

101.7

0.8 Permeability [perm in]

0.0941797

[perm in]

0.6 0.4 0.2

101.6 101.5 101.4 101.3

0.0

25 Suction Redist.

10-5

Moisture Range:

Water Content [lb/ft³]

[Btu/h ft°F]

Permeability

Liquid Transport Coefficient [ft²/s] Thermal Conductivity [Btu/h ft°F]

Porosity

10-5

1.0 1.0

10-6 10-7 10-8

0.2 0.4 0.6 0.8 Normalized Water Content [ - ]

1.0

W/Wmax

0.15

0.0 - 1.0 RH 0.95 - 1.0 RH

15 10 5 0

0 0.95

0.2 0.96

0.4 0.6 0.8 0.97 0.98 0.99 Relative Humidity [ - ]

1.0 1.0

0.10

0.05

0.00 -20

20 40 Temperature [°F]

WUFI® Pro 6.0 NonCommercial; SIP_HardiePlank.w6p; Case 1: #1; 4/2/2017

Page : 13

Volume 2 - Team Illinoize - Page 67

WUFI® Pro 6.0 NonCommercial

Boundary Conditions

Results from Last Calculation Status of Calculation

Exterior (Left Side) Location: Temperature Shift: Orientation / Inclination: Nighttime radiation cooling: Interior (Right Side) Indoor Climate:

Calculation: Time and Date

Chicago, IL; cold year 0.0 °F West / 90 ° no

4/2/2017 6:12:51 PM

Computing Time

0 min,36 sec.

Begin / End of calculation

1/1/2017 / 1/1/2021

No. of Convergence Failures

Check for numerical quality

ASHRAE 160P; derived from Chicago, IL; cold year Heating only; 5.04 °F; 69.98 °F M.Rate 1.00 lb/h; A.Ch.Rate 0.2 1/h; Vol. 17657.3334 ft³ Humidity Ratio Wo -1.0000 lb/lb

Surface Transfer Coefficients

Integral of fluxes, left side (kl,dl)

[lb/ft²]

0.04 -0.19

Integral of fluxes, right side (kr,dr)

[lb/ft²]

5.4E-9 0.05

Balance 1

[lb/ft²]

-0.2

Balance 2

[lb/ft²]

-0.2

Water Content [lb/ft²]

Exterior (Left Side)

Name

Description

Unit

Value

Total Water Content

[h ft² °F/Btu] 0.3339 yes

Water Content [lb/ft³]

Heat Resistance - includes long-wave radiation

External Wall

Permeance

No coating

[perm]

----

Short-Wave Radiation Absorptivity

No absorption/emission

[-]

----

Long-Wave Radiation Emissivity

No absorption/emission

[-]

----

Adhering Fraction of Rain

Depending on inclination o

[-]

0.7

Explicit Radiation Balance

Interior (Right Side)

Name

Description

Heat Resistance

External Wall

Permeance

No coating

Unit

Value

[h ft² °F/Btu] 0.7098 [perm]

----

Layer/Material

Start

End

Min.

Max.

0.63

0.43

0.38

0.63

Start

End

Min.

Max.

4.71 0.12 0.00 0.00 5.61 0.02 5.61 0.00 0.12 0.39 0.39

4.03 0.08 0.00 0.00 4.41 0.01 2.89 0.00 0.02 0.13 0.13

2.32 0.04 0.00 0.00 4.07 0.01 2.83 0.00 0.01 0.11 0.11

5.86 0.12 0.00 0.00 5.63 0.03 5.61 0.00 0.12 0.39 0.39

Heat Flux, left side

[Btu/ft²]

-21412.78

Heat Flux, right side

[Btu/ft²]

-21292.85

Moisture Fluxes, left side

[lb/ft²]

-0.15

Moisture Fluxes, right side

[lb/ft²]

0.05

Composite Wood Siding Air Layer 40 mm vapor retarder (10perm) weather resistive barrier (sd=0,1m) Oriented Strand Board high Extruded Polystyrene Insulation Oriented Strand Board high vapor retarder (0.1perm) Air Layer 40 mm Gypsum Board (USA) Gypsum Board (USA) Time Integral of fluxes

WUFI® Pro 6.0 NonCommercial; SIP_HardiePlank.w6p; Case 1: #1; 4/2/2017

Page : 14

WUFI® Pro 6.0 NonCommercial

Page : 15

WUFI® Pro 6.0 NonCommercial Rain, Radiation (Exterior Climate)

Hygrothermal Sources

Heat Sources

WUFI® Pro 6.0 NonCommercial; SIP_HardiePlank.w6p; Case 1: #1; 4/2/2017

[Btu/ft²]

0.0

Moisture Sources

[lb/ft²]

0.0

Unreleased Moisture Sources (due to cut-off)

[lb/ft²]

0.0

Rain [in/h]

0 300 Solar Radiation

Solar Radiation [Btu/h ft²]

240

180

120

243.3

486.6

729.9

973.2

1216.5

1459.8

Time [days]

WUFI® Pro 6.0 NonCommercial; SIP_HardiePlank.w6p; Case 1: #1; 4/2/2017

Page : 16

WUFI® Pro 6.0 NonCommercial; SIP_HardiePlank.w6p; Case 1: #1; 4/2/2017

Page : 17

Volume 2 - Team Illinoize - Page 68

WUFI® Pro 6.0 NonCommercial

Air Temperature, RH (Exterior, Interior)

Heat, Moisture Fluxes

120

120 Exterior Air Interior Air

Exterior Surface Interior Surface

60 Heat Flux [Btu/h ft²]

Air Temperature [°F]

-60

-120

-30

-180

100

1.10-4 Exterior Air Interior Air

Exterior Surface Interior Surface

Moisture Flux [lb/h ft²]

Relative Humidity [%]

5.10-5

243.3

486.6

729.9

973.2

1216.5

-5.10-5

1459.8

243.3

486.6

Time [days]

729.9

973.2

1216.5

1459.8

Time [days]

WUFI® Pro 6.0 NonCommercial; SIP_HardiePlank.w6p; Case 1: #1; 4/2/2017

Page : 18

WUFI® Pro 6.0 NonCommercial

WUFI® Pro 6.0 NonCommercial; SIP_HardiePlank.w6p; Case 1: #1; 4/2/2017

Page : 19

WUFI® Pro 6.0 NonCommercial

Temperature, RH (Monitor Position 1, 2)

Water Content of Individual Materials

120

8 Exterior Surface Interior Surface

Composite Wood Siding Air Layer 40 mm

90 Water Content [lb/ft³]

Temperature [°F]

6 60

2 0

-30

100

0.5 Exterior Surface Interior Surface

vapor retarder (10perm) weather resistive barrier (sd=0,1m)

0.4 Water Content [lb/ft³]

Relative Humidity [%]

0.3

0.2

25 0.1

243.3

486.6

729.9

973.2

1216.5

0.0

1459.8

Time [days]

WUFI® Pro 6.0 NonCommercial; SIP_HardiePlank.w6p; Case 1: #1; 4/2/2017

243.3

486.6

729.9

973.2

1216.5

1459.8

Time [days]

Page : 20

WUFI® Pro 6.0 NonCommercial; SIP_HardiePlank.w6p; Case 1: #1; 4/2/2017

Page : 21

Volume 2 - Team Illinoize - Page 69

WUFI® Pro 6.0 NonCommercial

Water Content of Individual Materials

0.5 Oriented Strand Board high Extruded Polystyrene Insulation

Air Layer 40 mm Gypsum Board (USA)

0.4 Water Content [lb/ft³]

Water Content [lb/ft³]

0.3

0.2

2 0.1

0.0

0.5 Oriented Strand Board high vapor retarder (0.1perm)

Gypsum Board (USA)

0.4 Water Content [lb/ft³]

Water Content [lb/ft³]

0.3

0.2

2 0.1

243.3

486.6

729.9

973.2

1216.5

0.0

1459.8

243.3

486.6

Time [days]

729.9

973.2

1216.5

1459.8

Time [days]

WUFI® Pro 6.0 NonCommercial; SIP_HardiePlank.w6p; Case 1: #1; 4/2/2017

Page : 22

WUFI® Pro 6.0 NonCommercial

WUFI® Pro 6.0 NonCommercial; SIP_HardiePlank.w6p; Case 1: #1; 4/2/2017

Page : 23

WUFI® Pro 6.0 NonCommercial

Total Water Content in Construction

Profiles

90 1.1.17 0 31.12.20 23:59:59:883

2.0

Temperature [°F]

Total Water Content [lb/ft²]

1.5

1.0

0.5

10 100 1.1.17 0 31.12.20 23:59:59:883

243.3

486.6

729.9

973.2

1216.5

1459.8 Relative Humidity [%]

0.0

Time [days]

0 8

Water Content [lb/ft³]

1.1.17 0 31.12.20 23:59:59:883

3.04

6.08

9.12

12.16

Distance [in] WUFI® Pro 6.0 NonCommercial; SIP_HardiePlank.w6p; Case 1: #1; 4/2/2017

Page : 24

WUFI® Pro 6.0 NonCommercial; SIP_HardiePlank.w6p; Case 1: #1; 4/2/2017

Page : 25

Volume 2 - Team Illinoize - Page 70

ŽŶƐƚƌƵĐƚŝŽŶ ŽƐƚ ^ƵŵŵĂƌǇ

dĞĂŵ͗

dĞĂŵ /ůůŝEK/^

ŽŶƚĞƐƚ ĂƚĞŐŽƌǇ͗

ƚƚĂĐŚĞĚ ,ŽƵƐŝŶŐ

E , ϮϬϭϯ ǀĞƌĂŐĞ ^Ƌ͘ &ƚ͘ dĞĂŵ ƐƋ͘Ĩƚ͘ ϮϲϬϳ ƐƋ͘Ĩƚ͘ ϮϰϲϬ ƐƋ͘Ĩƚ͘ E , >Žƚ ^ŝǌĞ ^Ƌ͘ &ƚ͘ >Žƚ ^ŝǌĞ ^Ƌ͘ &ƚ͘ ϭϰϯϱϵ ƐƋ͘Ĩƚ͘ ϯϬϬϬ ƐƋ͘Ĩƚ͘

ŽŶƐƚƌƵĐƚŝŽŶ ŽƐƚ ƌĞĂŬĚŽǁŶ

E , ϮϬϭϯ sĂůƵĞ ^ŚĂƌĞ ŽĨ ŽŶƐƚƌƵĐƚŝŽŶ sĂůƵĞ ΀ϭ΁ WĞƌ ƐƋ͘Ĩƚ͘

dĞĂŵ ĞĨĂƵůƚ ƐƚŝŵĂƚĞ ĨŽƌ ^ŚĂƌĞ ŽĨ ŽŶƐƚƌƵĐƚŝŽŶ sĂůƵĞ

/Ĩ Ă ĐĞůů ŝŶ ĐŽůƵŵŶ , ŝƐ ĐŽůŽƌĞĚ ΖŐƌĞĞŶΖ͕ ũƵƐƚŝĨŝĐĂƚŝŽŶͬŶŽƚĞƐ ŝƐ ƌĞƋƵŝƌĞĚ͘

dĞĂŵ ƐƚŝŵĂƚĞ ^ŚĂƌĞ ŽĨ dĞĂŵ ŽŶƐƚƌƵĐƚŝŽŶ ƐƚŝŵĂƚĞ EŽƚĞƐ :ƵƐƚŝĨŝĐĂƚŝŽŶͬEŽƚĞƐ ;ZĞƋƵŝƌĞĚ ĨŽƌ sĂůƵĞƐ ĚŝĨĨĞƌĞŶƚ sĂůƵĞ WĞƌ ƐƋ͘Ĩƚ͘ ZĞƋƵŝƌĞĚ͍ ƚŚĂŶ ĞĨĂƵůƚ sĂůƵĞͿ

^ŝƚĞ tŽƌŬ ;ƐƵŵ ŽĨ ƚŽ Ϳ ƵŝůĚŝŶŐ WĞƌŵŝƚ &ĞĞƐ /ŵƉĂĐƚ &ĞĞ tĂƚĞƌ Θ ^ĞǁĞƌ &ĞĞƐ /ŶƐƉĞĐƚŝŽŶƐ

Ψ ϭϲ͕ϴϮϱ Ψ ϯ͕ϲϰϳ Ψ ϯ͕ϯϭϮ Ψ ϰ͕ϯϰϲ

Ψ ϲ͘ϰϱ Ψ ϭ͘ϰϬ Ψ ϭ͘Ϯϳ Ψ ϭ͘ϲϳ

Ψ ϭϱ͕ϴϳϲ Ψ ϯ͕ϰϰϭ Ψ ϯ͕ϭϮϱ Ψ ϰ͕ϭϬϭ

Ψ ϳ͕ϰϯϴ͘ϬϬ Ψ ϯϰϱ Ψ ϭ͕ϰϮϮ Ψ Ͳ

Ψ Ϯ͘ϴϱ Ψ Ϭ͘ϭϰ z ^ Ψ Ϭ͘ϱϴ z ^ Ψ Ͳ z ^

ƌĐŚŝƚĞĐƚƵƌĞ͕ ŶŐŝŶĞĞƌŝŶŐ KƚŚĞƌ &ŽƵŶĚĂƚŝŽŶƐ ;ƐƵŵ ŽĨ & ƚŽ 'Ϳ

Ψ ϯ͕ϳϮϭ Ψ ϭ͕ϳϵϵ Ψ Ϯϯ͕ϰϬϭ

Ψ ϭ͘ϰϯ Ψ Ϭ͘ϲϵ Ψ ϴ͘ϵϴ

Ψ ϯ͕ϱϭϭ Ψ ϭ͕ϲϵϴ Ψ ϮϮ͕Ϭϴϭ

Ψ ϰ͕ϬϬϬ Ψ ϭ͕ϲϳϭ Ψ ϮϬ͕ϲϵϮ

Ψ ϭ͘ϲϯ z ^ Ψ Ϭ͘ϲϴ z ^ Ψ ϳ͘ϵϰ

ǆĐĂǀĂƚŝŽŶ͕ &ŽƵŶĚĂƚŝŽŶ͕ ŽŶĐƌĞƚĞ͕ ZĞƚĂŝŶŝŶŐ & ǁĂůůƐ͕ ĂŶĚ ĂĐŬĨŝůů ' KƚŚĞƌ &ƌĂŵŝŶŐ ;^Ƶŵ ŽĨ , ƚŽ >Ϳ , &ƌĂŵŝŶŐ ;ŝŶĐůƵĚŝŶŐ ƌŽŽĨͿ / dƌƵƐƐĞƐ ;ŝĨ ŶŽƚ ŝŶĐůƵĚĞĚ ĂďŽǀĞͿ : ^ŚĞĂƚŚŝŶŐ ;ŝĨ ŶŽƚ ŝŶĐůƵĚĞĚ ĂďŽǀĞͿ < 'ĞŶĞƌĂů DĞƚĂů͕ ^ƚĞĞů > KƚŚĞƌ ǆƚĞƌŝŽƌ &ŝŶŝƐŚĞƐ ;ƐƵŵ ŽĨ D ƚŽ WͿ D ǆƚĞƌŝŽƌ tĂůů &ŝŶŝƐŚ E ZŽŽĨŝŶŐ

Ψ Ϯϯ͕ϬϮϴ Ψ ϯϳϯ Ψ ϰϳ͕Ϭϯϲ Ψ ϯϲ͕ϰϯϴ Ψ ϱ͕ϰϲϭ Ψ Ϯ͕ϯϯϮ Ψ ϭ͕ϲϬϰ Ψ ϭ͕ϮϬϭ Ψ ϯϱ͕ϰϳϯ Ψ ϭϲ͕ϴϲϳ Ψ ϳ͕ϵϯϮ

Ψ ϴ͘ϴϯ Ψ Ϭ͘ϭϰ Ψ ϭϴ͘Ϭϰ Ψ ϭϯ͘ϵϴ Ψ Ϯ͘Ϭϵ Ψ Ϭ͘ϴϵ Ψ Ϭ͘ϲϮ Ψ Ϭ͘ϰϲ Ψ ϭϯ͘ϲϭ Ψ ϲ͘ϰϳ Ψ ϯ͘Ϭϰ

Ψ Ϯϭ͕ϳϯϬ Ψ ϯϱϮ Ψ ϰϰ͕ϯϴϰ Ψ ϯϰ͕ϯϴϯ Ψ ϱ͕ϭϱϯ Ψ Ϯ͕ϮϬϭ Ψ ϭ͕ϱϭϰ Ψ ϭ͕ϭϯϯ Ψ ϯϯ͕ϰϳϯ Ψ ϭϱ͕ϵϭϲ Ψ ϳ͕ϰϴϱ

Ψ ϮϬ͕ϯϰϬ Ψ ϴ͘Ϯϳ z ^ Ψ ϯϱϮ Ψ Ϭ͘ϭϰ z ^ Ψ ϲϯ͕Ϭϲϯ Ψ Ϯϰ͘ϭϵ Ψ ϰϭ͕Ϭϲϴ Ψ ϭϲ͘ϲϵ z ^ Ψ Ϯϭ͕ϬϬϬ Ψ ϴ͘ϱϰ z ^ Ψ Ϯϴϲ Ψ Ϭ͘ϭϮ z ^ Ψ Ͳ Ψ Ͳ z ^ Ψ ϳϬϵ Ψ Ϭ͘Ϯϵ z ^ Ψ ϰϮ͕ϬϬϮ Ψ ϭϲ͘ϭϭ Ψ ϭϱ͕ϵϴϬ Ψ ϲ͘ϱϬ z ^ Ψ Ͳ z ^

K tŝŶĚŽǁƐ ĂŶĚ ŽŽƌƐ ;ŝŶĐůƵĚŝŶŐ ŐĂƌĂŐĞ ĚŽŽƌͿ W KƚŚĞƌ DĂũŽƌ ^ǇƐƚĞŵƐ ZŽƵŐŚͲŝŶƐ ;ƐƵŵ ŽĨ Y ƚŽ dͿ

Ψ ϭϬ͕ϭϭϳ Ψ ϱϱϳ Ψ ϯϮ͕ϵϱϵ

Ψ ϯ͘ϴϴ Ψ Ϭ͘Ϯϭ Ψ ϭϮ͘ϲϰ

Ψ ϵ͕ϱϰϳ Ψ ϱϮϲ Ψ ϯϭ͕ϭϬϭ

Y WůƵŵďŝŶŐ ;ĞǆĐĞƉƚ ĨŝǆƚƵƌĞƐͿ Z ůĞĐƚƌŝĐĂů ;ĞǆĐĞƉƚ ĨŝǆƚƵƌĞƐͿ ^ ,s d KƚŚĞƌ /ŶƚĞƌŝŽƌ &ŝŶŝƐŚĞƐ ;ƐƵŵ ŽĨ h ƚŽ Ϳ h /ŶƐƵůĂƚŝŽŶ s ƌǇǁĂůů t /ŶƚĞƌŝŽƌ dƌŝŵƐ͕ ŽŽƌƐ͕ ĂŶĚ DŝƌƌŽƌƐ y WĂŝŶƚŝŶŐ z >ŝŐŚƚŝŶŐ ĂďŝŶĞƚƐ͕ ŽƵŶƚĞƌƚŽƉƐ ƉƉůŝĂŶĐĞƐ

Ψ ϭϭ͕ϴϮϯ Ψ ϵ͕ϵϲϳ Ψ ϭϬ͕ϵϴϬ Ψ ϭϴϵ Ψ ϳϮ͕Ϯϰϭ Ψ ϰ͕ϳϴϲ Ψ ϵ͕ϯϳϲ Ψ ϭϬ͕ϱϯϲ Ψ ϴ͕ϯϱϱ Ψ ϯ͕ϬϬϴ Ψ ϭϮ͕ϳϴϱ Ψ ϰ͕ϭϴϵ

Ψ ϰ͘ϱϰ Ψ ϯ͘ϴϮ Ψ ϰ͘Ϯϭ Ψ Ϭ͘Ϭϳ Ψ Ϯϳ͘ϳϭ Ψ ϭ͘ϴϰ Ψ ϯ͘ϲϬ Ψ ϰ͘Ϭϰ Ψ ϯ͘ϮϬ Ψ ϭ͘ϭϱ Ψ ϰ͘ϵϬ Ψ ϭ͘ϲϭ

&ůŽŽƌŝŶŐ WůƵŵďŝŶŐ &ŝǆƚƵƌĞƐ &ŝƌĞƉůĂĐĞ KƚŚĞƌ &ŝŶĂů ^ƚĞƉƐ ;ƐƵŵ ŽĨ & ƚŽ :Ϳ & >ĂŶĚƐĐĂƉŝŶŐ ' KƵƚĚŽŽƌ ƐƚƌƵĐƚƵƌĞƐ ;ĚĞĐŬ͕ ƉĂƚŝŽ͕ ƉŽƌĐŚĞƐͿ , ƌŝǀĞǁĂǇ / ůĞĂŶ ƵƉ : KƚŚĞƌ KƚŚĞƌ < KƚŚĞƌ > ZĞŶĞǁĂďůĞ ŶĞƌŐǇ ^ǇƐƚĞŵƐ ;KƉƚŝŽŶĂůͿ

Ψ ϭϮ͕ϯϳϴ Ψ ϰ͕Ϯϲϱ Ψ Ϯ͕Ϭϱϳ Ψ ϱϬϲ Ψ ϭϲ͕Ϯϱϰ Ψ ϱ͕ϳϰϰ Ψ Ϯ͕ϴϵϭ Ψ ϯ͕ϳϰϭ Ψ Ϯ͕Ϯϲϭ Ψ ϭ͕ϲϭϳ Ψ Ϯ͕Ϯϲϱ Ψ Ϯ͕Ϯϲϱ Ψ Ͳ Ψ Ϯϰϲ͕ϰϱϰ

dŽƚĂů

E , ^ĂůĞƐ WƌŝĐĞ ƌĞĂŬĚŽǁŶ &ŝŶƐŚĞĚ >Žƚ ŽƐƚ ;ŝŶĐůƵĚŝŶŐ ĨŝŶĂŶĐŝŶŐ ĐŽƐƚƐͿ͗ &ŝŶĂŶĐŝŶŐ ŽƐƚƐ KǀĞƌŚĞĂĚ ĂŶĚ 'ĞŶĞƌĂů ǆƉĞŶƐĞƐ DĂƌŬĞƚŝŶŐ ŽƐƚ ^ĂůĞƐ ŽŵŵŝƐƐŝŽŶ WƌŽĨŝƚ dŽƚĂů ^ĂůĞƐ WƌŝĐĞ

ϮϬϭϯ sĂůƵĞ ΀Ϯ΁ Ψ ϳϰ͕ϱϬϵ Ψ ϱ͕ϰϳϵ Ψ ϭϳ͕ϯϰϬ Ψ ϰ͕ϮϲϬ Ψ ϭϰ͕Ϯϯϱ Ψ ϯϳ͕Ϯϱϱ Ψ ϯϵϵ͕ϱϯϮ

ZĞǀŝĞǁĞĚ ĐŝƚǇ ƉĞƌŵŝƚ ĨĞĞƐ ĨŽƌ ŶĞǁ ƐŝŶŐůĞ ĨĂŵŝůǇ͕ ŚƚƚƉ͗ͬͬĐŚĂŵƉĂŝŐŶŝ ƐƚŝŵĂƚĞ ƉƌŽǀŝĚĞĚ ďǇ ůŽĐĂů ĚĞǀĞůŽƉĞƌ ƚŽ ƚĞĂŵ͘ EŽ /ŶƐƉĞĐƚŝŽŶ ZĞƋƵŝƌĞĚ͕ ŚƚƚƉ͗ͬͬǁǁǁ͘ŝůůŝŶŽŝƐƌĞĂůƚŽƌ͘ŽƌŐͬƐŝƚĞƐͬŝůůŝŶŽŝ ƵƐƚŽŵ ĚĞƐŝŐŶ ŚĂƐ ŚŝŐŚĞƌ ĨĞĞƐ ƚŚĂŶ ƚǇƉŝĐĂů ďƵŝůĚĞƌ͘ hƐŝŶŐ ĚĞĨĂƵůƚ ĞƐƚŝŵĂƚĞ͘

^ůĂď ŽŶ ŐƌĂĚĞ͘ hƐŝŶŐ ĚĞĨĂƵůƚ ĞƐƚŝŵĂƚĞ͘ ĚǀĂŶĐĞĚ ĨƌĂŵŝŶŐ ŝƐ ƐŽŵǁŚĂƚ ŵŽƌĞ ĞǆƉĞŶƐŝǀĞ͘ tŽŽĚ &ůŽŽƌ dƌƵƐƐĞƐ ĨƌŽŵ DŝĚǁĞƐƚĞƌŶ DĂŶƵĨĂĐƚƵƌŝŶŐ ĞƌŽ ĞŶĞƌŐǇ ƌĞĂĚǇ ƐŚĞĂƚŚŝŶŐ ŝƐ ŵŽƌĞ ĞǆƉĞŶƐŝǀĞ͘ DĞƚĂů ^ƚƵĚƐ ĨŽƌ ĨŝƌĞ ƌĂƚĞĚ ƉĂƌƚǇ ǁĂůů ^ŝŵƉƐŽŶ ^ƚƌŽŶŐdŝĞ

DŝĚǁĞƐƚ D

:ĂŵĞƐ ,ĂƌĚŝĞ ,ĂƌĚŝĞWůĂŶŬ Z E 'Z z ^ƚĂŶĚŝŶŐ ƐĞĂŵ ŵĞƚĂů ƌŽŽĨ ŚĂƐ ŚŝŐŚĞƌ ŝŶŝƚŝĂů ĐŽƐƚ

,ĂƌĚŝĞWůĂŶ

Ψ Ϯϱ͕ϱϱϬ Ψ ϭϬ͘ϯϵ z ^ Ψ ϰϳϮ Ψ Ϭ͘ϭϵ z ^ Ψ ϭϵ͕Ϭϭϱ Ψ ϳ͘Ϯϵ

ǆĂŵƉůĞ ĐŚĂŶŐĞ͗ ,ŝŐŚͲƉĞƌĨŽƌŵĂŶĐĞ ǁŝŶĚŽǁƐ

^ŽůĂƚƵďĞƐ

Ψ ϭϭ͕ϭϱϲ Ψ ϵ͕ϰϬϱ Ψ ϭϬ͕ϯϲϭ Ψ ϭϳϴ Ψ ϲϴ͕ϭϲϴ Ψ ϰ͕ϱϭϲ Ψ ϴ͕ϴϰϳ Ψ ϵ͕ϵϰϮ Ψ ϳ͕ϴϴϰ Ψ Ϯ͕ϴϯϴ Ψ ϭϮ͕Ϭϲϰ Ψ ϯ͕ϵϱϯ

Ψ ϯ͕ϰϬϮ Ψ ϭ͘ϯϴ z ^ Ψ ϲ͕ϮϳϬ Ψ Ϯ͘ϱϱ z ^ Ψ ϵ͕ϭϲϱ Ψ ϯ͘ϳϯ z ^ Ψ ϭϳϴ Ψ Ϭ͘Ϭϳ z ^ Ψ ϰϭ͕ϱϭϳ Ψ ϭϱ͘ϵϯ Ψ ϭϮ͕ϰϰϬ Ψ ϱ͘Ϭϲ z ^ Ψ ϯ͕ϮϱϬ Ψ ϭ͘ϯϮ z ^ Ψ ϭ͕ϬϬϭ Ψ Ϭ͘ϰϭ z ^ Ψ ϴϱϱ Ψ Ϭ͘ϯϱ z ^ Ψ ϲϱ Ψ Ϭ͘Ϭϯ z ^ Ψ ϴ͕ϯϬϬ Ψ ϯ͘ϯϳ z ^ Ψ ϭϬ͕ϰϬϬ Ψ ϰ͘Ϯϯ z ^

ĨĨŝĐŝĞŶƚ ƉůƵŵďŝŶŐ ƌƵŶƐ ĂŶĚ ĨĞǁĞƌ ďĂƚŚƌŽŽŵƐ ƚŚĂŶ ƚǇƉ͘ ^ŝŵƉůĞ ĨůŽŽƌƉůĂŶ ĂŶĚ ĐŝƌĐƵŝƚƐ ŵŝŶŝŵŝǌĞ ǁŽƌŬ͘ ,ŝŐŚ ƋƵĂůŝƚǇ ĞŶǀůŽƉĞ ĂůůŽǁƐ ƐŵĂůůĞƌ ƐŝǌĞ ,s ͘ ĞĨĂƵůƚ

Ψ ϰ͘ϳϱ Ψ ϭ͘ϲϰ Ψ Ϭ͘ϳϵ Ψ Ϭ͘ϭϵ Ψ ϲ͘Ϯϯ Ψ Ϯ͘ϮϬ Ψ ϭ͘ϭϭ Ψ ϭ͘ϰϯ Ψ Ϭ͘ϴϳ Ψ Ϭ͘ϲϮ Ψ Ϭ͘ϴϳ Ψ Ϭ͘ϴϳ Ψ Ͳ

Ψ ϭϭ͕ϲϴϬ Ψ ϰ͕ϬϮϱ Ψ ϭ͕ϵϰϭ Ψ ϰϳϳ Ψ ϭϱ͕ϯϯϳ Ψ ϱ͕ϰϮϬ Ψ Ϯ͕ϳϮϴ Ψ ϯ͕ϱϯϬ Ψ Ϯ͕ϭϯϰ Ψ ϭ͕ϱϮϲ Ψ Ϯ͕ϭϯϳ Ψ Ϯ͕ϭϯϳ Ψ Ͳ

Ψ ϯ͕ϬϮϱ Ψ ϭ͘Ϯϯ z ^ Ψ ϭ͕ϳϬϰ Ψ Ϭ͘ϲϵ z ^ Ψ Ͳ Ψ Ͳ z ^ Ψ ϰϳϳ Ψ Ϭ͘ϭϵ z ^ Ψ ϭϮ͕ϯϰϱ Ψ ϰ͘ϳϰ Ψ Ϯ͕ϱϱϬ Ψ ϭ͘Ϭϰ z ^ Ψ ϳ͕ϰϰϬ Ψ ϯ͘ϬϮ z ^ Ψ Ͳ Ψ Ͳ z ^ Ψ ϭ͕ϲϰϵ Ψ Ϭ͘ϲϳ z ^ Ψ ϳϬϲ Ψ Ϭ͘Ϯϵ z ^ Ψ Ϯϳ͕ϳϯϬ Ψ ϭϬ͘ϲϰ Ψ ϭ͕ϭϳϳ Ψ Ϭ͘ϰϴ z ^ Ψ Ϯϲ͕ϱϱϯ Ψ ϭϬ͘ϳϵ z ^

Ψ ϵϰ͘ϱϰ

Ψ ϮϯϮ͕ϱϱϳ

,ŝŐŚĞƌ ƚŚĂŶ ƚǇƉŝĐĂů ŝŶƐƵůĂƚŝŽŶ ŝŶĐůƵĚĞĚ͘ >ĞǀĞů ϱ ĚƌǇǁĂůů ĨŝŶŝƐŚ ŝŶĐůƵĚĞĚ͘ ^ƚĂŶĚĂƌĚ ŝŶƚĞƌŝŽƌ ƚƌŝŵƐ ĂŶĚ ĚŽŽƌƐ ĞĨĂƵůƚ > ůŝŐŚƚŝŶŐ ŚĂƐ ŚŝŐŚĞƌ ŝŶƚŝĂů ĐŽƐƚ͘ WĂƉĞƌƐƚŽŶĞ ƉƌŽĚƵĐƚƐ ĐŚĞĂƉĞƌ ƚŚĂŶ ŐƌĂŶŝƚĞ͘ dǇƉŝĐĂů ĞŶĞƌŐǇ ƐƚĂƌ ĂƉƉůŝĂŶĐĞƐ ƐƉĞĐŝĨŝĞĚ͘ tŽŽĚ ĨůŽŽƌƐ ƐƉĞĐŝĨŝĞĚ ƚŚƌŽƵŐŚŽƵƚ͕ ŚŝŐŚĞƌ ƚŚĂŶ ƚǇƉŝĐĂů͘ &ĞǁĞƌ ĨŝǆƚƵƌĞƐ ƚŚĂŶ ƚƌĂĚŝƚŝŽŶĂů ŚŽƵƐĞ ŽĨ ƚŚŝƐ ƐŝǌĞ͘ EŽ ĨŝƌĞƉůĂĐĞ͘ ĞĨĂƵůƚ DŝŶŝŵĂů ůĂŶĚƐĐĂƉŝŶŐ ŝŶĐůƵĚĞĚ ĚƵĞ ƚŽ ƐŵĂůů ůŽƚ͘ DŝŶŝŵĂů ĚĞĐŬ ƐƉĂĐĞ ŝŶĐůƵĚĞĚ EŽ ĚƌŝǀĞǁĂǇ ĨŽƌ ƵƌďĂŶ ůŽƚ ĞĨĂƵůƚ ĞĨĂƵůƚ

EŽ ĚƌŝǀĞǁ

ĞĨĂƵůƚ ǆĂŵƉůĞ ĐŚĂŶŐĞ͗ ^ŽůĂƌ Ws ƐǇƐƚĞŵ

Ψ Ϯϯϯ͕ϴϬϮ Ψ ϵϱ͘Ϭϰ

dĞĂŵ ĞĨĂƵůƚ ƐƚŝŵĂƚĞ

dĞĂŵ ĚũƵƐƚĞĚ ƐƚŝŵĂƚĞ

Ψ ϳϬ͕ϯϬϴ Ψ ϱ͕ϭϳϬ Ψ ϭϲ͕ϯϲϮ Ψ ϰ͕ϬϮϬ Ψ ϭϯ͕ϰϯϮ Ψ ϯϱ͕ϭϱϱ Ψ ϯϳϳ͕ϬϬϰ

Ψ ϰϱ͕ϬϬϬ Ψ ϱ͕ϰϳϵ Ψ ϭϳ͕ϯϰϬ Ψ ϰ͕ϮϲϬ Ψ ϭϰ͕Ϯϯϱ Ψ ϭϳ͕Ϯϴϭ Ψ ϯϯϳ͕ϯϵϳ

:ƵƐƚŝĨŝĐĂƚŝŽŶͬEŽƚĞƐ ;ZĞƋƵŝƌĞĚ ĨŽƌ sĂůƵĞƐ ĚŝĨĨĞƌĞŶƚ ƚŚĂŶ ĞĨĂƵůƚ sĂůƵĞͿ z ^ z ^ z ^ z ^ z ^ z ^

ZĞůĂƚŝǀĞůǇ ĐŚĞĂƉĞƌ ůŽƚ

ŽŶƐŝĚĞƌŝŶŐ ƚĂǆ ƌĞďĂƚĞƐ͘

Volume 2 - Team Illinoize - Page 71

> @ 15(/ 5HVRXUFH KWWS H\HRQKRXVLQJ RUJ FRVW RI FRQVWUXFWLQJ D VLQJOH IDPLO\ KRPH LQ > @ 15(/ 5HVRXUFH KWWS H\HRQKRXVLQJ RUJ FRVW RI FRQVWUXFWLQJ D VLQJOH IDPLO\ KRPH LQ

Volume 2 - Team Illinoize - Page 72

&ŝŶĂŶĐŝĂů ŶĂůǇƐŝƐ ^ƵŵŵĂƌǇ

,ŽŵĞ ŽƐƚ ŽŶƐƚƌƵĐƚŝŽŶ ŽƐƚƐ dŽƚĂů ,ŽŵĞ ŽƐƚƐ

WƌŽƉĞƌƚǇ dĂǆ WƌŽƉĞƌƚǇ dĂǆ ZĂƚĞ ŶŶƵĂů WƌŽƉĞƌƚǇ dĂǆ &ŝŶĂŶĐŝŶŐ ŶŶƵĂů /ŶƚĞƌĞƐƚ ZĂƚĞ zĞĂƌƐ WĂǇŵĞŶƚƐ ƉĞƌ zĞĂƌ EƵŵďĞƌ ŽĨ WĂǇŵĞŶƚƐ ŽǁŶ ƉĂǇŵĞŶƚ WƌŝŶĐŝƉůĞ ŵŽƵŶƚ DŽŶƚŚůǇ WĂǇŵĞŶƚ

ĞĨĂƵůƚ ƐƚŝŵĂƚĞ

ϭ͘ϭϱй Ψ ϯ͕ϵϴϲ

dĞĂŵ͗

dĞĂŵ /ůůŝEK/^

ŽŶƚĞƐƚ ĂƚĞŐŽƌǇ͗

ƚƚĂĐŚĞĚ ,ŽƵƐŝŶŐ

sĂůƵĞ :ƵƐƚŝĨŝĐĂƚŝŽŶͬEŽƚĞƐ Ψ Ϯϯϯ͕ϴϬϮ Ψ ϯϯϳ͕ϯϵϳ

ϭ͘ϭϱй ĞĨĂƵůƚ ĞƐƚŝŵĂƚĞĚ ƌĂƚĞ Ψ ϯ͕ϴϴϬ

ϰ͘ϱϬй

ϯ͘ϭй >Žǁ ŝŶƚĞƌĞƐƚ ZD ůŽĂŶ ϯϬ ǇĞĂƌƐ ϭϮ ϯϲϬ Ψ ϲϵ͕ϯϭϲ Ψ ϭϬϭ͕Ϯϭϵ ϯϬй ŽĨ dŽƚĂů ,ŽŵĞ ŽƐƚ Ψ Ϯϯϲ͕ϭϳϴ Ψ ;ϭ͕ϬϭϮͿ

ZĞƐŽƵƌĐĞƐ ĂŶĚ EŽƚĞƐ

ŚƚƚƉƐ͗ͬͬƐŵĂƌƚĂƐƐĞƚ͘ĐŽŵͬƚĂǆĞƐͬŝůůŝŶŽŝƐͲƉƌŽƉĞƌƚǇͲƚĂǆͲĐĂůĐƵůĂƚŽƌηŵŚĚdϯ<ϳĨǌϵ

ŚƚƚƉƐ͗ͬͬǁǁǁ͘ƋƵŝĐŬĞŶůŽĂŶƐ͘ĐŽŵͬŵŽƌƚŐĂŐĞͲĂƉƉůŝĐĂƚŝŽŶͬĨŽƵƌͲƐƚĞƉƐ͍ŐĐůŝĚс /tŝͲ>ŵyŝƚD &Yϲϰǁ Ž

ϯϬй ŽĨ ƚŽƚĂů ŚŽŵĞ ĐŽƐƚ

ĨĨŽƌĚĂďŝůŝƚǇ ƐƚŝŵĂƚĞĚ dĂƌŐĞƚ &ĂŵŝůǇ /ŶĐŽŵĞ DŽŶƚŚůǇ hƚŝůŝƚǇ ŽƐƚƐ ůĞĐƚƌŝĐŝƚǇ EĂƚƵƌĂů 'ĂƐ tĂƚĞƌ KƚŚĞƌ dŽƚĂů Ğďƚ ƚŽ /ŶĐŽŵĞ ZĂƚŝŽ DŽŶƚŚůǇ ,ŽƵƐĞŚŽůĚ Ğďƚ ;Ϭ͘ϱй D&/Ϳ KƉĞƌĂƚŝŽŶƐ ĂŶĚ DĂŝŶƚĞŶĂŶĐĞ ŽƐƚƐ DŽŶƚŚůǇ hƚŝůŝƚǇ ŽƐƚƐ WƌŽƉĞƌƚǇ dĂǆ /ŶƐƵƌĂŶĐĞ DŽƌƚŐĂŐĞ WĂǇŵĞŶƚ ĂůĐƵůĂƚĞĚ Ğďƚ ƚŽ /ŶĐŽŵĞ ZĂƚŝŽ

Ψ ϱϮ͕ϮϱϬ

Ψ ϲϱ͕ϬϬϬ dĂƌŐĞƚ &ĂŵŝůǇ /ŶĐŽŵĞ

Ψ ϭϭϭ Ψ ϯϭ Ψ ϭϴ Ψ Ͳ Ψ ϭϲϬ

Ψ ϯϵ Ψ Ͳ Ψ ϭϰ Ψ ϭϰ Ψ ϲϳ

Ψ Ϯϲϭ Ψ ϭϵϲ Ψ ϭϲϬ Ψ ϯϯϮ Ψ ϳϵ Ψ ϭ͕ϰϬϱ

Ψ ϯϮϱ Ψ ϭϵϲ Ψ ϲϳ Ψ ϯϮϯ Ψ ϳϵ Ψ ϭ͕ϬϭϮ

ϱϲй

&ŽƌĞĐĂƐƚĞĚ ĚƵĞ ƚŽ ĞĨĨŝĐŝĞŶƚ ĐŽŶƐƚƌƵĐƚŝŽŶ ĂŶĚ ƐŽů ŚƚƚƉ͗ͬͬǁǁǁ͘ĞŝĂ͘ŐŽǀͬĞůĞĐƚƌŝĐŝƚǇͬƐĂůĞƐͺƌĞǀĞŶƵĞͺƉƌŝĐĞͬƉĚĨͬƚĂďůĞϱͺĂ͘ƉĚĨ ůů ĞůĞĐƚƌŝĐ ŚŽƵƐĞ͘ ŚƚƚƉ͗ͬͬǁǁǁ͘ĂůůĐŽŶŶĞĐƚ͘ĐŽŵͬůƉͲŐĂƐͬŶĂƚƵƌĂůͲŐĂƐͲƵƐĂŐĞͲĐĂůĐƵůĂƚŽƌ͘Śƚŵů ĨĨŝĐŝĞŶƚ ĂƉƉůŝĂŶĐĞƐ͘ ŚƚƚƉ͗ͬͬǁǁǁ͘ĐŝƌĐůĞŽĨďůƵĞ͘ŽƌŐͬǁĂƚĞƌŶĞǁƐͬϮϬϭϬͬǁŽƌůĚͬƚŚĞͲƉƌŝĐĞͲŽĨͲǁĂƚĞƌͲĂͲĐŽŵƉĂƌŝƐŽŶͲŽĨͲǁĂƚĞ ^ŽůĂƌ >ĞĂƐĞ ŽƐƚ ^ŽůĂƌ >ĞĂƐĞ ŽƐƚ

ŚƚƚƉ͗ͬͬǁǁǁ͘ŝƌƐ͘ŐŽǀͬ ƵƐŝŶĞƐƐĞƐͬ^ŵĂůůͲ ƵƐŝŶĞƐƐĞƐͲΘͲ^ĞůĨͲ ŵƉůŽǇĞĚͬ>ŽĐĂůͲ^ƚĂŶĚĂƌĚƐͲ,ŽƵƐŝŶŐͲĂŶĚ

ϯϳй ,ŽŵĞŽǁŶĞƌƐŚŝƉ ĨĨŽƌĚĂďŝůŝƚǇ dĂƌŐĞƚ ŝƐ ϯϴй

Volume 2 - Team Illinoize - Page 73

dĞĂŵ EĂŵĞ͗ ŽŶƚĞƐƚ ĂƚĞŐŽƌǇ͗

dĞĂŵ /ůůŝEK/^ ƚƚĂĐŚĞĚ ,ŽƵƐŝŶŐ ŽŶƐƚƌƵĐƚŝŽŶ ŽƐƚ ^ƵŵŵĂƌǇ ĂƐĞůŝŶĞ ĞƐŝŐŶ

dĞĂŵ ĞƐŝŐŶ

^ŝƚĞ tŽƌŬ &ŽƵŶĚĂƚŝŽŶƐ &ƌĂŵŝŶŐ ǆƚĞƌŝŽƌ &ŝŶŝƐŚĞƐ DĂũŽƌ ^ǇƐƚĞŵƐ ZŽƵŐŚͲŝŶƐ /ŶƚĞƌŝŽƌ &ŝŶŝƐŚĞƐ &ŝŶĂů ^ƚĞƉƐ KƚŚĞƌ

Ψ ϭϱ͕ϴϳϲ Ψ ϮϮ͕Ϭϴϭ Ψ ϰϰ͕ϯϴϰ Ψ ϯϯ͕ϰϳϯ Ψ ϯϭ͕ϭϬϭ Ψ ϲϴ͕ϭϲϴ Ψ ϭϱ͕ϯϯϳ Ψ Ϯ͕ϭϯϳ

Ψ ϳ͕ϰϯϴ Ψ ϮϬ͕ϲϵϮ Ψ ϲϯ͕Ϭϲϯ Ψ ϰϮ͕ϬϬϮ Ψ ϭϵ͕Ϭϭϱ Ψ ϰϭ͕ϱϭϳ Ψ ϭϮ͕ϯϰϱ Ψ Ϯϳ͕ϳϯϬ

dŽƚĂů ŽŶƐƚƌƵĐƚŝŽŶ ŽƐƚƐ

Ψ ϮϯϮ͕ϱϱϳ

Ψ Ϯϯϯ͕ϴϬϮ

^ĂůĞƐ WƌŝĐĞ ^ƵŵŵĂƌǇ ĂŶĚ ŽƐƚ ŽĨ >ŝǀŝŶŐ ĂƐĞůŝŶĞ ĞƐŝŐŶ dŽƚĂů ^ĂůĞƐ WƌŝĐĞ DŽŶƚŚůǇ ,ŽƵƐĞŚŽůĚ Ğďƚ ;Ϭ͘ϱй D&/Ϳ KƉĞƌĂƚŝŽŶƐ ĂŶĚ DĂŝŶƚĞŶĂŶĐĞ ŽƐƚƐ DŽŶƚŚůǇ hƚŝůŝƚǇ ŽƐƚƐ WƌŽƉĞƌƚǇ dĂǆ /ŶƐƵƌĂŶĐĞ DŽƌƚĂŐĂŐĞ dŽƚĂů ƐƚŝŵĂƚĞĚ dĂƌŐĞƚ &ĂŵŝůǇ /ŶĐŽŵĞ Ğďƚ ƚŽ /ŶĐŽŵĞ ZĂƚŝŽ

dĞĂŵ ĞƐŝŐŶ

Ψ ϯϳϳ͕ϬϬϰ

Ψ ϯϯϳ͕ϯϵϳ

Ψ Ϯϲϭ Ψ ϭϵϲ Ψ ϭϲϬ Ψ ϯϯϮ Ψ ϳϵ Ψ ϭ͕ϰϬϱ Ψ Ϯ͕ϰϯϯ

Ψ ϯϮϱ Ψ ϭϵϲ Ψ ϲϳ Ψ ϯϮϯ Ψ ϳϵ Ψ ϭ͕ϬϭϮ Ψ Ϯ͕ϬϬϮ

Ψ ϱϮ͕ϮϱϬ ϱϲй

Ψ ϲϱ͕ϬϬϬ ϯϳй

Volume 2 - Team Illinoize - Page 74