SRI SAI GANESH LOGISTICS PARK Your Modern Logistics Partner
116, SHOLAVARAM VILLAGE, PONNERI, TIRUVALLUR +91 98410 45246
SRI SAI GANESH LOGISTICS PARK
COVERED AREA DETAILS FOR WAREHOUSE
SRI SAI GANESH LOGISTICS PARK
BUILDING DIMENSION Approx. dimension of the building is 38.8m W (There is no intermediate column) x 111.0m L outer to outer as detailed in our drawing Equivalent Area 46341 Sqft. Clear Height : 10.0 m clear from FFL.
DESIGN CRITERIA FOR PEB STRUCTURE Design, deflection as per MBMA-2006/AISC using MBS software. Wind calculations and co efficient asper AISE/MBMA. Importance factor – 1.0.
DESIGN LOADS FOR PEB STRUCTURE Live Load - 0.57 KN/ m2 Wind Speed - 50 m /sec Seismic Zone - III Collateral Loads on purlins - 15 Kg/Sqm on purlins for sprinkler system by others Additional Loads on columns - NIL
SRI SAI GANESH LOGISTICS PARK
APPLICABLE CODES FOR PEB STRUCTURE Loads are applied in accordance with: The 2006 Edition of Low Rise Building System Manual Metal Building Manufactures Association (MBMA)
Hot rolled and Built up sections are designed in accordance with: Manual of Steel Construction, 13th Edition, 2005 American Institute of Steel Construction (AISC) All strength calculations are made as per Allowable stress Design (ASD) of AISC manual.
Cold-formed members are designed in accordance with: 2001 Edition of Cold formed Steel Design Manual, American Iron and Steel Institute (AISI) All cold formed steel structure shall be designed as per above mentioned code. Welding is applied in accordance with: American Welding Society (AWS D1.1/D1.1M:2008) Structural Welding Code – Steel
SRI SAI GANESH LOGISTICS PARK
ROOF SHEETING / INSULATION /
WIND BRACING
WALL SHEETING : Rod bracing considered Roof Sheeting : 0.47mm
in roof and sidewalls (as per design).Full
TCT Hi-Rib (Screw Down) profile. Bare
height cross bracing on one side
galvalume steel panel of 550 Mpa Yield
wall & on end wall. (No cross bracing on
strength with insulation
front end wall – canopy side)
Roof slope will be 1 :10.
Portal bracing upto 7.0m height & above cross bracing considered.
Insulation of Roofing of the Main Warehouse : This shall be insulated with
VENTILATION
4mm thick Air buble insulation without weldmesh
Ridge ventilator of size 600 mm throat x continuous length (leaving 4.0 m length on
Roofing of Canopy area, lean to areas EB
both ends).
Room, will be of single skin (Screw Down) Tracdeck Hi-Rib or equivalent bare galvalume of 26 gauge (0.47mm) 550 Mpa, Bare Galvalume high tensile profiled steel panels. 2mm thick Polycarbonate sheet on roof of size 1000mm (width) x 3000mm (length) with GI mesh of 75 x 75 x 2.0mm on bottom.
AIR CHANGES 3 to 4 Air changes approx. will be achieved per hour. The above air change can be achieved considering 30% of the rolling shutters are kept open.
SRI SAI GANESH LOGISTICS PARK
CANOPY Canopy 1 - 4.0m width cantilever throughout
Canopy 3
the length of 39.5 m on one side as shown in the drawing with clear minimum
4.0m width cantilever throughout
height of 4.5m from FFL level (5.7 m from Road
the length of 8.0 m on one side as shown
Level) supported from the main
in the drawing with clear minimum height
portal columns of the warehouse, water will
of 5.8m from FFL level (7 m from Road
free flow by considering Curved
Level) supported from the main portal
Eaves.
columns of the warehouse, water will free flow by considering Curved Eaves.
Canopy 2 - 4.0m width cantilever throughout the length of 23.5 m on one side as
Roofing of Canopy area will be of single
shown in the drawing with clear minimum
skin bare galvalume of 26 gauge
height of 4.5m from FFL level (5.7 m from Road
(0.47mm). (Screw Down)
Level) supported from the main portal columns of the warehouse, water will free flow by considering Curved Eaves.
SRI SAI GANESH LOGISTICS PARK
SIDE WALLS
ROLLING SHUTTERS
Wall Cladding : Single skin Tracdek
We will be providing 5 Nos. on the east
0.50mm thick Hi-Rib (screw down) profile
side and 10 Nos. on the west side of size
color coated Galvalume 550 Mpa
2.5m x 3.0m (on the east side) of
yield strength with insulation.
electrically operated Non Perforated rolling shutters of with Compact Gear
All side wall columns are fixed base & end wall
Operating system & One No.of size
columns are pinned base considered.
3.5m x5.5m.
Framed opening of size 3.50m(width) X 5.50m
The detailed location of all the rolling
(height) @ RSW 2nd bay as shown in the
shutters are shown in the enclosed
drawing.
drawing.
2mm thick polycarbonate sheet of size
All these rolling shutters will be operated
1.0m(w) X 3.0m(ht) with GI mesh of 75 x 75 x
from inside the warehouse.
2.0mm on bottom. Rolling shutters shall be provided with one Side end wall (East Side) upto 3.5m height by
coat of primer and one coat of enamel
9” thick brick wall and balance wall cladding.
paint.
Side end wall (West Side) upto 3.5m height by
EMERGENCY DOORS
9” thick brick wall and balance wall cladding. Front end wall (South Side) upto 3.0m height by 9” thick brick wall and balance wall cladding. Back end wall (North Side) upto 3.0m height by 9” thick brick wall and balance wall cladding.
RAMP We shall provide 1 No. of Ramp as shown in the drawing (width of 4m x 11m length) as shown in the drawing.
We will be providing 5 Nos. of emergency doors of 2 hours fire rating opening outside from the warehouse of 1200mm x 2400mm. Brick steps and hand rails will also be provided.
EAVE GUTTER AND DOWNSPOUTS Eave gutter and down takes are made out of galvalume. Gutter & down take are NOT considered for canopy as it’s free fall type.
SRI SAI GANESH LOGISTICS PARK
PAINTING
Wall Painting : One coat of white cement and 2 coats of emulsion.
PAINTING OF PEB STRUCTURE
SRI SAI GANESH LOGISTICS PARK
CAGE LADDERS
FLOORING
1 No. roof cage ladders will be provided up to roof height externally for any maintenance.
The flooring will be FM2 compliance.
SKY LIGHT
We will be designing the warehouse flooring capable of withstanding 6 MT/m2
Ridge ventilator of size 600 mm throat x continuous length (leaving 4.0 m length on both ends).
with floor hardener and dust sealer.
TOILET BLOCK
We will be providing adequate Nos. of
Dimension : approx. 6.0m X 4.0m as shown in the drawing - equivalent area 258 Sq.ft. Clear height 3m 2 IWC, 2 EWC, 5 Urninal pots and 3 Nos. wash basins. Adequate lighting shall be provided.. The entire toilet walls will be cladded to an height of 6’ using ceramic tiles of somany, Johnson tiles or equivalent make.
Finish to be burnished (power trowelled). contraction and expansion joints. The detailed design of the floor will be provided at the time of execution. Floor level of the warehouse will be raised to 1.2m from the road level.
FIRE PROTECTION Fire protection equipments such as fire hydrant, hose reels shall be provided.
Adequate exhaust fans will be provided. The location and details are furnished in the enclosed drawing.
All to be incompliance with local fire authorities and standards. The sump will have a capacity of 1,00,000 ltrs underground RCC tank.
SRI SAI GANESH LOGISTICS PARK
LIGHTING Warehouse Area : For the warehouse area, the lighting will be of LED / metal halide and the intensity will be 150 Lux at 1m above the floor level.
ELECTRICAL DRAWING AND APPROVAL The detailed electrical drawing of the entire warehouse will be provided.
Outside the warehouse area : The lighting will be of 50 Lux approx.
We shall obtain necessary approval from the concerned authorities with regard to electrical installation.
Street Lighting : We shall provide LED all around the warehouse i.e. in Cement Concrete Road area.
We will provide adequate lightening arresters.
Other Amenities areas like toilet etc. shall be provided with 150 Lux lighting. CANOPY Area : Lighting of 100 Lux will be provided in the Canopy Area.
INTERNAL ROAD A CC road will be provided all around the warehouse with a load bearing capacity of 2 MT / m2. The dimension of the road are mentioned in the enclosed drawing.
BOUNDARY WALL The entire logistic park shall be provided with a compound wall all around the area with a minimum height of 8 to 10 ft from the road level when measured from outside of the logistic park by using 6” Solid Blocks without plastering. The top of the compound wall shall be secured with barbed wire / Concertina coils for a height of around 2 ft with necessary supports.
ELECTRICAL CONNECTION We will be providing LT supply upto 100 HP and however any subsequent enhancement of power will be to the scope of the Lessee. Dimension : approx.5.0m X 2.5m as shown in the drawing - equivalent area 134 Sq.ft. Cement flooring All four sides will be closed using brick walls and the front side, we will be providing manually operated rolling shutters. Adequate lighting will be provided with necessary ventilation. The Electrical Panel room will be complete of PEB construction. The Electrical Panel Room will be of single skin bare galvalume of 26 gauge (0.47mm). (Screw Down) Structures shall be painted with one coat of red oxide primer and 2 coats of enamel paints. The location and details are furnished in the enclosed drawing
SRI SAI GANESH LOGISTICS PARK Your Modern Logistics Partner 116, SHOLAVARAM VILLAGE, PONNERI, TIRUVALLUR +91 98410 45246