Manual de serviço mini system SONY modelos HCD-GR8 e HCD-RX90. by Portal da Eletrônica

HCD-GR8/RX90 SERVICE MANUAL

AEP Model UK Model HCD-RX90

Ver 1.1 2002.06

E Model Australian Model Tourist Model HCD-GR8

HCD-GR8/RX90 is the tuner, deck, CD and amplifier section in MHC-GR8/RX90.

Photo: HCD-RX90

Dolby noise reduction manufactured under license from Dolby Laboratories Licensing corporation. "DOLBY" and the double-D symbol a are trademarks of Dolby Laboratories Licensing Corporation.

CD Section

Model Name Using Similar Mechanism

HCD-GR7/RX70

CD Mechanism Type

CDM38L-5BD29AL

Base Unit Name

BU-5BD29AL

Optical Pick-up Name Tape deck Section

KSS-213D/Q-NP

Model Name Using Similar Mechanism Tape Transport Mechanism Type

HCD-H881 TCM-220WR2

SPECIFICATIONS Amplifier section DIN power output (RX90) 80+80 watts (8 ohms, at 1kHz, DIN) Continuous RMS power output RX90: 100+100 watts (8ohms at 1kHz, 10% THD) GR8: 90+90 watts (8ohms at 1kHz, 10% THD) Peak music power output GR8: 1500 watts Music power output RX90: 160+160 watts (8ohms at 1kHz, 10% THD) Inputs VIDEO/MD IN (phono jacks): voltage 250 mV, impedance 47 kilohms MIX MIC (phone jack): sensitivity 1 mV, impedance 10 kilohms Outputs VIDEO/MD OUT (phone jacks): voltage 250 mV impedance 1 kilohms PHONES (stereo phone jack): accepts headphones of 8 ohms or more. SPEAKER: accepts impedance of 8 to 16 ohms

SURROUND SPEAKER: accepts impedance of 16 ohms. SUPER WOOFER: Voltage 1 V, impedance 1 kilo ohm CD player section System Compact disc and digital audio system Laser Semiconductor laser (λ=780 nm) Emission duration: continuous Laser output Max. 44.6 µW* *This output is the value measured at a distance of 200 mm from the objective lens surface on the Optical Pick-up Block with 7 mm aperture. Frequency response 2 Hz – 20 kHz (±0.5 dB) Wavelength 780 – 790 nm

9-960-881-12

Sony Corporation

2002F0500-1 C 2002.06

Home Audio Company Published by Sony Engineering Corporation

Signal-to-noise ratio More than 90 dB Dynamic range More than 90 dB CD OPTICAL DIGITAL OUT (Square optical connector jack, rear panel) Wavelength 600 nm Output Level –18 dBm Tape player section Recording system 4-track 2-channel stereo Frequency response 60 – 13,000 Hz (±3 dB), (DOLBY NR OFF) using Sony TYPE I casstte 60 – 14,000 Hz (±3 dB), using Sony TYPE II cassette Wow and flutter ±0.15% W.Peak (IEC) 0.1% W.RMS (NAB) ±0.2% W.Peak (DIN)

– Continued on next page –

MINI Hi-Fi COMPONENT SYSTEM

Tuner section FM stereo, FM/AM superheterodyne tuner

MODEL IDENTIFICATION – BACK PANEL –

FM tuner section Tuning range EE and CIS models:

65.0 – 74.0 MHz 87.5 – 108.0 MHz Other models: 87.5 – 108.0 MHz Aerial FM lead aerial Aerial terminals 75 ohm unbalanced Intermediate frequency 10.7 MHz

PARTS No.

UKV tuner section (EE and CIS models) Tuning range 65.0 – 74.0 MHz Polar stereo AM tuner section Tuning range RX90:

MW: 531 – 1,602 kHz (with interval set at 9kHz) LW: 153 – 279 kHz (with interval set at 3kHz) MX, AUS, EA4 and TH models: 531 – 1,602 kHz (with the AM tuning interval st at 9 kHz) 530 – 1,710 kHz (with the AM tuning interval set at 10 kHz) Other models MW: 531 – 1,602 kHz (With the MW tuning interval set at 9 kHz) 530 – 1,710 kHz (With the MW tuning interval set 10 kHz) SW: 5.95 – 17.9 MHz (with the SW tuning interval set at 5 kHz) Aerial AM loop aerial Aerial terminals External aerial terminal Intermediate frequency 450 kHz General Power requirements RX90: MX model: MY and AUS models: TH model: Other models: Power consumption RX90: GR8: Mass: Supplied accessories:

220 – 230 V AC, 50/60 Hz 120 V AC, 50/60 Hz 220 – 240 V AC, 50/60 Hz 220 V AC, 50 Hz 110 – 120 V or 220 – 240 V AC, 50/60 Hz Adjustable with voltage selector 230 watts 220 watts Approx. 9.5 kg AM loop aerial (1) Remote RM-SD80 (1) Sony SUM-3 (NS) Batteries (2) FM lead aerial (1) Speaker cords (4)

Design and specifications are subject to change without notice.

MODEL

4-986-845-1π

GR8 : MY model

4-986-845-2π

GR8 : E3, IA models

4-988-021-0π

GR8 : E2 model

4-988-021-1π

GR8 : SP model

4-988-021-2π

GR8 : TW, JE models

4-988-021-3π

GR8 : HK model

4-988-021-4π

GR8 : AUS model

4-988-021-5π

GR8 : MX model

4-988-021-6π

GR8 : EA4, TH, SAF models

4-988-021-7π

RX90 : AEP model (Made in Malaysia)

4-986-845-0π

RX90 : AEP (Made in Indonesia), AED, G, UK models

4-986-982-0π

RX90 : EE, CIS model

4-986-982-1π

• Abbreviation AED : Northern European AUS : Australian E2 : 120 V AC Area in E model E3 : 240 V AC Area in E model EA3 : Saudi Arabia EA4 : Israeli EE : East European G : German HK : Hong Kong IA : Indonesia JE : Tourist MX : Mexican MY : Malaysia SAF : South African SP : Singapore TH : Thailand TW : Taiwan

–2–

PARTS NO.

GR8 : EA3 model

CAUTION Use of controls or adjustments or performance of procedures other than those specified herein may result in hazardous radiation exposure. This appliance is classified as a CLASS 1 LASER product. The CLASS 1 LASER PRODUCT MARKING is located on the rear exterior.

Laser component in this product is capable of emitting radiation exceeding the limit for Class 1. The following caution label is located inside the unit.

SAFETY-RELATED COMPONENT WARNING!! COMPONENTS IDENTIFIED BY MARK ! OR DOTTED LINE WITH MARK ! ON THE SCHEMATIC DIAGRAMS AND IN THE PARTS LIST ARE CRITICAL TO SAFE OPERATION. REPLACE THESE COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS PUBLISHED BY SONY.

–3–

TABLE OF CONTENTS

SERVICING NOTES NOTES ON HANDLING THE OPTICAL PICK-UP BLOCK OR BASE UNIT

Servicing Notes ..........................................................................

GENERAL ....................................................................

DISASSEMBLY .......................................................... 25

TEST MODE ................................................................ 31

MECHANICAL ADJUSTMENTS ......................... 33

The laser diode in the optical pick-up block may suffer electrostatic break-down because of the potential difference generated by the charged electrostatic load, etc. on clothing and the human body. During repair, pay attention to electrostatic break-down and also use the procedure in the printed matter which is included in the repair parts. The flexible board is easily damaged and should be handled with care.

ELECTRICAL ADJUSTMENTS

NOTES ON LASER DIODE EMISSION CHECK

Deck Section ..................................................................... 33 Tuner Section .................................................................... 36 CD Section ........................................................................ 39

DIAGRAMS

6-1. 6-2. 6-3. 6-4. 6-5. 6-6. 6-7. 6-8. 6-9. 6-10. 6-11. 6-12. 6-13. 6-14. 6-15.

Printed Wiring Board –Tuner Section– ............................ Schematic Diagram –Tuner Section– ............................... Printed Wiring Board –CD Section– ................................ Schematic Diagram –CD Section– ................................... Printed Wiring Boards –CD Motor Section– .................... Schematic Diagram –CD Motor Section– ........................ Printed Wiring Boards –Deck Section– ............................ Schematic Diagram –Deck Section– ................................ Schematic Diagram –Main /Power Section– .................... Printed Wiring Boards –Main /Power Section– ................ Schematic Diagram –Panel Section– ................................ Printed Wiring Boards –Panel Section– ........................... Printed Wiring Board –Power Amp Section– ................... Schematic Diagram –Power Amp Section– ...................... IC Pin Function Description .............................................

EXPLODED VIEWS ................................................. 92

ELECTRICAL PARTS LIST ................................... 103

42 45 49 51 53 55 57 59 63 67 71 75 79 80 88

The laser beam on this model is concentrated so as to be focused on the disc reflective surface by the objective lens in the optical pickup block. Therefore, when checking the laser diode emission, observe from more than 30 cm away from the objective lens. Notes on chip component replacement • Never reuse a disconnected chip component. • Notice that the minus side of a tantalum capacitor may be damaged by heat. Flexible Circuit Board Repairing • Keep the temperature of the soldering iron around 270 ˚C during repairing. • Do not touch the soldering iron on the same conductor of the circuit board (within 3 times). • Be careful not to apply force on the conductor when soldering or unsoldering.

–4–

SECTION 2 DISASSEMBLY • This set can be disassembled in the order shown below.

CASE (Page 25)

FRONT PANEL SECTION (Page 25)

CD MECHANISM DECK SECTION (Page 26)

BASE UNIT (Page 27) MAIN BOARD (Page 27) TRAY SECTION (Page 28)

TAPE MECHANISM DECK SECTION (Page 26)

AUDIO BOARD (Page 30)

SLED MOTOR (Page 29) CAPSTAN MOTOR (Page 30)

Note: Follow the disassembly procedure in the numerical order given.

3 three screws (BVTT 3 × 6)

2 screw (case 3 TP2) (3 × 10)

CASE

OPTICAL PICK-UP (Page 29)

BD BOARD (Page 29)

4 Remove the case to direction of the arrow. 2 screw (case 3 TP2) (3 × 10)

1 two screws (case 3 TP2) (3 × 8)

FRONT PANEL SECTION

1 Turn the cam to direction of the arrow A.

3 loading panel

A 5 screw (BVTP 3 × 10)

2 Pull the tray

4 three flat wires (CN102, 205, 206)

5 screw (BVTP 3 × 10)

8 front panel section

6 four screws (BVTT 3 × 6)

7 two claws

– 25 –

CD MECHANISM DECK SECTION

1 two connectors (CN203, 204)

3 two screws (BVTP 3 × 8)

2 flat wire (CN202)

4 CD mechanism deck section Note: The CD mechanism deck will fall if three screws are removed. Support it by hand, then remove three screws.

TAPE MECHANISM DECK SECTION

3 three screws (BVTP 2.6 × 8) 4 tape mechanism deck section

2 Open the cassette lids.

1 Push the two buttons.

– 26 –

BASE UNIT 2 boss

1 two yoke bracket

3 base unit

MAIN BOARD 4 four screws (BVTP 3 × 8)

1 connector (CN901) 2 connector (CN105) 3 flat wire (CN201)

IC201

6 main board

4 two screws (BVTP 3 × 8) 5 connector (CN101)

– 27 –

TRAY SECTION

claw A claw B 3 flat wire (CN705)

flat wire

Note: When installing the tray, pull around the flat wire to pass through the claw A and claw B, as shown in the figure.

4 two claws

2 Pull the tray. 5 Removal the tray. 1 Turn the cam to direction of the arrow.

Note: When installing the tray, take care so that the collars (A) and (B) are properly inserted into the slots.

slots

collar A collar B

â&#x20AC;&#x201C; 28 â&#x20AC;&#x201C;

BD BOARD 1 two screws (PTPWH M2.6 × 6)

1 two screws (PTPWH M2.6 × 6)

2 optical pick-up section 3 two springs 3 two springs

5 screw (BVTP 2.6 × 8)

4 flat wire (CN101)

6 Removal the four solders.

7 BD board

limit switch

OPTICAL PICK-UP, SLED MOTOR 3 optical pick-up

4 two screws (P 2 × 3)

2 sled shaft

1 claw 5 sled motor

– 29 –

AUDIO BOARD 1 connector (CN651)

2 two rivets

4 four screws (BTP 2.6 × 4)

3 Break the soldering of two flexible flat cables. 5 AUDIO board

CAPSTAN MOTOR

4 Removal the capstan motor to direction of the arrow. 2 two screws (BTP 2.6 × 8)

1 Break the soldering of motor lead. 3 claw

5 Hang the two belts.

– 30 –

SECTION 3 TEST MODE [MC Cold Reset] • The cold reset clears all data including preset data stored in the RAM to initial conditions. Execute this mode when returning the set to the customer. Procedure: 1. Press three buttons SPECTRUM ANALYZER , ENTER/NEXT , and DISC 1 simultaneously. 2. The fluorescent indicator tube becomes blank instantaneously, and the set is reset. [CD Delivery Mode] • This mode moves the pickup to the position durable to vibration. Use this mode when returning the set to the customer after repair. Procedure: 1. Press POWER button to turn the set ON. 2. Press PLAY button and POWER button simultaneously. 3. A message “LOCK” is displayed on the fluorescent indicator tube, and the CD delivery mode is set. [MC Hot Reset] • This mode resets the set with the preset data kept stored in the memory. The hot reset mode functions same as if the power cord is plugged in and out. Procedure: 1. Press three buttons SPECTRUM ANALYZER , ENTER/NEXT , and DISC 2 simultaneously. 2. The fluorescent indicator tube becomes blank instantaneously, and the set is reset. [Sled Servo Mode] • This mode can run the CD sled motor freely. Use this mode, for instance, when cleaning the pickup. Procedure: 1. Select the function “CD”. 2. Press three buttons SPECTRUM ANALYZER , ENTER/NEXT , and FUNCTION simultaneously. 3. The Sled Servo mode is selected, if “CD” is blanking on the fluorescent indicator tube. 4. With the CD in stop status, press ) button in CD section to move the pickup to outside track, or 0 button to inside track. 5. To exit from this mode, perform as follows: 1) Move the pickup to the most inside track. 2) Press three buttons in the same manner as step 2. Note: • Always move the pickup to most inside track when exiting from this mode. Otherwise, a disc will not be unloaded. • Do not run the sled motor excessively, otherwise the gear can be chipped.

[Change-over of AM Tuner Step between 9kHz and 10kHz] • A step of AM channels can be changed over between 9kHz and 10kHz. Procedure: 1. Press POWER button to turn the set ON. 2. Select the function “TUNER”, and press TUNER/BAND button to select the BAND “AM”. 3. Press POWER button to turn the set OFF. 4. Press ENTER/NEXT and POWER buttons simultaneously, and the display of fluorescent indicator tube changes to “AM 9k STEP” or “AM 10k STEP”, and thus the channel step is changed over. [LED and Fluorescent Indicator Tube All Lit, Key Check Mode] Procedure: 1. Press three buttons SPECTRUM ANALYZER , ENTER/NEXT , and DISC 3 simultaneously. 2. LEDs and fluorescent indicator tube are all turned on. Press DISC 2 button, and the key check mode is activated. 3. In the key check mode, the fluorescent indicator tube displays “K 1 V0 J0”. Each time a button is pressed, “K”value increases. However, once a button is pressed, it is no longer taken into account. “J” value increases like 1, 2, 3 ... if rotating JOG knob in “+” direction, or it decreases like 0, 9, 8 ... if rotating in “–” direction. “V” value increases like 1, 2, 3 ... if rotating VOLUME knob in “+” direction, or it decreases like 0, 9, 8 ... if rotating in “–” direction. 4. To exit from this mode, press three buttons in the same manner as step 1, or disconnect the power cord.

[Change-over of FUNCTION Name] • The FUNCTION name of external input terminal can be changed over to VIDEO or MD. Procedure: 1. Press POWER button to turn the set OFF. 2. Press POWER button together with FUNCTION button, and the power is turned on, the display of fluorescent indicator tube changes to “MD” or “VIDEO” instantaneously, and thus the FUNCTION is changed over.

– 31 –

[Aging Mode] This mode can be used for operation check of CD section and tape deck section. • If an error occurred: The aging operation stops. • If no error occurs: The aging operation continues repeatedly. 1. Aging Mode in CD Section 1-1. Operating Method of Aging Mode 1. Set discs in DISC1 and DISC2 trays. 2. Select the function “CD”. 3. Press three buttons SPECTRUM ANALYZER , ENTER/NEXT , and KARAOKE PON/MPX simultaneously. 4. The aging mode is activated, if a roulette mark on the fluorescent indicator tube is blinking. 5. In the aging mode, the aging is executed in a sequence given in “1-2. Operation during Aging Mode”. The aging continues unless an alarm occurred. 6. To exit from the aging mode, press POWER button to turn the set OFF. • If a button other than buttons In CD section is pressed during aging, the aging in the CD section is finished. • To execute aging to the tape deck section successively, press · button in the deck A. “AGING” is displayed on the fluorescent indicator tube. (For the aging in tape deck, see “2. Aging Mode in Tape Deck Section”. 1-2. Operation during aging Mode In the aging mode, the program is executed in the following sequence. 1. The disc table is ejected. 2. The disc tray turns to select a disc. (For a disc selection sequence, see Section 1-3.) 3. TOC of disc is read. 4. The pickup accesses to the last track. 5. A disc is ejected. 6. Steps 2 through 5 are repeated.

7. In the aging mode, the aging is executed in a sequence given in “2-2. Operation during Aging Mode”. The aging continues unless an alarm occurred. 8. To exit from the aging mode, press POWER button to turn the set OFF. 2-2. Operation during Aging Mode In the aging mode, the program is executed in the following sequence. 1. A tape on FWD side is played for one minute. 2. PAUSE STOP is made. 3. Recording is made for 3 minutes. (For the deck not having the record function, the play is executed. In this case, · LED does not light up.) 4. FF is executed up to the end of tape. 5. A tape is reversed, and the tape on REV side is played for one minute. 6. PAUSE STOP is made. 7. Recording is made for 3 minutes. (For the deck not having the record function, the play is executed. In this case, ª LED does not light up.) 8. FF is executed up to the end of tape. 9. Steps 1 through 8 are executed for the other deck. 10. Steps 1 through 9 are repeated unless an alarm occurred. 2-3. Deck Selection Sequence • During the aging mode, decks are selected in the following sequence: Deck A (FWD) → Deck A (REV) ↑ ↓ Deck B (REV) ← Deck B (FWD)

1-3. Disc Selection Sequence • During the aging mode, discs are selected in the following sequence: Disc 1 → Disc 2 ↑ ↓ Disc 2 ← Disc 1 2. Aging Mode in Tape Deck Section 2-1. Operating Method of Aging Mode 1. Load a commercially available 10-minute tape into the decks A and B respectively. (If a 10-minute tape is not available, another tape may be used but a cycle time will be longer.) 2. Select the function “TAPE”. 3. Rewind tapes in advance by pressing 0 button respectively on decks A and B. 4. Press three buttons SPECTRUM ANALYZER , ENTER/NEXT , and KARAOKE PON/MPX simultaneously. 5. Press · button on deck A. (This button triggers the aging mode.) 6. The aging mode is activated if “AGING A” is displayed on the fluorescent indicator tube.

– 32 –

SECTION 4 MECHANICAL ADJUSTMENTS

SECTION 5 ELECTRICAL ADJUSTMENTS

PRECAUTION 1. Clean the following parts with a denatured-alcohol-moistened swab: record/playback head pinch roller erase head rubber belts capstan idlers 2. Demagnetize the record/playback head with a head demagnetizer. 3. Do not use a magnetized screwdriver for the adjustments. 4. After the adjustments, apply suitable locking compound to the parts adjusted. 5. The adjustments should be performed with the rated power supply voltage unless otherwise noted. • Torque Measurement Mode

Torque Meter

Meter Reading

Forward

CQ-102C

36 to 61g•cm (0.50 – 0.84 oz•inch)

Forward Back Tension

CQ-102C

2 to 6g•cm (0.026 – 0.082 oz•inch)

Reverse

CQ-102RC

36 to 61g•cm (0.50 – 0.84 oz•inch)

Reverse Back Tension

CQ-102RC

2 to 6g•cm (0.026 – 0.082 oz•inch)

FF, REW

CQ-201B

0 dB=0.775V

1. Demagnetize the record/playback head with a head demagnetizer. (Do not bring the head demagnetizer close to the erase head.) 2. Do not use a magnetized screwdriver for the adjustments. 3. After the adjustments, apply suitable locking compound to the parts adjust. 4. The adjustments should be performed with the rated power supply voltage unless otherwise noted. 5. The adjustments should be performed in the order given in this service manual. (As a general rule, playback circuit adjustment should be completed before performing recording circuit adjustment.) 6. The adjustments should be performed for both L-CH and R-ch. 7. Switches and controls should be set as follows unless otherwise specified. 8. Set to test mode. (Press key switch same time SPECTRUM ANALYZER ENTER/NEXT and EFFECT ON/OFF button.) •

Test Tape

61 to 143g•cm (0.85 – 1.98 oz•inch)

• Tape Tension Measurement Mode

DECK SECTION

Tape

Signal

Used for

P-4-A100

10 kHz, –10 dB

Azimuth Adjustment

WS-48B

3 kHz, 0dB

Tape Speed Adjustment

P-4-L300

315 Hz, 0dB

Level Adjustment

Record/Playback Head Azimuth Adjustment DECK A

Tension Meter

Meter Reading

Forward

CQ-403A

more than 100 g (3.53 oz)

Reverse

CQ-403R

more than 100 g (3.53 oz)

DECK B

Note: Perform this adjustments for both decks Procedure: 1. Mode: Playback (FWD) test tape P-4-A100 (10 kHz, –10 dB)

main board CN207 Pin 1 (L-CH) Pin 3 (R-CH) level meter set

+ – main board CN207 Pin 2

– 33 –

2. Turn the adjustment screw and check output peaks. If the peaks do not match for L-CH and R-CH, turn the adjustment screw so that outputs match within 1dB of peak.

within 1dB

L-CH peak

within 1dB

output level

Screw position

Tape Speed Adjustment DECK A Note: Start the Tape Speed adjustment as below after setting to the test mode. In the test mode, the tape speed is high during pressing the HIGH SPEED DUBBING button. Procedure: 1. Turn the power switch on. 2. Press the SPECTRUM ANALYZER button, ENTER/NEXT button and EFFECT ON/OFF button simultaneously. To exit from the test mode, press the POWER button. Mode: Playback (FWD)

R-CH peak L-CH peak

test tape WS-48B (3 kHz, 0 dB)

Screw position

R-CH peak

frequency counter

3. Mode: Playback (FWD) test tape P-4-A100 (10kHz, –10dB) L-CH

main board CN207 (Pin 1 : L-CH) (Pin 3 :R-CH)

oscilloscope pin 1

main L board CN207 R set

pin 2 V

R-CH

pin 3 waveform of oscilloscope

in phase 45°

+ –

set

90° 135° 180°

good

wrong

4. Repeat steps 1 to 3 in playback (REV) mode. 5. After the adjustments, apply suitable locking compound to the pats adjusted. Adjustment Location: Record/Playback Head (Deck A and B) and main board.

1. Insert the WS-48B into the deck A and the blank tape into the deck B. 2. Press the REC button and · button on the deck B. Then the deck B is at recording mode. 3. Set the deck A to playback mode. 4. Keep pressing the HIGH SPEED DUBBING button in playback mode. Then at HIGH speed mode. 5. Adjust RV652 on the AUDIO board do that frequency counter reads 6,000 ± 60 Hz. 6. Take off the HIGH SPEED DUBBING button. Then at NORMAL speed mode. 7. Adjust RV651 on the AUDIO board so that frequency counter reads 3,000 +30 –10 Hz. 8. Frequency difference between deck A and deck B the beginning of the tape should be within ± 1.5 %. Adjustment Location: AUDIO board Playback level Adjustment Procedure: Mode: Playback (FWD) test tape P-4-L300 (315 Hz, 0 dB)

DECK A

DECK B

level meter

set

+ –

main board CN207 (Pin 1 : L-CH) (Pin 3 : R-CH)

Deck A is RV311 (L-CH) and RV411 (R-CH), Deck B is RV301 (LCH) and RV401 (R-CH) so that adjustment within adjustment level as follows. Adjustment Level: CN207 PB level: 301.5 to 338.3 mV (–8.2 to –7.2 dB) level difference between the channels: within ±0.5 dB Adjustment Location: AUDIO and main boards forward

reverse

– 34 –

Record bias Current Adjustment Procedure: 1. Mode: record

Adjustment Location: main board

DECK B

[MAIN BOARD] (Component Side)

Pin 6 (L-CH) of IC1501 on the main board. Pin #¶ (L-CH) of IC1501 on the main board. 1) 315 Hz  2) 10 kHz  50 mV (–23.8 dB)  AF OSC blank tape CN-123 600 Ω attenuator

RV1501 IC1501 IC201

IC301

CN205

CN207 RV1551

RECORD LEVEL

set Pin 2 (GND) of ICN207 on the main board.

2. Mode: Playback recorded portion

level meter + –

L R RV301®L RV441 RV341 RV401®R PB LEVEL

Record Level Adjustment DECK B Procedure: 1. Mode: record Pin 6 (L-CH) of IC1501 on the main board. Pin #¶ (R-CH) of IC1501 on the main board. 315 Hz, 50 mV (–23.8 dB)

AF OSC

blank tape CS-123

600 Ω attenuator set

Pin 2 (GND) of CN207 on the main board.

2. Mode: Playback recorded portion

level meter

set

TAPE SPEED

    

Confirm playback the signal recorded in step 1 become adjustable limits as follows. If these levels do not adjustable limits, adjustment the RV341 (L-CH) and RV441 (R-CH) on the AUDIO board to repeat steps 1 and 2. Adjustable limits: Playback output of 315 Hz to playback output of 10 kHz: ±0.5 dB Adjustment Location: AUDIO and main boards

RECORD BAIS

          

CN207 (Pin 1 : L-CH) (Pin 3 : R-CH)

    

[AUDIO BOARD] (Conductor Side)

+ –

CN207 (Pin 1 : L-CH) (Pin 3 : R-CH)

Confirm playback the signal recorded in step 1 become adjustable limits as follows. If these levels do not adjustable limits, adjustment the RV1501 (LCH) and RV1551 (R-CH) on the main board to repeat steps 1 and 2. Adjustable limits: CN207 PB level: 47.3 to 53.1 mV (–24.3 to –23.3 dB)

– 35 –

– DECK B –

(NORMAL) RV651 ® PB LEVEL

    

set

(HIGH) RV652 ® RV311 L ® RV411 R®

– DECK A –

TUNER SECTION

0 dB=1 µV

(GR8: Tourist/RX90 only) Note: As a front-end (FE1) is difficult to repair if faulty, replace it with new one. AM Section Adjustment Setting: loop antenna (Supplied accessories)

loop antenna AM RF SSG

set 30% amplitude modulation by 400 Hz signal

AM ANTENNA terminal (TM1)

60 cm

Field strength dB (µV/m) =SSG output level dB (µV/m) –26 dB.

AM Tuned Level Adjustment Band: AM or MW Procedure: 1. Set the output of SSG so that the input level of the set becomes 55 dB. 2. Tune the set to 999 kHz. 3. Adjust RV41 to the point (moment) when the TUNED indicator will change from going off to going on. Adjustment Location : TCB board

Adjustment Location: [TCB BOARD] (Component Side)

FM Section Adjustment Note: This adjustment should be performed after the AM Tuned Level Adjustment due to the same adjustment element. Setting:

IC41

RV41

RV42 TM1

FE1

FM RF stereo signal generator 75 Ω coaxial set Carrier frequency : 98 MHz Modulation : AUDIO 1 kH, 75 kHz FM ANTENNA terminal deviation (100%) (TM1) (75 Ω open)

FM Tuned Level Adjustment Band: FM Procedure: 1. Supply a 25 dBµ 98 MHz signal from the ANTENNA terminal. 2. Tune the set to 98 MHz. 3. If the TUNED indicator does not light, adjust RV42 to the point (moment) when the TUNED indicator will change from going off to going on. Adjustment Location: TCB board

– 36 –

Adjustment Location:

SW OSC Voltage Adjustment (GR8: Tourist only)

[TCB BOARD] (Component Side) Setting: Band: SW

RV41 D1, CV2, T2 SW OSC Voltage Adjustment

Procedure: 1. Connect digital Voltmeter to diode D1 center lead and ground. 2. Adjust for a following value reading on digital voltmeter.

frequency Adjustment

part Reading on

digital voltmeter

5.95 MHz

1.2 ± 0.1 V

17.9 MHz

CV2

8.5 ± 0.2 V

RV42

D1 TM1 T1

CV1, T1 SW Tracking Adjustment

Setting: Band: SW level meter

AM RF SSG

set SPEAKER terminal AM ANTENNA terminal

Procedure: Adjust for maximum reading on level meter.

IC41

SW Tracking Adjustment (GR8: Tourist only)

30% amplitude modulation by 400Hz signal

CV2 CV1

Set frequency Adjustment

part

7 MHz

17 MHz

CV1

• Repeat the procedures is each adjustment several times, and the frequency coverage and tracking adjustment should be finally done by the trimmer capacitors.

– 37 –

FM Polar Adjustment (RX90: EE, CIS only)

Procedure : 1. Set the modulation of FM RF SSG to AUDIO 1 kHz, 10 kHz deviation according to "Connection 1". 2. Tune the set to 69 MHZ. 3. Adjust the RV1702 so that the reading of frequency counter connected to TP1702 becomes within 31.25 kHz ± 0.05 kHz.(VCO adjustment) 4. Then record the reading of the level meter connected to TP1701 5. Set the modulation of FM RF SSG to AUDIO 31.25 kHz, 10 kHz deviation according to "Connection 2". 6. Tune the set to 69 MHz. 7. Set the CT1701 to be mechanical center. 8. Adjust the L1701 so that the reading of the level meter connected to TP1701 become maximum. Then adjust the CT1701 so that the reading of the level meter connected to TP1701 becomes maximum. (SUB CARRIER PEAK Adjustment) 9. Adjust the RV1701 so that the level at the moment becomes 14dB higher value than the level recorded in step 4. (SUB CARRIER LEVEL Adjustment)

Connection 1: FM RF SSG 75 Ω coaxial set

FM ANTENNA terminal (75 Ω)

Carrier frequency : 69 MHz Output level : 1mV (60dBµ) (at 75 Ω open) Modulation : AUDIO 1 kHZ, 10kHz deviation Connection 2: AF OSC FM RF SSG 75 Ω coaxial set Audio 31.25 kHz external modulation terminal

FM ANTENNA terminal (75 Ω)

Carrier frequency : 69 MHz Output level : 1mV (60 dBµ) (at 75 Ω open) Modulation : AUDIO 31.25 kHZ, 10 kHz deviation (EXTERNAL MODULATION) Adjustment Location : EE, CIS: [TCB BOARD] (Component Side) • Abbreviation EE: East European model RV41 AM tuned level Adjustment

RV41

TM1

IC41 FE1

RV42

RV42 FM tuned level Adjustment

RV1701, TP1701 Sub carrier level Adjustment

CT1701, L1701, TP1701 Sub carrier peak Adjustment

L1701

RV1701

LEVEL METER

CT1701

+ –

(FILTER) TP1701 FREQUENCY COUNTER IC1701

RV1702, TP1702 VCO Adjustment

TP1702 (VCO) RV1702

– 38 –

+ –

S Curve Check

CD SECTION Note: 1. CD Block is basically designed to operate without adjustment. Therefore, check each item in order given. 2. Use YEDS-18 disc (3-702-101-01) unless otherwise indicated. 3. Use an oscilloscope with more than 10M impedance. 4. Clean the object lens by an applicator with neutral detergent when the signal level is low than specified value with the following checks. 5. Adjust the focus bias adjustment when optical block is replaced. Focus Bias check oscilloscope (DC range)

oscilloscope BD board TP (FEO) TP (VC)

+ –

Procedure: 1. Connect oscilloscope to test point TP (FEO). 2. Connect between test point TP (FOK) and GND by lead wire. 3. Turn Power switch on. 4. Put disc (YEDS-18) in and turned Power switch on again and actuate the focus search. (actuate the focus search when disc table is moving in and out.) 5. Check the oscilloscope waveform (S-curve) is symmetrical between A and B. And confirm peak to peak level within 3±1 Vp-p.

BD board TP (RF) TP (VC)

S-curve waveform

+ –

symmetry

Procedure: 1. Connect oscilloscope to test point TP (RF). (GND terminal : VC) 2. Turned Power switch on. 3. Put disc (YEDS-18) in and playback. 4. Confirm that the shape “≈” can be clearly distinguished at the center of the waveform and check the RF signal level. • RF signal VOLT/DIV: 200 mV TIME/DIV: 500 ns

within 3 ± 1 Vp-p

6. After check, remove the lead wire connected in step 2. Note: • Try to measure several times to make sure than the ratio of A : B or B : A is more than 10 : 7. • Take sweep time as long as possible and light up the brightness to obtain best waveform. RF Level Check oscilloscope

level: 1.3 ± 0.3 Vp-p

BD board TP (RF) TP (VC)

+ –

Procedure: 1. Connect oscilloscope to test point TP (RF) on BD board. 2. Turned Power switch on. 3. Put disc (YEDS-18) in and playback. 4. Confirm that oscilloscope waveform is clear and check RF signal level is correct or not. Note: Clear RF signal waveform means that the shape “≈” can be clearly distinguished at the center of the waveform. • RF signal VOLT/DIV: 200 mV TIME/DIV: 500 ns

level: 1.3 ± 0.3 Vp-p

– 39 –

Adjustment Location:

E-F Balance (1 Track Jump) check (Without remote commander)

[BD BOARD] (Conductor Side) oscilloscope

BD board

VC + –

Procedure: 1. Connect oscilloscope to test point TP (TEO) on BD board. 2. Turned Power switch on. 3. Put disc (YEDS-18) in to play the number five track. 4. Press the “P (Pause)” button. (Becomes the 1 track jump mode) 5. Check the level B of the oscilloscope's waveform and the A (DC voltage) of the center of the Traverse waveform. Confirm the following:

FOK

CNU101

TP (TEO) TP (VC)

IC101

IC I02

TEO FEO

GND

IC103

A–B × 100 = ±7 (%) 2 (A + B)

GND

1 track jump waveform

Center of the waveform

CNU102

B A (DC voltage)

symmetry level : 500 mV ± 100 mVp-p

– 40 –

SECTION 6 DIAGRAMS • Circuit Boards Location TRANS board TCB board (GR8: Tourist/RX90) ENCAPSULATED COMPONENT (EXCEPT GR8: Tourist/RX90)

DECO board

CD SW board

PANEL board

HP/MIC board DJ board

MAIN board TC SW board

POWER AMP board

SENSOR board

MOTOR (TURN) board CONNECTOR board

MOTOR board BD board

MOTOR (SLIDE) board

AUDIO board LEAF SWITCH board

– 41 –

AIN2

PD2

PD1

AIN1

AOUT1

VDD

FMIN

AMIN

IO2

24 23 22

VSS

XOUT

AOUT2

• IC Block Diagrams IC21 LC72130 (TCB BOARD)

PHASE DETECTOR CHARGE PUMP UNLOCK DETECTOR

POWER ON RESET

1/2

SWALLOW COUNTER 1/16, 1/17 4BITS

REFERENCE DIVIDER

12BITS PROGRAMMABLE DRIVER

11 IO1

CE D1 CL D0

BO4

XIN

BO5

BO3

3 4 5 6

BO2

BO1

FM-AFC

AM-RF-IN

AGC

AM. CUT

AM/FM

VCO

MPX-IN

OUT R

OUT L

AMP-IN R

AMP-IN L

17 16

ALC

AM OSC

AM RF. AMP

AM MIX

DECODER ANTI BIRDIE

BUFF

STEREO SW

AGC STEREO DRIVE

S METER FM IF

FF VCO

AM/FM IF BUFF

AM/FM SW

2 3

AM-MIX IF

REG

AM-IF

GND

TU-LED

ST-LED

DET

VCC

IF-BUFF

VCC

FM-IN

GND

VCO-STOP

REG

PHASE DET

AM/FM

FM DET

MUTE

PILOT DET

COMP TUNING DRIVE AM

TRIG FF

AM. SD

FM IF

S-CURVE

AM DET

AM. SD

LEVEL DET

AM-OSC

LA1835 (TCB BOARD)

FM-SD

IC41

UNIVERSAL COUNTER

DATA SHIFT REGISTER LATCH

IFIN

C2B I/F

– 82 –

LPF2A

LPF2B

GND

DETIN

19 18

LPF1B

VCO

LPF1A

SUBOUT MON

IR3R42 (TCB BOARD)

SUBIN

IC1701

14 13

AMP 1/2

1/2

PHASE COMPARATOR

OSC

AMP

PHASE COMPARATOR 2

PHASE

TRIGGER WAVEFORM SEP.

6 7

10 LAMP

MUTE

VCO STOP

LHC

IC1702

RHC

SAMPLE & HOLD BUFFER

POUT

1 VCC

GATE

REGULATOR

ROUT LOUT

AMP

MC14053BCP (TCB BOARD)

16 VDD 15 B.COM OPEN

C.COM

14 A.COM 13 A1 OPEN

12 A0

INH

11 A

VEE

VSS

OPEN

10 B 9

– 83 –

RF_O

RF_I

CC1

CC2

FOK

RF_M

RFTC

PD1

CXA1992AR (BD BOARD) PD2

IC101

VEE

+ –

– +

PD1 IV AMP

– +

PD2 IV AMP

– +

RF SUMMING AMP – +

26 SENS2

+ –

FE_BIAS 40 VCC

+ –

– +

APC

– +

LASER POWER CONTROL F IV AMP

VCC VCC

FE AMP – +

– + – +

– +

TZC 49

20 CLK

19 LOCK

DFCTO

IFB1-6 BAL1-4 TOG1-4

DFCT

FS1-4

TG1-2

TM1-7

PS1-4 ISET

VCC VCC

VCC 16 SL_O

TRACKING PHASE COMPENSATION

TG1

TM4

– +

TM6

15 SL_M VCC VEE

FOCUS PHASE COMPENSATION

TM7

FS1

TM5

TM3

+ –

VEE DFCT

VEE

FS2

– +

Charge up

FZC COMP.

FSET TG2 + –

FS4

FLB

FE_O

13 TA_O

FGD

TA_M

FDFCT

FSET

TG2

TGU

SRCH

FE_M

2 FEI

VEE 1 FEO

FZC 52

17 ISET

TM1

TDFCT 50

VCC

18 VCC

VCC

– +

VC 51

21 XLT

IIL DATA REGISTER INPUT SHIFT REGISTER ADDRESS DECODER SENS SELECTOR OUTPUT DECODER

ATSC WINDOW COMP.

TZC COMP.

TTL ↓ IIL

CC1

MIRR

TGFL

IFB5

IFB6

IFB4

FOH FOL TGH TGL BALH BALL ATSC TZC FZC

TEI 47

ATSC 48

LPC

+ –

LDON

+ –

E-F BALANCE WINDOW COMP.

IIL ↓ TTL

MIRR

FOK

TRK. GAIN WINDOW COMP.

LPCL

TOG4

IFB3

IFB1 TGFL

BAL3

BAL4

BAL1

BAL2 TOG3

TOG2

TOG1

LPFI 46

VCC + –

+ –

23 XRST

VEE + –

– + + –

VEE LEVEL S

22 DATA

FO. BIAS WINDOW COMP.

+ –

TEO 45

DFCT

+ –

VEE

+ –

VEE

+ –

– +

IFB2

E IV AMP EI 43

24 C. OUT

DFCT1

VCC

– +

25 SENS1

– +

E 42

VEE 44

IIL ↓ TTL

VEE

F 41

– 84 –

14 SL_P TM2

GND

20 NC

OUT4B

OP IN (+)

OUT4A

OP IN (–)

OUT3B

OP OUT

OUT3A

IN3A

VCC

IN3B

IN4A

BA5941FP-E2 (BD BOARD)

IN4B

IC102

– + + –

+ –

LEVEL SHIFT

+ –

LEVEL SHIFT

+ –

LEVEL SHIFT + –

LEVEL SHIFT

+ –

14 OUT1B

– +

OUT1A

GND

+ –

OUT2B

– +

OUT2A

VCC

Vcc

IN2A

IN2B

MUTE

GND

4 IN1A

3 IN1B

LRCKI

PCMD

PCMDI

BCK

BCKI

VSS

VDD

GTOP

XUGF

XPCK

GFS

RFCK

C2PO

XROF

MNT3

MNT1

MNT0

XTSL

FSTT

C4M

DOUT

EMPH

EMPHI

WFCK

SCOR

SBSO

EXCK

VSS

SYSM

CXD2519Q (BD BOARD) VDD

VCC

IC103

2 BIAS IN

Vcc

+ –

Vcc

80 79 78 77 76 75 74 73 72 71 70 69 68 67 66 65 64 63 62 61 60 59 58 57 56 55 54 53 52 51

NC 81

50 LRCK

AVSS 82

49 WDCK

AVDD 83

48 ASYE

AOUT1 84

AVSS 87 XVDD 88 XTAI 89 XTAO 90

AVSS 92

– +

PWM

XVSS 91

– +

ASYMMETRY CORRECTOR

3RD-ORDER NOISE SHAPER

LOUT1 86

47 ASYO – +

– +

PWM

AIN1 85

45 BIAS 44 RF

ERROR CORRECTOR

43 AVDD

D/A INTERFACE

EFM DEMODURATOR

42 CLTV DIGITAL PLL

39 FILO

DIGITAL OUT

16K RAM

38 PCO

AIN2 94

OSC

AOUT2 95

AVSS 97

41 AVSS 40 FILI

LOUT2 93

AVDD 96

46 ASYI

37 VCTL 36 V16M

SERIAL-IN INTERFACE

35 VCKI

SUB CODE PROCESSOR

OVER SAMPLING DIGITAL FILTER

CLOCK GENERATOR

NC 98

34 VPCO1 33 VPCO2

TIMING LOGIC

NC 99

LOCK

PWMI

MDS

MDP

MON

VSS

VDD

FOK

XLON

DATA

SPOC

SENS

SPOD

SQSO

– 85 –

SPOB

SQCK

CLKO

10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30

SPOA

XLTO

CNIN

DATO

SEIN

XLAT

CLOK

CKOUT

31 TES0

TES2

VSS

32 TES1 DIGITAL CLV

LMUT

CPU INTERFACE

RMUT

VDD

XRST 100

SERVO AUTO SEQUENCER

OFFSET DET

OP2OUT

LPF2IN

LPF2OUT

VCC ON MUTE

F/F

OP2IN

OVER LOAD DET

M65850P (HP/MIC BOARD)

REF

IC751

CLOCK

µPC1237HA (MAIN BOARD)

VCC

IC281

OSCILLATOR

D/A

LPF2

1/2 VCC

LATCH/ AUTORESET

RESET

AC OFF DET

20KBIT SRAM

µPC1330HA (AUDIO BOARD)

7 GND

LPF1

CC2

CC1

OP1IN

OP1OUT

IC602

LPF1OUT

LPF1IN

MAIN CONTROL D1 DO0 A/D

VCC 1

DO1

CLOCK AUTO RESET

INVERTER

COMPARATER 1

SW R1 GND

SW P1 CONT

GND

VCC

SW P2 GND

9 SW R2

IC701 M54641L (MOTOR (TURN) BOARD)

IC801 BA6286N (MOTOR (SLIDE) BOARD)

VCC 1 OUT2 2

RIN 2

REG 8 VCC IN1 3

VREF 3 OUT2 4

INPUT AMP.

RNF 5

CONTROL

POWER AMP.

INPUT AMP.

GND 6

7 OUT1

OUT1 7 VM 8

POWER AMP. GND 4

POWER SAVE

GND 1

6 IN2 5 REFERENCE

VCC 9 FIN 10

– 86 –

TSD

CONTROL LOGIC

LA5617 (MAIN BOARD)

CURRENT LIMITER

ON/OFF

CURRENT LIMITER

VMUTE

VCC

VREF VCC ERROR AMP

START CIRCUIT

ON/OFF

_140uA ~ COMPARATER

IC901

VREF OVER HEAT PROTECT

VREF ~_1.8V

CN1

EN DISPLAY

GND

CN2

VEE

VO2

VO1

VCC

ERROR AMP

IC1502 LB1641(MAIN BOARD)

T.S.D

O.C.P MOTOR DRIVE

MOTOR DRIVE

IC401

CLAMP

FWD.IN

REV.IN

VCC 1

VCC 2

20 PGM

ADDRESS & COMMAND CONTROLLER

19 18 17 16

544KBIT ROM (EDITING ROM & ADDRESS ROM CONTAINS 22KBIT)

I3/PORT1 I2/PORT0 I1 I0

15 ST 14 CMD

CH 5 RESET 6 BUSY 7 NAR 8

MSM6653A-485RS (DJ BOARD)

VPP 1

I4 2 I5/SI 3 I6/SD 4

MOTOR DRIVE

NOISE FILTER

GND

MOTOR DRIVE

FWD/REV/STOP CONTROL LOGIC

I/O INTERFACE

ADPCM SYNTHESIZER

17BIT MULTIPLEXER

DATA CONTROLLER

17BIT ADDRESS COUNTER

PCM SYNTHESIZER 12 12BIT DAC AOUT 9 GND 10

LPF

MELODY GENERATOR BEEP TONE GENERATOR

OSC

13 XT 12 XT

TIMING CONTROLLER 11 VDD

– 87 –

6-15. IC PIN FUNCTION DESCRIPTION MAIN BOARD IC301 µPD780018YGF-011-3BA (MASTER CONTROL) Pin No.

Pin Name

I/O

TA-MUTE

Line mute signal output

Function

DBFB-H/L

DBFB H/L select signal output

427-LAT

Latch signal output for IC201 (M62427FP)

K-CON-LAT

K-CON-ON

F-RELAY

Main speaker relay control output

R-RELAY

Surround speaker relay control output

PL-RELAY

Surround speaker relay control output

TEST

Connected ground

VDD

–

XT2

XT1

Not used

X'tal (5MHz) Power supply (+5V) X'tal (32.768 kHz)

RESET

(INT/IN)

Reset signal input

(INT/IN/OUT)

SCOR

Subcode data request signal output

SOFT-TEST

Software test port

AC-CUT

Reset signal input

RDS-INT

Serial data transfer clock signal input (HCD-RX90: AEP, German, UK, Northern European models only)

RDS-DATA

Serial data input (HCD-RX90: AEP, German, UK, Northern European models only)

VDD

–

Power supply (+5V)

AVDD

Analog reference voltage input

ADJ

CD adjust point port

A-SHUT

A Deck reel pulse detector

B-SHUT

B Deck reel pulse detector

B-HALF

Half detector signal input

CLK-CHECK

Connected ground

SPEC-IN

Version select signal input

ADJ 2

Connected ground

DEMO-MODE

DEMO H/L select signal input

AVSS

–

Ground

SQ-DATA-IN

Subcode Q data clock input

—

–

Not used

SQ-CLK

Sub code Q data clock input

SW-ON/OFF

Not used

38, 39

FUNC 1, 2

Connected ground

VSS

–

Ground

VOL-LAT

PL-LAT

COM-DIN

Connected ground

Not used Connected ground

– 88 –

Pin No.

Pin Name

I/O

COM-DOUT

Common serial data output

Function

COM-CLK

Common serial clock output

CD-POWER

CD power on signal output

CD-DATA

CD data output

CD-CLK

CD clock output

MSM-CND

DJ effect command output

MSM-BUSY

Busy signal input

MSM-LAT

Serial latch pulse output

MSM-NAR

NAR signal input

MSM-CH

CH select output

INPUT-CHANGE

GAIN control output

1IC-DATA

Data output for IC601

1IC-CLK

Clock output for IC601

XRST

CD reset signal output

XLT

CD latch signal output

FOUCUS-SW

Focus switching signal output

TBL-L

TBL-R

TRAY-LED

LOAD-OUT

LOAD-IN

ST-CLK

Table motor control output CD tray LED ON/OFF output Loading motor control signal output Tuner clock output

ST-DIN

Tuner data input

ST-DOUT

Tuner data output

ST-CE

Tuner chip enable output

TUNED

Tuned detection for tuner

STEREO

Stereo detection for tuner

VSS

–

Ground

ST-MUTE

Tuner mute signal output

SENS2

SENS

DISC-SENS

Not used

T-SENS

CD table detection signal input

UPSW

Up SW (S201) signal input (Not used)

ENC 3

ENC 2

ENC 1

OUT-OPEN

Out switch signal input

CAP-H/N

Capstan motor H/N speed select signal output

BD Condition signal input

Disctray address detect encoder input

B-TRG

Trigger motor control output

A-TRG

Trigger motor control output

TRG-LOW

Trigger motor control output

CAP-M-ON/OFF

Capstan motor ON/OFF signal output

– 89 –

Pin No.

Pin Name

I/O

PB-A/B

PB Deck A/Deck B select output

Function

EQ-H/N

Equalizer H/N select output

BIAS

Bias ON/OFF signal output

REC-MUTE

REC mute ON/OFF selection output

NR-ON/OFF

NR ON/OFF signal output

R/P-PASS

REC/PB/PASS selection output

TC-MUTE

TC mute ON/OFF selection output

A-PLAY-SW

Deck A play detect

B-PLAY-SW

Deck B play detect

RELAY

REC/PB head selection output for IC602

A-HALF

Deck A cassette detect

POWER

POWER ON/OFF signal output

SW-F-CON

Super woofer mode signal output (Not used)

100

STK-MUTE

Power amp ON/OFF signal output

– 90 –

PANEL BOARD IC601 TMP87CH75F-6543 (GRAPHIC CONTROL) Pin No.

Pin Name

I/O

SEG-35

Fluorescent display tube segment signal output

Function

V-LOAD

–

–30V for Fluorescent display tube

3-10

LED1-LED8

LED driver output

VSS

–

Ground

X-OUT

X'tal (8MHz)

X-IN

X'tal (8MHz)

RESET

15, 16 LED9, LED10

Reset signal input from master control

LED driver output

TEST

Connected ground

18-23

LED11-LED16

LED driver output

VOL-A

Rotaly encoder pulse input

LED 17

Not used

JOG-A

Rotaly encoder pulse input

CLOCK

Serial clock input from master control

DATA

Serial data input from master control

LED SELECT

LED select signal output

VDD

–

Power supply (+5V)

VSS

–

Ground

MODEL

Connected ground

33-37

KEY1-KEY5

Key input

EWS STANDBY

–

Not used

SIRCS

Remote commander signal input

VOL-B

Rotaly encoder pulse input

JOG-B

Rotaly encoder pulse input

42-45

SPEANA 1-4

Spectrum analyzer signal input

L+R

Spectrum analyzer (high frequency) input

EWS SIGNAL /LED 18

Not used

VASS

–

Ground

VAREF

Analog reference voltage input

VDD

–

Power supply (+5V)

51-66

GR1-GR16

Fluorescent display tube gride signal output

Fluorescent display tube segment signal output

67-100 SEG1-SEG34

– 91 –

Ver 1.1

SECTION 7 EXPLODED VIEWS

NOTE: • -XX and -X mean standardized parts, so they may have some difference from the original one. • Color Indication of Appearrance Parts Example: KNOB, BALANCE (WHITE) . . . (RED) ↑ ↑ Parts Color Cabinet's Color • Abbreviation AED : Northern European model AUS : Australian EA3 : Saudi Arabia EA4 : Israeli EE : East European

• Items marked “*” are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. • The mechanical parts with no reference number in the exploded views are not supplied. • Hardware (# mark) list and accessories are given in the last of the electrical parts list.

E2 E3 G HK IA

: 120V AC Area in E model : 240V AC Area in E model : German : Hong Kong : Indonesia

JE MX MY SAF SP

The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified.

TH TW

: Tourist : Mexican : Malaysia : South African : Singapore

: Thailand : Taiwan

(1) CASE, MD ASS'Y SECTION

13 11 12

5 8 9 #2

10 14 #1

15 17 #1

4 3

TCM-220WR2

18 1

– 92 –

Ver 1.1

Ref. No. 1 2 2 3 3

4 5 5 5 5

5 8 8 8

Part No.

Description

Remark

4-989-904-11 SPRING (B DECK) X-4947-923-1 LID (B) ASSY, CASSETTE (BLACK) (GR8: E2, MX/RX90: AEP, AED, G, UK) X-4948-119-1 LID (B) ASSY, CASSETTE (METALLIC) (EXCEPT GR8: E2, MX/RX90: AEP, AED, G, UK) X-4947-922-1 LID (A) ASSY, CASSETTE (BLACK) (GR8: E2, MX/RX90: AEP, AED, G, UK) X-4948-118-1 LID (A) ASSY, CASSETTE (METALLIC) (EXCEPT GR8: E2, MX/RX90: AEP, AED, G, UK) 4-989-903-11 SPRING (A DECK) 4-986-858-41 PANEL, LOADING (METALLIC) (GR8: EA3, MY) 4-988-078-01 PANEL, LOADING (BLACK) (RX90: AEP, AED, G, UK) 4-988-078-11 PANEL, LOADING (BLACK) (GR8: E2, MX) 4-988-078-41 PANEL, LOADING (METALLIC) (GR8: E3, EA4, HK, IA, SAF, TH, TW, AUS, JE) 4-911-701-31 PANEL, LOADING (METALLIC) (RX90: EE, CIS) 4-986-843-11 BUTTON (EJECT) (BLACK) (GR8: E2, MX/RX90: AEP, AED, G, UK) 4-986-843-21 BUTTON (EJECT) (METALLIC) (GR8: EA3,EA4, MY, SAF, TH) 4-986-843-31 BUTTON (EJECT) (METALLIC) (GR8: E3, HK, IA, SP, TW, AUS, JE/RX90: EE, CIS)

Ref. No. 9 9 10 11 12 * 13 * 13 * 13 14 15 16 16 17 * 18 * 19

– 93 –

Part No.

Description

Remark

4-990-129-01 SPRING (OPEN A) (GR8: EA3, EA4, MY, SAF, TH) 4-990-129-11 SPRING (OPEN A) (EXCEPT GR8: EA3, EA4, MY, SAF, TH) 4-951-620-01 SCREW (2.6X8), +BVTP 3-363-099-01 SCREW (CASE 3 TP2) (3X8) 3-363-099-41 SCREW (CASE 3 TP2) (3X10) 4-986-851-31 CASE (BLACK) (GR8: E2, MX/RX90: AEP, AED, G, UK) 4-988-767-11 CASE (METALLIC) (GR8: EA3, EA4, MY, SAF, TH) 4-988-767-51 CASE (METALLIC) (GR8: E3, HK, IA, SP, TW, AUS, JE/RX90: EE, CIS) 1-773-160-11 WIRE (FLAT TYPE) (21 CORE) 1-769-947-11 WIRE (FLAT TYPE) (11 CORE) 4-990-130-01 SPRING (OPEN B) (GR8: EA3, EA4, MY, SAF, TH) 4-990-130-11 SPRING (OPEN B) (EXCEPT GR8: EA3, EA4, MY, SAF, TH) 3-354-957-01 JOINT (LOCK LEVER) 3-354-954-01 LEVER (LOCK LEVER R) 3-354-953-01 LEVER (LOCK LEVER L)

Ver 1.1

(2) FRONT PANEL SECTION

60 59 58

64 63 57

GR8: EA3

not supplied

73 72

70 74

84 57

57 83

54 not supplied

not supplied

77 78

80 supplied with S602

– 94 –

Ver 1.1

Ref. No. 51 51 51 52 52 52 54 54 55 55

55 * 56 57 58 58

* 59 * 59 * 60 61 61

62 62 63 64 65

Part No.

Description

Remark

4-986-877-11 KNOB (VOL) (BLACK) (GR8: E2, MX/RX90: AEP, AED, G, UK) 4-986-877-21 KNOB (VOL) (METALLIC) (GR8: EA3, EA4, MY, SAF, TH) 4-986-877-31 KNOB (VOL) (METALLIC) (GR8: E3, HK, IA, SP, TW, AUS, JE/RX90: EE, CIS) 4-986-869-21 WINDOW (STR) (GR8: E2, MX) 4-986-869-31 WINDOW (STR) (RX90: AEP, AED, G, UK) 4-986-869-71 WINDOW (STR) (EXCEPT GR8: E2, MX/RX90: AEP, AED, G, UK) 4-986-889-01 BUTTON (PAD) (BLACK) (GR8: E2, MX/RX90: AEP, AED, G, UK) 4-986-889-11 BUTTON (PAD) (METALLIC) (EXCEPT GR8: E2, MX/RX90: AEP, AED, G, UK) 4-986-893-11 KNOB (MICROPHONE) (BLACK) (GR8: E2, MX/RX90: AEP, AED, G, UK) 4-986-893-21 KNOB (MICROPHONE) (METALLIC) (GR8: EA3, EA4, MY, SAF, TH) 4-986-893-31 KNOB (MICROPHONE) (METALLIC) (GR8: E3, HK, IA, SP, TW, AUS, JE/RX90: EE, CIS) 1-664-025-11 HP/ MIC BOARD 4-951-620-01 SCREW (2.6X8), +BVTP 4-986-863-01 INDICATOR (CD) (GR8: EA3, EA4, MY, SAF, TH) 4-986-863-11 INDICATOR (CD) (EXCEPT GR8: EA3, EA4, MY, SAF, TH) 4-986-865-01 HOLDER (LED) (GR8: EA3, EA4, MY, SAF, TH) 4-986-865-11 HOLDER (LED) (EXCEPT GR8: EA3, EA4, MY, SAF, TH) 1-664-028-11 DECO BOARD 4-986-860-11 BUTTON (POWER) (BLACK) (GR8: E2, MX/RX90: AEP, AED, G, UK) 4-986-860-31 BUTTON (POWER) (METALLIC) (EXCEPT GR8: E2, MX/RX90: AEP, AED, G, UK) 4-986-901-11 BUTTON (A DECK) (BLACK) (GR8: E2, MX/RX90: AEP, AED, G, UK) 4-986-901-31 BUTTON (A DECK) (METALLIC) (EXCEPT GR8: E2, MX/RX90: AEP, AED, G, UK) 4-986-862-11 BUTTON (CD) 1-777-869-11 WIRE (FLAT TYPE) (10 CORE) 1-777-936-11 WIRE (FLAT TYPE) (5 CORE)

Ref. No. * * * *

68 69 70 70 71 71 72 72 73 73

74 75 75 76 76 76 76 77 78 78 78 79 80 81 82

* 68 * 68

* 68

1-773-051-11 WIRE (FLAT TYPE) (17 CORE) 1-664-023-11 CD SW BOARD A-4392-381-A PANEL BOARD, COMPLETE (RX90: AEP, AED, G, UK) A-4392-382-A PANEL BOARD, COMPLETE (RX90: EE, CIS) A-4392-383-A PANEL BOARD, COMPLETE (GR8: E2, E3, HK, IA, MX, SP, TW, AUS, JE)

Description

Remark

A-4398-184-A 1-664-024-11 4-986-880-01 4-986-880-11

PANEL BOARD, COMPLETE (GR8: EA3, MY) TC SW BOARD HOLDER (JOG) (GR8: EA3, EA4, MY, SAF, TH) HOLDER (JOG) (EXCEPT GR8: EA3, EA4, MY, SAF, TH) 4-986-881-01 JOG (PLATE) (GR8: EA3, EA4, MY, SAF, TH)

4-986-881-11 JOG (PLATE) (EXCEPT GR8: EA3, EA4, MY, SAF, TH) X-4947-918-1 KNOB (JOG) ASSY (BLACK) (GR8: E2, MX/RX90: AEP, AED, G, UK) X-4948-113-1 KNOB (JOG) ASSY (METALLIC) (EXCEPT GR8: E2, MX/RX90: AEP, AED, G, UK) 4-986-861-11 BUTTON (PLAY) (GR8: E2, MX/RX90: AEP, AED, G, UK) 4-986-861-31 BUTTON (PLAY) (METALLIC) (EXCEPT GR8: E2, MX/RX90: AEP, AED, G, UK) 1-769-909-11 WIRE (FLAT TYPE) (9 CORE) 4-986-902-11 BUTTON (B DECK) (BLACK) (GR8: E2, MX/RX90: AEP, AED, G, UK) 4-986-902-31 BUTTON (B DECK) (METALLIC) (EXCEPT GR8: E2, MX/RX90: AEP, AED, G, UK) X-4947-915-1 PANEL ASSY, FRONT (RX90: AEP, AED, G, UK) X-4947-916-1 PANEL ASSY, FRONT (GR8: E2, MX) X-4948-105-1 PANEL ASSY, FRONT (GR8: EXCEPT E2, EA3, MX/RX90: EE) X-4948-121-1 PANEL ASSY, FRONT (GR8: EA3) 4-930-336-61 FOOT (FELT) X-4947-921-1 BUTTON (F/T) ASSY (BLACK) (RX90: AEP, AED, G, UK) X-4947-941-1 BUTTON (F/T) ASSY (BLACK) (GR8: E2, MX) X-4948-109-1 BUTTON (F/T) ASSY (METALLIC) (EXCEPT GR8: E2, MX/RX90: AEP, AED, G, UK) 4-986-883-11 INDICATOR (JOG) 4-986-882-01 BUTTON (S/F) 4-986-897-01 BUTTON (BPM) X-4947-920-1 BUTTON (TIMER) ASSY (BLACK) (GR8: E2, MX/RX90: AEP, AED, G, UK)

84 85

X-4948-115-1 BUTTON (TIMER) ASSY (METALLIC) (EXCEPT GR8: E2, MX/RX90: AEP, AED, G, UK) X-4947-919-1 BUTTON (E/N) ASSY (BLACK) (GR8: E2, MX/RX90: AEP, AED, G, UK) X-4948-120-1 BUTTON (E/N) ASSY (METALLIC) (EXCEPT GR8: E2, MX/RX90: AEP, AED, G, UK) 4-984-085-01 SPRING (ENTER), COMPRESSION 4-962-708-21 EMBLEM (4-A), SONY

4-986-859-11 WINDOW (CD)

83 66 * 67 * 68

Part No.

A-4392-825-A PANEL BOARD, COMPLETE (GR8: EA4, TH, SAF)

– 95 –

(3) CHASSIS SECTION

115

113

CDM38L-5BD29AL

104

E3, IA, JE E, IA, MX, JE

105

118

#4 GR8: HK, AUS RX90: UK

#13 #4

not supplied

117 EA3, SP, TW

112

116

AEP, AED, EE, CIS, G, EA3, EA4, HK, MY, SAF, SP, TW

119 102

#4 AUS

#4 T901

120

#4 M901 UK

106 107

101

121 108

122

109 not supplied

110

– 96 –

111

Ref. No.

Part No.

* 101

A-4392-375-A POWER AMP BOARD, COMPLETE (RX90: AEP, AED, EE, CIS, G, UK) A-4392-376-A POWER AMP BOARD, COMPLETE (GR8: E, HK, IA, MX, SP, TW, AUS, JE) A-4392-823-A POWER AMP BOARD, COMPLETE (GR8: EA4, SAF, TH) A-4398-182-A POWER AMP BOARD, COMPLETE (GR8: EA3, MY)

* 101 * 101 * 101

Description

Remark

* 102 104 * 105 * 105

1-664-026-11 1-777-870-11 4-986-845-11 4-986-845-21

TRANS BOARD WIRE (FLAT TYPE) (19 CORE) PANEL, BACK (GR8: EA3) PANEL, BACK (GR8: MY)

* * * * *

105 105 105 105 105

4-986-982-01 4-986-982-11 4-988-021-01 4-988-021-11 4-988-021-21

PANEL, BACK (RX90: AEP, AED, G, UK) PANEL, BACK (RX90: EE, CIS) PANEL, BACK (GR8: E3, IA) PANEL, BACK (GR8: E2) PANEL, BACK (GR8: SP)

* * * * *

105 105 105 105 105

4-988-021-31 4-988-021-41 4-988-021-51 4-988-021-61 4-988-021-71

PANEL, BACK (GR8: TW, JE) PANEL, BACK (GR8: HK) PANEL, BACK (GR8: AUS) PANEL, BACK (GR8: MX) PANEL, BACK (GR8: EA4, SAF, HK)

106

1-233-545-11 ENCAPSULATED COMPONENT (GR8: E2, EA4, MX, TH, AUS) 1-233-546-11 ENCAPSULATED COMPONENT (GR8: E3, EA3, HK, IA, MY, SAF, SP, TW) A-4303-508-A TCB BOARD, COMPLETE (GR8: JE) A-4303-570-A TCB BOARD, COMPLETE (RX90: EE, CIS) A-4303-571-A TCB BOARD, COMPLETE (RX90: AEP, AED, G, UK)

106 106 106 106

* 107 107 107 108

Ref. No. 108 * 109 * 109 110 * 111

* 111 * 111

3-703-244-00 BUSHING (2104), CORD (GR8: EA3, EA4, HK, MY, SAF, SP, TW/RX90) 3-703-571-11 BUSHING (S) (4516), CORD (GR8: TH) 4-966-266-01 BUSHING (S) (FBS002), CORD (GR8: E, IA, MX, JE) 1-751-086-11 WIRE (FLAT TYPE) (13 CORE) (GR8: E, MX, TH, AUS)

Part No.

Description

Remark

1-773-012-11 WIRE (FLAT TYPE) (15 CORE) (GR8: E3, EA3, HK, IA, MY, SAF, SP, TW, JE/RX90) 4-988-533-01 HOLDER, PCB (GR8: EA3, EA4, MY, SAF, TH) 4-988-533-11 HOLDER, PCB (EXCEPT GR8: EA3, EA4, MY, SAF, TH) 4-965-822-01 FOOT A-4392-358-A MAIN BOARD, COMPLETE (RX90: AEP, AED, G, UK)

* 111 * 111 * 111

A-4392-359-A MAIN BOARD, COMPLETE (RX90: EE, CIS) A-4392-360-A MAIN BOARD, COMPLETE (GR8: E3, HK, IA, SP, TW) A-4392-361-A MAIN BOARD, COMPLETE (GR8: E2, MX) A-4392-362-A MAIN BOARD, COMPLETE (GR8: AUS) A-4392-491-A MAIN BOARD, COMPLETE (GR8: JE)

* 111 * 111 * 111 112 ! 113

A-4392-820-A A-4392-834-A A-4398-179-A 4-956-370-12 1-751-326-31

! 115 ! 116 ! 117 ! 118

1-777-462-11 1-569-007-11 1-569-008-11 1-575-651-11

MAIN BOARD, COMPLETE (GR8: EA4, TH) MAIN BOARD, COMPLETE (GR8: SAF) MAIN BOARD, COMPLETE (GR8: EA3, MY) BAND, PLUG FIXED (GR8: HK, AUS/RX90: UK) CORD, POWER (TH)

! 119

CORD, POWER (E, IA, MX, JE) ADAPTOR, CONVERSION 2P (E3, IA, JE) ADAPTOR, CONVERSION 2P (EA3, SP, TW) CORD, POWER (AEP, AED, EE, CIS, G, EA3, EA4, HK, MY, SAF, SP, TW) 1-690-608-11 CORD, POWER (AUS)

! 120 ! 121 * 122 M901 ! T901

1-696-570-21 1-770-019-11 1-664-088-11 1-698-792-11 1-429-994-11

! T901

1-429-995-11 TRANSFORMER, POWER (GR8: E, EA4, HK, IA, MX, SAF, SP, TH, TW, AUS, JE) 1-429-995-21 TRANSFORMER, POWER (GR8: EA3, MY)

! T901

CORD, POWER (UK) ADAPTOR, CONVERSION PLUG 3P (HK) DJ BOARD FAN, DC TRANSFORMER, POWER (RX90: AEP, AED, EE, CIS, G, UK)

The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified.

– 97 –

(4) CD MECHANISM DECK SECTION-1 (CDM38L-5BD29AL)

201

202

206

201

M701

203

204 #5

205 212

208 211 210

207 209

Ref. No. 201 202 203 204 205 * 206 207

Part No.

Description

4-917-583-21 4-977-945-01 X-4946-665-1 4-977-943-01 4-977-956-01

BRACKET, YOKE TRAY (TURN) SHAFT ASSY, WORM BELT (TURN) (1.2) WHEEL, WORM

1-658-577-11 MOTOR (TURN) BOARD X-4924-457-1 ROLLER ASSY

Remark

Ref. No.

Part No.

Description

208 * 209 210 211 212

4-977-941-01 1-658-576-11 4-934-376-01 4-977-944-01 4-981-187-01

BEARING (WORM) SENSOR BOARD SHAFT (ROLLER) TRAY (SLIDE) COLLER (WORM)

M701

– 98 –

A-4672-004-A MOTOR ASSY (TURN)

Remark

(5) CD MECHANISM DECK SECTION-2 (CDM38L-5BD29AL)

251 252

253

251

255 254 257 256 258

260

259 266

267 269

268

261

M801

262

261 BU-5BD29AL S811

263 #4

263 264 265 251 Ref. No.

Part No.

Description

251 252 253 254 255

4-917-583-71 4-977-954-01 4-977-953-01 4-977-955-01 4-977-942-01

BRACKET, YOKE PULLEY (SL) GEAR (SL-A) GEAR (SL-B) BELT (SL) (1.4)

256 257 258 * 259 * 260

X-4946-667-1 1-452-538-11 1-776-042-11 1-658-575-11 X-4946-668-1

CAM ASSY, BU MAGNET WIRE (FLAT TYPE) (8 CORE) CONNECTOR BOARD CHASSIS (CDM) ASSY

261 * 262 263

4-985-672-01 SCREW (+PTPWHM2.6), FLOATING 1-658-578-11 MOTOR (SLIDE) BOARD 4-982-447-01 SPRING (BU), COMPRESSION

Remark

Ref. No.

Part No.

Description

264 * 265 266 267 267

4-951-620-41 X-4946-666-1 4-989-494-01 4-989-492-11 4-989-492-21

SCREW (2.6), +BVTP HOLDER (BU) ASSY SCREW (SLIDER), STEP SLIDER (38) (GR8: EA3, EA4, MY, SAF, TH) SLIDER (38) (EXCEPT GR8: EA3, EA4, MY, SAF, TH)

268 269 269 M801 S811

– 99 –

Remark

4-989-819-02 SPRING, TENSION 4-989-491-11 COVER, LENS (GR8: EA3, EA4, MY, SAF, TH) 4-989-491-21 COVER, LENS (EXCEPT GR8: EA3, EA4, MY, SAF, TH) A-4672-004-A MOTOR ASSY (SLED) 1-473-335-11 ENCODER, ROTARY (BU, TRAY ADDRESS DET)

(6) BASE UNIT SECTION (BU-5BD29AL) 301

302

303

305

304

M101 M102

304 306

307

The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified.

308

Ref. No.

Part No.

Description

! 301 302 303 304 304

8-820-020-01 1-769-069-11 4-917-567-21 4-951-940-01 4-951-940-31

OPTICAL PICK-UP KSS-213D/Q-NP WIRE (FLAT TYPE) (16 CORE) GEAR (M) INSULATOR (BU) (EXCEPT GR8: EA3, MY) INSULATOR (BU) (GR8: EA3, MY/RX90: AEPM)

305

Remark

Ref. No.

Part No.

306 * 307

4-917-564-01 GEAR (P), FLATNESS A-4699-522-A BD BOARD, COMPLETE

308 M101 M102

4-917-565-01 SHAFT, SLED

– 100 –

Description

4-951-620-01 SCREW (2.6X8), +BVTP X-4917-523-4 MOTOR ASSY SPINDLE X-4917-504-1 MOTOR ASSY SLED

Remark

(7) TAPE MECHANISM DECK SECTION-1 (TCM-220WR2) #8

372

371

(including r C) rA

374

364

HP101 (including r A)

365

373

not supplied

370

366

362 357

371 364

363 361

359

365

358

356

not supplied HRPE101 (including r B)

351

366

371

362

368 357

353 356

352

369

not supplied

360

355 354

370

367

374 #9

363 361

359

#7 not supplied

355

not supplied

358 360

354

353 not supplied

352

not supplied

351 Ref. No.

Ref. No.

Part No.

Description

SPRING, AZIMUTH ADJUSTMENT SCREW, AZIMUTH ADJUSTMENT SLIDER (HEAD) ASSY SPRING, HEAD TOGGLE FITTING BLOCK, HEAD

365 366 367 368 * 369

3-917-141-01 X-3371-305-1 3-669-465-01 X-3370-173-1 4-980-439-01

SPRING, COMPRESSION REEL (T) ASSY WASHER (1.5), STOPPER TU ASSY FULCRUM, HOLDER

3-908-557-02 3-908-559-01 3-908-555-01 3-917-143-11 3-388-848-01

ROTARY BLOCK, HEAD STOPPER, AZIMUTH SLIDER (REV SLIDER) SPRING, TENSION SCREW (P2X6) (B TIGHT)

370 371 * 372 373 374

3-917-142-01 3-939-862-01 A-2007-131-A 3-930-972-01 3-354-963-01

SPRING, COMPRESSION CLIP AUDIO BOARD, COMPLETE DETENT, HALF DAMPER

3-939-371-01 X-3369-909-1 X-3369-908-1 3-908-613-01

SPRING (1), TENSION PINCH LEVER (REV) ASSY PINCH LEVER (FWD) ASSY GEAR (S), REEL

Part No.

Description

351 352 353 354 355

3-908-560-01 3-919-684-01 X-3373-113-1 3-908-556-01 3-908-558-02

356 * 357 358 359 360 361 362 363 364

Remark

HP101 1-500-093-11 HEAD, MAGNETIC (PLAYBACK) (DECK A) HRPE1011-500-094-11 HEAD, MAGNETIC (REC/PB/ERASE) (DECK B)

– 101 –

(8) TAPE MECHANISM DECK SECTION-2 (TCM-220WR2) r C: MOTOR board

M2 rC

418 419 #11 #12

421

410

417

420

#11

421 402

411 A

416

409

422

410

413

415 407 406

408

419

405 412 424

407

423 414

413

404

not supplied

403 #10

402

401

Ref. No.

Part No.

Description

401 402 403 404 405

3-908-597-01 3-908-608-11 X-3372-930-1 X-3370-169-1 3-928-047-01

CAM (A) SCREW, STEP ARM (A) ASSY, FR FLYWHEEL (AR) ASSY PULLEY, TENSION

406 407 408 409 410

3-908-599-01 3-908-601-01 3-908-603-01 X-3367-593-1 3-908-605-01

LEVER (REV-A) SPRING (REV LEVER), TORSION LEVER (TRIGGER A) FLYWHEEL (BF) ASSY SPRING (TRIGGER), TORSION

411 412 413

3-908-609-01 GEAR, TRIGGER 3-913-845-11 BELT (A) 3-913-846-11 BELT (FR)

#10 Remark

Ref. No.

Part No.

Description

414 415 * 416 417 418

X-3370-171-1 3-908-600-01 1-650-669-11 3-908-598-01 X-3372-931-1

FLYWHEEL (BR) ASSY LEVER (REV-B) LEAF SWITCH BOARD CAM (B) ARM (B) ASSY, FR

419 420 421 422 423

3-914-111-01 3-908-604-01 3-911-115-01 X-3371-441-1 3-917-176-11

SPRING (FR), TORSION LEVER (TRIGGER B) WASHER, STOPPER CHASSIS ASSY, MECHANICAL BELT (B)

424 M1 M2

X-3370-172-1 FLYWHEEL (AF) ASSY X-3371-223-1 MOTOR ASSY CAPSTAN A-2004-410-A MOTOR ASSY, DC (TRIGGER)

– 102 –

Remark

SECTION 8 ELECTRICAL PARTS LIST NOTE: • Due to standardization, replacements in the parts list may be different from the parts specified in the diagrams or the components used on the set.

AUDIO

• Items marked “*” are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items.

The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified.

• SEMICONDUCTORS In each case, u: µ, for example: uA. . : µA. . uPA. . : µPA. . uPB. . : µPB. . uPC. . : µPC. . uPD. . : µPD. .

• -XX and -X mean standardized parts, so they may have some difference from the original one. • RESISTORS All resistors are in ohms. METAL: Metal-film resistor. METAL OXIDE: Metal oxide-film resistor. F: nonflammable

When indicating parts by reference number, please include the board.

• CAPACITORS uF: µF • COILS uH: µH

• Abbreviation AED : Northern European model AUS : Australian E2 : 120V AC Area in E model E3 : 240V AC Area in E model EA3 : Saudi Arabia EA4 : Israeli

EE G HK IA JE MX

Ref. No.

Part No.

A-2007-131-A AUDIO BOARD, COMPLETE **********************

: East European : German : Hong Kong : Indonesia : Tourist : Mexican

Description

Remark

< CAPACITOR > C301 C302 C303 C304 C305

1-162-289-31 1-126-968-11 1-162-282-31 1-130-483-00 1-107-715-11

CERAMIC ELECT CERAMIC MYLAR ELECT

390PF 100uF 100PF 0.01uF 22uF

10% 20% 10% 5% 20%

50V 6.3V 50V 50V 16V

C311 C313 C314 C315 C331

1-162-289-31 1-162-282-31 1-130-487-00 1-126-233-11 1-137-427-11

CERAMIC CERAMIC MYLAR ELECT FILM

390PF 100PF 0.022uF 22uF 120PF

10% 10% 5% 20% 5%

50V 50V 50V 50V 50V

C332 C333 C401 C402 C403

1-162-288-31 1-162-209-31 1-162-289-31 1-126-968-11 1-162-282-31

CERAMIC CERAMIC CERAMIC ELECT CERAMIC

330PF 27PF 390PF 100uF 100PF

10% 5% 10% 20% 10%

50V 50V 50V 6.3V 50V

C404 C405 C411 C413 C414

1-130-483-00 1-107-715-11 1-162-289-31 1-162-282-31 1-130-487-00

MYLAR ELECT CERAMIC CERAMIC MYLAR

0.01uF 22uF 390PF 100PF 0.022uF

5% 20% 10% 10% 5%

50V 16V 50V 50V 50V

C415 C431 C432 C433 C601

1-126-233-11 1-137-427-11 1-162-288-31 1-162-209-31 1-104-396-11

ELECT FILM CERAMIC CERAMIC ELECT

22uF 120PF 330PF 27PF 10uF

20% 5% 10% 5% 20%

50V 50V 50V 50V 16V

C602 C611 C612 C621 C622

1-104-396-11 1-124-907-11 1-124-907-11 1-137-150-11 1-126-961-11

ELECT ELECT ELECT FILM ELECT

10uF 10uF 10uF 0.01uF 2.2uF

20% 20% 20% 5% 20%

16V 50V 50V 100V 50V

MY SAF SP TH TW Ref. No. C623 C624 C625 C627 C628 C642

: Malaysia : South African : Singapore : Thailand : Taiwan

Part No.

Description

1-136-155-00 1-130-481-00 1-130-481-00 1-124-903-11 1-136-153-00 1-104-664-11

FILM MYLAR MYLAR ELECT FILM ELECT

Remark 0.015uF 5% 0.0068uF 5% 0.0068uF 5% 1uF 20% 0.01uF 5% 47uF 20%

50V 50V 50V 50V 50V 16V

< CONNECTOR > CN601 CN602 * CN651

1-695-382-31 PIN, CONNECTOR (PC BOARD) 21P 1-564-718-11 PIN, CONNECTOR (SMALL TYPE) 2P 1-564-521-11 PLUG, CONNECTOR 6P < IC >

IC601 IC602 IC611

8-759-111-44 IC uPC4570C-1 8-759-143-54 IC uPC1330HA 8-759-111-44 IC uPC4570C-1 < COIL >

L331 L431

1-410-780-11 INDUCTOR 1-410-780-11 INDUCTOR

27mH 27mH

< TRANSISTOR > Q621 Q622 Q623 Q651

8-729-142-46 8-729-142-46 8-729-801-93 8-729-900-65

TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR

2SC2001-LK 2SC2001-LK 2SD1387 DTA144ES

< RESISTOR > R301 R302 R303 R304 R305

1-247-881-00 1-249-409-11 1-249-433-11 1-247-889-00 1-247-858-11

CARBON CARBON CARBON CARBON CARBON

120K 220 22K 270K 13K

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/4W

R311 R312

1-247-881-00 CARBON 1-247-807-31 CARBON

120K 100

5% 5%

1/4W 1/4W

– 103 –

AUDIO Ref. No.

Part No.

Description

Remark

R314 R315 R331

1-247-882-11 CARBON 1-247-850-11 CARBON 1-249-430-11 CARBON

130K 6.2K 12K

5% 5% 5%

1/4W 1/4W 1/4W

R401 R402 R403 R404 R405

1-247-881-00 1-249-409-11 1-249-433-11 1-247-889-00 1-247-858-11

CARBON CARBON CARBON CARBON CARBON

120K 220 22K 270K 13K

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/4W

R411 R412 R414 R415 R431

1-247-881-00 1-247-807-31 1-247-882-11 1-247-850-11 1-249-430-11

CARBON CARBON CARBON CARBON CARBON

120K 100 130K 6.2K 12K

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/4W

R601 R602 R608 R609 R611

1-249-409-11 1-249-409-11 1-249-409-11 1-249-433-11 1-249-409-11

CARBON CARBON CARBON CARBON CARBON

220 220 220 22K 220

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/4W

R612 ! R621 ! R622 R623 R624

1-249-409-11 1-212-851-00 1-212-851-00 1-249-432-11 1-249-432-11

CARBON FUSIBLE FUSIBLE CARBON CARBON

220 5.6 5.6 18K 18K

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/4W

R625 R651 R652 R653

1-249-429-11 1-247-856-00 1-247-856-00 1-249-441-11

CARBON CARBON CARBON CARBON

10K 11K 11K 100K

5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W

F F

< VARIABLE RESISTOR > RV301 RV311 RV341 RV401 RV411

1-238-598-11 1-238-598-11 1-238-551-11 1-238-598-11 1-238-598-11

RES, ADJ, CARBON 2.2K RES, ADJ, CARBON 2.2K RES, ADJ, CARBON 220K RES, ADJ, CARBON 2.2K RES, ADJ, CARBON 2.2K

RV441 RV651 RV652

1-238-551-11 RES, ADJ, CARBON 220K 1-238-599-11 RES, ADJ, CARBON 4.7K 1-238-599-11 RES, ADJ, CARBON 4.7K < TRANSFORMER >

T621 1-423-980-11 TRANSFORMER, BIAS OSCILLATION ************************************************************** A-4699-522-A BD BOARD, COMPLETE *******************

Ref. No.

Part No.

Description

Remark

C107 C108 C109 C110 C111

1-164-161-11 1-164-232-11 1-164-232-11 1-163-989-11 1-163-017-00

CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP

0.0022uF 10% 0.01uF 0.01uF 0.033uF 10% 0.0047uF 5%

100V 50V 50V 25V 50V

C112 C113 C114 C115 C116

1-163-017-00 1-164-161-11 1-164-005-11 1-126-607-11 1-163-016-00

CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CHIP CERAMIC CHIP

0.0047uF 5% 0.0022uF 10% 0.47uF 47uF 20% 0.0039uF 10%

50V 100V 25V 4V 50V

C117 C118 C119 C120 C121

1-164-005-11 1-164-004-11 1-163-038-91 1-124-779-00 1-163-038-91

CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CHIP CERAMIC CHIP

0.47uF 0.1uF 0.1uF 10uF 0.1uF

25V 25V 25V 16V 25V

C122 C123 C124 C125 C126

1-164-232-11 1-163-038-91 1-126-607-11 1-164-232-11 1-163-038-91

CERAMIC CHIP CERAMIC CHIP ELECT CHIP CERAMIC CHIP CERAMIC CHIP

0.01uF 0.1uF 47uF 0.01uF 0.1uF

C127 C128 C129 C130 C131

1-164-161-11 1-163-135-00 1-163-038-91 1-164-336-11 1-164-346-11

CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP

0.0022uF 10% 560PF 5% 0.1uF 0.33uF 1uF

100V 50V 25V 25V 16V

C140 C154 C161 C162 C163

1-110-501-11 1-163-235-11 1-164-005-11 1-164-232-11 1-163-117-00

CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP

0.33uF 22PF 0.47uF 0.01uF 100PF

16V 50V 25V 50V 50V

C164 C165 C166 C167 C168

1-163-145-00 1-164-004-11 1-163-137-00 1-163-121-00 1-163-137-00

CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP

0.0015uF 5% 0.1uF 10% 680PF 5% 150PF 5% 680PF 5%

50V 25V 50V 50V 50V

C169 C170 C171 C173 C174

1-163-121-00 1-163-099-00 1-163-237-11 1-163-038-91 1-163-038-91

CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP

150PF 18PF 27PF 0.1uF 0.1uF

50V 50V 50V 25V 25V

C175 C176 C177 C178 C179

1-163-038-91 1-163-038-91 1-163-038-91 1-163-038-91 1-163-038-91

CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP

0.1uF 0.1uF 0.1uF 0.1uF 0.1uF

C181 C182 C183 C185 C188

1-126-205-11 1-126-393-11 1-124-778-00 1-164-232-11 1-163-235-11

ELECT CHIP ELECT ELECT CHIP CERAMIC CHIP CERAMIC CHIP

47uF 33uF 22uF 0.01uF 22PF

20% 20% 20% 5%

6.3V 10V 6.3V 50V 50V

C189

1-163-235-11 CERAMIC CHIP

22PF

50V

10% 20%

20%

10% 5%

5% 5% 5%

50V 25V 4V 50V 25V

25V 25V 25V 25V 25V

< CAPACITOR > C101 C102 C103 C105 C106

1-126-607-11 1-163-141-00 1-164-346-11 1-163-038-91 1-164-161-11

ELECT CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP

47uF 20% 0.001uF 5% 1uF 0.1uF 0.0022uF 10%

4V 50V 16V 25V 100V

– 104 –

The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified.

BD Ref. No.

Part No.

Description

Remark

Ref. No.

< CONNECTOR > CNU101 1-777-937-11 CONNECTOR, FFC/FPC 16P CNU102 1-778-874-11 CONNECTOR, FFC(LIF(NON-ZIF))19P < FERRITE BEAD > FB101 FB103

1-414-234-11 INDUCTOR, FERRITE BEAD 1-414-234-11 INDUCTOR, FERRITE BEAD < IC >

IC101 IC102 IC103

8-752-080-62 IC CXA1992AR 8-759-429-32 IC BA5941FP-E2 8-752-378-66 IC CXD2519Q < CHIP CONDUCTOR >

JW101 JW104

1-216-295-91 CONDUCTOR, CHIP 1-216-295-91 CONDUCTOR, CHIP

(2012) (2012)

< TRANSISTOR > Q101

8-729-010-08 TRANSISTOR MSB710-R

Part No.

CD SW

Description

Remark

R136

1-216-073-00 METAL CHIP

10K

1/10W

R137 R138 R156 R157 R158

1-216-065-00 1-216-025-91 1-216-081-00 1-216-069-00 1-216-001-00

METAL CHIP METAL GLAZE METAL CHIP METAL CHIP METAL CHIP

4.7K 100 22K 6.8K 10

5% 5% 5% 5% 5%

1/10W 1/10W 1/10W 1/10W 1/10W

R159 R161 R162 R163 R164

1-216-121-91 1-216-097-91 1-216-073-00 1-216-121-91 1-216-061-00

METAL GLAZE METAL GLAZE METAL CHIP METAL GLAZE METAL CHIP

1M 100K 10K 1M 3.3K

5% 5% 5% 5% 5%

1/10W 1/10W 1/10W 1/10W 1/10W

R165 R166 R167 R168 R169

1-216-049-91 1-216-073-00 1-216-081-00 1-216-073-00 1-216-079-00

METAL GLAZE METAL CHIP METAL CHIP METAL CHIP METAL CHIP

1K 10K 22K 10K 18K

5% 5% 5% 5% 5%

1/10W 1/10W 1/10W 1/10W 1/10W

R170 R171 R172 R173 R174

1-216-081-00 1-216-073-00 1-216-079-00 1-216-025-91 1-216-033-00

METAL CHIP METAL CHIP METAL CHIP METAL GLAZE METAL CHIP

22K 10K 18K 100 220

5% 5% 5% 5% 5%

1/10W 1/10W 1/10W 1/10W 1/10W

R175 R176 R177 R178 R179

1-216-025-91 1-216-025-91 1-216-025-91 1-216-025-91 1-216-025-91

METAL GLAZE METAL GLAZE METAL GLAZE METAL GLAZE METAL GLAZE

100 100 100 100 100

5% 5% 5% 5% 5%

1/10W 1/10W 1/10W 1/10W 1/10W

R180 R181 R188 R190 R191

1-216-025-91 1-216-025-91 1-216-037-00 1-216-097-91 1-216-105-91

METAL GLAZE METAL GLAZE METAL CHIP METAL GLAZE METAL GLAZE

100 100 330 100K 220K

5% 5% 5% 5% 5%

1/10W 1/10W 1/10W 1/10W 1/10W

< RESISTOR > R102 R104 R105 R106 R107

1-216-001-00 1-216-093-00 1-216-088-00 1-216-088-00 1-216-088-00

METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP

10 68K 43K 43K 43K

5% 5% 5% 5% 5%

1/10W 1/10W 1/10W 1/10W 1/10W

R108 R109 R114 R115 R116

1-216-088-00 1-216-093-00 1-216-101-00 1-216-101-00 1-216-061-00

METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP

43K 68K 150K 150K 3.3K

5% 5% 5% 5% 5%

1/10W 1/10W 1/10W 1/10W 1/10W

R117 R118 R119 R120 R121

1-216-069-00 1-216-063-91 1-216-085-00 1-216-089-91 1-216-114-00

METAL CHIP METAL GLAZE METAL CHIP METAL GLAZE METAL GLAZE

6.8K 3.9K 33K 47K 510K

5% 5% 5% 5% 5%

1/10W 1/10W 1/10W 1/10W 1/10W

R122 R123 R124 R125 R126

1-216-097-91 1-216-099-00 1-216-091-00 1-216-069-00 1-216-063-91

METAL GLAZE METAL CHIP METAL CHIP METAL CHIP METAL GLAZE

100K 120K 56K 6.8K 3.9K

5% 5% 5% 5% 5%

1/10W 1/10W 1/10W 1/10W 1/10W

R127 R128 R129 R130 R131

1-216-089-91 1-216-098-00 1-216-025-91 1-216-079-00 1-216-079-00

METAL GLAZE METAL CHIP METAL GLAZE METAL CHIP METAL CHIP

47K 110K 100 18K 18K

5% 5% 5% 5% 5%

1/10W 1/10W 1/10W 1/10W 1/10W

R132 R133 R134 R135

1-216-061-00 1-216-061-00 1-216-065-00 1-216-065-00

METAL CHIP METAL CHIP METAL CHIP METAL CHIP

3.3K 3.3K 4.7K 4.7K

5% 5% 5% 5%

1/10W 1/10W 1/10W 1/10W

< SWITCH > S101

1-572-085-11 SWITCH, LEAF (LIMIT) < VIBRATOR >

X101 1-767-408-21 VIBRATOR, CRYSTAL (16.9344MHz) ************************************************************** 1-664-023-11 CD SW BOARD ************

< CONNECTOR > * CN602 CN606

1-568-824-11 SOCKET, CONNECTOR 5P 1-568-853-11 SOCKET, CONNECTOR 10P < DIODE >

D626 D627

– 105 –

8-719-056-13 DIODE SML79423C-TP15 (DISC IN/PLAY: DISC 1) 8-719-056-13 DIODE SML79423C-TP15 (DISC IN/PLAY: DISC 1)

CD SW Ref. No. D628 D629 D630

D631 D632 D633

CONNECTOR

Part No.

DECO

Description

DJ Remark

Ref. No.

8-719-056-13 DIODE SML79423C-TP15 (DISC IN/PLAY: DISC 2) 8-719-056-13 DIODE SML79423C-TP15 (DISC IN/PLAY: DISC 2) 8-719-056-13 DIODE SML79423C-TP15 (DISC IN/PLAY: DISC 3)

S654

8-719-056-13 DIODE SML79423C-TP15 (DISC IN/PLAY: DISC 3) 8-719-058-03 DIODE SEL5423E-TP15 (·) 8-719-057-97 DIODE SEL5923A-TP15 (∏)

Part No.

8-729-119-76 8-729-119-76 8-729-119-76 8-729-119-76

TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR

Remark

1-554-303-21 SWITCH, TACTILE (· ∏)

************************************************************* 1-658-575-11 CONNECTOR BOARD *****************

< CONNECTOR > * CN701 CN702

1-568-946-11 PIN, CONNECTOR 8P 1-750-413-11 CONNECTOR, FFC/FPC 8P

< TRANSISTOR > Q612 Q613 Q614 Q616

Description

< TRANSISTOR >

2SA1175-HFE 2SA1175-HFE 2SA1175-HFE 2SA1175-HFE

Q701

8-729-900-80 TRANSISTOR DTC114ES < RESISTOR >

< RESISTOR > R709 R710 R711 R712 R713

1-249-401-11 1-249-413-11 1-249-409-11 1-249-411-11 1-249-413-11

CARBON CARBON CARBON CARBON CARBON

47 470 220 330 470

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/4W

R714 R715 R716 R717 R718

1-249-415-11 1-249-417-11 1-249-419-11 1-249-421-11 1-247-804-11

CARBON CARBON CARBON CARBON CARBON

680 1K 1.5K 2.2K 75

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/4W

R719 R720 R721 R722 R723

1-247-804-11 1-247-804-11 1-247-804-11 1-247-804-11 1-247-804-11

CARBON CARBON CARBON CARBON CARBON

75 75 75 75 75

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/4W

R724 R725 R791 R792 R793

1-247-807-31 1-247-807-31 1-247-804-11 1-247-804-11 1-247-804-11

CARBON CARBON CARBON CARBON CARBON

100 100 75 75 75

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/4W

R794 R795 R796

1-247-804-11 CARBON 1-247-804-11 CARBON 1-247-804-11 CARBON

75 75 75

5% 5% 5%

1/4W 1/4W 1/4W

R703 1-249-435-11 CARBON 33K 5% 1/4W R704 1-249-429-11 CARBON 10K 5% 1/4W R705 1-249-417-11 CARBON 1K 5% 1/4W ************************************************************ 1-664-028-11 DECO BOARD ***********

< CONNECTOR >

< SWITCH > S645 S646 S647 S648 S649

1-554-303-21 1-554-303-21 1-554-303-21 1-554-303-21 1-554-303-21

SWITCH, TACTILE (POWER) SWITCH, TACTILE (≠ 0) SWITCH, TACTILE () ±) SWITCH, TACTILE (DISC SKIP EX-CHANGE) SWITCH, TACTILE (DISC 1)

S650 S651 S652 S653

1-554-303-21 1-554-303-21 1-554-303-21 1-554-303-21

SWITCH, TACTILE (DISC 2) SWITCH, TACTILE (DISC 3) SWITCH, TACTILE (p) SWITCH, TACTILE (§ OPEN/CLOSE)

* CN605

1-568-848-11 SOCKET, CONNECTOR 5P < DIODE >

D619 D620 D621 D622 D623

8-719-058-04 8-719-058-04 8-719-058-04 8-719-058-03 8-719-058-04

DIODE DIODE DIODE DIODE DIODE

SEL5223S-TP15 (RIGHT) SEL5223S-TP15 (RIGHT) SEL5223S-TP15 (CENTER) SEL5423E-TP15 (CENTER) SEL5223S-TP15 (CENTER)

D624 D625

8-719-058-04 DIODE SEL5223S-TP15 (LEFT) 8-719-058-04 DIODE SEL5223S-TP15 (LEFT) < TRANSISTOR >

Q610 Q611

8-729-119-76 TRANSISTOR 2SA1175-HFE 8-729-119-76 TRANSISTOR 2SA1175-HFE < RESISTOR >

R706 1-247-807-31 CARBON 100 5% 1/4W R707 1-247-807-31 CARBON 100 5% 1/4W R708 1-247-807-31 CARBON 100 5% 1/4W R746 1-247-807-31 CARBON 100 5% 1/4W ************************************************************** 1-664-088-11 DJ BOARD *********

< CAPACITOR > C401 C402

– 106 –

1-164-159-11 CERAMIC 1-126-967-11 ELECT

0.1uF 47uF

20%

50V 10V

HP/MIC

DJ Ref. No. C403 C404 C407

Part No.

Description

Remark

Part No.

Description

C761 C762 C764 C765

1-162-282-31 1-126-961-11 1-126-964-11 1-126-960-11

CERAMIC ELECT ELECT ELECT

1-564-788-11 PIN, CONNECTOR 10P

C766

< IC >

1-126-963-11 ELECT 1-164-159-11 CERAMIC 1-126-963-11 ELECT

4.7uF 0.1uF 4.7uF

20% 20%

50V 50V 50V

Ref. No.

Remark 100PF 2.2uF 10uF 1uF

10% 20% 20% 20%

50V 50V 50V 50V (GR8: EA3)

1-162-305-11 CERAMIC

0.0068uF 20%

C767

1-162-294-31 CERAMIC

0.001uF 10%

C768

1-136-495-11 FILM

0.068uF 5%

C769

1-126-957-11 ELECT

0.22uF

20%

C770

1-126-957-11 ELECT

0.22uF

20%

16V (GR8: EA3) 50V (GR8: EA3) 50V (GR8: EA3) 50V (GR8: EA3) 50V (GR8: EA3)

C771

1-126-967-11 ELECT

47uF

20%

C772

1-164-159-11 CERAMIC

0.1uF

C773

1-104-664-11 ELECT

47uF

C774

1-136-495-11 FILM

0.068uF 5%

C775

1-162-305-11 CERAMIC

0.0068uF 20%

< CONNECTOR > * CN401

IC401

8-759-447-25 IC MSM6653A-485RS < INDUCTOR >

L401

1-410-515-11 INDUCTOR

33uH

< TRANSISTOR > Q401

8-729-900-36 TRANSISTOR DTC124ES < RESISTOR > 20%

R401 R402 R403 R404 R405

1-249-429-11 1-247-807-31 1-247-807-31 1-247-807-31 1-247-807-31

CARBON CARBON CARBON CARBON CARBON

10K 100 100 100 100

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/4W

R406 R407 R408 R411 R412

1-247-807-31 1-247-807-31 1-247-807-31 1-247-807-31 1-249-441-11

CARBON CARBON CARBON CARBON CARBON

100 100 100 100 100K

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/4W

C776

1-162-294-31 CERAMIC

0.001uF 10%

C777

1-136-167-00 FILM

0.15uF

C778

1-126-960-11 ELECT

1uF

20%

R413

1-249-429-11 CARBON

10K

1/4W

C779

1-161-494-00 CERAMIC

0.022uF

C780

1-126-961-11 ELECT

2.2uF

20%

C782

1-162-290-31 CERAMIC

470PF

10%

< VIBRATOR > X401 1-767-353-11 VIBRATOR, CERAMIC (4.09MHz) ************************************************************** 1-664-025-11 HP/MIC BOARD *************

< CONNECTOR > * CN750

1-568-828-11 SOCKET, CONNECTOR 9P

1-690-880-11 LEAD (WITH CONNECTOR) < DIODE > < CAPACITOR > C750 C751 C752 C753 C754

1-162-294-31 1-162-294-31 1-164-159-11 1-164-159-11 1-162-306-11

CERAMIC CERAMIC CERAMIC CERAMIC CERAMIC

0.001uF 10% 0.001uF 10% 0.1uF 0.1uF 0.01uF 20%

50V 50V 50V 50V 16V

C755 C756 C757 C758 C759

1-126-961-11 1-162-294-31 1-162-215-31 1-126-964-11 1-126-959-11

ELECT CERAMIC CERAMIC ELECT ELECT

2.2uF 0.001uF 47PF 10uF 0.47uF

20% 10% 5% 20% 20%

50V 50V 50V 50V 50V

C760

1-162-215-31 CERAMIC

47PF

50V

D751 D752 D753

8-719-024-99 DIODE 11ES2-NTA2B (GR8: EA3) 8-719-024-99 DIODE 11ES2-NTA2B (GR8: EA3) 8-719-024-99 DIODE 11ES2-NTA2B (GR8: EA3) < IC >

IC750 IC751

8-759-634-51 IC M5218AP 8-759-450-96 IC M65850P (GR8: EA3) < JACK >

J750 J751

– 107 –

1-569-112-21 JACK, LARGE TYPE (PHONES) 1-569-112-21 JACK, LARGE TYPE (MIX MIC)

10V (GR8: EA3) 50V (GR8: EA3) 25V (GR8: EA3) 50V (GR8: EA3) 16V (GR8: EA3) 50V (GR8: EA3) 50V (GR8: EA3) 50V (GR8: EA3) 25V (GR8: EA3) 50V (GR8: EA3) 50V

HP/MIC Ref. No.

LEAF SWITCH

Part No.

MAIN

Description

Remark

Ref. No.

Part No.

< INDUCTOR > L751

1-410-521-11 INDUCTOR

Description

Remark

< RESISTOR > 100uH (GR8: EA3)

R1001 R1002 R1003 R1004 R1005

< RESISTOR > R750 R751 R752 R753 R754

1-249-429-11 1-249-417-11 1-249-441-11 1-249-417-11 1-249-433-11

CARBON CARBON CARBON CARBON CARBON

10K 1K 100K 1K 22K

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/4W

R755 R756 R757 R758

1-249-429-11 1-247-885-00 1-247-807-31 1-249-433-11

CARBON CARBON CARBON CARBON

10K 180K 100 22K

5% 5% 5% 5%

R759

1-249-433-11 CARBON

22K

1/4W 1/4W 1/4W 1/4W (GR8: EA3) 1/4W (GR8: EA3)

R760

1-249-433-11 CARBON

22K

R761

1-247-881-00 CARBON

120K

R762

1-249-433-11 CARBON

22K

R763

1-249-433-11 CARBON

22K

R764

1-249-433-11 CARBON

22K

R765

1-249-437-11 CARBON

47K

R766

1-249-431-11 CARBON

15K

R767

1-249-431-11 CARBON

15K

1-247-818-11 1-247-820-11 1-249-414-11 1-247-834-11 1-247-818-11

CARBON CARBON CARBON CARBON CARBON

300 360 560 1.3K 300

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/4W

< SWITCH >

1/4W (GR8: EA3) 1/4W (GR8: EA3) 1/4W (GR8: EA3) 1/4W (GR8: EA3) 1/4W (GR8: EA3) 1/4W (GR8: EA3) 1/4W (GR8: EA3) 1/4W (GR8: EA3)

S1001 S1002 S1004 S1005 S1006

1-692-832-11 1-692-832-11 1-571-281-21 1-571-281-21 1-572-248-11

SWITCH, PUSH (1 KEY) (A PLAY) SWITCH, PUSH (1 KEY) (B PLAY) SWITCH, LEAF (A HALF) SWITCH, LEAF (A CrO2) SWITCH, LEAF (REC A)

S1007 1-572-248-11 SWITCH, LEAF (B HALF) S1008 1-571-281-21 SWITCH, LEAF (B CrO2) S1009 1-571-281-21 SWITCH, LEAF (REC B) ************************************************************** * * * * *

A-4398-179-A A-4392-820-A A-4392-834-A A-4392-362-A A-4392-361-A

A-4392-360-A MAIN BOARD, COMPLETE (GR8: E3, HK, IA, SP, TW) A-4392-491-A MAIN BOARD, COMPLETE (GR8: JE) A-4392-358-A MAIN BOARD, COMPLETE (RX90: AEP, G, UK, AED) A-4392-359-A MAIN BOARD, COMPLETE (RX90: EE, CIS) *********************

* * *

MAIN BOARD, COMPLETE (GR8: EA3, MY) MAIN BOARD, COMPLETE (GR8: EA4, TH) MAIN BOARD, COMPLETE (GR8: SAF) MAIN BOARD, COMPLETE (GR8: AUS) MAIN BOARD, COMPLETE (GR8: E2, MX)

7-685-646-79 SCREW +BVTP

3X8 TYPE2 N-S

< CAPACITOR > < VARIABLE RESISTOR > RV750 RV751

1-223-983-11 RES, VAR, CARBON 50K (MIC LEVEL) 1-223-983-11 RES, VAR, CARBON 50K (ECHO LEVEL) (GR8: EA3) **************************************************************

C109 C121 C122

1-164-159-11 CERAMIC 1-162-286-31 CERAMIC 1-162-286-31 CERAMIC

0.1uF 220PF 220PF

10% 10%

50V 50V 50V

C123 C131

1-162-306-11 CERAMIC 1-136-495-11 FILM

0.01uF 20% 0.068uF 5%

16V 50V

1-650-669-11 LEAF SWITCH BOARD *****************

(RX90) C132

1-136-495-11 FILM

0.068uF 5%

50V

C133

1-162-294-31 CERAMIC

0.001uF 10%

50V

C171 C172 C173

1-162-286-31 CERAMIC 1-162-286-31 CERAMIC 1-162-306-11 CERAMIC

220PF 220PF 0.01uF

50V 50V 16V

C181

1-136-495-11 FILM

0.068uF 5%

50V

C182

1-136-495-11 FILM

0.068uF 5%

50V

C183

1-162-294-31 CERAMIC

0.001uF 10%

50V

< CONNECTOR >

(RX90)

* CN1001 1-568-854-11 SOCKET, CONNECTOR 11P

(RX90)

< TRANSISTOR > Q1001 Q1002

8-749-010-90 TRANSISTOR PHOTO REFLECTOR NJL5165KA-H2 8-749-010-90 TRANSISTOR PHOTO REFLECTOR NJL5165KA-H2

10% 10% 20%

(RX90) (RX90) (RX90)

– 108 –

MAIN Ref. No.

Part No.

Description

Remark

Ref. No.

Part No.

Description

Remark

C191 C192

1-126-963-11 ELECT 1-164-159-11 CERAMIC

4.7uF 0.1uF

20%

50V 50V

C291 C301

1-126-959-11 ELECT 1-126-967-11 ELECT

0.47uF 47uF

20% 20%

50V 10V

C201 C202 C203 C204 C205

1-136-169-00 1-136-169-00 1-130-493-00 1-130-493-00 1-130-486-00

FILM FILM MYLAR MYLAR MYLAR

0.22uF 0.22uF 0.068uF 0.068uF 0.018uF

5% 5% 5% 5% 10%

50V 50V 50V 50V 50V

C302 C303 C304 C305 C309

1-164-159-11 1-136-165-00 1-126-926-11 1-162-306-11 1-102-514-11

CERAMIC FILM ELECT CERAMIC CERAMIC

0.1uF 0.1uF 1000uF 0.01uF 22PF

5% 20% 20% 5%

50V 50V 10V 16V 50V

C206 C207 C208 C209 C210

1-130-486-00 1-130-480-00 1-130-479-00 1-130-474-00 1-126-964-11

MYLAR MYLAR MYLAR MYLAR ELECT

0.018uF 10% 0.0056uF 5% 0.0047uF 5% 0.0018uF 5% 10uF 20%

50V 50V 50V 50V 50V

C310 C311 C315 C316 C390

1-102-514-11 1-164-159-11 1-126-933-11 1-136-165-00 1-126-933-11

CERAMIC CERAMIC ELECT FILM ELECT

22PF 0.1uF 100uF 0.1uF 100uF

C211 C212 C213 C214 C215

1-126-964-11 1-130-483-00 1-136-165-00 1-136-165-00 1-162-294-31

ELECT MYLAR FILM FILM CERAMIC

10uF 0.01uF 0.1uF 0.1uF 0.001uF

20% 5% 5% 5% 10%

50V 50V 50V 50V 50V

C391 C392 C393 C394 C395

1-162-306-11 1-126-933-11 1-126-925-11 1-164-159-11 1-162-282-31

CERAMIC ELECT ELECT CERAMIC CERAMIC

0.01uF 100uF 470uF 0.1uF 100PF

20% 20% 20%

C216 C221 C222 C223 C224

1-136-167-00 1-126-967-11 1-126-967-11 1-126-964-11 1-162-290-31

FILM ELECT ELECT ELECT CERAMIC

0.15uF 47uF 47uF 10uF 470PF

5% 20% 20% 20% 10%

50V 10V 10V 50V 50V

C396 C398 C903 C904 C904

1-126-961-11 1-126-961-11 1-136-165-00 1-128-547-11 1-126-937-11

ELECT ELECT FILM ELECT ELECT

2.2uF 2.2uF 0.1uF 6800uF 4700uF

20% 20% 5% 20% 20%

C226 C231 C241 C242 C243

1-126-964-11 1-126-960-11 1-126-964-11 1-162-292-31 1-126-964-11

ELECT ELECT ELECT CERAMIC ELECT

10uF 1uF 10uF 680PF 10uF

20% 20% 20% 10% 20%

50V 50V 50V 50V 50V

C906 C906

1-126-923-11 ELECT 1-126-933-11 ELECT

220uF 100uF

20% 20%

C244 C245 C246 C247

1-162-286-31 1-162-306-11 1-162-306-11 1-162-306-11

CERAMIC CERAMIC CERAMIC CERAMIC

220PF 0.01uF 0.01uF 0.01uF

10% 20% 20% 20%

50V 16V 16V 16V

C909 C910 C911 C912 C913

1-126-964-11 1-126-933-11 1-126-964-11 1-126-916-11 1-126-943-11

ELECT ELECT ELECT ELECT ELECT

10uF 100uF 10uF 1000uF 2200uF

20% 20% 20% 20% 20%

50V 10V 50V 6.3V 25V

C251

1-136-169-00 FILM

0.22uF

50V

1-136-169-00 1-130-493-00 1-130-493-00 1-130-486-00 1-130-486-00

FILM MYLAR MYLAR MYLAR MYLAR

0.22uF 0.068uF 0.068uF 0.018uF 0.018uF

5% 5% 5% 10% 10%

50V 50V 50V 50V 50V

1-126-767-11 1-126-967-11 1-164-159-11 1-126-968-11 1-126-968-11

ELECT ELECT CERAMIC ELECT ELECT

1000uF 47uF 0.1uF 100uF 100uF

20% 20%

C252 C253 C254 C255 C256

C914 C915 C916 C917 C918

16V 16V 50V 50V 50V

C257 C258 C259 C260 C261

1-130-480-00 1-130-479-00 1-130-474-00 1-126-964-11 1-126-964-11

MYLAR MYLAR MYLAR ELECT ELECT

0.0056uF 5% 0.0047uF 5% 0.0018uF 5% 10uF 20% 10uF 20%

50V 50V 50V 50V 50V

C919 C920 C953 C954 C956 C956

1-126-964-11 1-126-947-11 1-136-165-00 1-126-768-11 1-126-923-11 1-126-933-11

ELECT ELECT FILM ELECT ELECT ELECT

10uF 47uF 0.1uF 2200uF 220uF 100uF

20% 20% 5% 20% 20% 20%

C262 C263 C264 C276 C281

1-130-483-00 1-136-165-00 1-136-165-00 1-126-964-11 1-126-933-11

MYLAR FILM FILM ELECT ELECT

0.01uF 0.1uF 0.1uF 10uF 100uF

5% 5% 5% 20% 20%

50V 50V 50V 50V 10V

C1501 C1502 C1503 C1504 C1505

1-130-479-00 1-162-290-31 1-164-159-11 1-126-160-11 1-126-964-11

MYLAR CERAMIC CERAMIC ELECT ELECT

0.0047uF 5% 470PF 10% 0.1uF 1uF 20% 10uF 20%

50V 50V 50V 50V 50V

C282 C283 C284

1-126-961-11 ELECT 1-126-933-11 ELECT 1-126-923-11 ELECT

2.2uF 100uF 220uF

20% 20% 20%

50V 10V 10V

C1506 C1507 C1508 C1522

1-126-157-11 1-126-160-11 1-126-933-11 1-126-964-11

ELECT ELECT ELECT ELECT

10uF 1uF 100uF 10uF

16V 50V 10V 50V

(RX90)

– 109 –

20% 5% 20%

10%

20% 20%

20% 20% 20% 20%

50V 50V 10V 50V 10V 16V 10V 10V 50V 50V 50V 50V 50V 16V (GR8) 16V (RX90) 10V (GR8) 10V (RX90)

50V 35V 50V 16V 10V (GR8) 10V (RX90)

MAIN Ref. No.

Part No.

Description

Remark

C1523

1-126-933-11 ELECT

100uF

20%

16V

C1531 C1532 C1533 C1534 C1551

1-164-159-11 1-164-159-11 1-164-159-11 1-126-935-11 1-130-479-00

CERAMIC CERAMIC CERAMIC ELECT MYLAR

0.1uF 0.1uF 0.1uF 470uF 20% 0.0047uF 5%

50V 50V 50V 16V 50V

C1552 C1553 C1554 C1555 C1556

1-162-290-31 1-164-159-11 1-126-960-11 1-126-964-11 1-126-964-11

CERAMIC CERAMIC ELECT ELECT ELECT

470PF 0.1uF 1uF 10uF 10uF

20% 20% 20%

50V 50V 50V 50V 50V

C1557

1-126-960-11 ELECT

1uF

20%

50V

C1558

1-126-933-11 ELECT

100uF

20%

10V

10%

< CONNECTOR > CN101 * CN102 CN105 * CN201 * CN201

1-778-982-11 1-568-836-11 1-564-506-11 1-568-834-11

CONNECTOR, BOARD TO BOARD 13P SOCKET, CONNECTOR 17P PLUG, CONNECTOR 3P SOCKET, CONNECTOR 15P (GR8: EA3, MY, SAF, E3, HK, IA, JE, SP, TW/RX90) 1-568-832-11 SOCKET, CONNECTOR 13P (GR8: EA4, TH, AUS, E2, MX)

* CN202 * CN203 * CN204 CN205 * CN206

1-568-862-11 1-568-946-11 1-568-947-11 1-568-838-11 1-568-830-11

SOCKET, CONNECTOR 19P PIN, CONNECTOR 8P PIN, CONNECTOR 9P SOCKET, CONNECTOR 21P SOCKET, CONNECTOR 11P

* CN207

1-568-449-11 HOUSING, CONNECTOR(PC BOARD)3P

Ref. No.

Part No.

Description

D307 D902 D903 D904 D905

8-719-987-63 8-719-024-99 8-719-024-99 8-719-024-99 8-719-024-99

DIODE DIODE DIODE DIODE DIODE

1N4148M 11ES2-NTA2B 11ES2-NTA2B 11ES2-NTA2B 11ES2-NTA2B

D906 D907 D908 D909 D910

8-719-024-99 8-719-024-99 8-719-024-99 8-719-024-99 8-719-011-18

DIODE DIODE DIODE DIODE DIODE

11ES2-NTA2B 11ES2-NTA2B 11ES2-NTA2B 11ES2-NTA2B UZ-33BSC

D911 D912 D913 D914 D915

8-719-010-43 8-719-987-63 8-719-024-99 8-719-024-99 8-719-001-42

DIODE DIODE DIODE DIODE DIODE

UZ-5.6BSC 1N4148M 11ES2-NTA2B 11ES2-NTA2B UZL-11M1

D951 D952

8-719-987-63 DIODE 1N4148M 8-719-987-63 DIODE 1N4148M

Remark

< GROUND PLATE > * EPT101 4-870-539-11 PLATE, GROUND (EXCEPT GR8: EA4, TH, SAF) * EPT101 4-870-539-00 PLATE, GROUND (GR8: EA4, TH, SAF) < INDUCTOR > FB302

1-412-473-21 INDUCTOR (SMALL TYPE) < IC >

< DIODE >

IC102 IC201 IC202 IC231 IC241

8-759-000-48 8-759-460-02 8-759-634-50 8-759-634-50 8-759-634-50

IC IC IC IC IC

MC14052BCP M62427FP-A M5218AL M5218AL M5218AL

D141 D142 D143 D144 D145

8-719-987-63 8-719-987-63 8-719-987-63 8-719-987-63 8-719-987-63

DIODE DIODE DIODE DIODE DIODE

1N4148M 1N4148M 1N4148M 1N4148M 1N4148M

IC281 IC301 IC302 IC391 IC901

8-759-111-68 8-759-447-26 8-759-635-63 8-749-923-04 8-759-288-53

IC IC IC IC IC

uPC1237HA uPD780018YGF-011-3BA M51943BSL TOTX178 LA5617

D146 D147 D191 D192 D193

8-719-987-63 8-719-987-63 8-719-815-85 8-719-815-85 8-719-815-85

DIODE DIODE DIODE DIODE DIODE

1N4148M 1N4148M 1S1585 1S1585 1S1585

IC902 IC903 IC904 IC1501 IC1502

8-759-604-86 8-759-231-53 8-759-231-58 8-759-363-21 8-759-822-09

IC IC IC IC IC

M5F7807L TA7805S TA7812S HA12203NT LB1641

D194 D281 D291 D301

8-719-815-85 8-719-815-85 8-719-987-63 8-719-024-99

DIODE DIODE DIODE DIODE

1S1585 1S1585 1N4148M 11ES2-NTA2B

D302 D303 D304 D305 D306

8-719-024-99 8-719-987-63 8-719-987-63 8-719-987-63 8-719-987-63

DIODE DIODE DIODE DIODE DIODE

11ES2-NTA2B 1N4148M 1N4148M 1N4148M 1N4148M

< JACK > J101 J241

1-695-188-31 JACK, PIN 4P (VIDEO/MD, IN/OUT) 1-774-785-11 JACK, PIN 1P (SUPER WOOFER) < COIL >

L131 L181 L301 L392

– 110 –

1-420-872-00 1-420-872-00 1-410-509-11 1-410-521-11

COIL, AIR-CORE (RX90) COIL, AIR-CORE (RX90) INDUCTOR 10uH INDUCTOR 100uH

MAIN Ref. No. L393

Part No.

Description

1-410-515-11 INDUCTOR

Remark 33uH

Ref. No.

Part No.

Description

Remark

R131

1-260-076-11 CARBON

< TRANSISTOR >

R132

1-260-076-11 CARBON

R133

1-260-091-11 CARBON

220

1/2W (RX90) 1/2W (RX90) 1/2W

R134 R135 R136 R140 R141

1-260-091-11 1-249-441-11 1-249-441-11 1-249-429-11 1-249-437-11

CARBON CARBON CARBON CARBON CARBON

220 100K 100K 10K 47K

5% 5% 5% 5% 5%

1/2W 1/4W 1/4W 1/4W 1/4W

R142 R143 R144 R145 R146

1-249-429-11 1-249-429-11 1-249-437-11 1-249-429-11 1-249-429-11

CARBON CARBON CARBON CARBON CARBON

10K 10K 47K 10K 10K

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/4W

! R147 ! R148 ! R149 R171 R172

1-216-457-00 1-216-457-00 1-216-457-00 1-249-424-11 1-247-887-00

METAL OXIDE METAL OXIDE METAL OXIDE CARBON CARBON

1.2K 1.2K 1.2K 3.9K 220K

5% 5% 5% 5% 5%

2W 2W 2W 1/4W 1/4W

R173 R174 R176 R177 R181

1-249-426-11 1-249-429-11 1-249-417-11 1-249-441-11 1-260-076-11

CARBON CARBON CARBON CARBON CARBON

5.6K 10K 1K 100K 10

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/2W (RX90)

R182

1-260-076-11 CARBON

R183 R184 R191 R192

1-260-091-11 1-260-091-11 1-249-425-11 1-249-441-11

CARBON CARBON CARBON CARBON

220 220 4.7K 100K

5% 5% 5% 5%

1/2W (RX90) 1/2W 1/2W 1/4W 1/4W

R193 R194 R195 R196 R197

1-249-421-11 1-249-437-11 1-249-437-11 1-249-437-11 1-249-437-11

CARBON CARBON CARBON CARBON CARBON

2.2K 47K 47K 47K 47K

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/4W

R201 R202 R203 R205 R206

1-249-429-11 1-249-433-11 1-249-441-11 1-249-433-11 1-249-421-11

CARBON CARBON CARBON CARBON CARBON

10K 22K 100K 22K 2.2K

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/4W

R207 R208 R209 R210 R212

1-249-431-11 1-249-437-11 1-249-441-11 1-247-903-00 1-249-419-11

CARBON CARBON CARBON CARBON CARBON

15K 47K 100K 1M 1.5K

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/4W

R213 R214 R215 R216 R217

1-249-433-11 1-247-887-00 1-247-903-00 1-249-429-11 1-249-437-11

CARBON CARBON CARBON CARBON CARBON

22K 220K 1M 10K 47K

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/4W

Q101 Q102 Q103 Q141 Q142

8-729-141-30 8-729-900-63 8-729-900-36 8-729-140-82 8-729-140-84

TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR

2SC3623A-LK DTA124ES DTC124ES 2SA988-PAFAEA 2SC1841-PAFAEA

Q143 Q144 Q145 Q151 Q191

8-729-140-82 8-729-140-84 8-729-140-84 8-729-141-30 8-729-119-76

TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR

2SA988-PAFAEA 2SC1841-PAFAEA 2SC1841-PAFAEA 2SC3623A-LK 2SA1175-HFE

Q192 Q202 Q203 Q204 Q205

8-729-111-29 8-729-119-78 8-729-119-78 8-729-141-30 8-729-141-30

TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR

2SD1616A-K 2SC403SP-51 2SC403SP-51 2SC3623A-LK 2SC3623A-LK

Q231 Q232 Q241 Q252 Q253

8-729-900-63 8-729-900-63 8-729-141-30 8-729-119-78 8-729-119-78

TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR

DTA124ES DTA124ES 2SC3623A-LK 2SC403SP-51 2SC403SP-51

Q254 Q281 Q282 Q283 Q301

8-729-141-30 8-729-900-36 8-729-900-63 8-729-900-36 8-729-119-78

TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR

2SC3623A-LK DTC124ES DTA124ES DTC124ES 2SC403SP-51

Q309 Q901 Q902 Q903 Q904

8-729-900-63 8-729-040-20 8-729-900-36 8-729-030-18 8-729-030-19

TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR

DTA124ES RT1P137L-TP DTC124ES 2SD2525 2SB1640

Q905 Q906 Q907 Q1531 Q1532

8-729-040-20 8-729-900-63 8-729-119-78 8-729-801-93 8-729-900-80

TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR

RT1P137L-TP DTA124ES 2SC403SP-51 2SD1387 DTC114ES

Q1533 Q1534 Q1535

8-729-900-80 TRANSISTOR DTC114ES 8-729-119-77 TRANSISTOR 2SA1175-FEK 8-729-900-80 TRANSISTOR DTC114ES < RESISTOR >

R121 R122 R123 R124 R125

1-249-424-11 1-247-887-00 1-249-426-11 1-249-429-11 1-249-441-11

CARBON CARBON CARBON CARBON CARBON

3.9K 220K 5.6K 10K 100K

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/4W

R126 R127

1-249-417-11 CARBON 1-249-441-11 CARBON

1K 100K

5% 5%

1/4W 1/4W

– 111 –

The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified.

F F F

MAIN Ref. No.

Part No.

Description

Remark

R218 R219 R221 R222 R223

1-249-413-11 1-249-429-11 1-249-425-11 1-249-425-11 1-249-421-11

CARBON CARBON CARBON CARBON CARBON

470 10K 4.7K 4.7K 2.2K

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/4W

R225 R226 R227 R228 R231

1-249-422-11 1-249-421-11 1-249-441-11 1-249-429-11 1-249-437-11

CARBON CARBON CARBON CARBON CARBON

2.7K 2.2K 100K 10K 47K

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/4W

R232 R234 R235 R236 R241

1-249-437-11 1-247-886-11 1-249-421-11 1-249-441-11 1-249-437-11

CARBON CARBON CARBON CARBON CARBON

47K 200K 2.2K 100K 47K

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/4W

R242 R243 R244 R245 R246

1-247-843-11 1-249-429-11 1-249-417-11 1-249-441-11 1-249-417-11

CARBON CARBON CARBON CARBON CARBON

3.3K 10K 1K 100K 1K

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/4W

R247 R253 R257 R258 R259

1-249-429-11 1-249-441-11 1-249-431-11 1-249-437-11 1-249-441-11

CARBON CARBON CARBON CARBON CARBON

10K 100K 15K 47K 100K

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/4W

R260 R262 R263 R264 R265

1-247-903-00 1-249-419-11 1-249-433-11 1-247-887-00 1-247-903-00

CARBON CARBON CARBON CARBON CARBON

1M 1.5K 22K 220K 1M

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/4W

R266 R267 R271 R272 R273

1-249-429-11 1-249-437-11 1-249-425-11 1-249-425-11 1-249-421-11

CARBON CARBON CARBON CARBON CARBON

10K 47K 4.7K 4.7K 2.2K

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/4W

R275 R276 R277 R278 R281

1-249-422-11 1-249-421-11 1-249-441-11 1-249-429-11 1-249-429-11

CARBON CARBON CARBON CARBON CARBON

2.7K 2.2K 100K 10K 10K

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/4W

R282 R283 R284 R285 R286

1-249-429-11 1-249-435-11 1-249-397-11 1-249-441-11 1-249-429-11

CARBON CARBON CARBON CARBON CARBON

10K 33K 22 100K 10K

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/4W

R287 R288 R289 R291 R292

1-249-429-11 1-249-438-11 1-249-437-11 1-249-433-11 1-249-433-11

CARBON CARBON CARBON CARBON CARBON

10K 56K 47K 22K 22K

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/4W

Ref. No.

Part No.

Description

R293 R294 R295 R301 R302

1-249-417-11 1-249-441-11 1-247-903-00 1-249-413-11 1-249-425-11

CARBON CARBON CARBON CARBON CARBON

1K 100K 1M 470 4.7K

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/4W

R303 R304 R305 R309 R310

1-249-437-11 1-249-437-11 1-249-429-11 1-249-421-11 1-249-441-11

CARBON CARBON CARBON CARBON CARBON

47K 47K 10K 2.2K 100K

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/4W

R313 R314

1-247-807-31 CARBON 1-247-807-31 CARBON

R315

1-247-807-31 CARBON

R316 R318

1-249-429-11 CARBON 1-249-429-11 CARBON

5% 1/4W 5% 1/4W (RX90: AEP, G, UK, AED) 100 5% 1/4W (RX90: AEP, G, UK, AED) 10K 5% 1/4W 10K 5% 1/4W

R319 R320 R322 R323 R325

1-249-429-11 1-249-429-11 1-249-425-11 1-247-807-31 1-249-431-11

CARBON CARBON CARBON CARBON CARBON

10K 10K 4.7K 100 15K

5% 5% 5% 5% 5%

R325

1-249-425-11 CARBON

4.7K

R325

1-249-427-11 CARBON

R325

1-247-843-11 CARBON

R326

1-249-415-11 CARBON

R326

1-249-427-11 CARBON

R326

1-249-425-11 CARBON

4.7K

R326

1-247-843-11 CARBON

3.3K

R326

1-249-435-11 CARBON

33K

R327 R328

1-247-807-31 CARBON 1-247-807-31 CARBON

100 100

5% 5%

R330 R331 R332 R333 R334

1-247-807-31 1-247-807-31 1-247-807-31 1-247-807-31 1-247-807-31

CARBON CARBON CARBON CARBON CARBON

100 100 100 100 100

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/4W

R335 R336 R337 R338 R339

1-247-807-31 1-247-807-31 1-247-807-31 1-247-807-31 1-247-807-31

CARBON CARBON CARBON CARBON CARBON

100 100 100 100 100

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/4W

R340 R341

1-247-807-31 CARBON 1-247-807-31 CARBON

100 100

5% 5%

1/4W 1/4W

– 112 –

Remark

100 100

1/4W 1/4W 1/4W 1/4W 1/4W (GR8: EA4, TH)

1/4W (GR8: AUS) 6.8K 5% 1/4W (GR8: E2, JE, MX/RX90: EE, CIS) 3.3K 5% 1/4W (RX90: AEP, G, UK, AED) 680 5% 1/4W (GR8: EA4, TH) 6.8K 5% 1/4W (GR8: AUS/RX90: AEP, G, UK, AED) 1/4W (GR8: E2, MX) 1/4W (GR8: JE) 1/4W (RX90: EE, CIS) 1/4W 1/4W

MAIN Ref. No.

Part No.

Description

Remark

R342 R343 R344

1-247-807-31 CARBON 1-247-807-31 CARBON 1-247-807-31 CARBON

100 100 100

5% 5% 5%

1/4W 1/4W 1/4W

R345 R347 R348 R349 R350

1-247-807-31 1-247-807-31 1-247-807-31 1-247-807-31 1-247-807-31

CARBON CARBON CARBON CARBON CARBON

100 100 100 100 100

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/4W

R351 R352 R353 R354 R355

1-247-807-31 1-247-807-31 1-247-807-31 1-247-807-31 1-247-807-31

CARBON CARBON CARBON CARBON CARBON

100 100 100 100 100

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/4W

R356 R357 R358 R359 R361

1-247-807-31 1-247-807-31 1-247-807-31 1-247-807-31 1-247-807-31

CARBON CARBON CARBON CARBON CARBON

100 100 100 100 100

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/4W

R362 R363 R364 R366 R367

1-247-807-31 1-247-807-31 1-247-807-31 1-247-807-31 1-249-429-11

CARBON CARBON CARBON CARBON CARBON

100 100 100 100 10K

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/4W

R368 R370 R371 R372 R373

1-247-843-11 1-249-429-11 1-249-429-11 1-249-429-11 1-249-429-11

CARBON CARBON CARBON CARBON CARBON

3.3K 10K 10K 10K 10K

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/4W

R381 R384 R385 R395

1-247-807-31 1-249-429-11 1-249-429-11 1-247-807-31

CARBON CARBON CARBON CARBON

100 10K 10K 100

5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W

R396 R397 R398 R417 R913

1-249-435-11 1-247-807-31 1-249-435-11 1-249-441-11 1-249-409-11

CARBON CARBON CARBON CARBON CARBON

33K 100 33K 100K 220

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/4W

R914 R915 R916 R917 R918

1-249-417-11 1-249-425-11 1-249-409-11 1-249-409-11 1-249-425-11

CARBON CARBON CARBON CARBON CARBON

1K 4.7K 220 220 4.7K

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/4W

R920 R921 R951 R952 R1501

1-249-417-11 1-247-895-00 1-249-425-11 1-249-425-11 1-249-435-11

CARBON CARBON CARBON CARBON CARBON

1K 470K 4.7K 4.7K 33K

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/4W

R1502 R1503 R1504 R1505

1-249-417-11 1-249-426-11 1-247-840-00 1-249-433-11

CARBON CARBON CARBON CARBON

1K 5.6K 2.4K 22K

5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W

Ref. No.

Part No.

Description

Remark

R1506

1-249-421-11 CARBON

2.2K

1/4W

R1507 R1521 R1522 R1524 R1525

1-249-428-11 1-249-430-11 1-249-426-11 1-249-429-11 1-249-432-11

CARBON CARBON CARBON CARBON CARBON

8.2K 12K 5.6K 10K 18K

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/4W

R1526 R1527 R1531 R1532 R1533

1-249-429-11 1-249-429-11 1-247-843-11 1-249-411-11 1-249-427-11

CARBON CARBON CARBON CARBON CARBON

10K 10K 3.3K 330 6.8K

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/4W

R1534 R1535 R1536 R1541 R1542

1-249-429-11 1-249-425-11 1-249-425-11 1-249-425-11 1-249-425-11

CARBON CARBON CARBON CARBON CARBON

10K 4.7K 4.7K 4.7K 4.7K

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/4W

R1543 R1544 R1545 R1546 R1547

1-249-425-11 1-249-417-11 1-249-437-11 1-249-437-11 1-249-437-11

CARBON CARBON CARBON CARBON CARBON

4.7K 1K 47K 47K 47K

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/4W

R1548 R1551 R1552 R1553 R1554

1-249-437-11 1-249-433-11 1-249-417-11 1-249-426-11 1-247-840-00

CARBON CARBON CARBON CARBON CARBON

47K 22K 1K 5.6K 2.4K

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/4W

R1555 R1556 R1557

1-249-433-11 CARBON 1-249-421-11 CARBON 1-249-428-11 CARBON

22K 2.2K 8.2K

5% 5% 5%

1/4W 1/4W 1/4W

< VARIABLE RESISTOR > RV1501 1-238-598-11 RES, ADJ, CARBON 2.2K RV1551 1-238-598-11 RES, ADJ, CARBON 2.2K < RELAY > RY141 RY142 RY143

1-515-920-11 RELAY (24V) 1-515-920-11 RELAY (24V) 1-515-920-11 RELAY (24V) < TERMINAL >

TM131 TM132

1-537-240-31 TERMINAL BOARD (SPEAKER) 1-537-240-31 TERMINAL BOARD (SURROUND SPEAKER) < VIBRATOR >

X301 1-760-489-11 VIBRATOR, CERAMIC (5MHz) X302 1-567-098-41 VIBRATOR, CRYSTAL (32.768kHz) **************************************************************

– 113 –

MOTOR Ref. No.

Part No.

MOTOR (SLIDE)

MOTOR (TURN)

Description

Remark

Ref. No.

PANEL

Part No.

Description

Remark

< IC > MOTOR BOARD ************* (Included in AUDIO BOARD, COMPLETE)

IC701

8-759-633-65 IC M54641L < RESISTOR >

< CAPACITOR > C651 1-161-494-00 CERAMIC 0.022uF 25V ************************************************************** 1-658-578-11 MOTOR (SLIDE) BOARD ********************

1-162-306-11 CERAMIC 1-162-306-11 CERAMIC 1-124-907-11 ELECT

A-4398-184-A PANEL BOARD, COMPLETE (GR8: EA3, MY) A-4392-825-A PANEL BOARD, COMPLETE (GR8: EA4, TH, SAF) A-4392-383-A PANEL BOARD, COMPLETE (GR8: AUS, E, HK, IA, JE, MX, SP, TW) A-4392-381-A PANEL BOARD, COMPLETE (RX90: AEP, G, UK, AED) A-4392-382-A PANEL BOARD, COMPLETE (RX90: EE, CIS) **********************

* *

< CAPACITOR > C801 C804 C805

R706 1-249-411-11 CARBON 330 5% 1/4W R707 1-249-401-11 CARBON 47 5% 1/4W **************************************************************

* 0.01uF 0.01uF 10uF

20% 20% 20%

16V 16V 50V

* *

< CONNECTOR > * CN801

4-932-810-11 CUSHION (FL) 4-986-870-01 HOLDER, FL TUBE

* *

1-568-947-11 PIN, CONNECTOR 9P < DIODE >

D801 D804 D805

< CAPACITOR >

8-719-010-43 DIODE UZ-5.6BSC 8-719-987-63 DIODE 1N4148M 8-719-987-63 DIODE 1N4148M < IC >

IC801

8-759-274-09 IC BA6286N < RESISTOR >

R801

1-249-401-11 CARBON

1/4W

< SWITCH > S801 1-762-527-11 SWITCH, ROTARY (OPEN/CLOSE DET) ************************************************************** 1-658-577-11 MOTOR (TURN) BOARD *******************

< CAPACITOR > C701 C702 C705

1-162-306-11 CERAMIC 1-124-907-11 ELECT 1-162-306-11 CERAMIC

0.01uF 10uF 0.01uF

< CONNECTOR > CN703 CN704

1-750-413-11 CONNECTOR, FFC/FPC 8P 1-506-469-11 PIN, CONNECTOR 4P < DIODE >

D701

8-719-010-23 DIODE UZ-3.6BSB

20% 20% 20%

16V 50V 16V

C601 C602 C603 C604 C605

1-162-294-31 1-162-306-11 1-124-589-11 1-126-163-11 1-162-294-31

CERAMIC CERAMIC ELECT ELECT CERAMIC

0.001uF 0.01uF 47uF 4.7uF 0.001uF

10% 20% 20% 20% 10%

50V 16V 16V 50V 50V

C606 C607 C608 C609 C610

1-126-160-11 1-126-160-11 1-162-294-31 1-162-282-31 1-162-282-31

ELECT ELECT CERAMIC CERAMIC CERAMIC

1uF 1uF 0.001uF 100PF 100PF

20% 20% 10% 10% 10%

50V 50V 50V 50V 50V

C611 C612 C613 C614 C615

1-162-282-31 1-162-282-31 1-162-282-31 1-162-282-31 1-162-282-31

CERAMIC CERAMIC CERAMIC CERAMIC CERAMIC

100PF 100PF 100PF 100PF 100PF

10% 10% 10% 10% 10%

50V 50V 50V 50V 50V

C616 C617 C618 C619 C620

1-162-282-31 1-162-282-31 1-162-282-31 1-162-282-31 1-162-282-31

CERAMIC CERAMIC CERAMIC CERAMIC CERAMIC

100PF 100PF 100PF 100PF 100PF

10% 10% 10% 10% 10%

50V 50V 50V 50V 50V

C621 C622 C623 C624 C625

1-162-282-31 1-162-282-31 1-162-282-31 1-162-290-31 1-162-294-31

CERAMIC CERAMIC CERAMIC CERAMIC CERAMIC

100PF 100PF 100PF 470PF 0.001uF

10% 10% 10% 10% 10%

50V 50V 50V 50V 50V

C626 C627 C628 C629 C630

1-124-589-11 1-162-306-11 1-162-306-11 1-162-306-11 1-162-306-11

ELECT CERAMIC CERAMIC CERAMIC CERAMIC

47uF 0.01uF 0.01uF 0.01uF 0.01uF

20% 20% 20% 20% 20%

16V 16V 16V 16V 16V

– 114 –

PANEL Ref. No.

Part No.

Description

Remark

C636 C637 C638 C639 C640

1-126-160-11 1-136-161-00 1-124-464-11 1-124-464-11 1-162-306-11

ELECT FILM ELECT ELECT CERAMIC

1uF 0.047uF 0.22uF 0.22uF 0.01uF

20% 5% 20% 20% 20%

50V 50V 50V 50V 16V

C641 C642 C643 C644 C646

1-124-464-11 1-136-159-00 1-162-302-11 1-124-464-11 1-162-293-31

ELECT FILM CERAMIC ELECT CERAMIC

0.22uF 20% 0.033uF 5% 0.0022uF 30% 0.22uF 20% 820PF 10%

50V 50V 16V 50V 50V

C647 C648 C649 C650 C653

1-124-464-11 1-162-306-11 1-124-589-11 1-124-464-11 1-162-282-31

ELECT CERAMIC ELECT ELECT CERAMIC

0.22uF 0.01uF 47uF 0.22uF 100PF

50V 16V 16V 50V 50V

C654

1-164-159-11 CERAMIC

Ref. No.

Part No.

Description

Remark

< IC > IC601 IC602

8-759-446-27 IC TMP87CH75F-6543 8-759-332-18 IC GP1U27XB < INDUCTOR >

20% 20% 20% 20% 10%

0.1uF

L601

10uH

< TRANSISTOR >

50V

< CONNECTOR > CN601 CN603 CN609

1-410-509-11 INDUCTOR

Q601 Q602 Q603 Q604 Q605

8-729-118-00 8-729-118-00 8-729-119-78 8-729-119-76 8-729-119-76

TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR

2SB1116-L 2SB1116-L 2SC403SP-51 2SA1175-HFE 2SA1175-HFE

Q606 Q607 Q608 Q609 Q623

8-729-119-76 8-729-119-76 8-729-119-76 8-729-119-76 8-729-119-76

TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR

2SA1175-HFE 2SA1175-HFE 2SA1175-HFE 2SA1175-HFE 2SA1175-HFE

1-568-860-11 SOCKET, CONNECTOR 17P 1-568-853-11 SOCKET, CONNECTOR 10P 1-691-645-11 SOCKET, CONNECTOR 9P

< RESISTOR >

< DIODE > D601 D602 D603 D604 D605

8-719-058-03 8-719-057-44 8-719-057-40 8-719-058-04 8-719-058-04

DIODE DIODE DIODE DIODE DIODE

SEL5423E-TP15 (TUNER/BAND) HLMF-K305-2UP (GROOVE ) HLMF-K305-2VB (SONIC FORMATION) SEL5223S-TP15 (EFFECT ON/OFF) SEL5223S-TP15 (JOG)

D606 D607 D608 D609 D610

8-719-057-44 8-719-057-44 8-719-057-44 8-719-057-44 8-719-057-30

DIODE DIODE DIODE DIODE DIODE

HLMF-K305-2UP (±) HLMF-K305-2UP (≠) HLMF-K305-2UP (+) HLMF-K305-2UP (–) HLMF-K205-2UL (ENTER/NEXT)

D611 D612 D614 D615 D650

8-719-056-13 8-719-056-13 8-719-057-44 8-719-058-04 8-719-987-63

DIODE DIODE DIODE DIODE DIODE

SML79423C-TP15 (AUTO BPM) SML79423C-TP15 (AUTO BPM) HLMF-K305-2UP (NON STOP) SEL5223S-TP15 (BEAT ON/OFF) 1N4148M

D651 D652 D653 D654 D655

8-719-987-63 8-719-987-63 8-719-987-63 8-719-987-63 8-719-987-63

DIODE DIODE DIODE DIODE DIODE

1N4148M 1N4148M 1N4148M 1N4148M 1N4148M

D656

8-719-987-63 DIODE 1N4148M

R601 R602 R603 R604 R605

1-247-903-00 1-247-807-31 1-249-429-11 1-249-429-11 1-249-429-11

CARBON CARBON CARBON CARBON CARBON

1M 100 10K 10K 10K

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/4W

R606 R607 R608 R609 R610

1-249-429-11 1-249-429-11 1-247-843-11 1-247-843-11 1-247-807-31

CARBON CARBON CARBON CARBON CARBON

10K 10K 3.3K 3.3K 100

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/4W

R611 R612 R613 R614 R615

1-247-807-31 1-249-429-11 1-249-415-11 1-249-431-11 1-249-429-11

CARBON CARBON CARBON CARBON CARBON

100 10K 680 15K 10K

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/4W

R616 R617 R618 R619 R620

1-249-429-11 1-247-804-11 1-247-804-11 1-249-401-11 1-249-419-11

CARBON CARBON CARBON CARBON CARBON

10K 75 75 47 1.5K

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/4W

R621 R622 R623 R624 R625

1-249-419-11 1-249-401-11 1-249-403-11 1-247-807-31 1-249-407-11

CARBON CARBON CARBON CARBON CARBON

1.5K 47 68 100 150

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/4W

R626 R627 R628 R629 R630

1-249-407-11 1-249-409-11 1-249-411-11 1-249-413-11 1-249-415-11

CARBON CARBON CARBON CARBON CARBON

150 220 330 470 680

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/4W

< INDUCTOR > FB601

1-412-473-21 INDUCTOR (SMALL TYPE) < FLUORESCENT INDICATOR TUBE >

FL601

1-517-618-11 INDICATOR TUBE, FLUORESCENT

– 115 –

PANEL Ref. No.

Part No.

Description

Remark

R631 R632 R633 R634 R635

1-249-417-11 1-249-419-11 1-249-421-11 1-249-419-11 1-249-401-11

CARBON CARBON CARBON CARBON CARBON

1K 1.5K 2.2K 1.5K 47

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/4W

R636 R637 R638 R639 R640

1-249-403-11 1-247-826-00 1-249-411-11 1-249-413-11 1-249-415-11

CARBON CARBON CARBON CARBON CARBON

68 620 330 470 680

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/4W

R641 R642 R643 R644 R645

1-249-417-11 1-249-419-11 1-249-421-11 1-247-843-11 1-249-419-11

CARBON CARBON CARBON CARBON CARBON

1K 1.5K 2.2K 3.3K 1.5K

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/4W

R646 R647 R648 R649 R650

1-249-401-11 1-249-403-11 1-247-807-31 1-249-407-11 1-249-407-11

CARBON CARBON CARBON CARBON CARBON

47 68 100 150 150

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/4W

R651 R652 R653 R654 R655

1-249-409-11 1-249-411-11 1-249-413-11 1-249-415-11 1-249-417-11

CARBON CARBON CARBON CARBON CARBON

220 330 470 680 1K

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/4W

R656 R657 R658 R659 R660

1-249-419-11 1-249-421-11 1-247-843-11 1-249-427-11 1-249-431-11

CARBON CARBON CARBON CARBON CARBON

1.5K 2.2K 3.3K 6.8K 15K

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/4W

R661 R662 R663 R664 R665

1-249-419-11 1-249-401-11 1-249-429-11 1-249-421-11 1-247-887-00

CARBON CARBON CARBON CARBON CARBON

1.5K 47 10K 2.2K 220K

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/4W

R666 R667 R668 R669 R670

1-249-421-11 1-249-409-11 1-249-409-11 1-247-807-31 1-249-406-11

CARBON CARBON CARBON CARBON CARBON

2.2K 220 220 100 120

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/4W

R671 R672 R673 R674 R675

1-249-409-11 1-249-409-11 1-249-409-11 1-249-409-11 1-249-409-11

CARBON CARBON CARBON CARBON CARBON

220 220 220 220 220

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/4W

R676 R677 R678 R679 R680

1-249-409-11 1-249-409-11 1-247-804-11 1-247-804-11 1-247-807-31

CARBON CARBON CARBON CARBON CARBON

220 220 75 75 100

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/4W

R681

1-249-409-11 CARBON

220

1/4W

Ref. No.

Part No.

Description

Remark

R685 R686 R687 R688

1-249-419-11 1-247-897-11 1-249-437-11 1-247-895-00

CARBON CARBON CARBON CARBON

1.5K 560K 47K 470K

5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W

R689 R690 R691 R692 R693

1-249-419-11 1-247-897-11 1-249-437-11 1-247-895-00 1-249-419-11

CARBON CARBON CARBON CARBON CARBON

1.5K 560K 47K 470K 1.5K

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/4W

R694 R695 R696 R698 R699

1-247-897-11 1-249-437-11 1-247-895-00 1-247-897-11 1-249-437-11

CARBON CARBON CARBON CARBON CARBON

560K 47K 470K 560K 47K

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/4W

R700 R748 R749

1-247-895-00 CARBON 1-249-435-11 CARBON 1-247-895-00 CARBON

470K 33K 470K

5% 5% 5%

1/4W 1/4W 1/4W

< SWITCH > S601 S602 S603 S604 S605

1-762-874-11 1-467-869-11 1-554-303-21 1-554-303-21 1-554-303-21

SWITCH, JOG (JOG) ENCODER, ROTARY (VOLUME) SWITCH, TACTILE (TIMER SELECT) SWITCH, TACTILE (CLOCK TIMER SET) SWITCH, TACTILE (DISPLAY/DEMO)

S606 S607 S608 S609 S610

1-554-303-21 1-554-303-21 1-554-303-21 1-554-303-21 1-554-303-21

SWITCH, TACTILE (SPECTRAM ANALYZER) SWITCH, TACTILE (DBFB) SWITCH, TACTILE (SURROUND) SWITCH, TACTILE (EDIT/DIRECTION) SWITCH, TACTILE (REPEAT/DOLBY NR)

S611 S612 S613 S614 S615

1-554-303-21 1-554-303-21 1-554-303-21 1-554-303-21 1-554-303-21

SWITCH, TACTILE (PLAY MODE) SWITCH, TACTILE (1/ALL DISCS) SWITCH, TACTILE (SLEEP) SWITCH, TACTILE (BEAT ON/OFF) SWITCH, TACTILE (LOOP)

S616 S617 S618 S619 S620

1-554-303-21 1-554-303-21 1-554-303-21 1-554-303-21 1-554-303-21

SWITCH, TACTILE (LOW FREQUENCY) SWITCH, TACTILE (HIGH FREQUENCY) SWITCH, TACTILE (ENTER/NEXT) SWITCH, TACTILE (AUTO BPM) SWITCH, TACTILE (NON STOP)

S621 S622 S623 S624 S625

1-554-303-21 1-554-303-21 1-554-303-21 1-554-303-21 1-554-303-21

SWITCH, TACTILE (WAVE) SWITCH, TACTILE (LEVEL+) SWITCH, TACTILE (LEVEL–) SWITCH, TACTILE (BEAT SELECT) SWITCH, TACTILE (BEAT SPEED)

S626 S627 S628 S629 S630

1-554-303-21 1-554-303-21 1-554-303-21 1-554-303-21 1-554-303-21

SWITCH, TACTILE (FLASH) SWITCH, TACTILE (PAD A) SWITCH, TACTILE (SONIC FORMATION) SWITCH, TACTILE (GROOVE) SWITCH, TACTILE (MEMORY)

S631 S632

1-554-303-21 SWITCH, TACTILE (P-FILE) 1-554-303-21 SWITCH, TACTILE (GAME)

– 116 –

PANEL Ref. No.

Part No.

Description

Remark

S633 S634 S635

1-554-303-21 SWITCH, TACTILE (MOVIE) 1-554-303-21 SWITCH, TACTILE (MUSIC) 1-554-303-21 SWITCH, TACTILE (EFFECT ON/OFF)

S636 S637 S638 S639 S640

1-554-303-21 1-554-303-21 1-554-303-21 1-554-303-21 1-554-303-21

S641

1-554-303-21 SWITCH, TACTILE (RDS) (RX90: AEP, G, UK, AED) 1-554-303-21 SWITCH, TACTILE (FUNCTION) 1-554-303-21 SWITCH, TACTILE (PAD B) 1-554-303-21 SWITCH, TACTILE (CHAIN)

S642 S643 S644

Ref. No.

Part No.

CN801

SWITCH, TACTILE (KARAOKE PON/MPX) SWITCH, TACTILE (TUNER/BAND) SWITCH, TACTILE (TUNER MEMORY) SWITCH, TACTILE (TUNING MODE) SWITCH, TACTILE (STEREO/MONO)

1-778-981-11 CONNECTOR, BOARD TO BOARD 13P

D801 D841 D842 D851 D901

8-719-815-85 8-719-987-63 8-719-987-63 8-719-815-85 8-719-510-68

DIODE DIODE DIODE DIODE DIODE

1S1585 1N4148M 1N4148M 1S1585 D5SBA20F01

< IC > IC801

8-749-921-04 IC STK-4211MK-2 < TRANSISTOR >

A-4398-182-A POWER AMP BOARD, COMPLETE (GR8: EA3, MY) A-4392-823-A POWER AMP BOARD, COMPLETE (GR8: EA4, TH, SAF) A-4392-376-A POWER AMP BOARD, COMPLETE (GR8: AUS, E, HK, IA, JE, MX, SP, TW) A-4392-375-A POWER AMP BOARD, COMPLETE (RX90: AEP, G, UK, AED, EE, CIS) ***************************

Remark

< DIODE >

X601 1-579-125-11 VIBRATOR, CERAMIC (8MHz) **************************************************************

Description < CONNECTOR >

< VIBRATOR >

POWER AMP

< CAPACITOR > C801 C802 C803 C804 C806

1-126-963-11 1-162-286-31 1-162-282-31 1-126-967-11 1-126-967-11

ELECT CERAMIC CERAMIC ELECT ELECT

4.7uF 220PF 100PF 47uF 47uF

20% 10% 10% 20% 20%

50V 50V 50V 10V 50V

C807 C809 C810 C811 C812

1-128-560-11 1-128-560-11 1-164-159-11 1-130-493-00 1-130-493-00

ELECT ELECT CERAMIC MYLAR MYLAR

22uF 22uF 0.1uF 0.068uF 0.068uF

20% 20% 5% 5%

100V 100V 50V 50V 50V

C814 C841 C851 C852 C853

1-162-306-11 1-126-925-11 1-126-963-11 1-162-286-31 1-162-282-31

CERAMIC ELECT ELECT CERAMIC CERAMIC

0.01uF 470uF 4.7uF 220PF 100PF

20% 20% 20% 10% 10%

16V 10V 50V 50V 50V

C854 C856 C857 C861 C862

1-126-967-11 1-126-967-11 1-128-560-11 1-130-493-00 1-130-493-00

ELECT ELECT ELECT MYLAR MYLAR

47uF 47uF 22uF 0.068uF 0.068uF

20% 20% 20% 5% 5%

10V 50V 100V 50V 50V

C901 C902 C951 C952

1-104-482-11 1-130-777-00 1-104-482-11 1-130-777-00

ELECT FILM ELECT FILM

4700uF 0.1uF 4700uF 0.1uF

20% 10% 20% 10%

63V 100V 63V 100V

Q801 Q831 Q832 Q851

8-729-140-84 8-729-900-36 8-729-119-78 8-729-140-84

TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR

2SC1841-PAFAEA DTC124ES 2SC403SP-51 2SC1841-PAFAEA

< RESISTOR > R801 R802 R803 R804 R805

1-249-417-11 1-249-437-11 1-249-413-11 1-249-437-11 1-260-107-11

CARBON CARBON CARBON CARBON CARBON

1K 47K 470 47K 4.7K

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/2W

R806 ! R807 ! R808 R809 R811

1-260-107-11 1-212-881-11 1-217-156-00 1-260-076-11 1-249-417-11

CARBON FUSIBLE WIREWOUND CARBON CARBON

4.7K 100 0.22 10 1K

5% 5% 10% 5% 5%

1/2W 1/4W 5W 1/2W 1/4W

R812 R813 R814 R816 ! R820 R831

1-249-431-11 1-249-441-11 1-260-103-11 1-260-103-11 1-202-972-61 1-249-441-11

CARBON CARBON CARBON CARBON FUSIBLE CARBON

15K 100K 2.2K 2.2K 1 100K

5% 5% 5% 5% 5% 5%

1/4W 1/4W 1/2W 1/2W 1/4W 1/4W

R832 R833 R841 R842 R843

1-249-441-11 1-249-441-11 1-249-425-11 1-247-884-11 1-249-421-11

CARBON CARBON CARBON CARBON CARBON

100K 100K 4.7K 160K 2.2K

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/4W

R844 R851 R852 R853 R854

1-249-429-11 1-249-417-11 1-249-437-11 1-249-413-11 1-249-437-11

CARBON CARBON CARBON CARBON CARBON

10K 1K 47K 470 47K

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/4W

R855 R856 ! R857 ! R858 R859

1-260-107-11 1-260-107-11 1-212-881-11 1-217-156-00 1-260-076-11

CARBON CARBON FUSIBLE WIREWOUND CARBON

4.7K 4.7K 100 0.22 10

5% 5% 5% 10% 5%

1/2W 1/2W 1/4W 5W 1/2W

– 117 –

The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified.

F F

POWER AMP Ref. No. R861 R862 R863

Part No.

SENSOR

TC SW

Description

1-249-417-11 CARBON 1-249-431-11 CARBON 1-249-441-11 CARBON

TCB

Remark 1K 15K 100K

5% 5% 5%

1/4W 1/4W 1/4W

< THERMISTOR > TH801 1-807-796-11 THERMISTOR ************************************************************** 1-658-576-11 SENSOR BOARD *************

Ref. No.

Part No.

Description

R736 R737 R738 R739 R740

1-249-421-11 1-247-843-11 1-249-427-11 1-249-431-11 1-247-807-31

CARBON CARBON CARBON CARBON CARBON

2.2K 3.3K 6.8K 15K 100

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/4W

R741 R742 R743 R744 R745

1-247-807-31 1-247-807-31 1-249-409-11 1-247-807-31 1-247-807-31

CARBON CARBON CARBON CARBON CARBON

100 100 220 100 100

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/4W

< IC > IC702 IC703

< SWITCH >

8-749-924-18 IC PHOTO INTERRUPTER RPI-1391 8-749-924-30 IC PHOTO REFLECTOR GP2S28 < RESISTOR >

R701 R702

1-249-416-11 CARBON 1-249-407-11 CARBON

820 150

5% 5%

1/4W 1/4W

************************************************************** 1-664-024-11 TC SW BOARD ************

S655 S656 S657 S658 S659

1-554-303-21 1-554-303-21 1-554-303-21 1-554-303-21 1-554-303-21

SWITCH, TACTILE (·: DECK B) SWITCH, TACTILE (ª: DECK B) SWITCH, TACTILE (): DECK B) SWITCH, TACTILE (0: DECK B) SWITCH, TACTILE (p: DECK B)

S660 S661 S662 S663 S664

1-554-303-21 1-554-303-21 1-554-303-21 1-554-303-21 1-554-303-21

SWITCH, TACTILE (P: PAUSE) SWITCH, TACTILE (r: REC) SWITCH, TACTILE (CD SYNCHRO) SWITCH, TACTILE (HIGH SPEED DUBBING) SWITCH, TACTILE (): DECK A)

S665 1-554-303-21 SWITCH, TACTILE (0: DECK A) S666 1-554-303-21 SWITCH, TACTILE (p: DECK A) S667 1-554-303-21 SWITCH, TACTILE (·: DECK A) S668 1-554-303-21 SWITCH, TACTILE (ª:DECK A) **************************************************************

< CONNECTOR > CN607

Remark

1-506-486-11 PIN, CONNECTOR 7P < DIODE >

D634 D635 D636 D637 D638

8-719-063-92 8-719-063-92 8-719-063-91 8-719-063-93 8-719-063-92

DIODE DIODE DIODE DIODE DIODE

D639

8-719-063-92 DIODE SLR325MC-M-T31-NP (ª: DECK A)

A-4303-508-A TCB BOARD, COMPLETE (GR8: JE) A-4303-571-A TCB BOARD, COMPLETE (RX90: AEP, G, UK, AED) A-4303-570-A TCB BOARD, COMPLETE (RX90: EE, CIS) ********************

SLR325MC-M-T31-NP (·: DECK B) SLR325MC-M-T31-NP (ª: DECK B) SLR325DC-P-T32 (P PAUSE) SLR325VC-N-T32 (r REC) SLR325MC-M-T31-NP (·: DECK A)

< CAPACITOR > C1

1-163-141-00 CERAMIC CHIP

0.001uF 5%

1-101-004-00 CERAMIC

1-163-031-11 CERAMIC (2012)

C10

1-163-031-11 CERAMIC (2012)

C11

1-163-038-91 CERAMIC (2012)

0.01uF 50V (GE8: JE/RX90: EE, CIS) 10000PF 50V (GR8: JE/RX90) 10000PF 50V (GR8: JE/RX90) 10000PF 50V (GR8: JE/RX90) 100000PF 25V (GR8: JE)

< TRANSISTOR > C2 Q617 Q618 Q619

8-729-119-76 TRANSISTOR 2SA1175-HFE 8-729-119-76 TRANSISTOR 2SA1175-HFE 8-729-119-76 TRANSISTOR 2SA1175-HFE

C3 C5

< RESISTOR > C6 R726 R727 R728 R729 R730

1-249-403-11 1-247-807-31 1-249-407-11 1-249-407-11 1-249-409-11

CARBON CARBON CARBON CARBON CARBON

68 100 150 150 220

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/4W

R731 R732 R733 R734 R735

1-249-411-11 1-249-413-11 1-249-415-11 1-249-417-11 1-249-419-11

CARBON CARBON CARBON CARBON CARBON

330 470 680 1K 1.5K

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/4W

– 118 –

50V (GR8: JE/RX90) 1-126-967-11 ELECT 47uF 20% 16V (GR8: JE/RX90) 1-163-038-91 CERAMIC (2012) 100000PF 25V (GR8: JE/RX90) 1-163-031-11 CERAMIC (2012) 10000PF 50V (GR8: JE/RX90) 1-163-038-91 CERAMIC (2012) 100000PF 25V (GR8: JE/RX90)

TCB Ref. No.

Part No.

Description

Remark

C14

1-163-038-91 CERAMIC (2012) 100000PF

C15

1-163-162-00

C16

1-163-038-91

C17

1-163-031-11

C18

1-163-088-11

C19 C21

1-163-249-11 CHIP CERAMIC (2012) 82PF (RX90) 1-163-141-00 CERAMIC CHIP 0.001uF 5% 50V (GR8: JE/RX90) 1-163-031-11 CERAMIC (2012) 10000PF 50V (GR8: JE/RX90) 1-163-235-11 CHIP CERAMIC (2012) 22PF 5% 50V (GR8: JE/RX90) 1-163-239-11 CHIP CERAMIC (2012) 33PF 5% 50V (GR8: JE/RX90)

C22 C23 C24

25V (GR8: JE) FILM 0.056uF 5% 50V (GR8: JE) CERAMIC (2012) 100000PF 25V (GR8: JE/RX90) CERAMIC (2012) 10000PF 50V (GR8: JE) CERAMIC CHIP (2012) 5PF 50V (GR8: JE)

C26

1-126-967-11 ELECT

C28

1-126-967-11

C29

1-162-306-11

C30

1-126-961-11

C31

1-163-031-11

47uF

20% 16V (GR8: JE/RX90) ELECT 47uF 20% 16V (GR8: JE/RX90) CERAMIC 0.01uF 20% 16V (GR8: JE/RX90) ELECT 2.2uF 20% 50V (GR8: JE/RX90) CERAMIC (2012) 10000PF 50V (GR8: JE/RX90) 25V (GR8: JE/RX90) CERAMIC (2012) 100000PF 25V (GR8: JE/RX90) CHIP CERAMIC (2012) 12PF 5% 50V (RX90) CHIP CERAMIC (2012) 8PF 50V (GR8: JE) CERAMIC (2012) 100000PF 25V (GR8: JE/RX90)

Ref. No.

Part No.

Description

Remark

C44

1-163-031-11 CERAMIC (2012) 10000PF

C45

1-163-038-91 CERAMIC (2012) 100000PF

C46

1-163-077-00 CERAMIC CHIP

C47

1-126-967-11

C48

1-163-031-11

C49

1-126-959-11

C50

1-126-960-11

C51

1-126-960-11 ELECT

1uF

C52

1-126-963-11 ELECT

4.7uF

C52

1-126-964-11 ELECT

10uF

C53

1-126-964-11 ELECT

10uF

C54

1-104-396-11 ELECT

10uF

C55

1-104-396-11 ELECT

10uF

C56

1-104-396-11 ELECT

C57

1-163-017-00 CERAMIC CHIP

0.1uF

10% 25V (GR8: JE/RX90) ELECT 47uF 20% 16V (GR8: JE/RX90) CERAMIC (2012) 10000PF 50V (GR8: JE/RX90) ELECT 0.47uF 20% 50V (GR8: JE/RX90) ELECT 1uF 20% 50V (GR8: JE/RX90)

1-163-038-91 CERAMIC (2012) 100000PF

C58

1-163-017-00 CERAMIC CHIP

C33

1-163-038-91

C59

1-163-989-11 CERAMIC CHIP

C34

1-163-229-11

C60

1-163-989-11 CERAMIC CHIP

C34

1-163-229-11

C61

1-126-301-11 ELECT

C35

1-163-038-91

C62

1-163-141-00 CERAMIC CHIP

C63

1-163-017-00 CERAMIC CHIP

C64

1-126-967-11 ELECT

C65

1-163-031-11 CERAMIC (2012) 10000PF

C66

1-126-162-11 ELECT

3.3uF

C67

1-126-933-11 ELECT

100uF

C68

1-162-306-11 CERAMIC

0.01uF

C71

1-162-306-11 CERAMIC

0.01uF

1-163-141-00 CERAMIC CHIP

C37

1-163-141-00

C38

1-162-211-31

C39

1-163-141-00

C40

1-163-031-11

0.001uF 5%

50V (GR8: JE/RX90) CERAMIC CHIP 0.001uF 5% 50V (GR8: JE/RX90) CERAMIC (2012) 33PF 5% 50V (GR8: JE) CERAMIC CHIP 0.001uF 5% 50V (GR8: JE/RX90) CERAMIC (2012) 10000PF 50V (GR8: JE/RX90)

C41

1-163-031-11 CERAMIC (2012) 10000PF

C42

1-163-038-91 CERAMIC (2012) 100000PF

C43

1-163-038-91 CERAMIC (2012) 100000PF

50V (GR8: JE/RX90) 25V (GR8: JE/RX90) 25V (GR8: JE/RX90)

– 119 –

20% 50V (GR8: JE/RX90) 20% 50V (RX90) 20% 50v (GR8: JE) 20% 50v (GR8: JE/RX90) 20% 16V (GR8: JE/RX90)

20% 16V (GR8: JE/RX90) 10uF 20% 16V (GR8: JE/RX90) 0.0047uF 5% 50V (GR8: JE/RX90) 0.0047uF 5% 50V (GR8: JE/RX90) 0.033uF 10% 25V (GR8: JE/RX90)

C32

C36

50V (GR8: JE/RX90) 25V (GR8: JE/RX90)

0.033uF 10% 25V (GR8: JE/RX90) 1uF 20% 50V (GR8: JE/RX90) 0.001uF 5% 50V (GR8: JE/RX90) 0.0047uF 5% 50V (GR8: JE/RX90) 47uF 20% 16V (GR8: JE/RX90) 50V (GR8: JE/RX90) 20% 50V (GR8: JE/RX90) 20% 10V (GR8: JE/RX90) 20% 16V (GR8: JE/RX90) 20% 16V (GR8: JE/RX90)

TCB Ref. No.

Part No.

Description

C72

1-126-967-11 ELECT

C120

1-163-105-00 CERAMIC CHIP

C1701

1-162-294-31 CERAMIC

C1702

1-130-014-00 PP FILM

C1703

1-126-959-11 ELECT

Remark 47uF

1-126-964-11 ELECT

C1756

1-126-961-11 ELECT

C1757

1-162-288-31 CERAMIC

0.47uF

C1760

C1705

1-163-035-00 CERAMIC CHIP

C1706

1-126-960-11 ELECT

C1707

1-163-129-00 CERAMIC CHIP

C1710

1-163-141-00 CERAMIC CHIP

C1711

1-163-141-00 CERAMIC CHIP

0.001uF 5%

C1712

1-130-736-11 PP FILM

0.01uF

C1713

1-130-736-11 PP FILM

0.01uF

C1714

1-126-960-11 ELECT

1uF

C1715

1-126-960-11 ELECT

1uF

20% 50V (RX90: EE, CIS) 0.047uF 50V (RX90: EE, CIS) 1uF 20% 50V (RX90: EE, CIS) 330P 5% 50V (RX90: EE, CIS) 0.001uF 5% 50V (RX90: EE, CIS)

C1716

1-126-960-11 ELECT

1uF

C1719

1-126-967-11 ELECT

47uF

C1720

1-163-031-11 CERAMIC CHIP

0.01uF

C1723

1-163-031-11 CERAMIC CHIP

0.01uF

C1724

1-163-031-11 CERAMIC CHIP

0.01uF

C1725

1-126-967-11 ELECT

47uF

C1726

1-126-960-11 ELECT

C1727

1-126-960-11 ELECT

C1728

1-126-966-11 ELECT

C1751

1-164-159-21 CERAMIC

C1753

1-262-964-11 ELECT

C1754

1-162-291-31 CERAMIC

Description

C1755

1-126-959-11 ELECT

1-126-967-11 ELECT

Part No.

20% 16V (GR8: JE/RX90) 33PF 5% 50V (RX90: AEP, G, UK AED) 0.001uF 10% 50V (RX90: EE, CIS) 470PF 5% 16V (RX90: EE, CIS) 0.47uF 20% 50V (RX90: EE, CIS)

C1704

C1752

Ref. No.

50V (RX90: EE, CIS) 5% 16V (RX90: EE, CIS) 5% 16V (RX90: EE, CIS) 20% 50V (RX90: EE, CIS) 20% 50V (RX90: EE, CIS) 20% 50V (RX90: EE, CIS) 20% 16V (RX90: EE, CIS) 50V (RX90: EE, CIS) 50V (RX90: EE, CIS) 50V (RX90: EE, CIS)

20% 16V (RX90: EE, CIS) 1uF 20% 50V (RX90: EE, CIS) 1uF 20% 50V (RX90: EE, CIS) 33uF 20% 16V (RX90: EE, CIS) 0.01uF 50V (RX90: AEP, G, UK, AED) 47uF

20% 16V (RX90: AEP, G, UK, AED) 10uF 20% 50V (RX90: AEP, G, UK, AED) 560PF 10% 50V (RX90: AEP, G, UK, AED)

C1758 C1759

C1761

C1762

Remark 10uF

20% 50V (RX90: AEP, G, UK, AED) 2.2uF 20% 50V (RX90: AEP, G, UK, AED)

330PF 10% 50V (RX90: AEP, G, UK, AED) 1-163-031-11 CERAMIC (2012) 10000PF 50V (RX90: AEP, G, UK, AED) 1-163-135-00 CERAMIC CHIP 560PF 5% 50V (RX90: AEP, G, UK, AED) 1-163-031-11 CERAMIC (2012) 10000PF 50V (RX90: AEP, G, UK, AED) 1-163-243-11 CERAMIC CHIP 47PF 5% 50V (RX90: AEP, G, UK, AED) 1-163-249-11 CERAMIC CHIP

82PF

5% 50V (RX90: AEP, G, UK, AED)

< CERAMIC FILTER > CF1 CF1 CF2 CF3 CF3

1-567-389-11 1-579-374-11 1-760-393-11 1-567-389-11 1-760-393-11

FILTER, CERAMIC (GR8: JE/RX90: EE, CIS) FILTER, CERAMIC (RX90: AEP, G, UK, AED) FILTER, CERAMIC (RX90: AEP, G, UK, AED) FILTER, CERAMIC (GR8: JE/RX90: EE, CIS) FILTER, CERAMIC (RX90: AEP, G, UK, AED) < CONNECTOR >

* CN1

1-568-834-11 SOCKET, CONNECTOR 15P (GR8: JE/RX90) < TRIMMER >

CT1701 1-141-444-11 CAP, CERAMIC TRIMMER 50PF (RX90: EE, CIS) CV1 1-141-227-00 CAP, TRIMMER 20PF (GR8: JE) CV2 1-141-227-00 CAP, TRIMMER 20PF (GR8: JE) < DIODE > D1 D21 D41 D42 D42

8-719-976-30 8-719-976-99 8-719-016-74 8-719-987-63 8-719-016-74

DIODE DIODE DIODE DIODE DIODE

KV1560NT (GR8: JE) UDZ-TE-17-5.1B (GR8: JE/RX90) 1SS352-TPH3 (GR8: JE/RX90) 1N4148M-TA (RX90: AEP, G, UK, AED) 1SS352-TPH3 (RX90: EE, CIS)

D43 D1701 D1702 D1703 D1704

8-719-016-74 8-719-016-74 8-719-016-74 8-719-987-63 8-719-016-74

DIODE DIODE DIODE DIODE DIODE

1SS352-TPH3 (RX90: EE, CIS) 1SS352-TPH3 (RX90: EE, CIS) 1SS352-TPH3 (RX90: EE, CIS) 1N4148M-TA (RX90: EE, CIS) 1SS352-TPH3 (RX90: EE, CIS)

D1751

8-719-016-74 DIODE 1SS352-TPH3 (RX90: AEP, G, UK, AED) < TUNER UNIT >

FE1 FE1 FE1 FE2 FE2

– 120 –

1-693-251-11 1-693-357-11 1-693-335-11 1-233-262-11 1-233-514-11

FRONT END (GR8: JE) FRONT END (4 GANG) (RX90: AEP, G, UK, AED) FRONT END (3 GANG) (RX90: EE, CIS) ENCAPSULATED COMPONENT (GR8: JE) ENCAPSULATED COMPONENT (RX90)

TCB Ref. No.

Part No.

Description

Remark

Ref. No.

Part No.

< IC > IC21 IC41 IC1701 IC1702 IC1751

8-759-288-54 8-759-176-03 8-759-063-04 8-759-140-53 8-759-963-51

IC IC IC IC IC

IC1752

8-759-450-86 IC BU1922 (RX90: AEP, G, UK, AED)

Remark

< TRANSISTOR >

LC72130 (GR8: JE/RX90) LA1835 (GR8: JE/RX90) IR3R42 (RX90: EE, CIS) MC14053BCP (RX90: EE, CIS) NJM4558D (RX90: AEP, G, UK, AED)

Q1 Q2 Q3 Q4 Q5

8-729-201-27 8-729-201-27 8-729-201-27 8-729-201-27 8-729-424-08

Q8 Q9 Q10 Q11 Q12

8-729-033-67 TRANSISTOR 2SK211-Y-TE85L (GR8: JE) 8-729-216-22 TRANSISTOR 2SA812-T1-M5M6 (GR8: JE/RX90) 8-729-216-22 TRANSISTOR 2SA812-T1-M5M6 (GR8: JE) 8-729-421-22 TRANSISTOR MUN2211T1 (RX90) 8-729-421-22 TRANSISTOR MUN2211T1 (GR8: JE/RX90)

Q13 Q14 Q1701 Q1702 Q1703

8-729-421-22 8-729-421-22 8-729-424-08 8-729-907-00 8-729-421-22

< IFT > IFT41

Description

1-409-636-11 TRANSFORMER,IF (CERAMIC FILTER) (GR8: JE/RX90) < CHIP CONDUCTOR >

TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR

2SC2715Y-TE85L (GR8: JE/RX90) 2SC2715Y-TE85L (GR8: JE/RX90) 2SC2715Y-TE85L (GR8: JE/RX90) 2SC2715Y-TE85L (GR8: JE/RX90) MUN2111T1 (GR8: JE/RX90)

MUN2211T1 (GR8: JE/RX90) MUN2211T1 (GR8: JE/RX90) MUN2111T1 (RX90: EE, CIS) RT1N141M-TP-1 (RX90: EE, CIS) MUN2211T1 (RX90: EE, CIS)

JR2 JR6 JR8 JR9 JR45

1-216-295-91 1-216-295-91 1-216-295-91 1-216-295-91 1-216-295-91

CONDUCTOR, CHIP (2012) (RX90) CONDUCTOR, CHIP (2012) (RX90) CONDUCTOR, CHIP (2012) (RX90) CONDUCTOR, CHIP (2012) (RX90) CONDUCTOR, CHIP (2012) (GR8: JE)

JR46 JR47 JR48 JR49 JR50

1-216-296-91 1-216-295-91 1-216-295-91 1-216-296-91 1-216-295-91

CONDUCTOR, CHIP (3216) (GR8: JE/RX90) CONDUCTOR, CHIP (2012) (GR8: JE/RX90) CONDUCTOR, CHIP (2012) (GR8: JE/RX90) CONDUCTOR, CHIP (3216) (GR8: JE/RX90) CONDUCTOR, CHIP (2012) (GR8: JE)

1-249-401-11 CARBON

1-216-037-00 METAL CHIP

330

1-216-037-00 METAL CHIP

330

JR51 JR52 JR53 JR54 JR1701

1-216-295-91 1-216-295-91 1-216-296-91 1-216-295-91 1-216-295-91

CONDUCTOR, CHIP (2012) (GR8: JE/RX90) CONDUCTOR, CHIP (2012) (GR8: JE/RX90) CONDUCTOR, CHIP (3216) (GR8: JE/RX90) CONDUCTOR, CHIP (2012) (GR8: JE/RX90) CONDUCTOR, CHIP (2012) (RX90: EE, CIS)

1-216-037-00 METAL CHIP

330

1-216-081-00 METAL CHIP

22K

1-216-037-00 METAL CHIP

330

JR1702 JR1703 JR1704 JR1705

1-216-295-91 1-216-295-91 1-216-295-91 1-216-295-91

CONDUCTOR, CHIP (2012) (RX90: EE, CIS) CONDUCTOR, CHIP (2012) (RX90: EE, CIS) CONDUCTOR, CHIP (2012) (RX90: EE, CIS) CONDUCTOR, CHIP (2012) (RX90: EE, CIS)

1-216-037-00 METAL CHIP

330

1-216-081-00 METAL CHIP

22K

R10

1-216-037-00 METAL CHIP

330

R11

1-216-081-00 METAL CHIP

22K

R12

1-216-037-00 METAL CHIP

330

R13

1-216-037-00 METAL CHIP

330

R14

1-216-081-00 METAL CHIP

22K

R18

1-216-065-00 METAL CHIP

4.7K

R18

1-216-073-00 METAL CHIP

10K

R19

1-216-073-00 METAL CHIP

10K

R21

1-216-049-00 METAL CHIP

< RESISTOR >

< INDUCTOR > L1 L2

L41

1-410-521-11 INDUCTOR, MICRO 100uH (GR8: JE) 1-414-142-11 INDUCTOR, MICRO 10uH (RX90: AEP, G, UK, AED) 1-410-521-11 INDUCTOR, MICRO 100uH (GR8: JE/RX90) 1-410-515-11 INDUCTOR, MICRO 33uH (RX90: AEP, G, UK, AED) 1-410-119-11 MICRO INDUCTOR 1mH (GR8: JE)

L41 L1701

1-407-500-00 MICRO INDUCTOR 1-409-497-11 COIL

L3 L4

L1751

4.7mH (RX90) 5.19mH (FILTER) (RX90: EE, CIS) 1-410-521-11 INDUCTOR, MICRO 100uH (RX90: AEP, G, UK, AED) < LOW-PASS FILTER >

LPF41 LPF42

1-239-845-11 FILTER, LOW-PASS 1-239-845-11 FILTER, LOW-PASS

– 121 –

1/4W (GR8: JE/RX90) 1/10W (GR8: JE/RX90) 1/10W (GR8: JE/RX90) 1/10W (GR8: JE/RX90) 1/10W (GR8: JE/RX90) 1/10W (GR8: JE/RX90) 1/10W (GR8: JE/RX90) 1/10W (GR8: JE/RX90) 1/10W (GR8: JE/RX90) 1/10W (GR8: JE/RX90) 1/10W (GR8: JE/RX90) 1/10W (GR8: JE/RX90) 1/10W (GR8: JE/RX90) 1/10W (GR8: JE) 1/10W (RX90)

1/10W (GR8: JE/RX90) 1K 5% 1/10W (GR8: JE/RX90: AEP, G, UK, AED)

TCB Ref. No.

Part No.

Description

R21

1-249-417-11 CARBON

R22

1-216-049-00 METAL CHIP

R22

1-249-417-11 CARBON

R23

1-216-049-00 METAL CHIP

R23

1-249-417-11 CARBON

R24

1-216-025-91 CHIP (2012)

R25

1-249-417-11 CARBON

R26

1-249-437-11 CARBON

Remark 1K

1/4W (RX90: EE, CIS) 1K 5% 1/10W (GR8: JE/RX90: AEP, G, UK, AED) 1K 5% 1/4W (RX90: EE, CIS)

Ref. No.

Part No.

Description

Remark

1K 5% 1/10W (GR8: JE/RX90: AEP, G, UK, AED) 1K 5% 1/4W (RX90: EE, CIS) 100 5% 1/10W (GR8: JE/RX90) 1K 5% 1/4W (GR8: JE/RX90) 47K 5% 1/4W (GR8: JE/RX90)

R27

1-249-429-11 CARBON

10K

R28

1-249-417-11 CARBON

R29

1-216-061-00 METAL CHIP

3.3K

R30

1-216-186-00 CHIP (3216)

330

R31

1-216-025-91 CHIP (2012)

100

R32

1-249-425-11 CARBON

4.7K

R33

1-249-425-11 CARBON

4.7K

R34

1-216-065-00 METAL CHIP

4.7K

R35

1-216-214-00 CHIP (3216)

4.7K

R36

1-216-025-91 CHIP (2012)

100

R37

1-216-073-00 METAL CHIP

10K

R38

1-216-089-91 CHIP (2012)

47K

R39

1-249-429-11 CARBON

10K

R42

1-216-073-00 METAL CHIP

10K

R43

1-216-042-00 METAL CHIP

510

R44

1-216-021-00 METAL CHIP

R44

1-216-013-00 METAL CHIP

R45

1-247-843-11 CARBON (SMALL) 3.3K

R46

1-216-073-00 METAL CHIP

10K

R47

1-216-097-91 CHIP (2012)

100K

1/4W (GR8: JE/RX90) 1/4W (GR8: JE/RX90) 1/10W (GR8: JE/RX90) 1/8W (GR8: JE/RX90) 1/10W (GR8: JE/RX90)

R48

1-247-843-11 CARBON

3.3K

R48

1-249-417-11 CARBON

R49

1-216-061-00 CHIP (2012)

3.3K

R49

1-216-049-91 CHIP (2012)

1.0K

R50

1-216-065-00 METAL CHIP

4.7K

R51

1-216-065-00 METAL CHIP

4.7K

R53

1-249-429-11 CARBON

R54

1-249-399-11 CARBON

R55

1-216-162-00 CHIP (3216)

R56

1-249-393-11 CARBON

R91

1-216-065-00 METAL CHIP

4.7K

R91 R92

1-216-295-91 CONDUCTOR, CHIP (2012) (RX90) 1-216-073-00 METAL CHIP 10K 5% 1/10W (GR8: JE/RX90) 1-216-073-00 METAL CHIP 10K 5% 1/10W (GR8: JE) 1-216-073-00 METAL CHIP 10K 5% 1/10W (GR8: JE/RX90: AEP, G, UK, AED)

R93 1/4W (GR8: JE/RX90) 1/4W (GR8: JE/RX90) 1/10W (GR8: JE/RX90) 1/8W (GR8: JE/RX90) 1/10W (GR8: JE/RX90) 1/10W (GR8: JE/RX90) 1/10W (GR8: JE/RX90) 1/4W (GR8: JE/RX90) 1/10W (GR8: JE/RX90) 1/10W (GR8: JE/RX90) 1/10W (GR8: JE) 1/10W (RX90) 1/4W (GR8: JE/RX90) 1/10W (GR8: JE/RX90) 1/10W (GR8: JE/RX90)

R94

1/10W (GR8: JE/RX90) 10K 5% 1/4W (GR8: JE/RX90) 33K 5% 1/4W (GR8: JE/RX90: AEP, G, UK, AED) 33 5% 1/8W (GR8: JE/RX90) 10 5% 1/4W (GR8: JE/RX90)

R99

1-249-399-11 CARBON

R1701

1-216-081-00 METAL CHIP

22K

R1702

1-216-085-00 METAL CHIP

33K

R1703

1-216-069-00 METAL CHIP

6.8K

R1704

1-216-075-00 METAL CHIP

12K

R1705

1-216-049-91 METAL CHIP

R1706

1-216-049-91 METAL CHIP

R1707

1-216-097-91 METAL CHIP

100K

R1708

1-216-095-00 METAL CHIP

82K

R1709

1-216-089-91 METAL CHIP

47K

R1710

1-216-073-00 METAL CHIP

10K

R1711

1-249-429-11 CARBON

10K

R1714

1-216-067-00 METAL CHIP

5.6K

– 122 –

1/4W (GR8: JE) 1/4W (RX90) 1/10W (GR8: JE) 1/10W (RX90) 1/10W (GR8: JE/RX90)

1/10W (GR8: JE)

1/4W (RX90) 1/10W (RX90: EE, CIS) 1/10W (RX90: EE, CIS) 1/10W (RX90: EE, CIS) 1/10W (RX90: EE, CIS) 1/10W (RX90: EE, CIS) 1/10W (RX90: EE, CIS) 1/10W (RX90: EE, CIS) 1/10W (RX90: EE, CIS) 1/10W (RX90: EE, CIS)

1/10W (RX90: EE, CIS) 5% 1/4W (RX90: EE, CIS) 5% 1/10W (RX90: EE, CIS)

TRANS

TCB Ref. No.

Part No.

Description

Remark

R1715

1-216-067-00 METAL CHIP

5.6K

1/10W (RX90: EE, CIS) 5% 1/10W (RX90: EE, CIS)

R1716

1-216-097-91 METAL CHIP

100K

R1717

1-216-097-91 METAL CHIP

100K

R1718

1-249-429-11 CARBON

10K

R1719

1-216-097-91 METAL CHIP

100K

R1720

1-249-434-11 CARBON

27K

R1721

1-216-073-00 METAL CHIP

10K

R1751

1-247-807-31 CARBON

R1752

1-216-073-00 METAL CHIP

R1753

1-216-067-00 METAL CHIP

R1754

1-216-097-91 METAL CHIP

R1755

1-216-097-91 METAL CHIP

100K 5% 1/4W (RX90: AEP, G, UK, AED) 10K 5% 1/10W (RX90: AEP, G, UK, AED) 5.6K 5% 1/10W (RX90: AEP, G, UK, AED) 100K 5% 1/10W (RX90: AEP, G, UK, AED) 100K 5% 1/10W (RX90: AEP, G, UK, AED)

Ref. No.

Part No.

Description

1-664-026-11 TRANS BOARD ************

Remark

< CONNECTOR >

R1756

1-249-401-11 CARBON

R1757

1-216-057-00 METAL CHIP

1/10W (RX90: EE, CIS) 1/4W (RX90: EE, CIS) 1/10W (RX90: EE, CIS) 1/4W (RX90: EE, CIS) 1/10W (RX90: EE, CIS)

5% 1/4W (RX90: AEP, G, UK, AED) 2.2K 5% 1/10W (RX90: AEP, G, UK, AED)

* CN901 * CN902 CN903

< FUSE > ! F901 ! F902

T1 T2

1-238-601-11 1-238-600-11 1-238-600-11 1-238-599-11

FH901 FH902 FH951 FH952

1-533-223-11 HOLDER, FUSE (EXCEPT GR8: MX) 1-533-223-11 HOLDER, FUSE (GR8: EA3, E, HK, IA, JE, MX, SP, TW) 1-533-223-11 HOLDER, FUSE (EXCEPT GR8: MX) 1-533-223-11 HOLDER, FUSE (GR8: EA3, E, HK, IA, JE, MX, SP, TW) < RESISTOR >

! R901 ! R902 ! R903 ! R904

1-219-120-11 1-219-120-11 1-219-120-11 1-219-120-11

FUSIBLE FUSIBLE FUSIBLE FUSIBLE

0.15 0.15 0.15 0.15

5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W

ADJ, CARBON 22K (GR8: JE/RX90) ADJ, CARBON 10K (GR8: JE/RX90) ADJ, CARBON 10K (RX90: EE, CIS) ADJ, CARBON 4.7K (RX90: EE, CIS)

! S901

< COIL >

! T901

1-572-675-11 SWITCH, POWER VOLTAGE CHANGE (VOLTAGE SELECTOR) (GR8: EA3, E, HK, IA, JE, SP, TW) < TRANSFORMER >

1-429-994-11 TRANSFORMER, POWER (RX90: AEP, AED, EE, CIS, G, UK) ! T901 1-429-995-11 TRANSFORMER, POWER (GR8: E, EA4, HK, IA, MX, SAF, SP, TH, TW, AUS, JE) ! T901 1-429-995-21 TRANSFORMER, POWER (GR8: EA3, MY) **************************************************************

1-409-505-11 COIL (ANT. SW3) (GR8: JE) 1-402-960-11 COIL (0SC. SW3) (GR8: JE)

1-537-238-21 TERMINAL BOARD (ANT) (ANTENNA) (GR8: JE) 1-537-488-11 TERMINAL BOARD (ANT) (ANTENNA) (RX90) < VIBRATOR >

X21 X41 X42 X43

F F F F

< SWITCH >

< TERMINAL > TM1 TM1

1-532-203-00 FUSE, TIME-LAG (2A, 250V) (EXCEPT GR8: MX) 1-532-350-00 FUSE, TIME-LAG (4A, 250V) (GR8: EA3, E, HK, IA, JE, MX, SP, TW) < FUSE HOLDER >

< VARIABLE RESISTOR > RV41 RV42 RV1701 RV1702

1-564-522-11 PLUG, CONNECTOR 7P 1-564-518-11 PLUG, CONNECTOR 3P 1-564-321-00 PIN, CONNECTOR 2P

1-760-549-11 1-760-220-11 1-527-981-00 1-577-075-11

VIBRATOR, CRYSTAL (4.5MHz) (GR8: JE/RX90) FILTER, CERAMIC (10.7MHz) (GR8: JE/RX90) FILTER, CERAMIC (450kHz) (GR8: JE/RX90) OSCILLATOR, CERAMIC (456kHz) (GR8: JE/RX90) X1751 1-579-900-21 VIBRATOR, CRYSTAL (4.332MHz) (RX90: AEP, G, UK, AED) **************************************************************

– 123 –

The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified.

HCD-GR8/RX90

Ref. No.

Part No.

Description

Remark

Ref. No.

Part No.

MISCELLANEOUS ************** 1-773-160-11 1-769-947-11 1-777-869-11 1-777-936-11 1-773-051-11

74 104 106

1-769-909-11 WIRE (FLAT TYPE) (9 CORE) 1-777-870-11 WIRE (FLAT TYPE) (19 CORE) 1-233-545-11 ENCAPSULATED COMPONENT (GR8:E2, EA4, MX, TH, AUS) 1-233-546-11 ENCAPSULATED COMPONENT (GR8:E3, EA3, HK, IA, MY, SAF, SP, TW) 1-751-086-11 WIRE (FLAT TYPE) (13 CORE) (GR8:E2, EA4, MX, TH, AUS)

108

108 ! 113 ! 115 ! 116 ! 117 ! 118 ! 119 ! 120 ! 121 257

WIRE (FLAT TYPE) (21 CORE) WIRE (FLAT TYPE) (11 CORE) WIRE (FLAT TYPE) (10 CORE) WIRE (FLAT TYPE) (5 CORE) WIRE (FLAT TYPE) (17 CORE)

1-773-012-11 WIRE (FLAT TYPE) (15 CORE) (GR8: E3, EA3, HK, IA, MY, SAF, SP, TW, JE,/ RX90) 1-751-326-31 CORD, POWER (TH) 1-777-462-11 CORD, POWER (E, IA, MX, JE) 1-569-007-11 ADAPTOR, CONVERSION 2P (E3, IA, JE) 1-569-008-11 ADAPTOR, CONVERSION 2P (EA3, SP, TW)

#1 #2 #3 #4 #5

7-685-871-01 7-685-647-79 7-685-650-79 7-685-646-79 7-621-775-10

SCREW +BVTT 3X6 (S) SCREW +BVTP 3X10 TYPE2 N-S SCREW +BVTP 3X16 TYPE2 IT-3 SCREW +BVTP 3X8 TYPE2 N-S SCREW +B 2.6X4

#6 #7 #8 #9 #10

7-621-255-15 7-685-533-19 7-685-131-19 7-685-862-09 7-685-534-19

SCREW +P 2X3 SCREW +BTP 2.6X6 TYPE2 N-S SCREW +BTP 2.6X4 TYPE2 N-S SCREW +BVTT 2.6X6 (S) SCREW +BTP 2.6X8 TYPE2 N-S

#11 7-623-921-01 RING, RETAINING, CAPSTAN #12 7-621-775-00 SCREW +B 2.6X3 #13 7-685-872-09 SCREW +BVTT 3X8 (S) ************************************************************

1-575-651-11 CORD, POWER (AEP, AED, EE, CIS, G, EA3, EA4, HK, MY, SAF, SP, TW) 1-690-608-11 CORD, POWER (AUS) 1-696-570-21 CORD, POWER (UK) 1-770-019-11 ADAPTOR, CONVERSION PLUG 3P (HK) 1-452-538-11 MAGNET

ACCESSORIES ************ 1-501-374-11 1-501-659-11 1-501-659-41 3-859-545-11 3-859-545-31 3-859-545-41

258 1-776-042-11 ! 301 8-820-020-01 302 1-769-069-11 HP101 1-500-093-11 HRPE1011-500-094-11

Remark

************** HARDWARE LIST **************

14 15 64 65 66

106

Description

WIRE (FLAT TYPE) (8 CORE) OPTICAL PICK-UP KSS-213D/ Q-NP WIRE (FLAT TYPE) (16 CORE) HEAD, MAGNETIC (PLAYBACK) (DECK A) HEAD, MAGNETIC (REC/ PB/ ERASE) (DECK B)

M1 M2 M101 M102 M701

X-3371-223-1 A-2004-410-A X-4917-523-4 X-4917-504-1 A-4672-004-A

MOTOR ASSY CAPSTAN MOTOR ASSY, DC (TRIGGER) MOTOR ASSY SPINDLE MOTOR ASSY SLED MOTOR ASSY (TURN)

M801 M901 S811 ! T901

A-4672-004-A 1-698-792-11 1-473-335-11 1-429-994-11

MOTOR ASSY (SLED) FAN, DC ENCODER, ROTARY (BU, TRAY ADDRESS DET) TRANSFORMER, POWER (RX90: AEP, AED, EE, CIS, G, UK)

4-979-371-01 8-917-582-90

ANTENNA, LOOP (GR8: IA, SAF, JE) ANTENNA (FM) (GR8: SAF) ANTENNA (FM) (GR8: IA, JE) MANUAL, INSTRUCTION (ENGLISH) (GR8: IA, JE) MANUAL, INSTRUCTION (CHINESE) (GR8: IA, JE) MANUAL, INSTRUCTION (KOREAN, PORTUGUESE) (GR8: JE) COVER, BATTERY (for RM-SD80) REMOCON, SONY RM-SD80//M SET (GR8: IA, SAF, JE)

! T901

1-429-995-11 TRANSFORMER, POWER (GR8: E, EA4, HK, IA, MX, SAF, SP, TH, TW, AUS, JE) ! T901 1-429-995-21 TRANSFORMER, POWER (GR8: EA3, MY) ************************************************************** The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified.

– 124 –

HCD-GR8/RX90 Printing Method for Large Sized Documents Such As Circuit Diagrams Printing the page that exceeds A4-size two pages (or letter size) is possible by specifying the print range. (Acrobat Reader Version 4.0 or later) 1. The enlarged print is made, if a smaller range than A4 size is specified and the A4 size is selected as a print paper. 2. Almost real sized print is made, if the range is specified, meeting the print paper size. 3. The reduced print is made, if a larger range than the print paper size is specified. Printing by Specifying a Range In printing out the drawings such as a schematic diagram and a printed wiring board larger than the printed paper size, they can be printed by specifying the range. (Acrobat Reader Version 4.0 or later) 1. Display the page to be printed. 2. From the File menu, select [Page Setup] and set the paper size. 3. From the Command bar, select [Graphic Select Tool]. (Keep pressing T , select

)

4. Dragging the cursor, enclose the range on the page to be printed. 5. From the File menu, select [Print] and make sure that the [Selected Graphic] is already checked. Also, if [Fit to page] is checked, the selected range is enlarged or reduced (and rotated as necessary) meeting the paper size.

6. To cancel the printed range, click an arbitrary position on the screen.

HCD-GR8/RX90

REVISION HISTORY Clicking the version allows you to jump to the revised page. Also, clicking the version at the upper right on the revised page allows you to jump to the next revised page. Ver. 1.0 1.1

Date 1997.02 2002.06

Description of Revision New Correction of Part No. for FRONT PANEL

(SPM-02030)